Coleman 5461 SERIES, 9966 Series Instructions For Use Manual

IMPORTANT

Read these instructions for use carefully. Familiarise yourself with the
appliance before connecting it to a gas cylinder. Keep these instructions
for future reference. This instruction manual contains important information
necessary for the proper assembly and safe use of the appliance. Follow all
warnings and instructions when using the appliance. If you have questions
about assembly, operation, servicing or repair of this product, please call
Coleman on 1800 224 350. Coleman Brands Pty Ltd. Suite W2C1, 75-85
O’Riordan St, Alexandria, NSW 2015.

Gas cylinders shall be changed in a well-ventilated location, preferably
outside away from people and any sources of ignition, such as naked
ames, pilot ames, electric heaters / equipment. If there is a leak on
your appliance (smell of gas) and you cannot stop the gas ow, remove
the appliance to a well-ventilated location away from any ignition source.
Check for leaks using soapy water. Do not try to detect leaks using a
ame. This appliance must only be serviced by an authorised person. Gas
cylinders must be stored outdoors in a well ventilated area out of the reach
of children, any indoor storage shall comply with AS/NZS 1596.

This appliance shall only be used with Propane LPG Coleman disposable
gas cylinders certied to DOT-39 NRC 232/290 M1110. OR rellable
Propane LPG cylinder certied to AS2030 & Coleman hose assembly.
IT MAY BE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPES OF GAS
CONTAINERS.

CAUTION: accessible parts may be very hot. Keep young children away,
USE OUTDOORS ONLY. Must only be operated on a horizontal surface.
Not suitable for marine environments. Do not modify this appliance.

Note: Propane tank is not included. Griddle is optional.

Propane Stoves
Instructions for use

© 2014 The Coleman Company, Inc
colemanaustralia.com.au

INSTASTART™ Electronic Ignition

Standard Ignition

5461 Series

* Model may vary from

picture.

1

If you smell gas:

1. Do not attempt to
light appliance.

2. Extinguish any
open flame.

3. Disconnect from
fuel supply.

FOR YOUR

SAFETY

Do not store or
use gasoline or
other liquids with
flammable vapors in
the vicinity of this or
any other appliance.

FOR YOUR

SAFETY

DANGER indicates an imminently
hazardous situation which, if not
avoided, will result in death or
serious injury.

DANGER

WARNING indicates a potentially
hazardous situation which, if not
avoided, could result in death or
serious injury.

WARNING

CAUTION indicates a potentially
hazardous situation which, if
not avoided, may result in minor
or moderate personal injury, or
property damage.

CAUTION

CARBON MONOXIDE

HAZARD

•ONLY USE IN WELL­VENTILATED AREAS.

•CARBON
MONOXIDE
HAZARD—USING
THIS APPLIANCE
IN AN ENCLOSED
SPACE MAY CAUSE
DEATH.

•DO NOT USE IN
CARAVANS, TENTS,
MARINE CRAFT,
CARS, MOBILE
HOMES OR SIMILAR
LOCATIONS.

DANGER

This manual contains important
information about the assembly, operation
and maintenance of this outdoor propane
appliance. General safety information is
presented on this page and is also located
throughout these instructions. Particular
attention should be paid to information
accompanied by the safety alert symbol
“

DANGER”, “ WARNING”,

“

CAUTION”.

Keep this manual for future reference and
to educate new users of this product. This
manual should be read in conjunction with
the labeling on the product.

Safety precautions are essential
when any mechanical or propane fueled
equipment is involved. These precautions
are necessary when using, storing, and
servicing. Using this equipment with the
respect and caution demanded will reduce
the possibilities of personal injury or
property damage.

The following symbols shown
below are used extensively throughout
these instructions. Always heed these
precautions, as they are essential when
using any mechanical or propane
fueled equipment.

2

CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and by products

of combustion of this fuel, contain
chemicals known to the state of
California to cause cancer, birth defects,
or other reproductive harm.

• Failure to comply with the
precautions and instructions
provided with these stoves can
result in death, serious bodily
injury and property loss or damage
from hazards of fire, explosion,
burn, asphyxiation, and/or carbon
monoxide poisoning.

• Only persons who can understand
and follow the instructions should
use or service these stoves.

• If you need assistance or information
such as an instruction manual
or labels, contact The Coleman
Company, Inc.

DANGER

• This product is fueled by propane
gas. Propane gas is invisible,
odorless, and flammable. An odorant
is normally added to help detect
leaks and can be described as a
“rotten egg” smell. The odorant can
fade over time so leaking gas is not
always detectable by smell alone.

