CHASSIS universal (ШАСI унiверсальні) ANSONIC 32HD1 AYA A24HD2405, A28BD2801, A28HD2801W, A32BD32052, A39CD3903 Service manual & schematics

MB55 IDTV

SERVICE MANUAL

TABLE OF CONTENTS

1. INTRODUCTION .......................................................................................................................................... 3

A. GENERAL BLOCK DIAGRAM ........................................................................................................ 4

B. PLACEMENT OF BLOCKS ............................................................................................................... 5

2. T/T2/C/A TUNER (U119) ............................................................................................................................. 6

3. S/S2 TUNER (U125) OPTIONAL ................................................................................................................. 8

4. T2 or S/S2 DEMODULATOR (U106) OPTIONAL ................................................................................... 10

5. LNB SUPPLY and CONTROL IC (U108) WITH SAT OPTIONAL ......................................................... 13

6. AUDIO AMPLIFIER STAGE ..................................................................................................................... 16

A. AD87587 (U124) (OPTIONAL FOR 6W and 8W PRODUCTS) ..................................................... 16

B. TS4962M (U122 & U123) (OPTIONAL FOR 2.5W PRODUCTS) ................................................. 21

C. DRV632 (U121) (OPTIONAL HP DRIVER FOR 2.5W PRODUCTS) ........................................... 22

7. POWER STAGE .......................................................................................................................................... 23

A. RT7278 (U101) (3A) – RT7240 (U101) (5A) ................................................................................... 24

B. MP1498 (U103 & U104) (2A) ........................................................................................................... 26

C. TLV70033 (U107) ............................................................................................................................. 28

D. TLV1117LV15 (U111) ...................................................................................................................... 30

E. LM1117 (U102 & U105) ................................................................................................................... 31

8. SHORT CCT PROTECTION CIRCUIT ..................................................................................................... 33

9. MICROCONTROLLER – Novatek ............................................................................................................. 34

A. NT72567 (MAIN IC) (U112)............................................................................................................. 34

10. USB INTERFACE .................................................................................................................................... 44

11. DDR3 SDRAM K4B1G1646G 1GB G-DIE (U113) ................................................................................ 45

12. SCALER AND LVDS SOCKETS ............................................................................................................ 48

13. PANEL SUPPLY SWITCH CIRCUIT ..................................................................................................... 48

14. SPI FLASH MEMORY ............................................................................................................................. 49

A. 3V 64M-BIT SERIAL FLASH MEMORY WITH DUAL/QUAD SPI & QPI (U114) .................... 50

B. 3V 32M-BIT SERIAL FLASH MEMORY WITH DUAL/QUAD SPI & QPI (U115) .................... 52

15. CONNECTORS ........................................................................................................................................ 55

A. SCART (SC100) ................................................................................................................................ 55

B. HDMI (CN115, CN116) .................................................................................................................... 56

C. USB (CN112) ..................................................................................................................................... 56

D. VGA (CN117) .................................................................................................................................... 57

E. ETHERNET (CN114) ........................................................................................................................ 57

F. COMMON INTERFACE (CI) (CN106) ........................................................................................... 58

16. SERVICE MENU SETTINGS .................................................................................................................. 58

A. VIDEO SETTINGS ........................................................................................................................... 59

B. AUDIO SETTINGS ........................................................................................................................... 59

C. OPTIONS SETTINGS ....................................................................................................................... 60

D. TUNNING SETTINGS ...................................................................................................................... 61

E. SOURCE SETTINGS ........................................................................................................................ 62

F. DIAGNOSTIC ................................................................................................................................... 62

G. USB OPERATIONS .......................................................................................................................... 63

17. SOFTWARE UPDATE ............................................................................................................................. 63

18. TROUBLESHOOTING ............................................................................................................................ 64

A. NO BACKLIGHT PROBLEM .......................................................................................................... 64

B. CI MODULE PROBLEM .................................................................................................................. 65

