Coleman p9945-700, 9945-700 User Manual
IMPORTANT
Read this manual carefully before assembling,
using or servicing this unit. Keep this manual for
future reference. If you have questions about
assembly, operation, servicing or repair, please
call Coleman at 1-800-835-3278 or TDD:
316-832-8707. In Canada call 1-800-387-6161.
For Outdoor use only
®
Assembly and
Instruction Manual
Charcoal Grill
Model 9945-700
U. S. patents pending
Contents
Introduction 2
General Safety Information 2
Assembly 2 - 4
Instructions for Use 4 - 5
Notes 6
Replacement Parts 7
Warranty 8
2
Assembly
DANGER
WARNING
FOLLOW INSTRUCTIONS AND WARNINGS TO
AVOID FIRE, SERIOUS INJURY OR DEATH.
•Outdoor use only. Never use in enclosed area. Use
in unventilated areas can cause death.
•Keep away from all combustible materials including
gasoline and other flammable liquids and vapors.
• Read & follow all warnings on charcoal package.
• Use on a level, noncombustible surface only. Keep
away from house, garage, balconies, or eave overhangs.
• Keep out of the reach of children.
•Exercise the same care you would with an open fire.
• Never leave unit unattended when hot or in use.
•Completely extinguish fire before leaving.
• Use gloves when handling or moving. Ashes can remain
warm for a long time after extinguishing.
• Dispose of cold ashes properly.
• Do not modify in any way or use with parts not expressly
approved by Coleman.
Contact local authorities regarding possible burn
restrictions before using product.
Combustion by-products produced when using this product contain
chemicals known to the State of California to cause cancer, birth defects,
or other reproductive harm.
Follow these instructions for assembly and read carefully,
particularly the safety statements. The safety alert symbol,
is a universally recognized symbol used to identify safety
information about hazards that can result in personal injury.
When this symbol is used you should pay very close attention
to what is written. Review these instructions before beginning
assembly or using your grill.
Introduction
• BURN HAZARD
• Unit is hot when being used. Use care when servicing.
• Keep out of reach of children.
WARNING
General Safety Information
For use only with charcoal.
LEFT LEG ASSEMBLY
■ Align Left Leg with Bracket
and attach as shown.
Left Leg
Base
L-1
L-3
L-4
L-5
NOTE: After Left Leg is assembled the Leg should have slight
resistance in movement.
■ Hand tighten Nut. (Step 2)
■ Repeat for other side.
■ Tighten bolts and nuts. (Step 3)
L-2
Step 1a
Step 2
Step 3
Left Leg Assembled
Bracket
See Blister Pack for
hardware identification.
Step 1
3
Assembly
(cont)
HANDLE ASSEMBLY
■ Place Lid upside
down on a nonabrasive surface to
protect the finish and
attach as shown.
(Step 8)
Lid
H-2
H-3
H-1
Handle
LID ASSEMBLY
■ Place Lid on Base.
■ Align holes in Top Hinges
with holes in Bottom
Hinges then secure with
Bolt Hardware as shown.
(Step 8)
RIGHT LEG ASSEMBLY
■ Tap one L-7 onto Wheel Axle. (Step 4)
Wheel
Axle
L-6
Wheel
Axle
L-6
Wheel
A-1
Clip
NOTE: Clip orientation is important. See Detail 5b.
Clip
Clip
A-1
■ Align Right Leg with Bracket and repeat Steps 1, 2, and 3.
NOTE: After Right Leg is assembled the Leg should have slight
resistance in movement.
HH-1
HH-2
HH-3
Step 4
Step 5
Detail 5a
Right Leg Assembled
Step 7
Step 8
Step 9
Step 8
■ Install Axle and hardware as shown. (Step 5)
See Blister Pack for hardware identification.
Step 6
Be careful not to overtighten.
CHARCOAL GRATE ASSEMBLY
■ Place Charcoal Grate in Base and rotate allowing Lever to slide
through opening in Base as shown.
Step 8a
See Blister Pack for
hardware identification.
See Blister Pack for hardware identification.
See Blister Pack for
hardware identification.
Detail 5b
Lever
Loading...