• Propane gas is heavier than air and
leaking propane will sink to the
lowest level possible. It can ignite by
ignition sources including matches,
lighters, sparks or open flames of
any kind many feet away from the
original leak. Use only propane gas
set up for vapor withdrawal.

• Propane gas should be stored
or used in compliance with local
ordinances and codes or with ANSI/
NFPA 58. Turn off propane when not
in use.

WARNING

EXPLOSION - FIRE HAZARD

• Never store propane near high heat,
open flames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed
120 ºF (49 °C).

• Propane is heavier than air and can
accumulate in low places. If you
smell gas, leave the
area immediately.

• Never install or remove propane
tank while outdoor stove is lighted,
near flame, pilot lights, other ignition
sources or while outdoor stove is hot
to touch.

• During lighting and operation, this
product can be a source of ignition.
Never use the stove in spaces that
contain or may contain volatile or
airborne combustibles, or products
such as gasoline, solvents, paint
thinner, dust particles or
unknown chemicals.

• Minimum clearances from
combustible materials: 12 inches
from the sides and 48 inches from
the top.

• Provide adequate clearances around
air openings into the
combustion chamber.

DANGER

CARBON MONOXIDE HAZARD

• This stove is a combustion
appliance. All combustion appliances
produce carbon monoxide (CO)
during the combustion process.
This product is designed to produce
extremely minute, non-hazardous
amounts of CO if used and
maintained in accordance with all
warnings and instructions. Do not
block air flow into or out of the stove.

• Carbon Monoxide (CO) poisoning
produces flu-like symptoms, watery
eyes, headaches, dizziness, fatigue
and possibly death. You can’t see it
and you can’t smell it. It’s an invisible
killer. If these symptoms are present
during operation of this product get

fresh air immediately!

• For outdoor use only.

• Never use inside house, camper,

tent, vehicle or other unventilated
or enclosed areas. This stove
consumes air (oxygen) and
produces carbon monoxide
(CO). Do not use in unventilated
or enclosed areas to avoid
endangering your life.

DANGER

3

SERVICE SAFETY

• Keep all connections and fittings
clean. Inspect propane cylinder
and stove propane connections for
damage before attaching.

• During set up, check all connections
and fittings for leaks using soapy
water. Never use a flame. Bubbles
indicate a leak. Check that the
connection is not cross-threaded
and that it is tight. Perform another
leak check. If there is still a leak,
remove the cylinder and contact
Coleman for service or repairs.

• Use as a cooking appliance only.
Never alter in any way or use with
any device or part not expressly
approved by Coleman.

• Clean stove and stove griddle (if
equipped) frequently to avoid grease
accumulation and possible grease fires.

CAUTION

BURN HAZARD

• Never leave stove unattended when
hot or in use.

• Keep out of reach of children.

WARNING

CARBON MONOXIDE HAZARD

• For outdoor use only.

• Never use inside house, camper,

tent, vehicle or other unventilated
or enclosed areas. This stove
consumes air (oxygen) and produces
carbon monoxide (CO). Do not use
in unventilated or enclosed areas to
avoid endangering your life.

DANGER

Technical
Characteristics

To Set Up

Not for home or

recreational vehicle use.

We cannot foresee every use which
may be made of our products. Check

with your local fire safety authority
if you have questions about use.

Other standards govern the use of fuel
gases and heat producing products
for specific uses. Your local authorities
can advise you about these.

• Never refill disposable cylinders.

• Use the preset regulator that came

with the stove. Do not attempt
to adjust.

• Use only Coleman

®

accessories or
parts. During stove set-up, check all
fittings for leaks using soapy water.
Never use a flame.

WARNING

NOTE: Use Coleman® 16.4 oz.
disposable propane cylinders. The
LP-gas cylinder(s) used with stoves
must be constructed and marked in
accordance with the specications for
LP-gas cylinders of the U.S. Department
of Transportation or Transport Canada,
CAN/CSA B339.

 Open lid. (Fig. 2)  Position wind

guards as desired.
(Fig. 3)

 Remove components from carton.

(Fig. 1)

Input: 11.6 MJ/h per burner
Category: Pressure regulated propane
Fuel: 16.4 oz. disposable propane cylinders
Regulator: 5430
Injector size: 0.40mm

Fig. 3

Fig. 1

Fig. 2

 Install pot

support as
shown. (Fig. 4)

Fig. 4

Pot Support

Regulator

Hose

Griddle

(optional)

 Place griddle on

pot support, if

equipped. (Fig. 5)
NOTE: The griddle is
optional.

Fig. 5