Chromalox STAR-02A-81-F, STAR-02A-41-F, STAR-02A-61-F, STAR-05A-81-F, STAR-05A-21-F Installation, Operation And Renewal Parts Identification
...
(Supersedes PG434-1)
Type STAR Radiant Heater
For Fixed Overhead Installations
© 2003 Chromalox, Inc.
Specifications – Table 1
Amperage Dimensions (In.) Wire Ga. (Min.)
Model Figure Volts KW
1 Phase 3 Phase
BTU
A Length B Width D Depth 1 Phase 3 Phase
STAR-02A-11-F 120 1.5 12.5 NA 5118 14 NA
STAR-02A-81-F 208 2 9.6 NA 6824 14 NA
STAR-02A-21-F 1 240 2 8.3 NA 6824 33-1/4 15-1/2 11-9/16 14 NA
STAR-02A-71-F 277 2 7.2 NA 6824 14 NA
STAR-02A-41-F 480 2 4.2 NA 6824 14 NA
STAR-02A-61-F* 600 2 3.3 NA 6824 14 NA
STAR-05A-81-F 208 4.5 21.6 NA 15354 12 NA
STAR-05A-21-F 240 4.5 18.8 NA 15354 12 NA
STAR-05A-71-F 1 277 4.5 15.9 NA 15354 55-3/4 15-1/2 11-9/16 14 NA
STAR-05A-41-F 480 4.5 9.4 NA 15354 14 NA
STAR-05A-61-F* 600 4.5 7.5 NA 15354 14 NA
STAR-06A-83-F 208 6 28.8 16.7 20472 10 12
STAR-06A-23-F 240 6 25.0 14.4 20472 10 12
STAR-06A-71-F 2 277 6 21.7 — 20472 32-1/2 23-5/8 11-1/2 10 —
STAR-06A-43-F 480 6 12.5 7.2 20472 12 12
STAR-06A-63-F* 600 6 10.0 5.8 20472 12 12
STAR-14A-83-F 208 13.5 NR 37.5 46062 NR 10
STAR-14A-23-F 240 13.5 NR 32.5 46062 NR 10
STAR-14A-71-F 2 277 13.2 47.7 — 45038 55-5/8 23-5/8 11-3/4 8
STAR-14A-43-F 480 13.5 28.1 16.2 46062 12 12
STAR-14A-63-F* 600 13.5 22.5 13.0 46062 12 12
* Not UL or CSA
NA - Not Available
NR - Not Recommended
Figure 2
"
"
"
3
"
"
Figure 1
"
9-7/8"
15-1/2"
"
"
"
2.0 kW 4.5 kW
6.0 kW 13.5 kW
http://www.chromalox.com
JULY, 2003
PG434-2
11-9/16
9-7/8" 23-5/8"
33-1/4
11-1/2
23-5/8
11-9/16"
55-3/4
11-1/2
23-5/8
2-1/2
55-5/8
IMPORTANT INSTRUCTIONS
When using electrical appliances, basic precautions should
always be followed to reduce risk of fire, electric shock and injury
to persons, including the following:
1. Read all instructions before using this heater.
2. This heater is hot when in use. To avoid burns, do not let bare
skin touch hot surfaces. Keep combustible materials, such as
furniture and papers at least 7 feet from the front of the heater.
3. Always disconnect heater when not in use.
4. Do not use outdoors in areas subject to wind.
5. Connect to properly grounded outlets or building ground.
6. This heater has hot surfaces. Do not use it in areas where gaso-
line, paint or flammable liquids are used or stored.
7. Use this heater only as described in this manual. Any other use
not recommended by the manufacturer may cause fire, electric
shock or injury to persons.
8. In order to prevent equipment damage, protect with a ground
fault device such as Chromalox STAR-GF series monitor.
9.
SAVE THESE INSTRUCTIONS
GENERAL
IMPORTANT:
SAVE THESE INSTRUCTIONS
FIRE HAZARD. Do not use as a residential or
household heater. Keep combustible material away
from heater. Do not operate heater where flammable vapors, gases or liquids are present.
To avoid personal injury read “IMPORTANT
INSTRUCTIONS” on this page before installation or
operation of heater.
INSTALLATION
The Chromalox STAR radiant heater is shipped fully assembled. The heater can be hung from the ceiling with 4 chains or rigid
angle brackets attached to the heater brackets located on the back
of the heater, for 2 and 4.5 kW heaters, chains can be attached to
the four holes in the corners of the back reflector. (Chromalox
offers hanging chain kits for these heaters that will allow for installations 2 to 6 feet from the ceiling.) Minimum spacings:
Ceiling to top of heater is 2 feet.
Wall to sides of heater is 3 feet.
Floor to bottom of heater is 10 feet.
Installer should consult state and local codes and
meet any applicable requirements regarding the
installation.
When used as a portable heater, do not leave the heater unattended while in operation.
2
Figure 4
!
http://www.chromalox.com
Loading...