CMA Dish Machines UC65e PARTS LIST

CMA Dishmachines 12700 Knott A venue Garden Grove, CA 92841
Toll Free: 1- (800) 854-6417 Fax: 1- (714) 895-2141
Service Re
placement Parts
Undercounter High Temperature Dishwasher
Models:
UC65e
CMA Dishmachines 12700 Knott Avenue Garden Grove, CA 92841 Toll Free: 1 (800) 854-6417 Fax: 1 (714) 895-2141
UC65e
Machine Serial No.
Issue Date: 2.21.14
Manual P/N 0512865 rev. D
For machines beginning with S/N W090217876 and above
Printed in the USA
For future reference, record your dishwasher information in the box below.
Model Number__________________________ Serial Number_______________________
Voltage________________Hertz_____________ Phase__________________
Service Agent __________________________________ Tel:______________________
Parts Distributor _________________________________ Tel:______________________
National Service Department
CMA Dishmachines 12700 Knott Avenue Garden Grove, CA 92841 Toll-free: 1 (800) 854-6417 Fax: 1 (714) 895-2141
ATTENTION:
The model no., serial no., voltage, Hz
and phase are needed to identify your
machine and to answer questions.
The machine data plate is located
on the lower front panel.
Please have this information ready
if you call for service assistance.
COPYRIGHT © 2014 All rights reserved Printed in the USA
Revision History
Revision History
The Revision History can contain part number changes, new instructions, or information that was not available at print time.
We reserve the right to make changes to these instructions without notice and without incurring any liability by making the changes..
Equipment owners may request a revised manual, at no charge, by calling CMA Dishmachines at 1 (800) 854-6417.
Revision Revised Serial Number Revision Date Pages Effectivity Description
6.04.09 All W090217876 Released First Edition
3.15.11 22-23 W090217876 Added motor fan cover to parts list
1.04.11 31 W090217876 Item 5 changed to P/N 0513110 33 Item 6 changed to P/N 0512120 Item 18 changed to P/N 0312840 35 Item 13 changed to P/N 0512855
6.09.11 44-45 W090217876 Item 13 changed to P/N 0312924 46-47 W090217876 Changed door assembly to P/N 0713141
4.19.13 5 All Added hose barb to instructions 24-55 W120631743 Revised pressure gauge piping 26-27 W120631743 Added P/N 109069 thermostat
All Revisedll/draintimer,P/N0713133
30-31 W120631743 Revised pressure gauge piping 34-35 All Added hose barb P/N 0512231 46-47 All AddedDoordripseals,P/N0512953 and P/N 0512954 53-62 All Added parts installation instructions
6.25.13 2-3 All Added hard wiring info to installation
11.18.13 All All Converted 0xxxxxx P/N's to CMA standards
i
Model Description
Model Description
UC65e
High temperature hot water sanitizing dishwasher with built-in 40°F/22°C rise booster heater. 208-240VAC/60/1
ii
Table of Contents
Table of Contents
Model UC65e Undercounter Dishwasher
Revision History...................................................................................................................i
Model Descriptions ..............................................................................................................ii
Service Replacement Parts .......................................................................1
iii
Blank Page
This Page
Intentionally
Left Blank
iv
Service Replacement Parts
Service Replacement Parts
Illustrations Page
Wash Pump/Motor Assembly ................................................................................................................................ 2
Booster Assembly ................................................................................................................................................... 4
Electrical Panel and Timer Assembly ..................................................................................................................... 6
Control Panel Assembly ......................................................................................................................................... 8
Upper Final Rinse Piping Assembly ....................................................................................................................... 10
Wash and Rinse Spray Arm Assemblies ................................................................................................................ 12
Drain Pump and Lower Hose Assemblies .............................................................................................................. 14
Wash Tank Heater and Drain Assemblies .............................................................................................................. 16
Fill Solenoid Valve Assembly .................................................................................................................................. 18
Detergent Pump Assembly ..................................................................................................................................... 20
Rinse-aid Pump Assembly...................................................................................................................................... 22
Panel Assembly ...................................................................................................................................................... 24
Door Assembly ....................................................................................................................................................... 26
Dish racks, Line Strainer and Pressure Regulating Vavle (PRV) ........................................................................... 28
1
Wash Pump/Motor Assembly
11
10
7
5
4
3
2
1
6
12
13
9
8
2
Item Part Description Qty. No. No.
