Page 1
Global LCD Panel Exchange Center
ʳ ʳ
Customer
Type TXW021 31.5"LCM
Date 2009-09-22
Revision number Ver. 01
www.panelook.com
Specifications
Doc. No1.
Code
QRA Manufacture
Customer Approved
CHI LIN TECHNOLOGY
Approved Checked Design
ʳ ʳʳʳ
Rev.: 01 Page: 1 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 2
Global LCD Panel Exchange Center
Version Date Page Section Description
01 20090922 All All
www.panelook.com
Specifications
Doc. No2.
Revision History
Rev.: 01 Page: 2 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 3
Global LCD Panel Exchange Center
ʹͿ΅ͶͿ΅΄ͷ;͵ΆͽͶΗΠΣˆ˄ˁˈͽʹ;
ˈкʼ
ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ
ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ ʳ
1.0 GENERAL SPECIFICATI0NS ..………………………………….. PAGE 4
1.1 OVERVIEW
1.2 GENERAL SPECIFICATI0NS
1.3 MECHANICAL SPECIFICATIONS
1.4 OPTICAL PARTS
2.0 ABSOLUTE MAXIMUM RATING …………………………………….. PAGE 5
2.1 ABSOLUTE RATINGS OF ENVIRONMENT
3.2 CCFL (Cold Cathode Fluorescent Lamp) Characteristics (Ta=2
3.0 ELECTRICAL CHARACTERISTICS …………………………………….. PAGE 6
3.1 TFT-LCD MODULE0
4.0 BLOCK DIAGRAM ..………....…..…………………….. PAGE 9
www.panelook.com
Specifications
Doc. No3.
4.1 TFT-LCD MODULE
5.0 INPUT TERMINAL PIN ASSIGNMENT …………………….………………. PAGE 10
5.1 TFT-LCD MODULE
5.2 LVDS DATA MAPPING TABLE
5.3 BACKLIGHT UNIT
5.4 COLOR DATA INPUT ASSIGNMENT
6.0 INTERFACE TIMING …………………….………………. PAGE 15
INPUT SIGNAL TIMING SPECIFICATIONS
6.1
6.2 POWER ON/OFF SEQUENCE
7.0 OPTICAL CHARACTERISTICS ……………………………………… PAGE 17
8.0 ELECTRICAL CHARACTERISTICS ……………………………………… PAGE 20
9.0 DEFINITION OF LABELS
9.1 Backlight Label
10.0 PACKING
10.1 Carton SPECIFICATIONS
10.2 Sea transportation
10.3 Air transportation
10.4 PACKAGING LABEL
……………………………………… PAGE 21
……………………………………… PAGE 23
11.0 LCD MODULE DRAWING ……………………………………… PAGE 26
12.0 STORAGE CONDITION ……………………………………… PAGE 27
13.0 WARRANTY ……………………………………… PAGE 27
14.0 LOT NO. GENERATION ……………………………………… PAGE 27
Rev.: 01 Page: 3 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 4
Global LCD Panel Exchange Center
1.0 GENERAL SPECIFICATI0NS
1.1 OVERVIEW
The TBW021 module is a 31.5”wide TFT-LCD module .The module use 4 U type-CCFL
Backlight Unit and a 30-pin 1ch-LVDS . The module support 1366*768 mode and 16.7
millions color.
ʳ
1.2 GENERAL SPECIFICATI0NS
www.panelook.com
Specifications
Doc. No4.
Item Specification Unit Note
Active Area
Bezel Opening Area 703.6 (H) x398.4 (V) mm
Driver Element a-si TFT active matrix -
Pixel Number
Pixel Pitch (Sub Pixel) 0.51075(H) x 0.51075(V) mm
Pixel Arrangement RGB vertical stripe -
Display Colors
Display Operation Mode Normally Black -
Surface Treatment Anti-Glare coating (Haze 20%),Hard coating (2H) -
497.69(H) x
392.26 (V) (31.5" diagonal)
1366 x R.G.B. x 768
16.7M
mm
pixel
color
1.3 MECHANICAL SPECIFICATIONS
Item Typ. Unit Note
Module Size
Horizontal(H)
Vertical(V)
Depth(D)
760
450
44
mm
mm
mm
Weight
5.2
Kg
1.4 OPTICAL PARTS
Item Part Model Vender
1 CCFL U shape GIO
2
Diffuser sheet PTR773-T75*3 Shinwha
3 Diffuser plate A53201 Entire
4 Refletor sheet RE-200T Eternal
Rev.: 01 Page: 4 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 5
Global LCD Panel Exchange Center
2.0 ABSOLUTE MAXIMUM RATING
2.1 ABSOLUTE RATINGS OF ENVIRONMENT
Item Symbol
www.panelook.com
Specifications
Doc. No5.
