Coleman Northern Nova 2555 Series User Manual
SHEET 1 OF 1
Wichita, Kansas USA 67219
The Coleman Company, Inc.
COMPOSITE- NO
CRITICAL DIMENSION
cm3
REV.
MATERIAL:
SEE NOTES
SEE NOTES
1:1
26-OCT-15
Black
Program: InDesign CS6
Jenny D
MANUAL FOR 2555 NOVA LANTERN
David N
01
4010048738
SCALE:
NAME:
DATE: DRAWN BY: APPROVED BY: REVISION
FINISH
SPEC.:
DATE
NAME
ECN NO.
MODIFICATIONS
grams
g/cm3
This drawing contains proprietary information and trade secrets of The Coleman Company, Inc.
Unauthorized use or copying is prohibited.
METRIC
[INCH]
CHECKING IS COMPULSORY
VOLUME
01 26-OCT-15 Jenny D 20052026NEW
MASS
DENSITY
GENERAL TOLERANCES
EXCEPT AS NOTED
0 TO 6mm = ±0.1
>6 TO 30mm = ±0.2
>30 TO 80mm = ±0.3
>80 TO 180mm = ±0.4
>180mm = ±0.5
ANGULAR = ± 3°
PART
NO.:
DO NOT PRINT THIS PAGE
Printing Notes:
Material: 20 Pound (US) or 80 GSM (International) bond paper, white
Ink: Black
Resolution: 150 DPI or above
Printing method: Offset Printing
Binding: Saddle Stitch
Folded size: 4 x 8.5 in (W x H)
IMPORTANT
Read this manual carefully before assembling, using or servicing these lanterns. Keep this manual for future reference. If you have questions about
assembly, operation, servicing or repair of these lanterns, please call The
Coleman Company, Inc. at 1-800-835-3278 or TDD: 1-316-832-8707. In
Canada call 1-800-387-6161.
IMPORTANT
Lisez attentivement ce manuel avant d’assembler, d’utiliser ou de réparer ces lanternes et
gardez-le pour référence ultérieure. Pour toute question en ce qui concerne l’assemblage,
le fonctionnement, l’entretien ou la réparation, appelez The Coleman Company, Inc. au
1-800-835-3278 ou ATS 1-316-832-8707 aux États-Unis et au 1-800-387-6161 au Canada.
IMPORTANTE
Lea este manual cuidadosamente antes del ensamblaje y el uso o el servicio de
las lámparas. Guarde este manual para uso de referencia en el futuro. Si usted
tiene preguntas acerca del ensamblaje, funcionamiento, servicio o reparación
de estas lámparas, por favor llame a The Coleman Company, Inc. al 1-800-8353278 o TDD: 1-316-832-8707. En Canadá llame al 1-800-387-6161.
Camp Light
Lanterne de camping
Lámpara para Campamento
Propane Lanterns
Lanternes à propane
Lámparas de Propano
Instructions for use
Notice d’emploi
Instrucciones de uso
© 2015 The Coleman Company, Inc.
www.coleman.com
Northern Nova
2555 Series
INSTASTART™ Electronic Ignition
Allumage électronique
Encendido electrónico
English-1
If you smell gas:
1. Do not attempt to
light appliance.
2. Extinguish any
open flame.
3. Disconnect from
fuel supply.
FOR YOUR
SAFETY
Do not store or use
gasoline or other liquids
with flammable vapors
in the vicinity of this or
any other appliance.
FOR YOUR
SAFETY
CARBON MONOXIDE
HAZARD
• This appliance can
produce carbon mon
oxide which has
no odor.
• Using it in an enclosed
space can kill you.
• Never use this appliance in an enclosed
space such as a camper, tent, car or home.
DANGER
This manual contains important information
about the assembly, operation and maintenance
of these propane lanterns. General safety information is presented on this page and is also located
throughout these instructions. Particular attention
should be paid to information accompanied by
the safety alert symbol “ DANGER”,
“ WARNING”, “ CAUTION”.
Keep this manual for future reference and to
educate new users of this product. This manual
should be read in conjunction with the labeling on
the product.
Safety precautions are essential when any
mechanical or propane fueled equipment is
involved. These precautions are necessary when
using, storing, and servicing. Using this equipment
with the respect and caution demanded will
reduce the possibilities of personal injury or
property damage.
The following symbols shown below are used
extensively throughout these instructions. Always
heed these precautions, as they are essential when
using any mechanical or propane fueled equipment.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and byproducts of
combustion of this fuel, contain chemicals known
to the state of California to cause cancer, birth
defects, or other reproductive harm.
