Coleman 533 User Manual

Download

Dual-FuelTMStove Instructions for use

533 Series

CSA B140.9.2-2008 Proposed

Portable Pressurized Type Liquid

Petroleum Fuelled Camp Stoves

Sportster®II Dual-Fuel

™

Stove

English

IMPORTANT

CONSUMER/USER:This instr uction manual contains important information necessar y for the proper assembly and safe use of the appliance. Read and follow all warnings and instructions before assembling and using the appliance. Follow all warnings and instructions when using the appliance. Keep this manual for future reference.

If you have questions about assembly, operation, servicing or repair of this appliance, please call Coleman at 1-800-835-3278 or TDD:316-832-8707.In Canada call 1-800-387-6161.

English-1

WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

DANGER

DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

This manual contains important information about the assembly, operation and maintenance of this outdoor liquid fueled appliance. General safety information is presented on this page and is also located throughout these instructions. Particular attention should be paid to information accompanied by the safety alert symbol “ DANGER”, “ WARNING”, “ CAUTION”.

Keep this manual for future reference and to educate new users of this product.This manual should be read in conjunction with the labeling on the product.

Safety precautions are essential when any Coleman® fueled equipment is involved. These precautions are necessary when using, storing, and servicing. Using this equipment with the respect and caution demanded will reduce the possibilities of personal injury or property damage.

The following symbols shown below are used extensively throughout these instructions.Always heed these precautions, as they are essential when using any Coleman® fueled equipment.

CAUTION

CAUTION indicates a potentially hazardous

situation which, if not avoided, may result in

minor or moderate personal injury, or

property damage.

Failure to comply with the precautions and

instructions provided with these stoves can

result in death, serious bodily injury and proper-

ty loss or damage from hazards of fire, explo-

sion, burn, asphyxiation, and/or carbon

monoxide poisoning.

Only persons who can understand and follow

the instructions should use or service

these stoves.

If you need assistance or information such

as an instruction manual or labels, contact

The Coleman Company, Inc.

CALIFORNIA PROPOSITION 65:

WARNING:This fuel, and byproducts of com-

bustion of this fuel, contain chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm.

DANGER

Do not store or use gasoline or other liquids with flammable vapors in the vicinity of this or any other appliance.

FOR YOUR

SAFETY

CARBON MONOXIDE

HAZARD

• This appliance can produce carbon monoxide which has no odor.

• Using it in an enclosed space can kill you.

• Never use this appliance in an enclosed space such as a camper ,tent, car or home.

DANGER

WARNING

English-2

WARNING

DANGER

• EXPLOSION - FIRE HAZARD

• During lighting and operation, this product can be a source of ignition. Never use the stove in spaces that contain or may contain volatile or airborne combustibles, or products such as gasoline, solvents, paint thinner, dust particles or unknown chemicals. Minimum clearances from combustible materials: 24 inches from the sides and 48 inches from the top.

• Provide adequate clearances around air openings into the combustion chamber.

WARNING

Not for home or recreational vehicle use.

We cannot foresee every use which may be made of our products.

Check with your local fire safety authority if you have questions about use.

Other standards govern the use of fuel and heat producing products for specific uses. Your local authorities can advise you about these.

• Use only Coleman

accessories or parts.

• During stove set-up, check all fittings for

leaks using soapy water.Never use a flame.

WARNING

• BURN HAZARD

• Never leave stove unattended when hot or in use.

• Keep out of reach of children.

This multi-fuel appliance may be fueled by Coleman®Liquid Fuel or unleaded gasoline.

• Never use kerosene or leaded automotive fuel.

• Store fuel in a clean, properly marked container away from flame (including pilot lights), other sources of ignition, or excessive heat.

DANGER

• EXPLOSION - FIRE HAZARD

• Coleman® fuel and gasoline are extremely flammable; handle with care. Fuel vapors are invisible, explosive, and can be ignited by ignition sources may feet away.

