Cole-Parmer 79202-00, 79202-05, 79202-30, 79202-35 Instruction Manual

OWNER’S MANUAL

FOR

AIR ADMIRAL® VACUUM/PRESSURE STATION

MODELS:

79202-00
79202-05
79202-30
79202-35

Model 79202-00 & 79202-05

Approval Agency’s

Model 79202-30 & 79202-35

WARNING

Not recommended for pumping acid,

base or organic vapors or gases.

Cole-Parmer Instrument Company
625 East Bunker Court
Vernon Hills, IL 60061-1844
Phone: [phone]
Fax: [phone]
E-Mail: [e-mail] Part No. 67-0889R1.2
Web-Page: www.coleparmer.com Printed in USA

INSTRUCTION

WARNING AND CAUTION

PLEASE READ BEFORE OPERATION

While reading your manual, please pay close attention to areas labeled:

WARNING AND CAUTION.

The description of each is found below.

WARNING

Warnings are given where failure to observe instruction could result

in injury or death to people.

CAUTION

Cautions are found where failure to observe the instruction could result

in damage to the equipment, associated equipment and process.

These units confirm to the SI International system of units of measurement.

The following symbols (with recommendation of IEC1010 ) of warning will be found on the pump.

Caution - refer to accompanying documents

Caution - risk of electrical shock

Caution - hot surface

Double Insulated

OFF (Power)

ON (Power)

WARNING

Motor includes a self resetting thermal cutout and the pump could

restart without actuation under fault condition.

2

TABLE OF CONTENTS

Section 01 - SAFETY INFORMATION

1.10 Caution To Prevent Injury

1.20 Caution To Reduce Risk Of Electrical Shock

1.30 Warning To Reduce Risk Of Electrocution

1.40 Danger To Reduce Risk Of Explosion Or Fire

Section 02 - INSTALLATION

2.10 Introduction

2.20 Unpacking

2.30 Pump Mounting

2.40 Pump Location

2.50 Intake And Discharge Provision

2.60 Electrical Power

2.70 Vacuum Connection

2.80 Vacuum Gauges

Section 03 - OPERATION

3.10 Starting Procedures

3.20 Leak Detection

3.30 Operating Pressure Range

3.40 Shutdown Procedures

Section 04 - MAINTENANCE

4.10 Maintenance Procedures

Section 05 - TROUBLESHOOTING

5.10 Vacuum Problems

5.20 Pressure Problems

5.30 Trouble Shooting Guide

Section 06 - SPECIFICATION

6.10 Specification Table

Section 07 - WARRANTY

3