Value
Unit Note
Min. Max.
Storage Temperature T ST
Operating Ambient Temperature TOP
Shock (Non-Operating) SNOP
Vibration (Non-Operating) VNOP
-20 +60
0 +50
- 50 G (3),(5)
- 1.0 G (4),(5)
ºC
ºC
(1),(3)
(1),(2),(3)
Rev.: 01 Page: 5 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 6
Global LCD Panel Exchange Center
3.0 ELECTRICAL CHARACTERISTICS
3.1 TFT-LCD MODULE
www.panelook.com
Specifications
Doc. No6.
Rev.: 01 Page: 6 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 7
Global LCD Panel Exchange Center
www.panelook.com
Specifications
Doc. No7.
Rev.: 01 Page: 7 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 8
Global LCD Panel Exchange Center
ˈкʼ
к
˃к
3.2 CCFL (Cold Cathode Fluorescent Lamp) Characteristics (Ta=2
www.panelook.com
Specifications
Doc. No8.
ValueParameter Symbol
Unit Note
Min. Typ. Max
Lamp Voltage VW 1530 V
Lamp Current IL 8.5 11.0 11.5 mA
Lamp Turn on
Voltage
Operating
Vs
FL 30 60 KHz
2190 V
2540 V
IL=11.0mA
RMS
RMS
RMS
RMS
Ta=25
Ta=
Frequency
Lamp Life time LBL 50000 Hrs
Rev.: 01 Page: 8 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 9
Global LCD Panel Exchange Center
4.0 BLOCK DIAGRAM
4.1 TFT-LCD MODULE
www.panelook.com
Specifications
Doc. No9.
Rev.: 01 Page: 9 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 10
Global LCD Panel Exchange Center
5.0 INPUT TERMINAL PIN ASSIGNMENT
5.1 TFT-LCD MODULE
www.panelook.com
Specifications
Doc. No10.
Rev.: 01 Page: 10 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 11
Global LCD Panel Exchange Center
5.2 LVDS DATA MAPPING TABLE
www.panelook.com
Specifications
Doc. No11.
Rev.: 01 Page: 11 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 12
Global LCD Panel Exchange Center
www.panelook.com
Specifications
Doc. No12.
Rev.: 01 Page: 12 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 13
Global LCD Panel Exchange Center
5.3 BACKLIGHT UNIT
The back light unit consists of 4 U-lighting type CCFLs
(Cold Cathode Fluorescent Lamp).
!
Wired
www.panelook.com
Specifications
Doc. No13.
LCDʳModule
G
Rev.: 01 Page: 13 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 14
Global LCD Panel Exchange Center
5.4 COLOR DATA INPUT ASSIGNMENT
THE brightness of each primary color (redΕgreen and blue) is based on the 8-bit gray scale
data input for the color.The higher the binary input,the brighter the color.The table below
provides the assignment of color versus data input.
www.panelook.com
Specifications
Doc. No14.
ʳ
Rev.: 01 Page: 14 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
ʳ
Page 15
Global LCD Panel Exchange Center
6.0 INTERFACE TIMING
6.1 INPUT SIGNAL TIMING SPECIFICATIONS
The input signal timing specifications are shown as the following table and timing diagram.
www.panelook.com
Specifications
Doc. No15.
Rev.: 01 Page: 15 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 16
Global LCD Panel Exchange Center
6.2 POWER ON/OFF SEQUENCE
The prevent a latch or DC operation of LCD module,the power on/off sequence should be as
the diagram below.
www.panelook.com
Specifications
Doc. No16.
Rev.: 01 Page: 16 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 17
Global LCD Panel Exchange Center
7.0 OPTICAL CHARACTERISTICS
Item Symbol Condition Min. Typ. Max. Unit Note
www.panelook.com
Specifications
Doc. No17.