Wash Pump/Motor Assembly
1 2103.01 SCREW, M4, PHIL, PAN HD. 9
2 2103.02 IMPELLER HOUSING COVER 1
3 2103.03 NUT, M6 (left-hand threads) 1
4 2103.04 WASHER, LOCK, 1/4" 1
5 2103.05 WASHER, PLAIN, M6 1
6 2103.06 IMPELLER 1
7 2103.07 SEAL 1
8 2103.30 GASKET, PUMP 1
9 2103.09 BACKPLATE, PUMP 1
10 2103.08 NUT, M4 9
11 2103.10 PUMP/MOTOR ASSEMBLY COMPLETE 1 220VAC/60/1
12 2103.37 COVER, REAR MOTOR FAN 1
13 2103.11 CAPACITOR 16μF 1
3
Booster Assembly
From
Fill
Valve
To
Final
10
Rinse
21
6
11
6
19
18
20
6
10
6
13
12
7
6
11
6
10
6
14
9
8
15
5
17
16
4
3
2
1
4
Item Part Description Qty. No. No.
Booster Assembly
1 2103.12 HEATER, BOOSTER 4kW, 208V, 40°F RISE 1
(Does not include gasket)
1 2103.13 HEATER, BOOSTER 6kW, 208V, 70°F RISE 1
(Does not include gasket)
2 2103.14 GASKET, BOOSTER HEATER 1
3 2103.15 THERMOSTAT, CONTROL 195°F 1
(Prior to S/N W120631743)
4 2103.36 THERMOSTAT, CONTROL 110-195°F 1
(Beginning with S/N W120631743)
5 2103.16 BOLT, HEX FLANGE, 1/4-20 X 3/8" SST 1
6 2103.38 CLAMP, 29/32" x 1/2" WIDE SST 6
7 2103.22 HOSE, BOOSTER FILL 1
8 2103.19 THERMOSTAT, HI-LIMIT FIXED SNAP 240°F 1
9 2103.20 TANK, BOOSTER (All S/N's) 1 (Includes Item 14)
10 2103.22 HOSE, 1/2" ID A/R
11 2103.23 TEE, RINSE 2
12 2103.24 FITTING, BOOSTER THERMOMETER 1
13 0302.00 THERMOMETER, 2" DIAL, 7' CAPILLARY 1
14 2103.26 PLUG, 1/8" SST 1
15 2103.27 NUT, GRIP 6-32 W/NYLON INSERT 2
16 2103.28 FITTING, BOOSTER THERMOSTAT 1
(Use with Item 3, Prior to S/N W120631743))
17 2103.61 FITTING, BOOSTER THERMOSTAT 1
(Use with Item 3, Beginning with S/N W120631743))
18 2103.62 FITTING, COMP. 1/4" OD X 1/8" MPT ELL J 1
19 13604.10 BUSHING, REDUCER 1/2" X 1/8" 1
20 2103.74 TUBING, 1/4" NATURAL 2 FT.
21 40014.00 COUPLER, 1/2" HOSE X 1/2" FNPT BRASS 1
5
Electrical Panel and Timer Assembly
11
3
2
1
6
4
WASH
RINSE
TEMPERATURE
5
BOOSTER
8
ON
OFF
FILL
10
9
7
11
12
15
11
13
Item 10, Timer Assembly includes: Items 12 and 13
20
19
18
11
11
16
11
17
14
6
Item Part Description Qty. No. No.
