Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 1 of 9
1. Identification
1.1. Product identifier
Product Identity
MOISTURE TRAP
Alternate Names
90-318, Blended Formula, MOISTURE TRAP
1.2. Relevant identified uses of the substance or mixture and uses advised against
Intended use
See Technical Data Sheet.
Application Method
See Technical Data Sheet.
1.3. Details of the supplier of the safety data sheet
Company Name
ComStar International Inc.
20-45 128th Street,
College Point, NY 11356
Telephone No.
718-445-7900
800-328-0142
Fax: 718-353-5998
2. Hazard(s) identification
2.1. Classification of the substance or mixture
Skin Irrit. 2; H315
Causes skin irritation
2.2. Label elements
Using the Toxicity Data listed in section 11 and 12 the product is labeled as follows.
Warning
Harmful if inhaled.
[Prevention]:
P261 Avoid breathing dust / fume / gas / mist / vapors / spray.
P271 Use only outdoors or in a well-ventilated area.
[Response]:
P304+312 IF INHALED: Call a POISON CENTER or doctor / physician if you feel unwell.
P340 Remove victim to fresh air and keep at rest in a position comfortable for breathing.
Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 2 of 9
[Storage]:
No GHS storage statements
[Disposal]:
No GHS disposal statements
3. Composition/information on ingredients
This product contains the following substances that present a hazard within the meaning of the relevant State and Federal Hazardous Substances
regulations.
Ingredient/Chemical Designations
Weight %
GHS Classification
Notes
Dipropylene Glycol Monomethyl Ether
CAS#: 34590-94-8
>10
Eye Irrit. 2B
Flammable Liquid: 4
[1][2]
Diethylene Glycol Monobutyl Ether
CAS#: 112-34-5
>10
Acute Toxicity 5
Eye irritation 2A
[1][2]
Propylene Glycol N-Butyl Ether
CAS#: 5134-66-8
>10
Eye Irritant Category 2
Skin Irritant Category 2
[1]
Isopropanol
CAS#: 67-63-0
<70
Flam. Liq. 2 H225
Eye Irrit. 2A H319
Carc. 2 H351
STOT SE 3 H335
[1][2]
In accordance with paragraph (i) of §1910.1200, the specific chemical identity and/or exact percentage (concentration) of composition has been
withheld as a trade secret.
[1] Substance classified with a health or environmental hazard.
[2] Substance with a workplace exposure limit.
[3] PBT-substance or vPvB-substance.
*The full texts of the phrases are shown in Section 16.
4. First aid measures
4.1. Description of first aid measures
General
In all cases of doubt, or when symptoms persist, seek medical attention.
Never give anything by mouth to an unconscious person.
Inhalation
Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped, give
artificial respiration. If unconscious place in the recovery position and obtain immediate
medical attention. Give nothing by mouth.
Eyes
Irrigate copiously with clean water for at least 15 minutes, holding the eyelids apart and
seek medical attention.
Skin
Remove contaminated clothing. Wash skin thoroughly with soap and water or use a
recognized skin cleanser.
Ingestion
If swallowed obtain immediate medical attention. Keep at rest. Do NOT induce vomiting.
4.2. Most important symptoms and effects, both acute and delayed
Overview
No specific symptom data available.
See section 2 for further details.
Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 3 of 9
Inhalation
Harmful if inhaled.
5.1. Extinguishing media
Water fog, C02, dry chemical, universal foams
5.2. Special hazards arising from the substance or mixture
Hazardous decomposition: No hazardous decomposition data available.
Avoid breathing dust / fume / gas / mist / vapors / spray.
5.3. Advice for fire-fighters
Wear self-contained breathing apparatus and protective clothing.
ERG Guide No. ---
6.1. Personal precautions, protective equipment and emergency procedures
Put on appropriate personal protective equipment (see section 8).
6.2. Environmental precautions
Do not allow spills to enter drains or waterways.
Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove
soiled clothing and wash thoroughly before reuse.
6.3. Methods and material for containment and cleaning up
Absorb spill with vermiculite or other inert material, then place in a container for chemical waste.
For Large Spills: Flush spill area with water spray. Prevent run-off from entering drains, sewers, or streams, collect
run-off.
7.1. Precautions for safe handling
Avoid contact with eyes and skin. Wash thoroughly after handling. Do not breathe vapors or fumes.
Prevention of Fire and Explosion: Keep from contact with oxidizing materials, alkalis and acids. Store away from heat,
sunlight and moisture.
See section 2 for further details. - [Prevention]:
7.2. Conditions for safe storage, including any incompatibilities
Handle containers carefully to prevent damage and spillage.
Incompatible materials: Oxidizing agents, alkali metals
See section 2 for further details. - [Storage]:
7.3. Specific end use(s)
5. Fire-fighting measures
6. Accidental release measures
7. Handling and storage
Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 4 of 9
No data available.
8. Exposure controls and personal protection
8.1. Control parameters
Exposure
CAS No.