Contrast Ratio CR
Response Time Tr 㧙 1.3 ms (6)
Center Luminance of White LC 450 㧙 cd/m2(1),(3)
White Variation W 㧙 㧙 㧙 (1),(4)
Color
Chromaticity
Viewing Angle
Red
Rx 0.630
Ry 0.340
Gx
Green
Gy 0.590
Bx 0.144
Blue
By 0.072
Wx 0.280
White
Wy
x+ 75 85 㧙
Horizontal
x- 75 85
Y+ 70 80 㧙
Vertical
Y-
ǰx=0°,ǰY=0°
Viewing
Normal Angle
CR10
2300
Typ
–0.03
70 80
2500
0.288
0.290
㧙
Typ +
0.03
㧙
㧙
㧙 (1), (2)
㧙 (1),(3)
Deg. (1),(5)
Note (1) Measurement Setup: The LCD module should be stabilized at given temperature for 1 hour to avoid
abrupt temperature change during measuring. In order to stabilize the luminance, the measurement
should be executed after lighting Backlight for 1 hour in a windless room.
Note (2) Definition of Contrast Ratio (CR):
The contrast ratio can be calculated by the following expression.
Contrast Ratio (CR) = L255 / L0
L255: Luminance of gray level 255
L 0: Luminance of gray level 0
CR = CR (5), where CR (X) is corresponding to the Contrast Ratio of the point X at the figure in
Note (4)
Rev.: 01 Page: 17 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 18
Global LCD Panel Exchange Center
Note㧔3㧕Measurement Method
Backlight Unit
www.panelook.com
Specifications
Doc. No18.
L
E
BM5A BM7 SRIIA SRIII CA210 CS1000
Item
Angle
0.2 1 0.2 0.2 2.5 2
Distance L 50cm 50cm 50cm 50cm 3cm 50cm
Note (4) Definition of White Variation (W):
Measure the luminance of gray level 255 at 5 points
W = Maximum [L (1), L (2), L (3), L (4), L (5)] / Minimum [L (1), L (2), L (3), L (4), L (5)]
where L (X) is corresponding to the luminance of the point X at the figure below.
Rev.: 01 Page: 18 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 19
Global LCD Panel Exchange Center
www.panelook.com
Specifications
Doc. No19.
Note㧔5㧕Definition of Viewing Angle㧔x, y㧕:
Note (6) Definition of Gray-to-Gray Switching Time:
Active Area
Rev.: 01 Page: 19 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 20
Global LCD Panel Exchange Center
ʳ
_
The driving signal means the signal of luminance 0%, 20%, 40%, 60%, 80%, 100%.
Gray to gray average time means the average switching time of luminance 0%,20%,
40%, 60%, 80%, 100% to each other.
8.0 ELECTRICAL CHARACTERISTICS
www.panelook.com
Specifications
Doc. No20.
Parameter Symbol
Min. Typ. Max.
Lamp Operate Voltage VL
Lamp Current IL
Vs
Operating Frequency FL 40 80
Lamp Life Time LBL 50000
Power Cosumption PL
㧙
㧙
㧙
㧙
㧙
Value
˄˄ˆˈ
12
-
-
㧙 㧙
79 ˀˀˀ
TBD V
--- (0)
1590 (25α
㧙
Unit Note
IL = 12.0mA㧔1㧕
RMS
mA
RMS
V
Lamp Starting Voltage
RMS
V
RMS
㧔1㧕
㧔2㧕
IL = 12.0mA㧔1㧕
Note㧔1㧕Lamp current is measured by utilizing high frequency current meters as shown below:
+
L=(100±50 mm)
Inverter Power Supply
Backlight
Galvanometer
Note㧔2㧕CCFL Lifetime
Definition of the Lifetime:
The situation as below is a definition of service life while taking place:
1) Surface brightness descends to 50% of initial value.
2) The starting voltage is larger than the max value at 0к in the Item 2.4.
Working Life
The guarantee lifetime of CCFL is 50000 hours in the operating mode.
Environment temperature 25±3
FL tube current
ˌˁ˃ mA rms
Lighting Status Continued Lighting
FL Lighting Frequency 50KHz
Rev.: 01 Page: 20 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 21
Global LCD Panel Exchange Center
9.0 DEFINITION OF LABELS
9.1 Backlight Label
The barcode nameplate is pasted on each backlight as illustration, and its definitions are as
following explanation.
www.panelook.com
Specifications
Doc. No21.