C. LED BLINKING PROBLEM ............................................................................................................ 67

D. IR PROBLEM .................................................................................................................................... 68

E. KEYPAD OR TOUCHPAD PROBLEM .......................................................................................... 69

F. USB PROBLEMS .............................................................................................................................. 70

G. NO SOUND PROBLEM AT MAIN SPEAKERS ............................................................................ 70

1

H. NO SOUND PROBLEM AT HEADPHONE.................................................................................... 71

. STANDBY ON/OFF PROBLEM ......................................................................................................... 72

J. DVD PROBLEM ................................................................................................................................... 72

K. NO SIGNAL PROBLEM .................................................................................................................. 73

2

1. INTRODUCTION

17MB55 main board is driven by Novatek NT72568. This IC is capable of handling Video and audio

processing, Scaling-Display processing, 3D comb filter, OSD and text processing, LVDS/mini-LVDS

transmitting, channel and MPEG2/4 decoding, integrated DVB-T/C demodulators and media center

functionality.

TV supports PAL, SECAM, NTSC color standards and multiple transmission standards as B/G, D/K, I/I’,

and L/L’ including German and NICAM stereo. Also DVB T, DVB-C is supported internal demodulators of

Novatek IC and DVB-S/S2 and DVB-T2 are supported with external demodulator.

Sound system output is supplying maximum 2X8W (less 10%THD at max output) for stereo 8 speakers.

Also there are 2 more audio power options, 2X6W @8  and 2X2.5W @4 

Supported peripherals are;

 1 RF input VHF I, VHF III, UHF @ 75Ohm (Common)
 1 Sat RF input @ 75Ohm (Optional)
 1 Side AV (CVBS, R/L Audio) (Common)
 1 SCART socket (Common)
 1 PC input (Common)
 2 HDMI 1.3 input (1 HDMI input is common, 1 input is optional)
 1 S/PDIF output (Optional)
 1 Headphone (Common)
 1 Common Interface (Common)
 1 USB (Common)
 1 On-board Keypad (Optional)
 1 External keypad Touchpad/Tact switch (Optional)

3

A. GENERAL BLOCK DIAGRAM

4

B. PLACEMENT OF BLOCKS

p

Power
Con.

DVD
Connector

LVDS

Connectors

Ext
converter
Connector

CI

T2/S2

Dem

USB

RJ45

S/PDIF

RAM

VGA

MAIN

IC

HDMI
Connectors

SCART

Satellite
Tuner

SPI

FL

SAV

Tuner

HP

3­WAY

HP

Amp

LED
CON

SPEAK.
CON

6W

Am

5

2. T/T2/C/A TUNER (U119)

The Si2158 is Silicon Labs' fourth-generation hybrid TV tuner supporting all worldwide terrestrial and

cable TV standards. Requiring no external balun, SAW filters, wire wound inductors or LNAs, the Si2158

offers the lowest-cost BOM for a hybrid TV tuner. Also included are an integrated power-on reset circuit and

an option for single power supply operation. As with prior-generation Silicon Labs TV tuners, the Si2158

maintains very high linearity and low noise to deliver superior picture quality and a higher number of received

stations when compared to other silicon tuners and discrete MOPLL-based tuners. The Si2158 also incorporates

a harmonic-rejection mixer to deliver excellent Wi-Fi and LTE immunity. For the best performance with next-

generation digital TV standards such as DVB-T2/C2, the Si2158 delivers industry-leading phase noise

performance.