CAUTION
CAUTION indicates a potentially hazardous
situation which, if not avoided, may result in
minor or moderate personal injury, or
property damage.
Failure to comply with the precautions and
instructions provided with these lanterns can
result in death, serious bodily injury and property loss or damage from hazards of fire, explosion, burn, asphyxiation, and/or carbon
monoxide poisoning.
Only persons who can understand and follow
the instructions should use or service
these lanterns.
If you need assistance or information such
as an instruction manual or labels, contact
The Coleman Company, Inc.
DANGER
DANGER
DANGER indicates an imminently hazardous
situation which, if not avoided, will result in
death or serious injury.
WARNING indicates a potentially hazardous
situation which, if not avoided, could result in
death or serious injury.
WARNING
English-2
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open
flames, pilot lights, direct sunlight, other ignition sources or where temperatures exceed
120 °F (49 °C).
• Propane is heavier than air and can accumu-
late in low places. If you smell gas, leave the
area immediately.
• Never install or remove propane tank while
lantern is lighted, near flame, pilot lights,
other ignition sources or while lantern is hot
to touch.
• During operation, this product can be a
source of ignition. Never use the lantern in
spaces that contain or may contain volatile or
airborne combustibles, or products such as
gasoline, solvents, paint thinner, dust particles
or unknown chemicals.
• Minimum clearances from combustible mate-
rials: 24 inches from the sides and 48 inches
from the top.
• Do not obstruct the flow of combustion or
ventilation air.
• Proper lantern operation produces a bright
white light.
WARNING
• BURN HAZARD
• Do not leave this appliance unattended
while it is in operation.
• Keep out of reach of children.
DANGER
• CARBON MONOXIDE HAZARD
• This lantern is a combustion appliance. All
combustion appliances produce carbon monoxide (CO) during the combustion process.
This product is designed to produce extremely minute, non-hazardous amounts of CO if
used and maintained in accordance with all
warnings and instructions. Do not block air
flow into or out of the lantern.
• Carbon Monoxide (CO) poisoning produces
flu-like symptoms, watery eyes, headaches,
dizziness, fatigue and possibly death. You
can’t see it and you can’t smell it. It’s an
invisible killer. If these symptoms are present
during operation of this product get fresh
air immediately!
• For outdoor use only.
• Never use inside house, camper, tent,
vehicle or other unventilated or enclosed
areas. This lantern consumes air (oxygen).
Do not use in unventilated or enclosed
areas to avoid endangering your life.
CAUTION
• SERVICE SAFETY
• Use only propane set up for vapor
withdrawal.
• Keep all connections and fittings clean.
Inspect propane cylinder and lantern propane
connections for damage before attaching.
• During set up, CHECK FOR LEAKS in one
or more ways: Apply soapy water to connections. Look for bubbles. Listen for hiss of
escaping gas. Feel for extreme cold. Smell
for rotten egg odor. Never use a flame.
Do not use if leaking.
• Use as a lighting appliance only. Never alter
in any way or use with any device or part not
expressly approved by Coleman.
• Never use as a space heater.
• Always use in upright position. Protect cylin-
der from excess heat.
Technical
Characteristics
Input: 8,000 BTU/h
Category: Pressure regulated propane
Fuel:
16.4 oz. disposable propane cylinders
Regulator: 2555
Not for home or recreational vehicle use.
We cannot foresee every use which may be
made of our products.
Check with your local fire safety authority if
you have questions about use.
Other standards govern the use of fuel gases
and heat producing products for specific
uses. Your local authorities can advise you
about these.
• Never refill disposable cylinders.
• Use the preset regulator that came with the
lantern. Do not attempt to adjust.
• Use only Coleman® accessories or parts
• During lantern set-up, check all fittings for
leaks using soapy water. Never use a flame.
WARNING
• This product is fueled by propane gas. Propane
gas is invisible, odorless, and flammable. An odorant is normally added to help detect leaks and
can be described as a ”rotten egg” smell. The
odorant can fade over time so leaking gas is not
always detectable by smell alone.
• Propane gas is heavier than air and leaking pro
pane will sink to the lowest level possible. It can
ignite by ignition sources including matches, lighters, sparks or open flames of any kind many feet
away from the original leak. Use only propane gas
set up for vapor withdrawal.
•
Propane gas should be stored or used in compliance with local ordinances and codes or with ANSI/
NFPA 58. Disconnect cylinder when not in use.
WARNING
DANGER
To Set Up
DANGER
• CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper, tent, vehicle
or other unventilated or enclosed areas. This
lantern consumes air (oxygen). Do not use
in unventilated or enclosed areas to avoid
endangering your life.
English-3
Always use genuine Coleman® #95 size mantles.