• Always fill outdoors.

• Never open a pressurized Coleman® fuel tank or fill fuel tank near flame (including pilot lights), or other ignition sources. It is normal for a pressurized fuel tank to vent a small amount of fuel mist when unscrewing the fuel cap.Be sure stove has no flame before unscrewing the fuel cap.

DANGER

• CARBON MONOXIDE HAZARD

• This stove is a combustion appliance. All combustion appliances produce carbon monoxide (CO) during the combustion process.This product is designed to produce extremely minute, non-hazardous amounts of CO if used and maintained in accordance with all warnings and instructions. Do not block air flow into or out of the stove.

• Carbon Monoxide (CO) poisoning produces flu-like symptoms, watery eyes, headaches, dizziness, fatigue and possibly death.You can’t see it and you can’t smell it. It’s an invisible killer.If these symptoms are present during operation of this product get fresh

air immediately!

• For outdoor use only.

• Never use inside house, camper, tent, vehi-

cle or other unventilated or enclosed areas.This stove consumes air (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life.

CAUTION

• SERVICE SAFETY

• Keep all connections and fittings clean. Inspect fuel cap for dirt or damage after refilling the fuel tank.Wipe up any spilled fuel and dispose of in a safe place.

• Use as a cooking appliance only.Never alter in any way or use with any device or part not expressly approved by Coleman.

• Clean stove frequently to avoid grease accumulation and possible grease fires.

• Check all connections for leaks.Liquid

Coleman® fuel present at connections indicates a leak.

1. Coleman®Fuel is extremely

flammable, handle with extreme care. Fuel vapors are invisible, explosive, and can be ignited by ignition sources many feet away.

2. Always fill outdoors.Never open or fill fuel tank near flame (including pilot lights), or other ignition sources. It is normal for a pressurized fuel tank to vent a small amount of fuel mist when unscrewing the fuel cap.

3. Always light and use stove outdoors; never inside house, camper, tent, or other unventilated or enclosed areas.

4. This stove consumes air (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life.

5. This stove is designed to use

Coleman

Fuel or unleaded

gasoline.

6. Store fuel in a clean, properly marked container away from flame (including pilot lights), other sources of ignition, or excessive heat.

7. Use for cooking only.Never alter in any way or use with any device or part not expressly approved by Coleman. Never use as a space heater.Never leave stove unattended while burning.

8. Keep stove away from flammables.Never allow fabric, clothing, or any flammable material come within 48 inches of the top and 24 inches of all sides of the stove.

9. When stove is in use, all metal parts of the stove assembly and generator become extremely hot. DO NOT TOUCH.

10. Never place heavy or large capacity utensils on stove.

11. Keep out of reach of children.

WARNING

English-3

Technical

Characteristics

Input: 10,500 BTU/HR Coleman®fuel

or unleaded gasoline.

Category: Direct pressure

multi-fuel stove

Fuel:

Coleman®fuel

unleaded gasoline

To Set Up

DANGER

• CARBON MONOXIDE HAZARD

• For outdoor use only.

• Never use inside house, camper, tent, vehicle or other unventilated or enclosed areas.This lantern consumes air (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life.

Thank you for purchasing your new Coleman®multi-fuel stove.We recommend operating your new stove in a safe location outside your home to familiarize yourself with its multi-fuel operation before your next outdoor experience.

Helpful Hints

• Liquid Coleman®fuel is recommended when using the stove in temperatures below 40° F or in high elevation.

• For best results, always use Coleman

Filter/Funnel Part No.5103A700T.

• If necessary, unleaded gasoline may be substituted for liquid Coleman®fuel.

• Do not use kerosene in this stove.

Filling the tank

Always fill outdoors.Never fill tank, loosen or remove fuel cap near flame (including pilot lights), or other ignition sources.

■ With stove on level surface, move red

fuel lever to off position.(Fig. 1)

Fig. 1

English-4

■ Close PUMP KNOB firmly.(Fig. 2)

Leak Check

• Perform leak test outdoors.