Features

 Worldwide hybrid TV tuner

o Analog TV: NTSC, PAL/SECAM
o Digital TV: ATSC/QAM, DVBT2/T/C2/C, ISDB-T/C, DTMB
o 42-1002 MHz frequency range

 Industry-leading margin to A/74,NorDig, DTG, ARIB, EN55020,OpenCable™
 Lowest BOM for a hybrid TV tuner

o No balun at RF input
o Integrated tracking filters requiring no external inductors or SAW filters
o Increased ESD protection on 6 pins

 Best-in-class real-world reception

o Exceeds MOPLL-based tuners
o Lowest phase noise
o High Wi-Fi and LTE immunity

 Low power consumption

o 3.3 V and 1.8 V power supplies
o 3.3 V single-supply option

 Integrated power-on reset circuit
 Single or separate output pins for ALIF/DLIF connection to SoC
 Standard CMOS process
 4 x 4 mm, 28-pin QFN package
 RoHS compliant

6

Block Diagram

Pinning

7

3. S/S2 TUNER (U125) OPTIONAL

The RDA5815s is a fully integrated direct conversion RF front end for DVB-S,DVB-S2&ABS-S,MMDS

digital satellite Reception standard CMOS process. The receiving frequency range is from 250MHz to

2150MHz, and the baseband filter’s bandwidth can be selected from 4MHz to 40MHz with 1MHz step.

The RDA5815s consists of a variable gain LNA, quadrature down converter, variable IF gain amplifiers,

variable low-pass filters, reference oscillator, VCOs, synthesizer and output baseband amplifier to drive

external ADC.

Based on RDA’s some innovative technique, the rda5815s offers excellent phase noise and very low

implementation loss, required for advanced modulation systems such as 8PSK and DVB-S2. This tuner RF IC

does not require a balun and its fully integrated design saves valuable board space and simplifies RF layout.

Features

 Single-Chip RF to baseband Satellite receiver
 CMOS Fully integrated RF front end
 Low noise and wide dynamic range zero IF receiver
 Input frequency range:250 to 2150 MHz
 Input signal level: -100 to 5dBm
 More than 85dB gain control range
 Fully integrated PLL
 Integrated RX VCO
 Integrated baseband LPF with selectable cut-off frequency from 4Mhz to 40Mhz with 1Mhz step
 Integrated LNA with RF AGC
 Integrated reference oscillator
 I2C bus interface
 Automatic gain control
 0.11um RF CMOS technology
 3V to 3.6V operations
 Power consumption of less than 600mW
 Lower profile packages 4X4mm QFN24

8

Block Diagram

Pinning

9

4. T2 or S/S2 DEMODULATOR (U106) OPTIONAL

The Si216X family has 3 different IC which are pin to pin compatible. DVB-S/S2 is supported by Si2166

and DVB-T2 is supported by Si2168.

10

Features

11

Block Diagram

Pinning

12

5. LNB SUPPLY and CONTROL IC (U108) WITH SAT OPTIONAL

Intended for analog and digital satellite receivers/Sat-TV and Sat-PC cards, the LNBH29 series is a

monolithic voltage regulator and interface IC, assembled in QFN16 (3x3) and QFN16 (4x4) specifically

designed to provide the 13 / 18 V power supply and the 22 kHz tone signaling to the LNB down-converter in

the antenna dish or to the multi-switch box. In this application field, it offers a complete solution with

extremely low component count, low power dissipation together with a simple design and I²C standard

interfacing.

This IC has a built-in DC-DC step-up converter that, from a single source from 9 V to 17.5 V, generates the

voltages (VUP) that allow the linear post-regulator to work with a minimum.

Dissipated power of 0.5 W typ. @ 500 mA load (the linear post-regulator drop voltage is internally kept at

VUP - VOUT = 1 V typ.). The IC is also provided with an under voltage lockout circuit that disables the whole

circuit when the supplied VCC drops below a fixed threshold (4.7 V typically). The step-up converter is

provided with a soft-start function which reduces the inrush current during startup. The SS time is internally

fixed at 4 ms typ. To switch from 0 to 13 V and 6 ms typ. to switch from 0 to 18 V.

