Craftsman 358791560 Owner’s Manual

Instruction Manual

25cc/1.5 cu.in. 2-Cycle

16 Inch Cutting Path / 0.080 Inch Line
GASOLINE WEEDWAOKER ®

Model No.

358.791560

• Safety

• Assembly

• Operation

• Maintenance

• Parts List

• Espar_ol

For Occasional Use Only

WARNING:

Read and follow all Safety Rules and Operating
Instructions before first use of this product.

For answers to your questions about this product:

Call 7 am-7 pm, Mon.-Sat., or 10 am-7 pm, Sun.

1-800-235-5878 (Hours listed are Central Time)

Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.

530166247-01 2/10/05

Warranty Statement 2 Storage 10
Safety Rules 2 Troubleshooting Chart 11

Assembly 4 Emissions Statement 13
Operation 5 Parts List 14
Maintenance 8 Spanish 16

Service & Adjustments 9 Parts and Ordering Back

FULL ONE YEAR WARRANTY ON CRAFTSMAN ® GAS POWERED

WEEDWACKER ® LINE TRIMMER

For one year from the date of purchase, when this Craftsman Gas Powered

Weedwacker Line Trimmer is maintained, lubricated, and tuned up according to
the operating and maintenance instructions in this manual, Sears will repair, free
of charge, any defect in materials or workmanship.

This warranty excludes nylon line, spark plug, and air filter, which are expendable
parts and become worn during normal use.

If this Weedwacker line trimmer is used for commercial purposes, this warranty ap-
plies for only 90 days from the date of purchase. If this Weedwacker line trimmer is
used for rental purposes, this warranty applies for only 30 days from the date of pur-

chase. This warranty applies only while this product is in use in the United States.
WARRANTY SERVICE ISAVAILABLEBY RETURNING THE WEEDWACKER LINE TRIMMER
TO THE NEAREST SEARS STORE OR SERVICE CENTER INTHE UNITED STATES.

This warranty gives you specific legal rights, and you may also have other rights
which vary from state to state.

Sears, Roebuck and Co., D/817 WA, Hoffman Estates, IL 60179

zt

dIllWARNING: When using gar-
dening appliances, basic safety pre-

cautions must always be followed to
reduce the risk of fire and serious

injury. Read and follow all instructions=

This power unit can be dangerous! Op-
erator is responsible for following

instructions and warnings on unit and in
manual. Read entire instruction manual

before using unit! Be thoroughly familiar
with the controls and the proper use of

the unit. Restrict the use of this unit to
persons who have read, understand,

and will follow the instructions and
warnings on the unit and in the manual.

Never allow children to operate this unit.

INSTRUCTION SAFETY INFORMATION
MANUAL ON THE UNIT

,_ DANGER: Never use blades or
flailing devices. This unit is designed

for line trimmer use only. Use of any

other accessories or attachments will

increase the risk of injury.

@O@

,it

_WARNING: Trimmer line throws
objects violently. You and others can be

blinded/injured. Wear eye and leg
protection. Keep body parts clear of ro-

tating line.

_Protection /_

Keep children, bystanders, and animals

50 feet (15 meters) away. Stop unit im-

mediately if approached.

If situations occur which are not cov-
ered in this manual, use care and
good judgment. If you need assis-

tance, contact your Sears Service
Center or call 1-800-235-5878=

OPERATORSAFETY

• Dressproperly.Alwayswearsafety
glassesorsimilareyeprotection
whenoperating,orperformingmain-

tenance,onyourunit(safety
glassesareavailable).Eyeprotec-

tionshouldbemarkedZ87.

• Alwayswearfaceordustmaskifop-
erationisdusty.

• Alwayswearheavy,longpants,long
sleeves,boots,andgloves.Wear-
ingsafetylegguardsisrecom-

mended.

• Alwayswearfootprotection.Donot
gobarefootorwearsandals.Stay

clearofspinningline.

• Securehairaboveshoulderlength.
Secureorremovelooseclothingor

clothingwithlooselyhangingties,
straps,tassels,etc.Theycanbe
caughtinmovingparts.

• Beingfullycoveredalsohelpspro-
tectyoufromdebrisandpiecesof
toxicplantsthrownbyspinningline.

• StayAlert.Donotoperatethisunit
whenyouaretired,ill,upsetorun-

dertheinfluenceofalcohol,drugs,
ormedication.Watchwhatyouare
doing;usecommonsense.

• Wearhearingprotection.

• Neverstartorruninsideaclosed
roomorbuilding.Breathingexhaust

fumescankill.

• Keephandlesfreeofoilandfuel.

UNIT / MAINTENANCE SAFETY

• Disconnect the spark plug before
performing maintenance except car-

buretor adjustments.

• Look for and replace damaged or
loose parts before each use. Look

for and repair fuel leaks before use.
Keep in good working condition.

• Replace trimmer head parts that are
chipped, cracked, broken, or dam-
aged in any other way before using

the unit.

• Maintain unit according to recom-
mended procedures. Keep cutting

line at proper length.

• Use only 0.080 inch (2 mm) diame-
ter Craftsman@ brand line. Never

use wire, rope, string, etc.

• Install required shield properly be-
fore using the unit. Use only speci-
fied trimmer head; make sure it is

properly installed and securely fas-
tened.