If using Insta-Clip® II tabbed mantles, follow the
instructions on the mantle package.
If using original wire clip mantles, attach MANTLE
to BURNER TUBE AND LOWER MANTLE
SUPPORT. Be sure clips engage grooves.
n Take lantern outdoors away from
ignition sources.
n Turn fuel valve off.
Remove protective cap from top of propane cyl
inder. Save cap for use in storing. Screw propane
cylinder into lantern. Take care not to crossthread. Hand tighten only.
n Note: Use Coleman® 16.4 oz. disposable
propane cylinders. The LP-gas cylinder(s) must
be constructed and marked in accordance with
the specifications for LP-gas cylinders of the
U.S. Department of Transportation or Transport
Canada, the Standard for Cylinders, Spheres,
and Tubes for the Transportation of Dangerous
Goods, CAN/CSA B339. Only cylinders marked
with the proper fuel type approved for this
appliance must be used.
n Extend legs
by first grasp
ing each
leg near the
bottom of the
lantern frame.
Then gently
pull each leg
away from the
lantern and
rotate until the
leg clicks into
its extended
position.
Repeat for all
3 legs.
CAUTION
• SERVICE SAFETY
• Keep all connections and fittings clean.
Inspect propane cylinder and lantern propane
connections for damage before attaching.
• During set up, check all connections and
fittings for leaks using soapy water. Bubbles
indicate a leak. Never use a flame.
To Tie On Mantles
n Twist clips.
Burner
Tube
• Replace any mantle with a hole in it. A hole
can cause lantern to overheat and create a
hazard. Never operate lantern without
heat shield.
WARNING
Lower
Mantle
Support
English-4
n Twist clips.
Repeat process to tie on second mantle. Light
mantles evenly and leave to burn. Once mantles
have been burned, they are very fragile. Be careful
not to touch them with your finger or match.
n Replace VENTILATOR and GUARD/
GLOBE ASSEMBLY. Position guard arms into
notch in frame.
NOTE: When re-installing globe onto lantern be
sure not to contact mantle clip. Mantle may be
dislodged from groove.
Lower
Mantle
Support
To Light
DANGER
• EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can accumulate in low places. If you smell gas, leave the
area immediately.
• Always attach or detach propane source
outdoors; never while lantern is lighted, near
flame, pilot lights, other ignition sources or
while lantern is hot to touch.
• Always light and use lantern outdoors.
• This lantern must not be exposed to flam-
mable vapors or liquids during lighting.
• This lantern is very hot during use and can
ignite flammables too close to the mantles.
Keep gasoline and other flammable liquids
and vapors well away from lantern.
Always light and use lantern outdoors; never
inside house, camper, tent or other unventilated or
enclosed areas.
If you smell gas:
1. Do not attempt to light appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
4. Call 1-800-835-3278.
WARNING
WARNING
• BURN HAZARD
• Never leave lantern unattended when hot
or in use.
• Keep out of reach of children.
n Brightness may be adjusted with fuel valve.
To Turn Off
n Turn fuel valve off.
To Store
English-5
n Turn fuel valve on. Push the red igniter button
and a spark should jump between the electrode
and air tube and ignite the mantles.
NOTE: If lantern does not light after pushing the
igniter button a few times, repeat above step after
turning fuel valve completely off. If the lantern is
wet due to rain, high humidity, etc., the valve may
not spark. Use match lighting procedure
as follows.
INSTASTART™
Electronic Ignition
Match Lighting
n Push lighted match through lighting hole, hold
near mantle and open fuel valve fully.
n Make sure lan-
tern is cool.
n Move lantern
away from flame
(including pilot
lights) and other
ignition sources.
n Disconnect
propane cylinder
from lantern.
n Replace
protective cap on
propane cylinder.
n
Collapse the legs
by first grasping
each leg near the
bottom of the
lantern frame. Then
gently pull each
leg away from the
lantern and rotate
until the leg clicks
into its collapsed
position. Repeat for
all 3 legs. Lantern
may be stored in
included carry case.
n The lantern may be carried by the handle.
English-6
Warranty
www.coleman.com
1. It is unsafe and illegal in some places to store or use
liquid propane cylinders of greater than 1.14 kg
(2.5 lbs.) water capacity (approximately 465g [1 lb.]
propane) in occupied enclosures.
2. Always have a spare set of Coleman
®
Mantles. Once
burned, a mantle is fragile and can be damaged if
touched or dropped.
3. The usual storage areas for camping and picnic
equipment are the basement, attic, or garage. To
avoid the accumulation of dust, cobwebs, etc., that is
common in these storage areas, place your lantern in
a plastic bag and seal it with a rubber band.