Features

 Complete interface between LNB and I²C bus
 Built-in DC-DC converter for single 12 V supply operation and high efficiency (typ. 93% @ 0.5 A)
 Selectable output current limit by external resistor
 Compliant with main satellite receiver output voltage specifications
 Accurate built-in 22 kHz tone generator suits widely accepted standards
 EXTM pin, auxiliary 22 kHz modulation input (LNBH29E) extends design flexibility
 22 kHz tone waveform integrity guaranteed also at no load condition
 Low-drop post regulator and high efficiency step-up PWM with integrated power N-MOS allowing low

power losses

 Overload and over temperature internal protection with I²C diagnostic bits
 LNB short-circuit dynamic protection
 +/- 4 kV ESD tolerant on output power pins

13

Block Diagram

Pinning

14

15

6. AUDIO AMPLIFIER ST AGE

AD87587 (U124) (OPTIONAL FOR 6W and 8W PRODUCTS)

A.

The AD87587 is an integrated audio system solution, embedding digital audio process, power stage

amplifier, and a stereo 2Vrms line driver, for driving stereo bridge-tied speakers and headphone. Using I2C

digital control interface, the user can control AD87587’s input format selection, mute and volume control

functions. AD87587 has many built-in protection circuits to safeguard AD87587 from connection errors. It can

provide 20W output power to stereo amplifiers or 40W output power for mono applications.

Features

 16/18/20/24-bit input with I2S, Left-alignment and Right-alignment data format
 PSNR & DR(A-weighting) Loudspeaker: 97dB (PSNR), 105dB (DR) @ 24V
 Multiple sampling frequencies (Fs)

32 kHz/ 44.1 kHz / 48 kHz and

64 kHz/ 88.2 kHz / 96 kHz and

128 kHz/176.4 kHz/192 kHz

 System clock = 64x, 128x, 256x, 384x, 512x, 768x,1024x Fs

256x~1024x Fs for 32 kHz/ 44.1 kHz / 48 kHz

128x~512x Fs for 64 kHz/ 88.2 kHz / 96 kHz

64x~256x Fs for 128 kHz/176.4 kHz/192 kHz

 Supply voltage

3.3V for digital circuit

10V~26V for loudspeaker driver

 Loudspeaker output power for Stereo@ 24V

10W x 2ch into 8_ @ 0.16% THD+N

15W x 2ch into 8_ @ 0.18% THD+N

20W x 2ch into 8_ @ 0.24% THD+N

 Sounds processing including:

Volume control (+24dB~-103dB, 0.125dB/step)

Dynamic range control

Power clipping

Channel mixing

User programmed noise gate

DC-blocking high-pass filter 1

 Anti-pop design
 Short circuit and over-temperature protection

16

 I2C control interface with selectable device address
 Internal PLL
 LV Under-voltage shutdown and HV Under-voltage detection
 Power saving mode
 Dynamic temperature control

Electrical Characteristics

17

18

Pinning

19

20

B. TS4962M (U122 & U123) (OPTIONAL FOR 2.5W PRODUCTS)

21

C. DRV632 (U121) (OPTIONAL HP DRIVER FOR 2.5W PRODUCTS)

The DRV632 is a 2-VRMS pop-free stereo line driver designed to allow the removal of the output dc-

blocking capacitors for reduced component count and cost. The device is ideal for single-supply electronics

where size and cost are critical design parameters.

The DRV632 is capable of driving 2 VRMS into a 10-k load with 3.3-V supply voltage. The device has

differential inputs and uses external gain-setting resistors to support a gain range of ±1 V/V to ±10 V/V, and

gain can be configured individually for each channel. The DRV632 has built-in active-mute control for pop-free

audio on/off control. The DRV632 has an external under voltage detector that mutes the output when the power

supply is removed, ensuring a pop-free shutdown.

The DRV632 does not require a power supply greater than 3.3 V to generate its 5.6-Vpp output, nor does it

require a split-rail power supply. The DRV632 integrates its own charge pump to generate a negative supply

rail that provides a clean, pop-free ground-biased 2-VRMS output. The DRV632 is available in a 14-pin

TSSOP.