Electrical Panel and Timer Assembly
1 2103.29 THERMOSTAT, WASH TANK 1
2 2103.15 THERMOSTAT, CONTROL 195°F 1
(Prior to S/N W120631743)
3 2103.36 THERMOSTAT, CONTROL 110-195°F 1
(Beginning with S/N W120631743)
4 2103.63 BRACKET, THERMOSTAT 1
(Use with Item 3 only)
5 2103.31 SWITCH, 3-POSITION, TOGGLE 1
6 2103.34 SCREW, NIBS RH 6-32 X 3/16" PHIL. SST 4
7 2103.32 LABEL, ON/OFF/BOOSTER FILL 1
8 2103.33 LABEL, WASH-RINSE TEMPERATURE 1
9 2103.35 BUSHING, 1" ID 2
10 00408.60 ASSEMBLY, TIMER (Includes Items 12, 13) 7
11 2103.59 SCREW, TRUSS SLOT, 8-32 X 1/4" SST 10
12 0411.00 SWITCH, TIMER 7
13 00501.00 MOTOR, TIMER 1
14* 2103.43* KIT, FILL/DRAIN TIMER (All S/N's) 1
15 2103.45 SCREW, RH 4-40 X 3/16" SLOTTED SST 4
16 2103.40 RELAY, 15 AMP, 120VAC COIL 1
17 2103.46 RELAY, 120VAC, 2PDT 1
18 2103.47 BLOCK, TERMINAL 1
19 2103.48 CONTACTOR, 25/40A, 3P, 120V COIL 1
20 2103.49 PANEL, CONTROL 1
* Note: See Kit Installation Instructions at the end of this manual
7
Control Panel Assembly
11
1
12
2
3
4
5
6
8
7
9
5
8
10
11
12
5
4
7
8
Item Part Description Qty. No. No.
Control Panel Assembly
1 2103.42 PANEL, FACIA, UC65e 1
2 2103.44 LABEL, FACIA, UC65e 1
3 2103.50 SWITCH, ON-OFF 1
4 2103.51 CONTACT, MOMENTARY, N.O. 2
5 2103.52 HOUSING, SWITCH 3
6 2103.53 BUTTON, SWITCH (GREEN) 1
7 2103.54 BUTTON, SWITCH (GREY) 2
8 2103.55 LIGHT, INDICATOR LED, 125VAC (GREEN) 2
9 2103.56 CONTACT, SWITCH (EXTENDED WASH) 1
10 2103.57 SWITCH, MOMENTARY (PRIME) 1
11 2103.58 GASKET, STEAM 2
12 2103.59 SCREW, TRUSS SLOT., 8-32 X 1/4" SST 2
9
UpperFinalRinsePipingAssembly
3
2
4
15
1
4
12
5
13
6
7
11
2
1
10
8
9
14
1
2
10
Item Part Description Qty. No. No.
UpperFinalRinsePipingAssembly
1 2103.60 HOSE, RUBBER 1/2ID X .84OD AR
2 2103.21 CLAMP, SS GEAR-MIN. 5/16-MAX.7/8 6
3 2103.62 FITT COMP 1/4OD X 1/8MPT ELL J 1
(Prior to S/N W120631743)
4 2103.26 PLUG, 1/8 HEX COUNTERSUNK 2
(Beginning with S/N W120631743)
5 2103.64 MANIFOLD, RINSE 1
6 2103.65 INJECTOR FITTING 1
7 2103.66 TUBING, 1/8OD X 1/16 ID AR
8 2103.67 NUT, HEX SS 1/4-20 2
9 2103.04 WASHER, SPLIT LOCK 1/4i 304SS 2
10 2103.69 BRACKET, VACUUM BREAKER 1
11 2103.70 NUT, LOCK 1/2" NICKEL PLATED 1
12 2103.71 VACUUM BREAKER, 1/2" BRASS 1
13 2103.72 REPAIR KIT, VACUUM BREAKER 1/2" 1
14 2103.73 COUPLER 1/2 MPT X 1/2" HOSE 1
15 2103.74 TUBING, 1/4" NATURAL AR
(Prior to S/N W120631743)
11
Wash and Rinse Spray Arm Assemblies
2
1
12
18
5
4
3
9
23
6
7
13
14
21
8
20
21
21
19
21
20
12
17
10
15
16
22
19
18
23
8
9
6
12
11
Item Part Description Qty. No. No.
