Chicco 430, 431, 437 User Manual

The Big Caboose Stand-On Triple

Instruction Manual

These instructions are for the

following Joovy Style #’s:

430, 431, 437

Patent No. 5,622,375

Please read this instruction manual completely before using

this stroller. Keep these instructions for future reference.

Joovy • 2919 Canton Street • Dallas, TX 75226 • [phone] • Fax: [phone]

E-mail: [e-mail] • Website: www.joovy.com

The Big Caboose Stand-On Triple Instruction Manual

Page 1

!

WARNINGS

• Failure to follow these instructions could result in serious injury or
death.

• Never leave child unattended.

• Avoid serious injury from falling or sliding out.

• Always use safety belts and insure that all children are positioned
according to these instructions.

3 Be certain that the stroller is fully opened, BOTH safety latches are in position,

and the wheel brakes are on before allowing children near the stroller.

3The maximum weight of the child that can be seated in each front seat is 40

pounds.

3The rear stand-on platform and the rear bench seat are designed for a child that

is at least 2-1/2 years old but LESS than 45 pounds and 40 inches tall.

3Use of the stroller with three children weighing more than 40 pounds each, or

children weighing a total of more than 125 pounds, will cause excessive wear
and stress on the stroller and may cause a hazardous unstable condition.

3Never use this stroller to carry more than 3 children at the same time.
3Never allow a child to step on the footrest to get into or out of the stroller.
3Do not use the stroller on stairways or escalators.
3Hanging purses, shopping bags, parcels, diaper bags or other accessory items

from the handle bars or any other parts of the stroller may change the balance
of the stroller and cause a hazardous unstable condition.

3The maximum weight that can be carried in the storage basket is 10 pounds.

Excessive weight may result in a hazardous unstable condition.

3 When installing an infant carrier onto the stroller, ALWAYS use the restraining

strap to secure the carrier in place.

3Never allow your stroller to be used as a toy.
3Discard all packaging materials properly. Do not allow children to play with

them.

3To clean, use only mild household soap or detergent and warm water on a

sponge or clean cloth.

3Check your stroller for loose rivets, snaps, worn parts, and torn material or

stitching on a regular basis.

3Discontinue use of the stroller should it malfunction or become damaged.
3Please contact our customer service department to arrange for repair or obtain

replacement parts.

Please do not return this product to the store

If you experience any difculty with the assembly or use of this product, if you have a

question regarding these instructions, please contact our Customer Service Department

at 1-888-597-0992 between the hours of 8:30 am and 5:00 pm Central Time.

Please note: Styles and colors may vary.

Page 2

The Big Caboose Stand-On Triple Instruction Manual

Assembling and Using your Stroller

To insure safe operation of your stroller, please follow these instructions carefully

Unpacking the Product

• Carefully remove stroller and all parts from the box and plastic bag.

• Identify the parts (stroller, front wheels (2), canopy (2), tray (2), car seat carrier
support (2) and documents) with the pictures in Figure 1.

• Discard all packaging materials properly.

• Remove the plastic coverings from all foam handles and any other areas of the
product and discard also.

• DO NOT allow children to play with any packaging materials.

Figure 1

CAUTION

Adult assembly is required for this product.

The Big Caboose Stand-On Triple Instruction Manual

Page 3

Unfolding the stroller

• Keep children away from stroller while unfolding.

• Position the stroller with the handle bar closest to you.

• Release the locking latch located on the right side by lifting the lever off of the
extended rivet. See Figure 2.

• Lift up slightly on the handle of the stroller. Then place one foot onto the rear
platform and pull up and back on the handle until both side frame bars snap into
their locking positions in the frame.

CAUTION: While unfolding the stroller, be careful to keep your ngers from

being pinched by moving parts.

• Lock the safety latches on the lower portion of each side of the stroller by
pushing the lever down over the extended rivet. See Figure 3.

• Ensure that the stroller is completely opened and the safety latches are secured
before ANY use of the stroller.

Figure 2 Figure 3

WARNING

ALWAYS secure the safety latches on the sides of the stroller

when it is in the unfolded use position. This will prevent

collapse of the stroller should the handle trigger locks be

accidentally opened.

Installing the Front Wheels

• Take one of the double wheel sets and locate the small hole in the rotating
bracket that is inside the red lever.

• Push the front axle into this hole and keep pushing the wheel set onto this axle
until you hear an audible click. See Figure 4.

• Pull downward on the wheel set to be sure that it has locked into position on the
axle.

• Repeat this same procedure for the other wheel set.

• When assembled properly, both wheel sets should rotate and roll smoothly
when the stroller is pushed.

Page 4

The Big Caboose Stand-On Triple Instruction Manual

Figure 4 Figure 5

Front Wheel Locks

The front wheels can be either in swivel mode or locked mode.

• To put the front wheels in their locked mode, rst rotate each wheel set so that

the wheels are pointed straight ahead.

• Pull up on the lever to engage the small tab on the lever with the slot in the
plastic frame sleeve. The lever can be either facing forward or rearward to lock
the wheels. See Figure 5.

• To unlock the wheels and put them into swivel mode, push down on the lever to
disengage the tab from the slot.

Installing and Operating the Canopy

• To attach the canopy, position the canopy on the stroller with the thick padded
edge toward the front of the stroller.

• Line up the male ttings on the canopy with the female ttings near the center
of the stroller and push downward until the ttings snap into place. See Figure

6. Pull upward on the canopy sides to be sure both are snapped securely in
place.

• To open the canopy, pull forward on the front edge of the canopy while holding
the back edge in place. Once the canopy is fully opened, push down on BOTH
side hinges to lock it in the open position.

• To close the canopy, unlock the side hinges and pull the front edge toward the
rear of the stroller until folded. See Figure 7.

Figure 6 Figure 7

The Big Caboose Stand-On Triple Instruction Manual

Page 5