Pin Description and Package View

22

Electrical and Operating Characteristics

7. POWER STAGE

The DC voltages required for different blocks of the main board and panel are provided by main power

supply unit. MB55 chassis can operate with PW05, IPS60, IPS61, IPS70, IPS20, IPS11, IPS16, IPS17, IPS19,

PW25, PW26, PW03, PW04, PW06, and PW07 as main power supply and also with 12V adaptor. The main

difference from previous projects MB55 uses the 2x6 pin power connector. And only 12V_STBY supply is

necessary to provide all required board supplies. As the main power board has 2x6 pin option, MB55 can

operate with above given power boards.

Which power board can be used for board to board or cable connection?

Board to board (BTB): PW05, IPS60, IPS61, IPS70, IPS11, IPS16, IPS17, IPS19
Power Cable: PW25, PW26, PW03, PW04, PW06, PW07, IPS20,

The power supplies generate 12V standby mode DC voltage and 24V system voltage only for audio IC

voltage in necessary situations. Power stage which is on-chassis generates 5V, 3V3 stand by voltage and 12V,

5V, 3V3, 2.5V, 1.5V, 1.2 and 1.15V supplies for other blocks of the chassis. The power block diagram with the

23

blocks power requirements of MB55 is given below. And also you can find below the details about the Step

down IC’s and LDO’s which are used in MB55 main board.

Power Management

A. RT7278 (U101) (3A) – RT7240 (U101) (5A)

The RT7278/RT7240 is a synchronous step down converter with Advanced Constant On-Time (ACOT)

mode control. The ACOT provides a very fast transient response with few external components. The low

impedance internal MOSFET supports high efficiency operation with wide input voltage range from 4.5V to

17V. The proprietary circuit of the RT7278/RT7240 enables to support all ceramic capacitors. The output

voltage can be adjustable between 0.8V and 8V. The soft-start is adjustable by an external capacitor.

Features

 ACOT Mode Enables Fast Transient Response
 4.5V to 17V Input Voltage Range
 3A Output Current
 60mOhm Internal Low Site N-MOSFET
 Advanced Constant On-Time Control
 Support All Ceramic Capacitors
 Up to 95% Efficiency

24

 700kHz Switching Frequency
 Adjustable Output Voltage from 0.8V to 8V
 Adjustable Soft-Start
 Cycle-by-Cycle Current Limit
 Input Under Voltage Lockout
 Thermal Shutdown Protection

Pinning

25

Electrical Characteristics

B. MP1498 (U103 & U104) (2A)

The MP1498 is a high-frequency, synchronous, rectified, step-down, switch-mode converter with built-in

internal power MOSFETs. It offers a very compact solution to achieve 2A continuous output current with

excellent load and line regulation over a wide input supply range. The MP1498 has synchronous mode

operation for higher efficiency over the output current load range. Current-mode operation provides a fast

transient response and eases loop stabilization. Protective features include over-current protection, thermal

shutdown, and external SS control.

26

Features

 Wide 4.5V-to-16V Operating Input Range
 100m/40m Low RDS(ON) Internal Power MOSFETs
 Proprietary Switching-Loss–Reduction Technique
 High-Efficiency Synchronous Mode Operation
 Fixed 1.4MHz Switching Frequency
 Can Synchronize to a 300kHz-to-3MHz External Clock
 Externally-Programmable Soft-Start
 OCP and Hiccup
 Thermal Shutdown
 Output Adjustable from 0.8V
 Available in an 8-pin TSOT-23 Package

Pinning

27

Electrical Characteristics

C. TLV70033 (U107)

The TLV700xx series of low-dropout (LDO) linear regulators are low quiescent current devices with

excellent line and load transient performance. These LDOs are designed for power-sensitive applications. A

precision band gap and error amplifier provides overall 2% accuracy. Low output noise, very high power-

supply rejection ratio (PSRR), and low dropout voltage make this series of devices ideal for most battery-

operated handheld equipment. All device versions have thermal shutdown and current limit for safety.