Ingredient
Source
Value
34590-94-8
DIPROPYLENE GLYCOL
MONOMETHYL ETHER
OSHA
100 ppm
ACGIH
100 ppm
NIOSH
TWA 100 ppm (600 mg/m3) ST 150 ppm (900 mg/m3) [skin]
Supplier
No Established Limit
112-34-5
Diethylene Glycol Monobutyl Ether
OSHA
100 ppm
ACGIH
100 ppm
NIOSH
No Established Limit
Supplier
No Established Limit
5134-66-8
Propylene Glycol N-Butyl Ether
OSHA
100 ppm
ACGIH
100 ppm
NIOSH
No Established Limit
Supplier
No Established Limit
67-63-0
Isopropanol
OSHA
500 ppm
ACGIH
500 ppm
NIOSH
400 ppm (983 mg/m3)
Supplier
No Established Limit
Carcinogen Data
CAS No.
Ingredient
Source
Value
34590-94-8
DIPROPYLENE GLYCOL MONOMETHYL
ETHER
OSHA
Select Carcinogen: No
NTP
Known: No; Suspected: No
IARC
Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No;
112-34-5
Diethylene Glycol Monobutyl Ether
OSHA
Select Carcinogen: No
NTP
Known: No; Suspected: No
IARC
Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No;
5134-66-8
Propylene Glycol N-Butyl Ether
OSHA
Select Carcinogen: No
NTP
Known: No; Suspected: No
IARC
Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No;
67-63-0
Isopropanol
OSHA
Select Carcinogen: No
NTP
Known: No; Suspected: No
IARC
Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No;
8.2. Exposure controls
Respiratory
If engineering controls do not maintain airborne concentrations to an acceptable level, a
Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 5 of 9
NIOSH approved respirator must be worn.
Respirator Type: Organic vapor. If respirators are used, a program should be instituted to
assure Compliance with OSHA Standard 29 CFR 1910.134.
Eyes
Safety glasses with side shields, goggles or face shield are recommended.
Skin
Wear overalls to keep skin contact to a minimum.
Engineering Controls
Good general ventilation (typically 10 air changes per hour) should be used. Ventilation
rates should be matched to conditions. Supplementary local exhaust ventilation, closed
systems, or respiratory protection may be needed in special circumstances such as poorly
ventilated spaces, evaporation from large surfaces, spraying, heating, etc. Recommended
Decontamination Facilities: Eye bath, washing facilities.
Other Work Practices
Use good personal hygiene practices. Wash hands before eating, drinking, smoking or
using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.
See section 2 for further details. - [Prevention]:
9. Physical and chemical properties
Appearance
Clear Liquid
Odor
Slight
Odor threshold
Not Measured
pH
Not Measured
Melting point / freezing point
Not Measured
Initial boiling point and boiling range
370 F/188 C
Flash Point
None
Evaporation rate (Ether = 1)
Not Measured
Flammability (solid, gas)
Not Applicable
Upper/lower flammability or explosive limits
Lower Explosive Limit: 135C(275F): NA
Upper Explosive Limit: 199C(390F): NA
Vapor pressure (Pa)
6 mmHg (at 70 F)
Vapor Density
Not Measured
Specific Gravity
> 2 (H20 = 1)
Solubility in Water
Complete
Partition coefficient n-octanol/water (Log Kow)
Not Measured
Auto-ignition temperature
(ASTM D 2155): NA
Decomposition temperature
Not Measured
Viscosity (cSt)
25C/77F: NA
Volatiles (% by weight)
NA Octanol/Water Partition Coefficient
NA
Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 6 of 9
9.2. Other information
No other relevant information.
10. Stability and reactivity
10.1. Reactivity
Hazardous Polymerization will not occur.
10.2. Chemical stability
Stable under normal circumstances.
10.3. Possibility of hazardous reactions
No data available.
10.4. Conditions to avoid
No data available.
10.5. Incompatible materials
Strong Oxidizers
10.6. Hazardous decomposition products
No hazardous decomposition data available.
11. Toxicological information
Acute toxicity
Ingredient
Oral LD50,
mg/kg
Skin LD50,
mg/kg
Inhalation
Vapor LC50,
mg/L/4hr
Inhalation
Dust/Mist LC50,
mg/L/4hr
Inhalation
Gas LC50,
ppm
DIPROPYLENE GLYCOL MONOMETHYL ETHER
(34590-94-8)
5230 mg/kg Rat
>13,000 mg/kg
500 ppm
No data
available
No data
available
Diethylene Glycol Monobutyl Ether (112-34-5)
5,660 mg/kg
Rat
2,700 mg/kg
Rabbit
No data
available
No data
available
No data
available
Propylene Glycol N-Butyl Ether (5134-66-8)
1,800, 2,400, or
3,200
mg/kg bw
2,000 mg/kg bw
650 ppm
No data
available
No data
available
Isopropanol (67-63-0)
5045 mg/kg
Rat;
12870 mg/kg
(Rabbit)
73 mg/l/4h
(Rat)
73 mg/l/4h (Rat)
No data
available
Note: When no route specific LD50 data is available for an acute toxin, the converted acute toxicity point estimate
was used in the calculation of the product's ATE (Acute Toxicity Estimate).
