Coleman 2300 User Manual
Instructions for Use
IMPORTANT
Read this manual carefully before assembling, using or servicing this product. Keep this manual for future reference. If you have questions about assembly, operation, servicing or repair,
please call Coleman at 1-800-835-3278 or TDD: 316-832-8707.
Outdoor use only
United States Patent D486,896 and 6,877,461
MODEL #2300 Series
CSA Requirement 3.03-US
Portable Water Heater For Outdoor Use
®
Contents
General Safety Information 2-3
System Overview 3
Before You Go 4
To Set Up 4-6
Use and Operation 6-7
Helpful Hints 8
Storage 8
This manual contains important information about the assembly, operation
and maintenance of this water heater. General safety information is presented in these first few pages and is also located throughout the manual.
Particular attention should be paid to information accompanied by the safety
alert symbol “ DANGER”, “ WARNING”, “ CAUTION”.
Keep this manual for future reference and to educate new users of this
product. This manual should be read in conjunction with the labeling on the
product.
Safety precautions are essential when any mechanical or propane fueled
equipment is involved. These precautions are necessary when using,
storing, and servicing. Using this equipment with the respect and caution
demanded will reduce the possibilities of personal injury or property
damage.
The symbols shown below are used throughout this manual. Always heed
these precautions, as they are essential when using any mechanical or
propane fueled equipment.
General Safety Information
DANGER
• CARBON MONOXIDE HAZARD
• This appliance can produce carbon monoxide
which has no odor.
• Using it in an enclosed space can kill you.
• Never use this appliance in an enclosed
space such as a camper, tent, car or home.
If you smell gas:
1. Do not attempt to light appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
FOR YOUR SAFETY
General Safety Information
cont.
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open flames, pilot lights, direct
sunlight, other ignition sources or where temperatures exceed 120
degrees F (49°C).
• Propane is heavier than air and can accumulate in low places. If you
smell gas, leave the area immediately.
• Never install or remove propane tank while heater is operating,
near flame, pilot lights, other ignition sources or while heater is hot
to touch.
• During operation, this product can be a source of ignition. Never
use the heater in spaces that contain or may contain volatile or airborne combustibles, or products such as gasoline, solvents, paint
thinner, dust particles or unknown chemicals. Minimum clearances
from combustible materials: 12 inches from the sides & 48 inches
from the top.
• Provide adequate clearances around air openings into the product.
DANGER
DANGER
DANGER indicates an imminently hazardous situation which, if not
avoided, will result in death or serious injury.
WARNING
WARNING indicates a potentially hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION
CAUTION indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate personal injury, or property
damage.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and byproducts of combustion of this fuel, contain
chemicals known to the state of California to cause cancer, birth defects,
or other reproductive harm.
2
Maintenance 8
Troubleshooting Guide 9
Service 9
Replacement Parts 10
Warranty Information 11
Accessories 12
Failure to comply with the precautions and instructions provided with this
product can result in death, serious bodily injury and property loss or damage from hazards of fire, explosion, burn, asphyxiation, and/or carbon
monoxide poisoning.
Only persons who can understand and follow the instructions should use
or service this product.
If you need assistance or information such as an instruction manual or
labels, contact The Coleman Company, Inc.
DANGER
General Safety Information
cont.
SERVICE SAFETY
• Keep all connections and fittings clean. Inspect propane cylinder and
propane connections for damage before attaching.
• During set up, check all connections and fittings for leaks using soapy
water. Never use a flame. Bubbles indicate a leak. Check that the
connection is not cross-threaded and that it is tight. Perform another
leak check. If there is still a leak, remove the cylinder and contact
Coleman for service or repairs.
• Use for water heating only. Never alter in any way or use with any
device or part not expressly approved by Coleman.
• Always use in an upright position.
CAUTION
WARNING
• This product is fueled by propane gas. Propane gas is invisible,
odorless, and flammable. An odorant is normally added to help
detect leaks and can be described as a “rotten egg” smell. The
odorant can fade over time so leaking gas is not always detectable
by smell alone.
• Propane gas is heavier than air and leaking propane will sink to
the lowest level possible. It can ignite by ignition sources including
matches, lighters, sparks or open flames of any kind many feet
away from the original leak. Use only propane gas set up for vapor
withdrawal.
• Propane gas should be stored or used in compliance with local
ordinances and codes or with ANSI/NFPA 58. Turn off propane
when not in use.
• Disconnect propane before storing the heater.