• Extinguish all open flames.

• NEVER leak test when smoking.

• Do not use the outdoor stove until connection

has been leak tested and does not leak.

WARNING

Fig. 2

■ Remove FUEL CAP. Using a funnel or suitable filling device, fill with clean, fresh fuel (Fig. 3). Do not tip stove.

■ Replace FUEL CAP on fuel container.

Tighten firmly.Move fuel container away from stove.WIPE UP ANY SPILLED FUEL AND DISPOSE OF IN A SAFE PLACE.

Fig. 3

Pumping

Be sure RED FUEL LEVER is in off position. (Fig. 4)

■ Open PUMP KNOB one full turn.

(Fig. 5)

Fig. 4 Fig. 5

■ With thumb over hole in PUMP KNOB, pump approximately 30 full strokes.(Fig. 6)

■ Close PUMP KNOB. (Fig. 7)

Fig. 6

Fig. 7

WARNING

• BURN HAZARD

• Never leave stove unattended when hot or in use.

• Keep out of reach of children.

To Light

■ Make sure FUEL VALVE is fully “OFF”.

■ CHECK FOR LEAKS in one or more

ways.Look for fuel mist or a wet appearance of fuel on surfaces.Listen for hiss of escaping gas.Smell for fuel odor.Never use a flame. Do not use if leaking. (Fig. 8)

CHECK

FOR

LEAKS

CHECK

FOR

LEAKS

CHECK FOR

LEAKS

Fig. 8

English-5

■ Close PUMP KNOB. (Fig. 12)

To Turn Off

Fig. 12

Fig. 14

■ CAUTION: If fuel or flames appear below BURNER, immediately turn RED FUEL LEVER off. Allow stove to cool.Turn stove upside down to empty any fuel accumulated in burner and wipe dry.Review instructions then relight stove.

■ Adjust flame to desired heat with RED FUEL LEVER. (Fig. 13)

Fig. 13

For temperatures below freezing

■ Note: In temperatures below freezing preheating paste may be required. Place a generous amount of PREHEATING PASTE on BURNER CAP beneath the GENERATOR.(Fig. 15)

■ Additional pumping may be required for full heat output (Fig. 14)

■ Light the paste (Fig. 16). After the paste is almost consumed, follow the previous lighting instructions.

Fig. 15

Fig. 16

Fig. 17

■ Move RED FUEL VALVE from off to

high” several times.(Fig. 17)

NEVER FILL OR LIGHT STOVE INSIDE HOUSE, CAMPER, OR TENT

■ Hold lit match at BURNER, then turn RED FUEL LEVER to high (LIGHT) position. (Fig. 9)

Fig. 9

■ When burner lights, open PUMP KNOB one tur n (Fig. 10) and pump for 30 full strokes (Fig. 11).

Fig. 11Fig. 10

English-6

WARNING

• Always turn fuel valve off before unscrewing fuel cap from fuel tank. Never remove fuel cap near ignition sources, while stove is lit, or hot to touch.

■ Be sure flame is extinguished. Flame will linger on burner for 1-2 minutes after fuel valve is “OFF”.

To Store

■ Make sure stove is cool.

■ Move stove away from flame (includ-

ing pilot lights) and other ignition sources.

• MAINTENANCE

• Keep stove area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

• Do not obstruct the flow of combustion and ventilation air.

• A good flame should be blue with minimal yellow tip.Some yellow tips on flames are acceptable as long as no carbon or soot deposits appear.

• Wipe clean with soft cloth and mild dish detergent. Do not use abrasives.

Fig. 18

■ Latch Red FUEL VALVE in off position. (Fig. 18)

English-7

Troubleshooting

Symptom

Burner will not light or flame selfextinguished.

Burner will not light or flame is low or flame selfextinguished.

Burner selfextinguishes during one minute warm-up.

Yellow flame.