Features



23

Very Low Dropout:

43 mV at I

85 mV at I

175 mV at I

OUT

OUT

OUT

 2% Accuracy

Q

 Low I

: 31 A

= 50 mA, V

= 100 mA, V

= 200 mA, V

OUT

OUT

OUT

= 2.8 V

= 2.8 V

= 2.35 V

 Available in Fixed-Output Voltages from 1.2 V to 4.8 V
 High PSRR: 68 dB at 1 kHz

28

Pin Description and Package View

Electrical Characteristics

29

D. TLV1117LV15 (U111)

The TLV1117LV series of low-dropout (LDO) linear regulators is a low input voltage version of the

popular 1117 voltage regulator. The TLV1117LV is an extremely low-power device that consumes 500 times

lower quiescent current than traditional 1117 voltage regulators, making it suitable for applications that

mandate very low standby current. The TLV1117LV family of LDOs is also stable with 0 mA of load current;

there is no minimum load requirement, making it an ideal choice for applications where the regulator is

required to power very small loads during standby in addition to large currents on the order of 1 A during

normal operation. The TLV1117LV offers excellent line and load transient performance, resulting in very small

magnitude undershoots and overshoots of output voltage when the load current requirement changes from less

than 1 mA to more than 500 mA.

Features

 1.5% Typical Accuracy
 Low IQ: 100 A (max)
 500 times lower than standard 1117 devices
 VIN: 2.0 V to 5.5 V
 Absolute maximum VIN = 6.0 V
 Stable with 0-mA Output Current
 Low Dropout: 455 mV at 1 A for VOUT = 3.3 V
 High PSRR: 65 dB at 1 kHz
 Minimum Ensured Current Limit: 1.1 A
 Stable with Cost-Effective Ceramic Capacitors:
 With 0- ESR
 Thermal Shutdown and Over current Protection

Pin Description and Package View

30

Electrical Characteristics

E. LM1117 (U102 & U105)

The LM1117 is a series of low dropout voltage regulators with a dropout of 1.2V at 800mA of load current.

It has the same pin-out as National Semiconductor’s industry standard LM317. The LM1117 is available in an

adjustable version, which can set the output voltage from 1.25V to 13.8V with only two external resistors. In

addition, it is also available in five fixed voltages, 1.8V, 2.5V, 2.85V, 3.3V, and 5V. The LM1117 offers

current limiting and thermal shutdown. Its circuit includes a zener trimmed band gap reference to assure output

voltage accuracy to within ±1%. The LM1117 series is available in SOT-223, TO-220, and TO-252 D-PAK

packages. A minimum of 10F tantalum capacitor is required at the output to improve the transient response

and stability.

31

Features

 Available in 1.8V, 2.5V, 2.85V, 3.3V, 5V, and Adjustable Versions
 Space Saving SOT-223 Package
 Current Limiting and Thermal Protection
 Output Current 800mA
 Line Regulation 0.2% (Max)
 Load Regulation 0.4% (Max)
 Temperature Range
 LM1117 0°C to 125°C
 LM1117I 40°C to 125°C

Pin Description and Package View

Electrical Characteristics

32

8. SHORT CCT PROTECTION CIRCUIT

Short circuit protection is necessary for protecting chassis and main IC against damages when any Vcc

supply shorts to ground. Protect pin should be logic high while normal operation. When there is a short circuit

protect pin should be logic low. After any short detection, SW forces the system to go into standby mode and to

indicate short circuit detection LEDs on LED card blinked in a determined sequence.

33

9. MICROCONTROLLER – Novatek

A. NT72567 (MAIN IC) (U112)

The NT72567 is an integrated digital TV system-on-chip which compliants with variety ATV as NTSC,

PAL and SECAM, and DTV standards as ISDB-T, DVB-T/-C, ITU-T J.83B, integrates DTV and multi-media

AV decoder, SIF demodulator, and support A/V post-processing.