Not for home or recreational vehicle use.
We cannot foresee every use which may be made of our products.
Check with your local fire safety authority if you have questions about use.
Other standards govern the use of fuel gases and heat producing
products for specific uses.Your local authorities can advise you
about these.
• Never refill disposable cylinders.
• Use the preset regulator that is installed in the water heater. Do
not attempt to adjust.
System Overview
Thank you for purchasing Coleman’s Hot Water on DemandTMunit. This portable and self-contained water heater provides hot water for
cleaning, cooking, washing – it even makes water hot enough for a satisfying mug of tea, coffee or cocoa. Here are some of the key
components.
3
• BURN HAZARD
• Never leave heater unattended when hot or in use.
• Keep out of reach of children.
WARNING
Recharging Port –
plug 12V and 110V/120V
Recharger cords
Rotating Faucet – full-sized faucet stores in handle for convenient storage and swings out when not in use.
Over-Temp Indicator Light – when illuminated, the red light is
signaling that the water temperatures have exceeded the maximum temp of 160°F. The burner cycles off but water continues to
run through heater. Burner will cycle on when water has cooled
to 120°F.
Battery Low Indicator Light – when illuminated, the yellow light is
signaling that the battery voltage is low and it is time to recharge.
The burner will not light when the battery is low.
Charging Indicator Light – begins illuminated red, then will
change to green to signal that the battery has been completely
recharged.
Heat Exchanger – evenly and efficiently transfers heat from the
burner to the copper heating coils.
Recharger cord storage compartment – 12V auto recharger
and 110V/120V household recharger cords are stored here
(cords included)
Control knob – push
to turn in a counterclockwise direction.
Adjust knob to desired
water temperature.
Battery compartment –
6 volt rechargeable
lead acid battery is
located in compartment
on opposite side of
heater. Battery
operates the pump
& circuitry and has
a 40-minute run time.
Hose & Pump – for convenient storage, the hose wraps around
the water heater and the pump is secured by the pump clip.
Propane access door –
press latch to open
door to access propane
cylinder (propane not
included)
Regulator – located inside of the propane door. This is where the
propane cylinder is installed.
WARNING
Before You Go
To Set Up
Preparing Hot Water on DemandTMunit for initial use.
• Unpack your new water heater from the carton and make sure that all of the parts are included. If you find that one of the
components is missing, please contact Coleman for a replacement. 1-800-835-3278 or TDD 1-316-832-8707.
5-Gallon Collapsible
Water Carrier
(#809A606T)
12 Volt Auto
Recharger Cord
(Located in storage compartment of your
Hot Water on DemandTMunit)
(#2300-4071)
110V/120 Volt Household
Recharger Cord
(Located in storage compartment of your
Hot Water on DemandTMunit)
(#2300-4081)
• Charge the battery. Plug either 12 Volt Auto Recharger Cord or 110V/120 Volt Household
Recharger Cord into unit and the power source.
• Charging LED should come on. Allow eight hours to fully charge the battery. RED color
indicates a charging battery. A GREEN color indicates a fully charged battery.
• Charge the battery before using your water heater for the first time (Fig. 1).
• Clean before first use. It is strongly recommended that you clean the heater prior to using
for the first time. Follow the simple steps on page 6 before you leave home, and then clean at
least once a year or when the hose becomes discolored with a white calcium build up.
• Select a level, sturdy surface for your water heater. A picnic table or camp table is ideal. Do not operate Hot Water on
DemandTMunit from a position directly on the ground. (This allows water to drain, preventing damage while the unit is off in
freezing temperatures.)
• Fill the 5-gallon collapsible water container with water – use only potable
drinking water
. Never use water from a lake or
stream that has not been purified. Do not run any other liquid through Hot Water on DemandTMunit.
• Unwrap the pump hose
from around the water
heater.
• Place the water carrier
at a level below the
water heater for proper
drainage.
• Screw the water pump
to the opening of the
water container & hand
tighten.
• Lay the water container
on its side so the pump
is towards the bottom
of the container (step 2).
• Make sure to rotate the
pump where “THIS
SIDE UP” is facing
upward so pump will
prime and water will flow.
Step 1: Screw the Pump
onto the opening of the
Water Container and Hand
Tighten.
Step 2: Lay the Water
Container on its side so
the Pump is towards the
bottom of the container.
You can also submerge
The Water Pump into an
open water container
such as a cooler.
(Cooler
not included.)
4
• WATER CONNECTION
Fig. 1
Loading...