Low heat.

Persistent small yellow flame.

Persistent high yellow flame.

Yellow smokey flame.

Pump does not pressurize the liquid fuel canister.

Intermittent yellow flame after extended use on low heat setting.

Problem

Fuel tank empty.

Little or no pressure in fuel tank.

Generator is not fully warmed up.

Excess fuel in burner.

Generator tip plugged.

Faulty generator.

Failure in the fuel delivery system.

Spider webs, insects, or other obstruction in the burner and air tube.

Pump seals are dry or worn.

Flame requires adjustment.

Solution

Refill fuel tank with clean and fresh Coleman®fuel or unleaded fuel.

Check that fuel cap is tight and pump 30 strokes.

In temperatures below freezing preheating paste may be required. Place a generous amount of preheating paste on burner cap beneath the generator.

A yellow flame is normal until the generator warms up.If yellow flame persists, turn off stove, allow flame to self-extinguish and the stove to cool.If necessary, invert stove to remove excess liquid fuel from the burner.Follow lighting instructions.

Turn red fuel lever back and forth several times to clean generator tip.Be sure to use only fresh and clean fuel.

Replace with a new generator. This is a normal periodic maintenance procedure.The generator life is dependent on the type of fuel used. Generator life is extended by using clean Coleman

fuel.

Replace with a new generator.

May need to replace pump assembly. Please contact Consumer Service (see page 9).

Remove burner to inspect and clean the burner and air tube.

Squirt a few drops of oil in the OIL HOLE in the pump cap.This will keep the pump functioning properly (Fig. 19). If this does not correct the problem, replace the pump seals or purchase a new pump assembly.

Adjust the flame to a slightly higher level with the red fuel lever.

English-8

Replacement Parts List

No. Part No. Description

1 220C1401 Fuel Cap 2 220A6201 Pump Repair Kit 3 533-5891 Generator 4 508A5571 Valve Assembly 5 400-3451 Bur ner Ring Set 6 413C3021 Burner Bowl 7 400-5401 Grate 8 639-1091 Pump Cup & Nut

9 400-5261 Burner Box Assembly 10 400A1261 Generator Bracket 11 400-0601 Screw Pkg. (6) 12 200-6381 Check Valve & Stem Assy. 13 400B5151 Valve Stem Assy.

11 9

English-9

Warranty

Limited Five Year Warranty

The Coleman Company, Inc. (“Coleman”) warrants that for a period of five years from the date of original retail purchase, this product will be free from defects in material and workmanship. Coleman, at its option, will repair or replace this product or any component of the product found to be defective during the warranty period.Replacement will be made with a new or remanufactured product or component. If the product is no longer available, replacement may be made with a similar product of equal or greater value. This is your exclusive warranty.

This warranty is valid for the original retail purchaser from the date of initial retail purchase and is not transferable.Keep the original sales receipt. Proof of purchase is required to obtain warranty performance.Coleman dealers, service centers, or retail stores selling Coleman

products do not have the right to alter, modify or in any way change the ter ms and conditions of this warranty.

What This Warranty Does Not Cover

This warranty does not cover normal wear of parts, parts

that are not genuine Coleman

parts, or damage resulting from any of the following:negligent use or misuse of the product; use on improper voltage or current; commercial use of the product; use contrary to the operating instructions; disassembly, repair or alteration by anyone other than Coleman or an authorized service center. Further, the warranty does not cover Acts of God, such as fire, flood, hurricanes and tornadoes. Warranty void if damage to product results from the use of a part other than a genuine Coleman

part.

COLEMAN SHALL NOT BE LIABLE FOR DEFECTS THAT ARE CAUSED BY THE USE OF UNAUTHORIZED PARTS OR SERVICE.COLEMAN SHALL NOT BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY THE BREACH OF ANY EXPRESS OR IMPLIED WARRANTY OR CONDITIONS. EXCEPT TO THE EXTENT PROHIBITED BY APPLICABLE LAW, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN DURA TION T O THE DURATION OF THE ABOVE WARRANTY OR CONDITIONS.SOME STATES, PROVINCES, OR JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE OR PROVINCE TO PROVINCE.

