Cleveland Range 36-CGM-16-300 User Manual

Cleveland

™

P

roject ________________________________

Item __________________________________

Quantity _______________________________

F

CSI Section ____________________________

A

pproval _______________________________

D

ate __________________________________

1333 East 179 St.,

Cleveland, Ohio, U.S.A. 44110

Tel: [phone]

Fax: [phone]

Web Site: www.ClevelandRange.com

Email: [e-mail]

1

0

0

%

5

Y

e

a

r

B

o

i

l

e

r

W

a

r

r

a

n

t

y

N

i

c

k

e

l

G

u

a

r

d

™

CLASSIC CONVECTION STEAMERS
15 PSI BOILER BASE STYLE

CONVECTION

®

ConvectionPro XVI

TWO LARGE COMPARTMENTS, PRESSURELESS
300M BTU GAS FIRED STEAM GENERATOR
36” WIDE CABINET BASE DESIGN, with NICKELGUARD™

Cleveland Standard Features

II

Cooking Capacity for up to eight 12˝ x 20˝ x 21⁄2˝ deep
Cafeteria Pans per compartment, or four 18˝ x 26˝ Buns Pans.

II

Pressureless cooking with forced convection steam, permitting
doors to be opened while cooking continues.

II

Solid State Controls operate water level and safety functions.
Each compartment is equipped with a 60 minute mechanica

II

timer, separate bypass switch for constant steaming.

II

Instant Steam Standby Mode: Holds generator at steaming
temperature. Allows unit to start cooking instantly.

II

Durable 10 Gauge Stainless Steel Construction:

For Compartment Door and Steam Cooking Cavity.

II

Separate Main Power Switch for “On/Off”

II

Exclusive Steam Cooking Distribution System:

sive Convection Jets produce a high velocity convection steam
without fans. Coved Corner design in cooking compartment dis­tributes heat evenly and is easy to keep clean. Creased bottom
enhances drainage. Cold Water Condenser for each compart­ment maintains a dry steam. Fully insulated cooking compart­ment for thermal efficiency. Removable Stainless Steel Slide
Racks for easy cleaning.

II

Heavy duty, one piece, solid compartment door design
with replaceable door gasket

II

Left Hand Door Hinging: Compartment Doors hinged left,
controls on the right.

II

Modular Cabinet Base with Hinged Door.

Heavy duty Stainless Steel Base Frame.

II

II

High Efficiency Gas Steam Generator with NickelGuard,

Electronic Spark Ignition and Automatic Water Fill on start up.

II

Automatic Generator Drain at shutdown: Contains a “Water
Jet” Spray Rinse Cleaning Cycle to keep drain clear.

II

Automatic Water Level Control System with Low Water
Power Cut-off Circuit.

II

Steam generator equipped with High Limit Pressure Safety
Switch, 15 psi Safety Valve, and Steam Generator Pressure
Gauge.

II

NSF Certified 6˝ Stainless Steel Legs with adjustable
flanged feet for a one inch level adjustment.

II

Gas Pressure Regulator and Control Valve.

II

Standard Voltage for Control: 115 volts, 60 Hz, single phase.

II

All Controls are serviceable from the front.

II

Compartment Door Steam Shut Off Switch.

Options & Accessories

Ë Electronic Timer with Compensating Load Feature. (ETC)
Ë ON/OFF Steam Switch only for compartment controls (MC)
Ë Cafeteria pans in depths of 1˝, 2

STEAMERS

1

⁄2˝, 4˝ and 6˝

l

The exclu-

MODEL:  36-CGM-16-300

Shown with optional
Electronic Timer

Short Form Specifications

Shall be Two Large Compartments, CLEVELAND Convection Steamer, Gas­fired Steam Generator, Model 36-CGM-16-300, NickelGuard, 300M BTU,
_____ gas, _____ volts, _____ Hz, single phase. Solid State Controls operate
timing, water level and safety functions.Type 304 Stainless Steel cooking
compartment. Insulated cooking compartments. One 60 minute Mechanical
Timer with Touch Control per compartment. Audible and Visual Signals for
cycle completion and steam shut-off.

Ë 18˝ x 26˝ Bun Pans
Ë Stainless Steel Insulated Flue Cover (SSF)
Ë Quick Disconnect for gas line (QDC)
Ë Correctional Packages
Ë Secondary Low Water Cut-Off, factory installed (CALG)

(Required for AZ. AR. CA. CO. CT. DE. FL. GA. HI. IL. IA. KS. MD. MA. MI.
MN. MT. NE. NV. NM. NC. OK. OR. PR. RI. TN. UT. VA. WA. WV., Buffalo, NY,
Wash. DC)

Ë Boiler Descaling Pump Kit (107142)
Ë Water Filters
Ë Rear Gas Connection (RGT)

SECT. III PAGE 27

1007

E

ach compartment has capacity for:

E

ight, 12˝ x 20˝ x 2

•

a

ccomodate 18˝ x 26˝ Bun Pans.

1

⁄2˝

deep Cafeteria Pans. Can

WATER QUALITY REQUIREMENT

The recommended minimum water quality standards
whether untreated or pre-treated, based upon 10 hours of
u

se per day, and a Daily Blowdown, are as follows:

TOTAL DISSOLVED SOLIDS less than 60 parts per million
TOTAL ALKALINITY less than 20 parts per million
S

ILICA less than 13 parts per million

p

H FACTOR greater than 7.5

CHLORINE less than 30 parts per million

C

onsult a local water treatment specialist for an on site
water analysis for recommendations concerning steam
generator feed water treatment (if required), in order to
r

emove or reduce harmful concentrations of minerals. The

u

se of highly mineralized water will mean that more

f

requent servicing of the steam generator will be
necessary. The fact that a water supply is potable is not
proof that it will be suitable for the generator.

Right - 6”, Left - 6”, Rear - 6” (12”
on control side if adjoining wall or
equipment is over 30” high for
service access)

** Do not connect to GFI
outlet. See note below.

Do not use PVC pipe for drain.

NOTES:

**DO NOT CONNECT TO GFI OUTLET. CLEVELAND RANGE RECOMMENDS GAS FIRED 120 VOLT STEAMERS BE HARD WIRED DIRECTLY TO ELECTRICAL SYSTEM.
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are ASME/N. Bd, UL/NSF#4 and CSA (AGA, CGA).

For use in non­combustible locations.

Contact factory for
variances to clearances

(NOT TO SCALE)

SECT. III PAGE 28

1007

Litho in U.S.A