Wash and Rinse Spray Arm Assemblies
1 2103.75 WASHER, 17/64 id X 9/16" OD SST 4
2 2103.76 NUT, HEX 1/40-20 NYLON INSERT SST 4
3 2103.77 HUB, UPPER WASH ARM 1
4 2103.78 WASHER, PACKING 1
5 2103.79 SCREW, RETAINING 1
6 2103.80 CLAMP, HOSE GEAR 1-1/2" SST 2
7 2103.81 HOSE, UPPER WASH ARM 1
8* 2103.82 BEARING ASSEMBLY 2
9 2103.83 O-RING, 2-1/8" OD X 1-3/4" ID X 3/16" 2
10 2103.84 HUB, LOWER WASH ARM 1
11 2103.85 MANIFOLD, LOWER FWR 1
12 2103.86 WASH ARM ASSEMBLY (Includes Item 8) 2
13 2103.88 WASHER, NYLITE 4
14 2103.89 BOLT, 1/4-20 X 1" SST 4
15 2103.90 SHAFT, LOWER 1
16 2103.91 O-RING 1
17 2103.92 HUB, RINSE ARM, MOLDED 2
18 2103.93 SCREW, TRUSS SLOTTED 8-32 X 1/4" SST 4
19 2103.94 ARM, RIGHT-HAND RINSE (7 JETS) 2
20 2103.95 ARM, LEFT-HAND RINSE (8 JETS) 2
21 2103.96 CAP, RINSE ARM, 5/16-24 4
22 2103.97 SPINDLE, RINSE ARM 2
23 2103.98 SPACER, NUT 2
--- 2103.99 RINSE ARM ASSEMBLY (Includes Items 18-23) 2
* Note: The bearing assembly, P/N 2103.82 includes 2 bearings, 1 locknut, and 1 wash arm hub. The bearings, locknut and hub are not available as separate service replacement parts.
13
Drain Pump and Lower Hose Assembly
17
5
18
18
16
To upper washarm hub
From Final Rinse Manifold
4
3
1
2
12
11
5
5
7
8
9
10
2
6
13
12
2
15
14
19
14
Item Part Description Qty. No. No.
Drain Pump and Lower Hose Assembly
1 02104.00 HOSE, FILL 1/2" X 7' C/W 3/4" FNPS 1
2 2103.16 BOLT, HEX FLANGE, 1/4-20 X 3/8" SST 6
3 2103.18 HOSE, BOOSTER FILL, 1/2" X 1' 1
4 2103.17 CLAMP, HOSE GEAR-TYPE 5/16" 1
5 2104.04 CLAMP, HOSE GEAR-TYPE, 1", SST 2
6 2104.05 HOSE, DRAIN PUMP SUCTION 1
7 2104.06 BRACKET, DRAIN PUMP 1
8 2104.07 PUMP, DRAIN 115VAC 1
9 2104.08 CLAMP, HOSE GEAR-TYPE SST 1
10 2104.84 HOSE, BRAIDE 1
11 2104.09 BRACKET, WASH PUMP 1
12 2104.10 CLAMP, HOSE GEAR-TYPE 1-13/16"- 2-3/4" MAX SST 2
13 2104.11 HOSE, SUCTION WASH PUMP 1
14 2103.80 CLAMP, HOSE GEAR-TYPE, 1-1/2", SST 2
15 2104.13 HOSE, DISCHARGE WASH PUMP 1
16 2103.81 HOSE, UPPER WASH ARM 1
17 2103.22 HOSE, RUBBER 1/2" 1D X .84" OD A/R
18 2103.21 CLAMP, HOSE GEAR-TYPE 2
19* 2103.68 COUPLER, 3/4" MPT X 3/4" HOSE BARB 1
* NOTE:
ITEM 19 IS STRAPPED TO THE DRAIN HOSE AS A SEPARATE PART FOR THE PLUMBING INSTALLER TO USE DURING INSTALLATION.
