Condux Fiber Optic Cable Puller Pole Mounting Frame User Manual

Limited Warranty

USER GUIDE USER GUIDE USER GUIDE

Condux International, Inc. extends the following warranty to the original
purchaser of these goods for use, subject to the qualifications indicated:

Condux International, Incorporated warrants to the original purchaser for use
that the goods or any component thereof manufactured by Condux
International will be free from defects in workmanship for a period of one year
from the date of purchase, provided such goods are installed, maintained, and
used in accordance with Condux’s written instructions.

Components not manufactured by Condux International but used within the
assembly provided by Condux International are subject to the warranty period
as specified by the individual manufacturer of said component, provided such
goods are installed, maintained, and used in accordance with Condux’s and
the original manufacturer’s written instructions.

Condux’s sole liability and the purchaser’s sole remedy for a failure of goods
under this limited warranty, and for any and all claims arising out of the
purchase and use of the goods, shall be limited to the repair or replacement
of the goods that do not conform to this warranty.

To obtain repair or replacement service under the limited warranty, the
purchaser must contact the factory for a Return Material Authorization (RMA).
Once obtained, send the RMA along with the defective part or goods,
transportation prepaid, to: Condux International, Inc.
145 Kingswood Drive
Mankato, MN 56001 USA

Fiber Optic Cable Puller

Pole Mounting Frame

THERE ARE NO EXPRESS WARRANTIES COVERING THESE GOODS
OTHER THAN AS SET FORTH ABOVE. THE IMPLIED WARRANTIES OR
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE
LIMITED IN DURATION TO ONE YEAR FROM DATE OF PURCHASE.

CONDUX ASSUMES NO LIABILITY IN CONNECTION
WITH THE INSTALLATION OR USE OF THIS
PRODUCT, EXCEPT AS STATED IN THIS LIMITED
WARRANTY. CONDUX WILL IN NO EVENT BE
LIABLE FOR INCIDENTAL OR CONSEQUENTIAL
DAMAGES.

®

CONDUX

Condux International, Inc. • P.O. Box 247 • 145 Kingswood Drive • Mankato, MN 56001 USA

1-507-387-6576 • 1-800-533-2077 • FAX [phone]
Internet: http://www.condux.com

© Copyright 2012, Condux International, Inc.

Printed in USA

Literature Part Number: 08676099

Revision Number: 1.2

Mounting Instructions

NOTE: Use the Fiber Optic Puller Pole Mounting Frame only on steel
or wood poles. Do not use on aluminum or fiberglass poles. The
center holding spike is for wood poles only; remove it with an
adjustable or 9⁄16" wrench, before mounting on a steel pole.

1. Ensure the conduit or pole can withstand the maximum rated load
of the Pole Mounting Frame (1000 lbs.).

2. Place the Pole Mounting Frame on the pole. The long, flat support
bar should be on the bottom side.

3. Wrap the web strap around the pole, and insert the end hook into
the retaining slot on the frame.

4. Tighten the web strap, using its ratcheting mechanism, as far as
possible.

5. Secure the Pole Mounting Frame by wrapping the attached chains
around the pole.

6. Place the Fiber Optic Puller on the Pole Mounting Frame, and insert
the holding pin.

7. Slowly begin pulling with the Fiber Optic Puller. If the frame moves,
stop the pull, release the tension, and remount the frame.

Removal Procedure

Replacement Parts

Part Number Description

08676012 Center Holding Strap
02273200 Web Strap

End Hook

Retaining Slot

Chains

Fig 1. Pole Mounting Frame

Holding Pin

Support Bar

Web Strap

Ratcheting
Mechanism

Fig 2. Pole Mounting Frame

on Wood Pole

1. Removal is the opposite of the mounting procedure.

!WARNING: Read and understand all procedure
and safety instructions before using the Condux
Fiber Optic Cable Puller and Pole Mounting Frame.
Failure to do so may result in serious personal
injury, property damage, or death. Save this user’s
guide for future reference.

ADVERTENCIA

!ADVERTENCIA: Favor de leer y comprender
todas las instrucciones de operación y seguridad
antes de usar el Condux Fiber Optic Puller Pole

Instrucciones
de Operación

Mounting Frame. Si Ud. no comprende las
instrucciones favor de consultarle a su jefe.

Inspect the web strap before each use. Do not use
a damaged web strap. Severe personal injury or property damage
could result.

Do not exceed the 1,000 lb. load rating. Severe
personal injury or property damage could result.

If the frame moves, stop the pull, release the
tension, and remount the frame. Failure to do so could result in
personal injury or property damage.

Secure the frame with the attached chains. Failure
to do so could result in personal injury or property damage.