Classification
Category
Hazard Description
Acute toxicity (oral)
---
Not Applicable
Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 7 of 9
Acute toxicity (dermal)
---
Not Applicable
Acute toxicity (inhalation)
---
Not Applicable
Skin corrosion/irritation
---
Not Applicable
Serious eye damage/irritation
---
Not Applicable
Respiratory sensitization
---
Not Applicable
Skin sensitization
---
Not Applicable
Germ cell mutagenicity
---
Not Applicable
Carcinogenicity
---
Not Applicable
Reproductive toxicity
---
Not Applicable
STOT-single exposure
---
Not Applicable
STOT-repeated exposure
---
Not Applicable
Aspiration hazard
---
Not Applicable
12. Ecological information
12.1. Toxicity
No additional information provided for this product. See Section 3 for chemical specific data.
Aquatic Ecotoxicity
Ingredient
96 hr LC50 fish,
mg/l
48 hr. EC50 crustacea,
mg/l
ErC50 algae,
mg/l
DIPROPYLENE GLYCOL MONOMETHYL
ETHER (34590-94-8)
>10,000, Pimephales
promelas
1919, Daphnia
Not Available
Diethylene Glycol Monobutyl Ether (112-34-5)
1,300 mg/L
100 mg/L
Not Available
Propylene Glycol N-Butyl Ether (5134-66-8)
560
1000
1000
Isopropanol (67-63-0)
4200 mg/l
> 10000 mg/l
Not Available
12.2. Persistence and degradability
There is no data available on the preparation itself.
12.3. Bioaccumulative potential
Not Measured
12.4. Mobility in soil
No data available.
12.5. Results of PBT and vPvB assessment
This product contains no PBT/vPvB chemicals.
12.6. Other adverse effects
No data available.
13. Disposal considerations
Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 8 of 9
13.1. Waste treatment methods
Observe all federal, state and local regulations when disposing of this substance.
14. Transport information
DOT (Domestic Surface
Transportation)
IMO / IMDG (Ocean
Transportation)
ICAO/IATA
14.1. UN number
Not Applicable
Not Regulated
Not Regulated
14.2. UN proper shipping
name
Not Regulated
Not Regulated
Not Regulated
14.3. Transport hazard
class(es)
DOT Hazard Class: Not
Applicable
IMDG: Not Applicable
Sub Class: Not Applicable
Air Class: Not Applicable
14.4. Packing group
Not Applicable
Not Applicable
Not Applicable
14.5. Environmental hazards
IMDG
Marine Pollutant: No
14.6. Special precautions for user
No further information
15. Regulatory information
Regulatory Overview
The regulatory data in Section 15 is not intended to be all-inclusive, only selected
regulations are represented.
Toxic Substance
Control Act (TSCA)
All components of this material are either listed or exempt from listing on the TSCA
Inventory.
WHMIS Classification
Not Regulated
US EPA Tier II Hazards
Fire:
No Sudden Release of Pressure:
No
Reactive:
No
Immediate (Acute):
No
Delayed (Chronic):
No
EPCRA 311/312 Chemicals and RQs:
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
EPCRA 302 Extremely Hazardous:
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
EPCRA 313 Extremely Hazardous:
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute
Proposition 65 - Carcinogens (>0.0%):
Safety Data Sheet
MOISTURE TRAP
SDS Revision Date:
07/01/2018
Page 9 of 9
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 - Developmental Toxins (>0.0%):
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 - Female Repro Toxins (>0.0%):
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 - Male Repro Toxins (>0.0%):
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
New Jersey RTK Substances (>1%):
DIPROPYLENE GLYCOL MONOMETHYL ETHER
Pennsylvania RTK Substances (>1%):
DIPROPYLENE GLYCOL MONOMETHYL ETHER
16. Other information
The information and recommendations contained herein are based upon data believed to be correct. However, no
guarantee or warranty of any kind, expressed or implied, is made with respect to the information contained herein.
We accept no responsibility and disclaim all liability for any harmful effects which may be caused by exposure to our
products. Customers/users of this product must comply with all applicable health and safety laws, regulations, and
orders.
The full text of the phrases appearing in section 3 is:
H302 Harmful if swallowed.
H331 Toxic if inhaled.
This is the first version in the GHS SDS format. Listings of changes from previous versions in other formats
are not applicable.
The opinions expressed are those of qualified experts within ComStar International Inc. We believe that the
information contained is current as of the date of the Material Safety Data Sheet. Since the use of this information and
of these opinions and the conditions of the use of the product are not within the control of ComStar International Inc.,
it is the user’s obligation to determine the conditions of safe use of the product.
End of Document
Loading...