15
Wash Tank Heater and Drain Assembly
1
27
26
25
2
23
22
24
21
3
4
5
6
7
8
2
11
5
20
3
9
13
3
4
10
4
12
13
14
15
16
17
19
16
18
Item Part Description Qty. No. No.
Wash Tank Heater and Drain Assembly
1 2104.17 GASKET, DOOR 1
2 2104.18 HEATER, WASH TANK, 2KW, 240VAC 1
3 968.00 WASHER, SPLIT LOCK 1/4" SST 4
4 2103.67 NUT, HEX 1/4-20 SST 4
5 2104.21 O-RING 2
6 2104.22 ADAPTER, THERMOSTAT 1
7 2103.28 BUSHING, THERMOSTAT 1
8 2103.29 THERMOSTAT, WASH TANK 1
9 2104.25 ADAPTER, THERMOMETER 1
10 2103.25 THERMOMETER, 2" DIAL C/W 7' CAPILLARY 1
11 2103.70 NUT, LOCK 1/2" NICKLE-PLATED 2
12 2104.28 THERMOSTAT, FIXED, SNAP 212°F 1
13 2103.27 NUT, GRIP 6-32 W/NYLON INSERT 4
14 2103.30 SCREW, 4-40 X 1/2" SST 2
15 43019.00 SWITCH, DOOR 15 AMP 1
16 2104.32 BRACKET, SWITCH 1
17 2104.33 PLATE, SWITCH NUT 1
18 2104.34 ELBOW, PUMP SUCTION 1
19 2104.35 GASKET, PUMP SUCTION 1
20 2104.36 FLANGE, PUMP SUCTION 1
21 2104.37 HOSE, 1/4" ID X 3/8" OD A/R
22 2104.38 ELBOW, 3/8" TUBE X 1/4" NPT 1
23 2104.39 GASKET, 1/4" FIBER 1
24 2104.40 LOCKNUT, 1/4" PLASTIC 1
25 2104.41 FILTER, SUMP 1
26 2104.42 SEAL, OVERFLOW TUBE 1
27 2104.43 TUBE, OVERFLOW 1
17
FillSolenoidValveAssembly
1
1a
4
3
2
6
5
18
Item Part Description Qty. No. No.
FillSolenoidValveAssembly
1 03604.00 VALVE, SOLENOID, DEMA 1/2" 115VAC/60/1 1
(Includes Items 1a)
1a 03604.30 KIT, REPAIR SOLENOID VALVE, DEMA 1/2" A/R
2 03604.50 FITTING, FLOW DISC, DEMA 1
3 03604.10 WASHER, FLOW, DEMA 1
4 2103.73 FITTING, BARB HOSE 1
5 2104.45 BRACKET, VALVE, UC65E 1
6 2103.16 BOLT, HEX FLANGE 1/4-20 X 3/8" SST 2
19
Detergent Pump Assembly
13
12
11
13
10a
10
6
8
7
9
5
14
5
9d
9c
9b
4
9a
3
20
2
1
Item Part Description Qty. No. No.
Detergent Pump Assembly
1 2104.47 STRAINER 1
2 2104.48 TUBE,1/2IDX11-7/8LG. STIFFENER 1
3 2104.49 LABEL, DETERGENT 1
4 2104.37 HOSE, 1/4ID X 3/8OD PVC A/R
5 2104.51 TIE, NYLON 4" 4
6 2104.52 ELBOW, 1/4 HOSE BARB 1
6 00435.10 TUBE, SQUEEZE PUMP 1
7 00911.00 SCREW 4
8 00418.00 COVER, PUMP 1
9 00419.00 ASSEMBLY, ROLLER 1
9a 00423.00 ROLLER 2
9b 00422.00 PIN, ROLL 1
9c 00424.00 BEARING, CARRIAGE 1
9d 00933.00 SCREW, SET 1
10 00919.00 SCREW 2
10a 00918.00 SCREW, FILISTER HD. 1
11 00417.00 BLOCK, PUMP 1
12 00416.00 MOTOR, PUMP 115VAC 1
13 00448.00 CONNECTOR, PUMP MOTOR 2
----- 00415.00 ASSEMBLY, PERI-PUMP COMPLETE 1 (Includes Items 6-13)
21
Rinse-Aid Pump Assembly
13
12
11
10a
6
8
9
10
13
5
7
9d
4
9c
9b
3
9a
22
2
5
14
1
Item Part Description Qty. No. No.