• Make sure unit is assembled cor-
rectly as shown in this manual.

• Make carburetor adjustments with
lower end supported to prevent line

from contacting any object.

• Keep others away when making car-
buretor adjustments.

• Use only recommended CraftsmanCR_
accessories and replacement parts.

• Have all maintenance and service
not explained in this manual per-

formed by a Sears Service Center.

FUEL SAFETY

• Mix and pour fuel outdoors.

• Keep away from sparks or flames.

• Use a container approved for fuel.

• Do not smoke or allow smoking near
fuel or the unit.

• Avoid spilling fuel or oil. Wipe up all
fuel spills.

• Move at least 10 feet (3 meters)
away from fueling site before start-
ing engine.

• Stop engine and allow to cool before
removing fuel cap.

• Always store gasoline in a container
approved for flammable liquids.

CUTTING SAFETY
,40&WARNING: Inspect the area be-

fore each use. Remove objects

(rocks, broken glass, nails, wire, etc.)

which can be thrown by or become
entangled in line. Hard objects can

damage the trimmer head and be
thrown causing serious injury.

• Use only for trimming, scalping, mow-
ing, edging and sweeping. Do not use

for pruning or hedge trimming.

• Keep firm footing and balance. Do
not overreach.

• Keep all parts of your body away
from muffler and spinning line. Keep

engine below waist level. A hot muf-
fler can cause serious burns.

• Cut only from your right to your left.
Cutting on left side of the shield will

throw debris away from the operator.

• Use only in daylight or good artificial
light.

• Use only for jobs explained in this
manual.

TRANSPORTING AND STORAGE

• Allow engine to cool; secure unit be-
fore storing or transporting in ve-

hicle.

• Empty the fuel tank before storing or
transporting the unit. Use up fuel left

in the carburetor by starting the en-
gine and letting it run until it stops.

• Store unit and fuel in area where
fuel vapors cannot reach sparks or
open flames from water heaters,

electric motors or switches, fur-
naces, etc.

• Storeunitsolinelimiterbladecan-
notaccidentallycauseinjury.The

unitcanbehungbytheshaft.

• Storeunitoutofreachofchildren.

SAFETYNOTICE:Exposuretovibra-
tionsthroughprolongeduseofgaso-
linepoweredhandtoolscouldcause

bloodvesselornervedamageinthe
fingers,hands,andjointsofpeople
pronetocirculationdisordersorab-
normalswellings.Prolongedusein

coldweatherhasbeenlinkedtoblood
vesseldamageinotherwisehealthy

people.Ifsymptomsoccursuchas
numbness,pain,lossofstrength,
changeinskincolorortexture,orloss

offeelinginthefingers,hands,or
joints,discontinuetheuseofthistool

andseekmedicalattention.Ananti-
vibrationsystemdoesnotguarantee

theavoidanceoftheseproblems.

Userswhooperatepowertoolsona

continualandregularbasismustmon-
itorcloselytheirphysicalconditionand

theconditionofthistool.

SPECIAL NOTICE: This unit is
equipped with a temperature limiting

muffler and spark arresting screen

which meets the requirements of Cali-
fornia Codes 4442 and 4443. All U.S.

forest land and the states of California,

Idaho, Maine, Minnesota, New Jersey,
Oregon, and Washington require by

law that many internal combustion en-

gines be equipped with a spark arrest-

ing screen. If you operate in a locale

where such regulations exist, you are

legally responsible for maintaining the

operating condition of these parts.

Failure to do so is a violation of the
law. For normal homeowner use, the
muffler and spark arresting screen will

not require any service. After 50 hours

of use, we recommend that your muf-
fler be serviced or replaced by your

Sears Service Center.

CARTON CONTENTS

Check carton contents against the fol-
lowing list.

Model 358.791560

• Trimmer

• Shield

• Wing Nut (screwed onto shield)

• Container of Oil

Examine parts for damage. Do not

use damaged parts.

NOTE: If you need assistance or find

parts missing or damaged, call

1-800-235-5878.
It is normal for the fuel filter to rattle in

the empty fuel tank.

Finding fuel or oil residue on muffler is

normal due to carburetor adjustments
and testing done by the manufacturer.

ASSEMBLY
_L.WARNING: If received as-

sembled, repeat all steps to ensure
your unit is properly assembled and all
fasteners are secure.

ADJUSTING THE HANDLE

_WARNING: When adjusting tile
assist handle, be sure it remains above

the safety label and below the mark or
arrow on the shaft.

1. Loosen wing nut on handle.

2. Rotate the handle on the shaft to an
upright position; retighten wing nut.

ATTACHING SHIELD

_WARNING: The shield must be

properly installed. The shield provides
partial protection to the operator and

others from the risk of thrown objects,
and is equipped with a line limiter blade

which cuts excess line to the proper

length. The line limiter blade (on under-

side of shield) is sharp and can cut you.

For proper orientation of shield, see
KNOW YOUR TRIMMER illustration in OP-
ERATIONsection.

1. Remove wing nut from shield.

2. Insert bracket into slot as shown.

3. Pivot shield until bolt passes
through hole in bracket.

4. Securely tighten wing nut onto bolt.

Slot Nut

Shield

Gearbox

PIVOT