Cleveland PEM-24-2 User Manual

Cleveland

™

P

roject ________________________________

Item __________________________________

Quantity _______________________________

F

CSI Section ____________________________

A

pproval _______________________________

D

ate __________________________________

1333 East 179 St.,

Cleveland, Ohio, U.S.A. 44110

Tel: [phone]

Fax: [phone]

Web Site: www.ClevelandRange.com

Email: [e-mail]

PRESSURE STEAMERS

PRESSURE STEAMERS

2 OR 3 COMPARTMENTS, CABINET MOUNTED
ELECTRIC STEAM GENERATOR
24, 36 OR 48 KW, 36” WIDE CABINET BASE

Cleveland Standard Features

I

I

5 psi Operating Pressure in cooking compartments

II

Mechanical interlock prevents unlatching door while compartment
is pressurized

II

Timers, one per compartment, are mechanical style with
audible signal

I

I

Thermostatic Trap vents cooking compartment automatically

II

Steam Inlet Valves and Exhaust Valves interlocked for
synchronous action

II

8 psi Compartment Safety Valve

II

Capacity per compartment for eight, 12” x 20” x 2 1/2” deep
Cafeteria Pans, or four, 18” x 26” Bun Pans

II

Heavy Duty, free floating, cast aluminum compartment doors

II

Compartment Door Hinges have adjustable hinge pins and
self-lubricating bushings

II

Door Gasket replaceable without tools

II

Pressure Gauge for compartment operating pressure

II

Compartment Slide Racks are removable without tools, for
easy cleaning

II

Type 430 Stainless Steel: external enclosure, Table Top and
eight gage plate cooking compartments

II

Modular Cabinet Base with Hinged Doors

II

High efficiency Electric Steam Generator with Automatic
Water Fill on start-up

II

Automatic Water Level Control System with Low Water Power
Cut-off Circuit

II

Steam Generator equipped with High-limit Pressure Safety
Switch and Safety Valve

II

Automatic Steam Generator (boiler) Blowdown allows intermittent
control, complete with additional Manual Drain Valve

II

Steam Generator Pressure Gauge

II

6” Stainless Steel Legs with level adjustment and flanged feet

II

Single Cold Water Connection (no hot water required)

Ë Secondary Low Water Cut-Off, factory installed (CALE)

(Required for AZ. AR. CA. CO. CT. DE. FL. GA. HI. IL. IA. KS. MD. MA. MI. MN. MT.
NE. NV. NM. NC. OK. OR. PR. RI. TN. UT. VA. WA. WV., Buffalo, NY, Wash. DC)

II

Standard Voltage 208-240 volts, 60 hz, single phase, three
wire

II

All Major Components are serviceable from the front of unit

Options & Accessories

MODELS:

2 Compartments 3 Compartments

 PEM-24-2  PEM-24-3
 PEM-36-2  PEM-36-3
 PEM-48-2  PEM-48-3

Short Form Specifications

Shall be _____ Compartments, CLEVELAND, Pressure Steamer, Model
PEM- _____ - _____ , Electric Steam Generator, _____ kw,
_____ volts, _____ ph, three wire. Each Cooking Compartment
equipped with: 60 Minute Timer; Heavy-duty, free floating Door with
Safety Interlock; and synchronous operating Steam Inlet and
Exhaust/Drain Valves. Solid State Controls operate Water Level and
Steam Generator (boiler) Safety Functions. Automatic Steam
Generator (boiler) Blowdown with additional Manual Drain Valve.

Ë Kettle Interconnecting Kit (IMK)

Ë Stainless Steel base Frame (FSS)

Ë Stainless Steel gas flue cover, insulated (SSF)

Ë Special compartment Slide Racks

Ë 12” x 20” Cafeteria Pans 1”, 2 1/2”, 4” or 6” deep

Ë Intermediate Pull-Out Shelf (POS)

Ë Spray Head with flexible Hose (SH)

Ë Voltages, other than standard

Ë

Water Filters

Ë Correctional Packages

Ë Automatic Steam Inlet and Exhaust Operation (AT-2): includes

60 minute Automatic Timers and Manual Bypass

Ë 15 psi for Kettle Operation, includes Power Take-Off (PTO)

SECT. VI PAGE 1

0609

Each compartment has capacity for:

C

•

Eight, 12˝ x 20˝ x 2

1

⁄2˝ Cafeteria Pans or
Six, 12˝ x 20˝ x 4˝ Cafeteria Pans or
Four, 12˝ x 20˝ x 6˝ Cafeteria Pans or

our, 18˝ x 26˝ Bun Pans

F
Many regional, state and local codes exist and it is

•

the responsibility of the owner and installer to com­ply with those codes.

Cleveland Range equipment is built to comply with

•

applicable standards for manufacturers. Included
among those approval agencies are: UL, NSF,
ASME/N.Bd., CSA.

WATER QUALITY REQUIREMENT

The recommended minimum water quality standards
whether untreated or pre-treated, based upon 10 hours
of use per day, and a Daily Blowdown, are as follows:

TOTAL DISSOLVED SOLIDS less than 60 parts per million
TOTAL ALKALINITY less than 20 parts per million
SILICA less than 13 parts per million
pH FACTOR greater than 7.5
CHLORINE less than 30 parts per million

Consult a local water treatment specialist for an on site
water analysis for recommendations concerning steam
generator feed water treatment (if required), in order to
remove or reduce harmful concentrations of minerals.
The use of highly mineralized water will mean that more
frequent servicing of the steam generator will be
necessary. The fact that a water supply is potable is not
proof that it will be suitable for the generator.

ELECTRIC

KW Volts Watts Ph Amps Wire

24 208 21,500 1 103.4 2

220 24,000 1 109.1 2

240 24,000 1 100.0 2

440 20,200 1 45.9 2

480 24,000 1 50.0 2

208 21,500 3 59.7 3

220 24,000 3 63.1 3

240 24,000 3 57.8 3

440 20,200 3 26.5 3

480 24,000 3 28.9 3

600 24,000 3 23.1 3

360 21,500 3 34.5 4

380 24,000 3 36.5 4

415 24,000 3 33.4 4

Cleveland Range reserves right of design improvement or modification, as warranted.

KW Volts Watts Ph Amps Wire
36 208 32,200 3 89.5 3

220 36,000 3 94.6 3
240 36,000 3 86.7 3
440 30,200 3 39.7 3
480 36,000 3 43.4 3
600 36,000 3 34.7 3
360 32,200 3 51.7 4
380 36,000 3 54.8 4
415 36,000 3 50.1 4

48 208 42,900 3 119.2 3

220 48,000 3 126.1 3
240 48,000 3 115.6 3
440 40,300 3 52.9 3
480 48,000 3 57.8 3
600 48,000 3 46.2 3
360 42,900 3 68.9 4
380 48,000 3 73.0 4
415 48,000 3 66.9 4

WATER DRAINAGE CLEARANCE

1/4˝ NPT
Cold Water Inlet

35 psi minimum

60 psi maximum

The Floor Drain must be located
outside the confines of the
equipment base.

1 1/2˝ I.P.S. common drain.
Do not connect other units to this
drain.
Do not use PVC pipe for drain.

D

Right - 3”, Left - 3”,
Rear - 3” (12” on control
side if adjoining wall or
equipment is over 30” high
for service access)

Contact factory for
variances to clearances.

(NOT TO SCALE)

SECT. VI PAGE 2

0609

Litho in U.S.A.