1. Part No. ID Code: M$
2. Part No.: Depend on CLT
3. Lot No. ID Code: L$
4. Vendor ID Code: 2 codes, Depend on Vendor.
5. Lamp, refer to BLU Specification.
6. Diffuser sheet, refer to BLU Specification.
7. Diffuser Plate, refer to BLU Specification.
8. Reflector, refer to BLU Specification.
9. Prism sheet, refer to BLU Specification.
10. Other Components, 2 Codes, refer to BLU Specification.
11. Production year: 2006:6 ; 2007:7 ; …….
12. Production month: 1,2,3,4,5,6,7,8,9,X,Y,Z
13. Date: 1,2,3,4,5,6,7,8,9,A,B,…H,J,K,L,M,N,P,Q…,T,W,X,Y,Z
14. Serial No.: 0001,0002,0003,……., Reset everyday
Notes:
1. Material: Synthetic Paper
2. Thickness: 0.137 %
3. Color: White
4. General Tolerance: 0.2
5. “ Ͽ” Marks the design critical dimension
6. Bar-code printer’s solution must be above 203dpi.
7. Without SPACE in front and behind “ А“ in barcode.
8. ΨA-BΨ= 2.0mm
Barcode: Code 93.
Rev.: 01 Page: 21 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 22
Global LCD Panel Exchange Center
NO2: Part No.: Depend on CLT 32inch Backlight(10040396-A0)
NO4: Vendor ID Code:
www.panelook.com
Specifications
Doc. No22.
CLT
NO5: CCFL vender :
Code CLT P/N P/N Vender Vender P/N
1
NO6: Diffuser sheet
Code CLT P/N P/N Vender Vender P/N
1
NO7: Diffuser plate
Code CLT P/N P/N Vender Vender P/N
1
NO8: Reflector sheet
Fab Tainan(CLT) Souzei(LSO) NingBo(LMO) FoShan(LCO)
Vendor ID Code
11390411-AP
C1 C2 C3 C4
U_Shape
GIO
12360001-A0 PTR773-T75*3 Shinwha
11440188-A0 A53201,PS Entire
N/A
N/A
N/A
Code CLT P/N P/N Vender Vender P/N
1
NO9: Prism sheet
Code CLT P/N P/N Vender Vender P/N
1
NO10: Other Components
Code CLT P/N P/N Vender Vender P/N
01 N/A CLT N/A
11590436-A0 RE-200T Eternal
N/A N/A N/A
N/A
N/A
NO11: mean“Y”Δ2008 as 8Ε2009 as 9…..
NO12: mean“M”Δ1.2.3.4.5.6.7.8.9.X.Y.Z
NO13: mean“D”Δ1.2.3.4.5.6.7.8.9.A.B.C.D…..V
NO14: “S/N”Δ0001……9999
Rev.: 01 Page: 22 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 23
Global LCD Panel Exchange Center
10. PACKING
10.1 Carton SPECIFICATIONS
㧔1㧕 7 LCD modules / 1Box
㧔2㧕 Box dimensions : 840㧔㧸㧕×575㧔㨃㧕×535㧔H㧕mm
㧔3㧕 Weight : approximately : 42 kg
10.2 Sea transportation
LCD TV Module
Anti-static Bag
www.panelook.com
Specifications
Doc. No23.
Carton dimensions: 840(L)x575(W)x535(H)mm
Weight : Approx.42Kg
Carton
Cushion(Bottom)
Corner Protector
PE Sheet
PP Belt
Film
(L1350*50*50mm t=3)
(L1150*W850*140mm)
Rev.: 01 Page: 23 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 24
Global LCD Panel Exchange Center
10.3 Air transportation
LCD TV Module
Anti-static Bag
Cushion(Bottom)
Carton
www.panelook.com
Specifications
Doc. No24.
Carton dimensions: 840(L)x575(W)x535(H)mm
Weight : Approx.42Kg
Corner Protector
PE Sheet
PP Belt
Film
Rev.: 01 Page: 24 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 25
Global LCD Panel Exchange Center
10.4 PACKAGING LABEL
www.panelook.com
Specifications
Doc. No25.
Rev.: 01 Page: 25 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 26
Global LCD Panel Exchange Center
11.0 LCD MODULE DRAWING
www.panelook.com
Specifications
Doc. No26.
Rev.: 01 Page: 26 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 27
Global LCD Panel Exchange Center
www.panelook.com
Specifications
Doc. No27.
Rev.: 01 Page: 27 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Page 28
Global LCD Panel Exchange Center
12.0 STORAGE CONDITION
Normal condition: Temperature: 15 ~35 ; Humidity: 30% ~70%кк
13.0 WARRANTY
The warranty period is one year after manufacturing.
14.0 LOT NO. GENERATION
According to the customer supply specification
www.panelook.com
Specifications
Doc. No28.
Rev.: 01 Page: 28 of 28 Date: 2009/02/24
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory!
www.panelook.com
Loading...