Page 1
Boiling Point
99°F (Initial)
Evaporation Rate (butyl acetate=1) >1
Flash Point (TCC)
None
Specific Gravity
1.35
Vapor Pressure @68°F 165 mmHg
Solubility in Water
Negligible
Dielectric Breakdown
(ASTM D-877)
26 kV
VOC* Content: Aerosol
Federal 15%
RoHS Compliant
Shelflife 5 years
CHEMTRONICS
Technical Data Sheet
Pow-R-Wash PN New & Improved!
Electronics Contact Cleaner
TDS # 1677
PRODUCT DESCRIPTION
Pow-R-Wash PN New & Improved!
electronics contact cleaner is a highly effective
solvent cleaner for electrical and electronic
components and assemblies. This cleaning agent
is both nonflammable and safe for use on
plastics and metals.
Same great features as original formulation
but without HCFC-141b
Rapidly cleans dirt, oils, carbon, grease and
other contaminants
Nonflammable
Excellent material compatibility
Displaces moisture
Evaporates fast
Leaves no residues
Enhances electrical signal
Low toxicity
Available with All-Way Spray valve
U.S. Patent 6,746,998
TYPICAL APPLICATIONS
Pow-R-Wash PN New & Improved!
effectively cleans and degreases:
Printed Circuit Boards
Circuit Breakers
Electrical Motors
Potentiometers
Contacts and Relays
Motors and Generators
Selector Switches
Solenoids
TYPICAL PRODUCT DATA AND
PHYSICAL PROPERTIES
CARB 75%
SCAQMD 783 g/L
*Volatile Organic Compound (VOC) information is calculated on a
weight basis using the VOC definition of California Air Resources
Board (CARB) Consumer Product Regulations, South Coast Air
Quality Management District (SCAQMD) Rule 102 and the Federal
definition published in 40 CFR 51.100(s).
COMPATIBILITY
Pow-R-Wash PN New & Improved! has
excellent compatibility with most materials used
in the electronics industry. With any cleaning
agent, compatibility with substrate should be
determined on a non-critical area prior to use.
Page 2
Material
Compatibility
ABS
Not Recommended
Buna-N
Not recommended
EPDM
Good
Graphite
Excellent
HDPE
Good
Kynar
Good
LDPE
Good
Lexan
Good
Neoprene
Good
Noryl
Good
Nylon 66
Excellent
Cross-Linked PE
Good
Polypropylene
Good
Polystyrene
Not Recommended
PVC
Excellent
Silicone Rubber
Good
Teflon
Good
Viton
Not Recommended
Performance
Grease Removal per gram solvent (mg)
New & Improved!
2.2
HFC-based Cleaner
0.50.5
Grease & Lubricating Oil Removal per gram
New & Improved!
7.423.823.8
HFC-based Cleaner
0.50.5
HCFC-141b
HCFC-225
None
Yes
HFC
nPB
Yes
None
to evaluate and use the data properly.
Pow-R-Wash PN
solvent (mg)
Pow-R-Wash PN
USAGE INSTRUCTIONS
For commercial use only.
Read MSDS carefully prior to use.
Spray 4-6 inches from surface to clean. Wash
parts from top to bottom, allowing the liquid to
flush away dirt and dissolved oil and grease. For
precise application use attached extension tube.
AVAILABILITY
ES 1677 12 oz. Aerosol
TECHNICAL & APPLICATION
ASSISTANCE
Chemtronics provides a technical hotline to
answer your tec hnical and application related
questions. The toll free number is: 1-800-
TECH-401.
ENVIRONMENTAL IMPACT DATA
Hydrochlorofluorocarbons (HCFCs) are regulated under the Montreal Protocol
as Class II ozone depleting substances. HCFC-141b is no longer produced in
the US under this legislation. HCFC-225 is planned for production phase-out
in 2015. Hydrofluorocarbons (HFCs) are not currently regulated.
EPA has listed n-propyl bromide (nPB) as an acceptable alternative to ozone
depleting substances in metal, precision, and electronics cleaning under
Section 612 of the Clean Air Act.
NOTE:
This information is believed to be accurate. It is
intended for professional end users having the skills
CHEMTRONICS does no t guarantee t he accuracy of
the data and assumes no liability in connection with
damages incurred while using it.
Chemtronics is a registered trademark of Chemtronics. All
rights reserve d. Pow-R-Wash is a trademark of Chemtronics.
All rights reserved.
All other trademarks herein are trademarks or registered
trademarks of their respective owners.
CHEMTRONICS
8125 COBB CENTER DRIVE
KENNESAW, GA 30152
1-770-424-4888
DISTRIBUTED BY:
REV. C (08/13)
Loading...