The integrated video ADC and video decoder support PC VGA port, YPbPr, SCART, CVBS and S-Video

Input. Regarding the tuner input, The digital VIF performs the universal analog TV demodulation (NTSC, PAL,

and SECAM), including IF processing, AGC, video demodulation, and second sound IF generation (SSIF). The

video decoder supports universal TV video format. The integrated audio ADC supports stereo audio input

corresponding to video input sources. The integrated TV sound decoder supports universal TV sound format.

34

The advanced picture quality and color engine create more vivid image impression than ever. The HDMI

receiver v1.4a supports deep color, CEC features and 3D formats. The USB high speed host supports updating

firmware code, multi-media playback from the external USB flash devices.

The standby controller can operate solely from the main system, powered by the standby power source from

power module, consumes as low current as possible. It meets the requirement of Green appliance.

General Features:

 Internal High-Speed ADC

o Integrated triple high speed ADCs/ PLL to support both YPbPr and RGB format signal
o 10-bits data resolution
o Maximum conversion up to 165 MSPS
o Support 0.7 ~ 1.0 Volts analog RGB/YUV input
o Guaranteed No Missing Code
o 3:1 analog input MUX
o Ultra Low PLL Jitter @210MHz
o Supports both non-interlaced and interlaced input signals
o Digital PLL with 64 steps of phase adjustment for each channel

 Analog Video Decoder

o Clamp and AGC (Automatic Gain Control) circuit to support 0.5 to 1.6V analog input signal
o Support multi-standards, macro-vision detection and related status report
o Embedded Teletext Level 2.5 / Close Caption and other VBI Decoder
o 2D and 3D adaptive Comb Filter for better Y/C Separation
o Maximum two SCART input
o Support VPS signal decode for EU channel sorting purpose

 Digital VIF Support general IF, 38.9 MHz, 45.75 MHz, and 33.1 MHz (can tuner with a digital-SAW

filter)

35

o Support Low IF, 5 ~ 8 MHz (silicon tuner)
o Support dual AGC (RF and IF) with programmable PWM
o Flexible channel bandwidth (6 MHz, 7 MHz, and 8 MHz)
o Digital video/audio splitting

 SIF Decoder

o NICAM-BG/DK/I/L, A2-BG/DK/I, BTSC, EIA-J, A2-M, AM SECAM-L
o Automatic standard and mode detection
o Automatic carrier mute and automatic NICAM fall back
o 32KHz audio output

 ISDB-T(SE2 confirmed)

o ISDB-T standard ARIB STD-B31
o SBTVD standard ABNT NBR 15601
o Receiver specifications ARIB STD-B21 & ABNT NBR 15604 fulfilled
o Channel bandwidth 6, 7 & 8 MHz supported
o Zero IF & nonzero IF with configurable mixing frequency
o Single IF AGC or dual RF/IF AGC controls with Delta modulation
o Partial (1-segment) & full (13-segment) reception supported
o Non-hierarchical (single-layer) & hierarchical (layers A/B/C) reception supported

 DVB-T Demodulator

o Compliant with ETSI EN 300 744, NorDig Unified V.2, and D-book V.6
o Automatic transmission parameter detection

 2K/8K modes
 Guard intervals of 1/4, 1/8, 1/16, 1/32
 All hierarchical and non-hierarchical constellations
 Code rates of 1/2, 2/3, 3/4, 5/6, 7/8

o Single IF AGC or dual RF/IF AGC controls
o Direct IF (36.167MHz or 43.75MHz) or low IF (4.57MHz) support
o Impulsive noise reduction
o Adjacent channel interference (ACI) filter and Co-channel interference (CCI) suppression
o RF signal strength monitoring
o Support power saving mode

 DVB-C Demodulator

Compliant with ETSI EN 300 429 DVB-C and ITU-T J.83 annex A/C Standards

o
o Support Direct IF/Low IF Sampling
o Programmable Digital Mixer
o Single IF AGC or dual RF/IF AGC controls