4. During operation, carry the lantern using the bail.
5. If not completely satisfied with the performance of
this product, please call one of the numbers listed on
the cover of this manual.
Things You Should Know
DANGER
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open
flames, pilot lights, direct sunlight, other ignition sources or where temperatures exceed
120 °F (49 °C).
• The cylinder must be disconnected when the
lantern is in storage.
Limited Three Year Warranty
The Coleman Company, Inc. (“Coleman”) warrants that
for a period of three (3) years from the date of original
retail purchase, this product will be free from defects in
material and workmanship. Coleman, at its option, will
repair or replace this product or any component of the
product found to be defective during the warranty period.
Replacement will be made with a new or remanufactured
product or component. If the product is no longer available,
replacement may be made with a similar product of equal
or greater value. This is your exclusive warranty.
This warranty is valid for the original retail purchaser from
the date of initial retail purchase and is not transferable.
Keep the original sales receipt. Proof of purchase is
required to obtain warranty performance. Coleman dealers,
service centers, or retail stores selling Coleman
®
products
do not have the right to alter, modify or in any way change
the terms and conditions of this warranty.
What This Warranty Does Not Cover
This warranty does not cover normal wear of parts, parts
that are not genuine Coleman
®
parts, or damage resulting
from any of the following: negligent use or misuse of the
product; commercial use of the product; use contrary to the
operating instructions; disassembly, repair or alteration by
anyone other than Coleman or an authorized service center.
Further, the warranty does not cover Acts of God, such
as fire, flood, hurricanes and tornadoes. Warranty void if
damage to the product results from the use of a part other
than a genuine Coleman
®
part.
COLEMAN SHALL NOT BE LIABLE FOR DEFECTS
THAT ARE CAUSED BY THE USE OF UNAUTHORIZED
PARTS OR SERVICE. COLEMAN SHALL NOT BE
LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES CAUSED BY THE BREACH OF ANY
EXPRESS OR IMPLIED WARRANTY OR CONDITIONS.
EXCEPT TO THE EXTENT PROHIBITED BY
APPLICABLE LAW, ANY IMPLIED WARRANTY
OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE IS LIMITED IN DURATION
TO THE DURATION OF THE ABOVE WARRANTY
OR CONDITIONS. SOME STATES, PROVINCES, OR
JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR
LIMITATION OF INCIDENTAL OR CONSEQUENTIAL
DAMAGES OR LIMITATIONS ON HOW LONG AN
IMPLIED WARRANTY LASTS, SO THE ABOVE
LIMITATIONS OR EXCLUSION MAY NOT APPLY TO
YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL
RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS
THAT VARY FROM STATE TO STATE OR PROVINCE
TO PROVINCE.
How to Obtain Warranty Service
Your product must be under warranty in order to obtain
warranty service. If your product is defective and is within
your warranty period, contact us at 1-800-835-3278 (TDD
1-316-832-8707) in order to receive a return authorization.
Do not return product to Coleman without authorization.
You will be directed to attach a tag to the product that
includes your name, address, daytime telephone number
and description of the problem. Include a copy of the
original sales receipt. Carefully package the product and
send insured by UPS, FedEx Ground or Parcel Post with
shipping and insurance prepaid to:
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219 U.S.A.
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1
The cost of transporting the product to Coleman for
warranty service is the responsibility of the purchaser.
Do not mail products with fuel in tanks, or with disposable
propane cylinders. Remove glass globes from lanterns and
wrap separately.
DO NOT RETURN THIS PRODUCT TO THE PLACE
OF PURCHASE.
If you have any questions regarding this warranty please
call 1-800-835-3278 or TDD 1-316-832-8707 in the United
States or 1-800-387-6161 in Canada.
• Keep lantern area clear and free from combustible materials, gasoline and other flammable
vapors and liquids.
• Do not obstruct the flow of combustion and
ventilation air.
• A proper burn should effectively ignite the entire
mantle with a pure white glow. No carbon or
soot deposits should appear. If your lantern
burns with a yellow smokey flame, check the
burner and air tube for spider webs.
• Wipe lantern clean with soft cloth and mild dish
detergent. Do not use abrasives.
Maintenance
Parts List
English-7
1
3
2
5
Item Part No. Description
1 5010004648 Ventilator Nut
2 5010004649 Ventilator & Bail Handle Assy
3 5010004650 Globe Guard Assy
4 2000030395 Globe
5 5010004651 Heat Shield Assy
6 5010004652 Control Knob Assy
7 5010004653 Leg Assy
8 #95 Size Tube Style Mantle
4
6
7
8
Loading...