Page 1
SAFETY DATA SHEET
Date Printed: 3/16/2018
Page 1 of 8
ACRYLIC PRIMER - GALLON
Chemsol, 12944 Farmington Rd, Livonia, MI 48150
1. Product and Company Identification
Product Name : ACRYLIC PRIMER - GALLON
Product Code : AP-GL
Recommended Use: Please refer to Product Information/Technical Data Sheet.
Company Identification:
Chemsol
12944 Farmington Rd.
Livonia, MI 48150
Information Phone: 888-697-6001
Emergency Phone: 703-527-3887
2. Hazards Identification
EMERGENCY OVERVIEW
NO SIGNAL WORD OR PICTOGRAMS APPLY TO THIS PRODUCT
Potential Health Effects
Eye:
May cause mechanical irritation.
Skin:
May cause mechanical skin irritation.
Ingestion:
Not hazardous in normal industrial use.
Inhalation:
Not expected to cause effects from inhalation.
Chronic (Cancer) Information:
IARC: No component of this product present at levels greater than or equal to
0.1% is identified as probably, possible
or confirmed human carcinogen by IARC.
ACGIH: No component of this product present at levels greater than or equal to
0.1% is identified as a carcinogen or
potential carcinogen by ACGIH.
OSHA: No component of this product present at levels greater than or equal to
0.1% is identified as a carcinogen or
potential carcinogen by OSHA.
NTP: No component of this product present at levels greater than or equal to
0.1% is identified as a known or
anticipated carcinogen by NTP.
Teratology (Birth Defects) Information:
No specific information.
Reproduction Information:
Page 2
SAFETY DATA SHEET
Date Printed: 3/16/2018
Page 2 of 8
ACRYLIC PRIMER - GALLON
Chemsol, 12944 Farmington Rd, Livonia, MI 48150
No specific information.
Aggravation of Pre-Existing Conditions:
No specific information.
3. Composition/Information on Ingredients
Component CAS# % by Wt.
*** NO REPORTABLE QUANTITIES OF HAZARDOUS INGREDIENTS ARE PRESENT ***
4. First Aid Measures
Eyes:
Any material that contacts the eye should be washed out immediately with water.
Flush with water for at least 15
minutes. If easy to do, remove contact lenses. Get medical attention if
symptoms persist.
Skin:
Wash with soap and water. Remove contaminated clothing and shoes. Get medical
attention if symptoms occur.
Ingestion:
Do NOT induce vomiting. Drink 1 or 2 glasses of milk or water to dilute. Call
a poison control center or get medical
attention immediately. Never give anything by mouth to an unconscious person.
Inhalation:
If symptomatic, move to fresh air. Get medical attention if symptoms persist.
Note to Physicians:
INFORMATION NOT AVAILABLE.
5. Fire Fighting Measures
Flammable Properties:
Flash Point: > 200 F Method: n/a
Explosive Limits:
Lower explosive limit: n/a
Upper explosive limit: n/a
Autoignition Temperature:
INFORMATION NOT AVAILABLE.
Hazardous Combustion Products:
INFORMATION NOT AVAILABLE.
Extinguishing Media:
Waterbased material will not burn until all water has boiled away. Residual
solids and/or product container may support
combustion. Use water, foam, dry chemical or CO2.
Firefighting Procedures:
Page 3
SAFETY DATA SHEET
Date Printed: 3/16/2018
Page 3 of 8
ACRYLIC PRIMER - GALLON
Chemsol, 12944 Farmington Rd, Livonia, MI 48150
Special Fire-Fighting Procedures: Wear self-contained breathing apparatus and
protective clothing.
Unusual Fire and Explosion Hazards: High temperatures can cause sealed
containers to rupture due to a build up of
internal pressure. Cool with water spray.
6. Accidental Release Measures
Small Spill:
See Information for Large Spill, below:
Large Spill:
Use personal protective equipment. Ensure adequate ventilation.
Environmental Precautions:
Methods/Materials for Containment and Cleaning Up:
Contain spillage, and then collect with non-combustible absorbent material,
(e.g. sand earth, diatomaceous earth,
vermiculite) and place in container for disposal according to
local/state/federal regulations.
7. Handling and Storage
Handling:
Store in a cool, dry, well ventilated area. Keep containers tightly closed.
EMPTY CONTAINER PRECAUTIONS: Attention! This container is hazardous when
empty. Follow label warnings even after
container is emptied since empty containers may retain product residues. Do not
re-use empty container without
professional cleaning for food, clothing or products. for human or animal
consumption or where skin contact can occur.
Storage:
Prevent unauthorized access.
Store in a well ventilated place.
Keep container tightly closed.
Keep cool.
8. Exposure Controls/Personal Protection
Airborne Exposure Limits:
SEE SECTION 3 FOR THIS INFORMATION
Engineering Controls:
Ventilation: Good general ventilation (typically 10 air changes per hour)
should be used.
Ventilation rates should be matched to conditions.
Ventilation should be explosion proof.
Page 4
SAFETY DATA SHEET
Date Printed: 3/16/2018
Page 4 of 8
ACRYLIC PRIMER - GALLON
Chemsol, 12944 Farmington Rd, Livonia, MI 48150
Supplementary local exhaust ventilation, closed systems, or respiratory
protection may be needed in special
circumstances such as poorly ventilated spaces, spray painting, mechanical
generation of dusts, heating, drying, etc.
Personal Protective Equipment
Respiratory Protection:
If engineering controls do not maintain airborne concentrations to an
acceptable level, an approved respirator must be
worn. In the United States of America, if respirators are used, a program
should be instituted to assure compliance
with OSHA Standard 63 CFR 1152, January 8, 1998. Respirator type: Organic
Vapor.
Skin Protection:
Wear impervious gloves to prevent skin contact.
Recommended Decontamination Facilities: eye bath, washing facilities, safety
shower.
Eye Protection:
Chemical safety goggles or glasses with side shields.
9. Physical and Chemical Properties
Boiling Point: 212 F
Freezing Point: 32 F
Vapor Pressure:
NO INFORMATION AVAILABLE
Vapor Density:
HEAVIER THAN AIR
Solubility in Water:
SOLUBLE
Evaporation Rate: SLOWER THAN ETHER
Specific Gravity: 1.026
pH Range: 8-10
Coating VOC: 0.06 lb/gl
Material VOC: 0.01 lb/gl
Odor:
Mild acrylic odor.
Appearance:
Liquid.
Partition Coefficient:
Page 5
SAFETY DATA SHEET
Date Printed: 3/16/2018
Page 5 of 8
ACRYLIC PRIMER - GALLON
Chemsol, 12944 Farmington Rd, Livonia, MI 48150
INFORMATION NOT AVAILABLE.
10. Stability and Reactivity
Chemical Stability (Conditions to Avoid):
Stable under normal storage/use conditions.
Incompatibility:
Avoid strong oxidizing agents, acids and alkalies.
Hazardous Decomposition Products:
Smoke, soot and carbon dioxide, carbon monoxide.
Hazardous Polymerization:
Will not occur under normal conditions.
11. Toxicological Information
Eye Irritation/Damage:
INFORMATION NOT AVAILABLE.
Skin Irritation/Damage:
INFORMATION NOT AVAILABLE.
Acute Oral Toxicity:
INFORMATION NOT AVAILABLE.
Acute Inhalation Toxicity:
INFORMATION NOT AVAILABLE.
Respiratory/Skin Sensitization:
INFORMATION NOT AVAILABLE.
Carcinogenicity:
INFORMATION NOT AVAILABLE.
Reproductive Toxicity:
INFORMATION NOT AVAILABLE.
Germ Cell Mutagenicity:
INFORMATION NOT AVAILABLE.
Aspiration Toxicity:
INFORMATION NOT AVAILABLE.
STOT-single exposure:
INFORMATION NOT AVAILABLE.
STOT-repeated exposure:
INFORMATION NOT AVAILABLE.
Routes of Exposure:
Inhalation of vapors, skin/eye/mucous membrane absorption, ingestion.
INFORMATION NOT AVAILABLE.
12. Ecological Information
Environmental Toxicity:
INFORMATION NOT AVAILABLE.
Persistance & degradability:
INFORMATION NOT AVAILABLE.
Bioaccumulative Potential:
Page 6
SAFETY DATA SHEET
Date Printed: 3/16/2018
Page 6 of 8
ACRYLIC PRIMER - GALLON
Chemsol, 12944 Farmington Rd, Livonia, MI 48150
INFORMATION NOT AVAILABLE.
Mobility in soil:
INFORMATION NOT AVAILABLE.
Other Adverse Ecological Effects:
No information
13. Disposal Considerations
Waste Disposal Method:
Discharge, treatment or disposal is subject to national, state, or local laws.
The toxicity characteristic (TC) has not
been evaluated by the Toxicity Characteristic Leaching Procedure (TCLP).
Federal Regulations may apply to empty container. State and/or local
regulations may be different.
Of the methods of disposal currently available, it is recommended that an
alternative be selected according to the
following order of preference, based upon environmental acceptability: (1)
recycle or rework, if feasible; (2)
incinerate at an authorized facility; or (3) treat at an acceptable waste
treatment facility.
Be sure to contact the appropriate government environmental agencies if further
guidance is required.
Contaminated Materials:
INFORMATION NOT AVAILABLE.
14. Transport Information
Domestic (Land, DOT), International (Water, IMO/IMDG), International (Air, ICAO)
Road and Rail (ADR/RID), Air (ICAO/IATA), Vessel (IMO/IMDG):
DOT (USA) Shipping Name: Not regulated by DOT/IATA/IMDG
UN/NA ID No: Not regulated by DOT/IATA/IMDG
Hazard Class: Not regulated by DOT/IATA/IMDG
Packing Group: Not regulated by DOT/IATA/IMDG
UN Number:
UN Shipping Name:
INFORMATION NOT AVAILABLE.
Transport Hazard Class:
Packing Group:
Environmental Hazards:
INFORMATION NOT AVAILABLE.
Marine Pollutant:
Components of this product do not appear on the list of Marine Pollutants (49CFR
172.101)
Special Precautions for User:
Page 7
SAFETY DATA SHEET
Date Printed: 3/16/2018
Page 7 of 8
ACRYLIC PRIMER - GALLON
Chemsol, 12944 Farmington Rd, Livonia, MI 48150
INFORMATION NOT AVAILABLE.
15. Regulatory Information
U.S. Federal Regulations:
TSCA: All components of this material are on the
US TSCA 8(b) Inventory or are exempt from listing.
OSHA:
This product is not considered to be hazardous under OSHA's Hazard Communication
Std.
CERCLA: SARA Hazard Category:
INFORMATION NOT AVAILABLE.
Section 313:
"*" Indicates toxic chemical(s) subject to the reporting requirements of
section 313 of Title III and of 40 CFR 372.
International Regulations:
Canadian WHMIS:
INFORMATION NOT AVAILABLE.
Canadian Environmental Protection Act (CEPA):
INFORMATION NOT AVAILABLE.
EINECS:
INFORMATION NOT AVAILABLE.
State Regulations:
INFORMATION NOT AVAILABLE.
Volatile Organic Compounds:
COATING VOC content is being expressed as mass of VOC per unit volume of
coating less water and exempt solvents, where
applicable.
MATERIAL VOC content is the actual weight of VOC per unit volume.
16. Other Information
Date Revised: 12/21/15
Prepared By: Regulatory Compliance
Information Contact: Regulatory Compliance 413-592-4191 ext 106
Manufacturer Disclaimer:
USERS RESPONSIBILITY: A bulletin such as this cannot be expected to cover all
possible individual situations. As the
user has the responsibility to provide a safe workplace, all aspects of an
individual operation should be examined to
determine if, or where, precautions - in addition to those described herein are required. Any health hazard and
safety information herein should be passed on to your customers or employees, as
the case may be.
DISCLAIMER OF LIABILITY: The information contained herein is, to the best of
our knowledge and belief, accurate.
Page 8
SAFETY DATA SHEET
Date Printed: 3/16/2018
Page 8 of 8
ACRYLIC PRIMER - GALLON
Chemsol, 12944 Farmington Rd, Livonia, MI 48150
However, since the conditions of handling and use are beyond our control, we
make no guarantee of results, and assume no
liability for damages incurred by use of this material. All chemicals may
present unknown health hazards and should be
used with caution. Although certain hazards are described herein, we cannot
guarantee that these are the only hazards
which exist. Final determination of suitability of the chemical is the sole
responsibility of the user. No
representations or warranties, either expressed or implied, of merchantability,
fitness for a particular purpose or any
other nature are made hereunder with respect to the information contained herein
or the chemical to which the
information refers. These data relate only to the specific material designated
herein and do not relate to use in
combination with any other material. It is the responsibility of the user to
comply with all applicable federal, state
and local laws and regulations.
End of Material Safety Data Sheet
Loading...