How to Obtain Warranty Ser vice

Take the product to an authorized Coleman service center. You can find the nearest author ized Coleman service center by visiting www.coleman.com or calling 1-800-835-3278 or TDD 316-832-8707 in the United States or 1 800 387-6161 in Canada. If a service center is not conveniently located, attach to the product a tag that includes your name, address, daytime telephone number and description of the problem. Include a copy of the original sales receipt. Carefully package the product and send either by courier or insured mail with shipping and insurance prepaid to:

For products purchased in the United States:

The Coleman Company, Inc. 3600 North Hydraulic Wichita, KS 67219

For products purchased in Canada:

Sunbeam Corporation (Canada) Limited DBA Jarden Consumer Solutions 20B Hereford Street Brampton, ON L6Y 0M1

The costs of transporting the product to Coleman or an authorized service center for warranty service is the responsibility of the purchaser.

Do not mail products with fuel in tanks, or with disposable LPG canisters. Remove glass globes from lanterns and wrap separately.

DO NOT RETURN THIS PRODUCT TO THE PLACE OF PURCHASE.

If you have any questions regarding this warranty please call 1-800-835-3278 or TDD 316-832-8707 in the United States or 1 800 387-6161 in Canada.

Things You Should Know

1. Preheating paste is available at most stores that sell backpacking equipment.

2. Rinse tank twice a year with fresh fuel to remove sediment, gum formations, and moisture accumulations.

3. Seasonally or before storage, squirt a few drops of oil into the OIL HOLE in the pump cap.This will keep the pump functioning properly.(Fig. 19)

4.The red fuel lever moves a small needle in and out of the generator gas tip.If stove is hard to light or does not produce full heat output, turn red fuel lever back and forth several times to clean generator.

5. Unleaded fuels may vary in quality and can affect generator life and performance. If you are having a problem with your stove or generator using unleaded fuel, replace the generator and try a different brand of unleaded fuel.

6.The usual storage areas for camping and picnic equipment are the basement, attic, or garage.To avoid the accumulation of dust, cobwebs, etc., that is common in these areas, place your stove in a plastic bag and seal it with a rubber band.

7. For repair service call one of the numbers listed below for location of your nearest Coleman Service Center. If stove must be mailed to a Service Center, attach to the product a tag that includes your name, address, daytime telephone number and a description of problem. Do NOT send LPG canister.Carefully package the product and send either by courier or insured mail with shipping and insurance prepaid to:

For products purchased in the United States:

The Coleman Company, Inc.

3600 N. Hydraulic • Wichita, KS 67219 U.S.A.

1-800-835-3278 • TDD:316-832-8707

For products purchased in Canada:

Sunbeam Corporation (Canada) Limited

DBA Jarden Consumer Solutions

20B Hereford Street

Brampton, ON L6Y 0M1

1-800-387-6161

8. If not completely satisfied with the

performance of this product, please call one of the numbers listed above.

OIL HOLE

Fig. 19

English-10

Notes:

4010003165 (20080310)

The Coleman Company, Inc. • 3600 Nor th Hydraulic • Wichita, KS 67219 U.S.A.

1-800-835-3278 • TDD:316-832-8707

Sunbeam Corporation (Canada) Limited • DBA Jarden Consumer Solutions

20B Hereford Street

Brampton, ON L6Y 0M1 • 1 800 387-6161

are registered trademarks and Dual Fuel™ is a trademark of The Coleman Company, Inc.

sont des marques déposées

alors que

Dual Fuel™

est une marque de commerce de

The Coleman Company, Inc.

son marcas registradas

Dual Fuel™

es una marca de la compañía

The Coleman Company, Inc.

www.coleman.com

Coleman 533 User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual