Cleveland Range 21-CET-8 General Manual

Cleveland

™

P

roject ________________________________

Item __________________________________

Quantity _______________________________

F

CSI Section ____________________________

A

pproval _______________________________

D

ate __________________________________

1333 East 179 St.,

Cleveland, Ohio, U.S.A. 44110

Tel: [phone]

Fax: [phone]

Web Site: www.ClevelandRange.com

Email: [e-mail]

STEAMCRAFT®GENERATOR STYLE
HIGH SPEED CONVECTION STEAMERS

SteamCraft®Ultra 3

COUNTER TYPE DESIGN
PRESSURELESS CONVECTION STEAMER
ELECTRIC STEAM GENERATOR, 8 KW

Cleveland Standard Features

Cooking Capacity for up to three 12˝ x 20˝ x 21⁄2˝ deep

II

Cafeteria Pans.

II

Innovative PowerPak Electric Steam Generator: One
Special Stainless Steel Fire Bar Heating Element. Strong
14 Gauge Stainless Steel Construction. Large 3.5 gallon
generator reservoir for fast steam cooking production. Fully
insulated rear mounted steam generator.

II

Easy Access Generator Cleaning Port: Generator Cleaning
Port located on the outside, top of the unit. Not necessary to
remove hot panels or rack guides to access.

II

Generator Cleaning Light: Indicator Light located on the
front of the unit warns operator it is time to delime generator.

II

Instant Steam Stand By Mode: Hold generator at a steaming
temperature. Allows unit to start cooking instantly.

II

Durable 14 Gauge, Stainless Steel Construction:

For compartment door, cavity and steam generator.

II

One 60 Minute Electro-Mechanical Timer and Switch for
manual operation: Audible signal for cooking time

completion.

II

Main Power On/Off Switch: With Automatic Water Fill.

II

Exclusive Steam Cooking Distribution System:

Maintenance Free Exclusive Brass Steam Jets produce a high
velocity convection steam without fans. Coved Corner design
in cooking compartment distributes heat evenly, and is easy to
keep clean. Creased top & bottom enhance drainage. Cold
water condenser behind drain maintains a dry steam. Fully
insulated cooking compartment for thermal efficiency.
Removable Stainless Steel Slide Racks for easy cleaning.

Automatic Generator Drain: Contains a “Water Jet” Spray

II

Rinse Drain Cleaning Cycle to keep drain clear.

II

Exclusive Automatic Remote Probe Type Water Level
Control: Separate from the generator for easy access.

II

Exclusive “Cool to the Touch” Two-Piece Compartment
Door Design: Free floating inner door with reversible gasket

provides an air tight seal. Stainless Steel Slam/Latch Door
Latch mechanism for reliability.

II

Left Hand Door Hinging: Compartment Doors hinged on the
left, controls on the right.

II

Available in most voltages, single or three phase only.

II

Stackable by using the optional (STKI) Stacking Kit and
Optional Stacking Stand (ES2130S) is available (2 units only)

Options & Accessories

Ë Right hand Door Hinging, Controls on the Left (DHR)
Ë Electronic Timer with Compensating Load Feature (ETC)

MODEL:  21-CET-8

Shown with optional
Electronic Timer

Short Form Specifications

Shall be CLEVELAND, SteamCraft
Counter-Type Steamer, Model 21-CET-8, ___volts, 8.5 KW, ___Hz.
Heavy duty all Stainless Steel construction. Rear mounted, insu­lated Steam Generator with Remote Probe Type Water Level
Controls and Automatic Steam Generator Blowdown with “Water
Jet” Drain Cleaning feature.

Ë ON/OFF Steam Switch for compartment controls (MC)
Ë

34" (864mm) High Stainless Steel Economy Stand, for one 21-CET­8 (UniStand34)

Ë 24" (610mm) High Stainless Steel Stacking Stand

for mounting two stacked

21-CET-8

Mounting Spacer

Ë

POSK Pull-Out Shelf Kit for UniStands (

Ë

URK Pan Rack Kit UniStands (

Ë Equipment Stacking Stand Shelf Type (ES2446)
Ë Stacking Kit

(P/N 107166)
drain and Generator Cleaning Port Connections (STKI) (2
units only)

.

Ë 4˝ Stainless Steel Legs (LF4)
Ë Dissolve

®

Descale Solution, 6 one gallon container w/quart

markings (106174)

Ë Compartment Door Steam Shut Off Switch (SCS)
Ë Additional Pan Racks for Equipment Stands (PR)
Ë Cafeteria Pans in depths of 1˝, 2
Ë Water Filters



Ultra 3, one compartment,

(UniStand25)

, includes 2" Stainless Steel

P/N 111724

P/N 111726

)

)

includes plumbing for water, a

1

⁄2˝ and 4˝

SECT. IV PAGE 1

,

0609

Compartment has capacity for:

C

Three, 12˝ x 20˝ x 21⁄2˝ deep Cafeteria Pans.

•

WATER QUALITY REQUIREMENT

The recommended minimum water quality standards
whether untreated or pre-treated, based upon 10 hours of

se per day, and a Daily Blowdown, are as follows:

u
TOTAL DISSOLVED SOLIDS less than 60 parts per million

TOTAL ALKALINITY less than 20 parts per million
SILICA less than 13 parts per million
pH FACTOR greater than 7.5
CHLORINE less than 30 parts per million

Consult a local water treatment specialist for an on site
water analysis for recommendations concerning steam gen­erator feed water treatment (if required), in order to remove
or reduce harmful concentrations of minerals. The use of
highly mineralized water will mean that more frequent ser­vicing of the steam generator will be necessary. The fact that
a water supply is potable is not proof that it will be suitable
for the generator.

ELECTRIC

1 Ph
Volts Watts Amps Wire

208 8,300 39.9 2
220 6,974 31.7 2
240 8,300 34.6 2

NOTES:

Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are UL, ULC, UL/NSF#4, CE and CSA.

3 Ph
Volts Watts Amps Wire

208 8,300 23.6 3
220 6,974 18.8 3
240 8,300 20.5 3
440 6,974 9.4 3
480 8,300 10.3 3
360 7,445 12.3 4
380 8,300 13.0 4
415 8,300 11.9 4

WATER DRAINAGE CLEARANCE

Cold water:

35 psi minimum
60 psi maximum

1

⁄4˝ NPT Tubing:

Two

C1 one for Condenser
C2 one for Steam Generator

Unit comes with a
40 Mesh Water Strainer
(installation required)

1

1

⁄4˝ N.P.T. tube

Do not connect other units
to this drain.

Drain line must be vented.

No PVC pipe for drain.

D

Right - 3”, Left - 3”, Rear - 3”
(12” on control side if adjoining
wall or equipment is over 30”
high for service access)

Contact factory for
variances to clearances.

(NOT TO SCALE)

SECT. IV PAGE 2

0609

Litho in U.S.A.