Cleveland Range 1SCE User Manual

Cleveland

™

roject ________________________________

tem __________________________________

Quantity _______________________________

FCSI Section ____________________________

pproval _______________________________

ate __________________________________

1333 East 179 St.,

Cleveland, Ohio, U.S.A. 44110

Tel: 1-216-481-4900

Fax: 1-216-481-3782

Web Site: www.ClevelandRange.com

Email: Steam@ClevelandRange.com

STEAMCUB™ BOILERLESS CONNECTIONLESS STEAMER

SteamCubTMPlus

PRESSURELESS STEAM COOKER, RETHERMALIZER & HOLDING CABINET

Cleveland Standard Features

n B

oilerless Pressureless Steam Cooker, Holding Cabinet and

Rethermalizer.

n Capacity: Full Size Steam Table Pans:

• Five: 2 1/2" x 12" x 20" (1/1 GN, 65mm)

• Ten: 1" x 12" x 20" (1/1GN, 40mm)

n Easy installation, no drain line, water connections or hood is

needed.

n Programmable Preheat and Holding Cycle Temperature

Controls with Compensating Thermostat.

•

• Digital Time-Temperature and Low Water Indicator Display

n Three Versatile Operating Modes.

• Steam and Hold

• Holding Only: Preset at 160˚ F (71˚ C)

• Constant Steaming

n 6" (152mm) Skid Resistant Stainless Steel

with Flanged Feet.

n 8 gauge stainless steel inner cooking compartment, 14

gauge stainless steel outer compartment with two piece compartment door for an airtight, leak-proof seal.

n 9 kW total output, with easy to remove 1 kW heating

elements (9ea) cast into aluminum bocks.

n Electronic Low-Water Shut-Off Safety Indicator with audible

alarm, High Indicator Light.

n Separate Power ON/OFF Control includes an Automatic Pre-

Heat when power is turned "ON".

n Easy-Access Manual Drain Valve located in front, Pan Slide

Guides located under unit to fit 12" x 20" (1/1GN) Pans. Includes one 4" x 12" x 20

n Approvals: cUL, NSF #4.

Timer settings for 10 minute, 1 minute or 10 second intervals

Adjustable Legs

emperature Safety Shut-Of

f and LED "Heat On"

MODEL: c 1SCE

Short Form Specifications

Shall be a Cleveland SteamCub Plus™ , Model 1SCE, one compartment counter top steamer, holding cabinet and rethermalizer model number 1SCE. Electronic controls with three operating modes: constants steaming, steamhold and holding only. 9 kW, 208 volts, 3 phase. Audible low water and high temperatur ment, 14 gauge stainless steel outer compartment with two piece compartment door

e safety indicator

8 gauge stainless steel inner cooking compar

Options & Accessories

p Equipment Stand Model UniStand34.

p POSK Pull-Out Shelf Kit for UniStands (P/N 111724)

p URK Pan Rack Kit UniStands (P/N 111726)

p Optional Voltages, 480 Volt (VOS2).

p 6 kW total Output Six - 1kW heating elements.

p Single Phase Operation.

* Consult local authorities for venting requirements

SECT. I PAGE 3

0707

17.434" 4

43mm

1.625"

549mm

3.100"

587mm

25.361" 644mm

2.100" 53mm

4.858"

631mm

1.574" 40mm

30.890" 785mm

1.500" 38mm

RIGHT

SIDE VIEW

FRONT

VIEW

REAR

VIEW

WATER QUALITY REQUIREMENT

The recommended minimum water quality standards whether untreated or pre-treated, based upon 10 hours of use per day, and a Daily Blowdown, are as follows:

OTAL DISSOLVED SOLIDS less than 60 parts per million

OTAL ALKALINITY less than 20 parts per million

T SILICA less than 13 parts per million pH FACTOR greater than 7.5 CHLORINE less than 30 parts per million

Consult a local water treatment specialist for an on site water analysis for recommendations concerning steam generator feed water treatment (if required), in order to remove or reduce harmful concentrations of minerals. The use of highly mineralized water will mean that more frequent servicing of the steam generator will be necessary. The fact that a water supply is potable is not proof that it will be suitable for the generator.

Compartment has capacity for:

•

Five, 12˝ x 20˝ x 2

⁄2˝ deep Cafeteria Pans.

ELECTRICAL

WATTS VOLTS PHASE WIRES

CYCLE HERTZ WIRE SIZE (COPPER)*

AMPS

Standard Wattage

Three Phase - 9 kW Standard

9400 208 3 3 60 26.1 10 9400

240

9400 480 3 3 60 11.4 14

Optional Low W

Three Phase - 6 kW option

6400 208 3 3 60 17.8 12

attage

6400 240 3 3 60 15.4 12 6400 480 3 3 60 7.7 14

* For supply connection use only copper wire suitable for at least 75˚C. (167˚F).

Note: Consult local authorities for venting and installation requirements.

∗

For supply connection use only copper wire suitable for at least 75

TES

Cleveland Range reserves right of design improvement or modification, as warranted. Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes. Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are

SUPPLY CONNECTION

22.6

WATTS VOLTS PHASE WIRES

Standard Wattage

Single Phase - 9 kW Standard

9400 208 1 2 60 45.2 6 9400

Optional Low W

Single Phase - 6 kW option

6400 208 1 2 60 30.8 8 6400 240 1 2 60 26.7 10

C (167

240

attage

°F).

U.L/NSF#4 and CSA (AGA, CGA).

CYCLE HERTZ WIRE SIZE (COPPER)*

AMPS

SUPPLY CONNECTION

39.2

O SCALE)

(NOT

SECT

I P

Litho in U.S.A.

AGE

0707