Rinse-Aid Pump Assembly
1 2104.47 STRAINER 1
2 2104.48 TUBE,1/2ID X 11-7/8LG. STIFFENER 1
3 2104.49 LABEL, RINSE AID 1
4 2104.50 TUBING, 1/8" OD X 1/16 ID" AR
5 2104.51 TIE, CABLE 4" 4
6 00836.00 TUBE, SQUEEZE PUMP 1
7 00911.00 SCREW 4
8 00418.00 COVER, PUMP 1
9 00419.00 ASSEMBLY, ROLLER 1
9a 00423.00 ROLLER 2
9b 00422.00 PIN, ROLL 1
9c 00424.00 BEARING, CARRIAGE 1
9d 00935.00 SCREW, SET 1
10 00919.00 SCREW 2
10a 00918.00 SCREW, FILISTER HEAD 1
11 00417.10 BLOCK, PUMP 1
12 00416.00 MOTOR, PUMP 115VAC 1
13 00448.00 CONNECTOR, PUMP MOTOR 2
14 2104.58 TUBE, PUMP, 1/8" ID X 2" LG. 1
----- 00815.20 ASSEMBLY, PERI-PUMP COMPLETE 1 (Includes Items 6-13)
23
23
Panel Assembly
14
14
11
14
12
13
12
1
3
2
4
5
10
9
9
24
6
8
9
7
7
Item Part Description Qty. No. No.
Panel Assembly
1 2103.62 FITT COMP 1/4" OD X 1/8 MPT ELL J 1
2 2104.60 ADAPTOR, 1/8" NPT X 1/4" TUBE 1
3 2103.74 TUBING, 1/4" NATURAL A/R
4 2104.62 LABEL, GUAGE 1
5 2104.63 GAUGE, PRESSURE 0-60PSI 1
6 2103.25 THERMOMETER, 2" DIAL, 7' CAPILLARY 2
7 2104.65 SCREW, 1/4-20 X 5/8" TRUSS HD. PHIL. SST 2
8 2104.66 PANEL, FRONT UC65e 1
9 2104.67 FOOT, ADJUSTING 4
10 2104.68 NUT, KEPS, 10-32 SST 1
11 2104.69 WRAP, OUTER PANEL 1
12 2104.70 CLAMP, DOUBLE CONDUIT 3
14 2103.39 SCREW TRUSS SLOT SS 10-32X3/8 4
13 2104.72 PANEL, REAR 1
25
Door Assembly
1
5
4
3
2
3
2
6
7
26
Item Part Description Qty. No. No.
Door Assembly
1 2104.73 DOOR WELDED ASSY 1
2 2104.76 ARM, DOOR SPRING 2
3 2104.77 SPRING, DOOR 2
4 2104.78 ACTUATOR, DOOR SWITCH 1
5 2103.41 SCREW, 8-32 X 3/16" PHIL. SST 2
6 2104.88 SEAL, DOOR DRIP, RH 1
7 2104.87 SEAL, DOOR DRIP, LH 1
27
DishRacks,LineStrainer,PRV
1
2
4
28
3
28
Item Part Description Qty. No. No.
DishRacks,LineStrainer,PRV
1 2104.80 DISH RACK, FLAT-BOTTOM AR
2 2104.81 DISH RACK, PEG AR
3 2104.82 STRAINER, LINE 1/2" BRONZE (OPTIONAL) 1
4 2104.83 VALVE, PRESSURE REGULATING (PRV) 1
29
Blank Page
This Page
Intentionally
Left Blank
30
Loading...