Page 1
Boiling Point
118 F (48 C)
Evaporation Rate
(butyl acetate=1)
>1
Flash Point (TCC)
None
Specific Gravity
Liquid
Aerosol
1.27
1.22
Vapor Pressure @68F
Liquid 267 mmHg
Aerosol 175mmHG
Appearance Clear, colorless liquid
Odor
Mild
Solubility in Water
Negligible
Dielectric Breakdown
(ASTM D-877)
Liquid
Aerosol
23.7 kV
8.0 kV
Kauri-Butanol
(KB) Number
100
Shelflife Aerosol - 5 years from DOM
Liquids - 2 years after opening
VOC* Content: Liquid Aerosol
CARB 100% 73%
SCAQMD 1201 g/L 854g/L
Federal 95% 70%
TDS # VVV1614
Technical Data Sheet
Electro-Wash Tri-V
Precision Cleaner
PRODUCT DESCRIPTION
Electro-Wash Tri-V Precision Cleaner is a
nonflammable cleaner that quickly removes flux,
grease, oils, dirt, dust, and other contaminants from
electronic components and assemblies. This solvent
system is engineered to remove all types of oil and
grease while evaporating quickly and leaving no
residues. Tri-V nPB replacement chemistry is a
novel new chemistry that does not contain any npropyl bromide, TCE, any hazardous air pollutants
or ozone depleting compounds.
Powerful cleaning agent to remove flux, oils,
dirt, grease, dust, and other contaminants, one
cleaner for electronics cleaning
Nonflammable, can be used on energized
equipment
Penetrates to clean hard to reach areas
Evaporates quickly and leaves no residues,
minimizes down time
Does not contain n-propyl bromide,
trichloroethylene, or perchloroethylene
Stabilized for metals such as aluminum,
magnesium, titanium, and brass
Noncorrosive, safe for sensitive metals
TYPICAL APPLICATIONS
Electro-Wash Tri-V Cleaner Degreaser removes
flux, dirt, grease, oxidation and other soils from:
Printed Circuit Boards
Relays and switches
Transformers
Electro-Mechanical Devices
Electric Motors and Generators
Electronic Controllers
Circuit breakers
TYPICAL PRODUCT DATA AND
PHYSICAL PROPERTIES
*Volatile Organic Compound (VOC) information is calculated on a
weight basis using the VOC definition of California Air Resources
Board (CARB) Consumer Product Regulations, South Coast Air
Quality Management District (SCAQMD) Rule 102 and the Federal
definition published in 40 CFR 51.100(s).
Page 2
Material
Compatibility
ABS
Non-Compatible
Buna-N
Fair
EPDM
Fair
Graphite
Excellent
HDPE
Excellent
LDPE
Good
Lexan
Fair
Neoprene
Fair
Noryl
Poor
Nylon 66
Excellent
Cross-Linked PE
Excellent
Polypropylene
Excellent
Polystyrene
Non-Compatible
PVC
Excellent
Silicone Rubber
Poor
Teflon
Excellent
Viton
Fair
Performance
Soil Removal – Vapor Degreasing
Lubrizol Corrosion Inhibitor
100% Removal
Unilube All Purpose Grease
80.5% Removal
5W30 Synthetic Oil
100% Removal
Fire Resistant Hydraulic Fluid
100% Removal
Chain Lubricant
100% Removal
Silicone Fluid
100% Removal
Soil Removal – Ultrasonic Cleaning
Lubrizol Corrosion Inhibitor
100% Removal
Unilube All Purpose Grease
100% Removal
5W30 Synthetic Oil
100% Removal
Fire Resistant Hydraulic Fluid
100% Removal
Chain Lubericant
100% Removal
Silicone Fluid
100% Removal
DISTRIBUTED BY:
COMPATIBILITY
Electro-Wash Tri-V Cleaner Degreaser is generally
compatible with most materials used in printed
circuit board fabrication, except acrylics, ABS
resins, polycarbonates and polystyrenes. As with
any cleaning agent solvent/component compatibility
must be determined on a non-critical area prior to
use.
USAGE INSTRUCTIONS
For commercial use only.
Read MSDS carefully prior to use.
For vapor degreasing or ultrasonic cleaning application,
charge sump tank with solvent. For ultrasonic or soak
applications, be sure to cover tank when not in use to
prevent evaporation. For aerosol applications, spray 4 to
6 inches from surface to clean. Wash parts from top to
bottom, allowing the liquid to flush away dirt and
dissolved soils. For precise application use attached
extension tube.
As with all vapor degreaser equipment and processes, observe all
safety precautions, guidelines and operating rules associated with
these units. Failure to do so may put operations personnel at
risk. Avoid excessive vapor losses, loss of refrigeration, excessive boil
sump heat, etc. Make sure all equipment is operated in accordance
with the manufacturer’s guidelines and instructions. If in doubt,
contact your manufacturer immediately.
AVAILABILITY
VVV1614 12 oz Aerosol
VVV114 1 gallon Liquid
VVV514 5 gallon Liquid
VVV5514 53 gallon Liquid
TECHNICAL & APPLICATION
ASSISTANCE
Chemtronics provides a technical hotline to answer your
technical and application related questions. The toll free
number is: 1-800-TECH-401.
NOTE:
This information is believed to be accurate. It is intended for
professional end users having the skills to evaluate and use the
data properly. CHEMTRONICS does not guarantee the
accuracy of the data and assumes no liability in connection
with damages incurred while using it.
Chemtronics and Electro-Wash are registered trademarks of
Chemtronics. All rights reserved. Tri-V
trademarks of Chemtronics. All rights reserved.
All other trademarks herein are trademarks or registered
trademarks of their respective owners.
™
and Controlwipes are
Loading...