36

o Variable Symbol Rate 1 MBaud ~ 7.2 MBaud Support
o Matched Filters (Roll-off factor= 0.15, 0.13)
o Superior Carrier Recovery, Acquisition range up to 5%(Symbol Rate)
o Robust Dual Adaptive Blind Equalizer (short echo/long echo)
o High monitoring capabilities

 C/N ratio (SNR)
 Signal Power
 RS uncorrectable error Number

 Digital Video Decoder

o Built-in multi-standard video codec
o Support pixel format YUV420 only for all video codec except JPEG
o H.264 Constrained Baseline/Main/High Profiles @ 1080p30 (Level 4.0 and Level 4.1 under

limited bit-rate).

o MVC Stereo High Profile @ 1080p48 and 720p120
o VP8 All Profiles @ 1080p30.
o AVS (Optional) Jizhun Profile @ 1080p30 (Level 6.0).
o VC-1(Optional) Simple/Main/Advanced Profiles @ 1080p30 (Level 3.0).
o Real Video (Optional) 8/9/10 @ 1080p30.
o MPEG-4 Simple/Advanced Simple Profiles @ 1080p30.
o H.263 Profile 0 @ 1080p30.
o DivX 3/4/5/6 @ 1080p30(Optional).
o Support GMC with 1 warp point.
o Sorenson Spark @ 1080p30.
o MPEG-2 Main Profile @ 1080p30.
o MPEG-1 @ 1080p30.
o JPEG baseline sequential mode.

 Support pixel formats in YUV420, YUV422 and YUV444.
 Support Motion JPEG @ 1080p30.

 Condition Access

o Support Common Interface
o Support Common Interface Plus
o Built-in Cryptograph Engine for conditional access and CI Plus
o Meet Common Interface Plus’s Robust and Compliance rule

37

 Copy Protection Engine

o Support Cryptograph Key Protection
o Support Demux Key Protection
o Support HDCP Key Protection

 External DRAM Interface 16 bit DDR3-SDRAM bus

o 16bit DDR3-SDRAM bus
o External DRAM Clock up to 533/666/800MHz
o Spread Spectrum PLL for EMI reduction
o Up to 4 Gb of DDR3-SDRAM density
o Embedded 1Gb/2Gb DDR3-SDRAM(MCM or internal DDR)

 De-Interlacing

o Support progressive scan 24Hz to 85Hz Frame Rate Conversion
o 5th generation High performance Motion- Adaptive De-interlacing
o 5th generation Diagonal Edge Enhancement for smoothing edge outline
o Automatic Video Source Detection
o Support Inverse 3:2/2:2 pull down and multiple cadence for film stream
o Scene Change Detection
o Built-in Anti-Cross color to remove abnormal color performance
o Built-in Color Performance stabilizer for SECAM video format
o Built-in Region Classifier engine to get flicker free image quality

 Visual Effect Processor

o Built-in Advanced Super Resolution
o 5th generation Advanced Scaling Up Engine
o Support Nonlinear Scaling

38

o 5th generation LTI/CTI function
o Support 5th Color Engine
o Global Brightness, Contrast, Hue Saturation and Intensity Adjustment
o Built-in I-Gamma and Black Stretch for Automatic Contrast Adjustment
o Support sRGB and xvYCC Adjustment Standard
o De-blocking, De-Mosquito, Temporal and Spatial Noise Filter
o Adaptively determine 3D noise filter for different noise level

o Linear Gamut Remapping
o SD2HD detection and Processing
o DP Meter for Dynamic backlight Control

 Display Processor

o Embedded dual 10 bit LVDS transmitter
o Supports single pixel / dual pixel output
o Dithering function supports 30-bit quality for 24 bit or 18-bit panel
o Optional Frame Sync or Free Run display synchronization modes
o Display Resolution up to 1920x1200@60Hz and 1920x540@120Hz HDTV format
o Built-in Gamma Correction for different type display device
o Supports Pivot (H flipping display)
o V flipping is in LBM
o Support H/V sync out

 2D-Graphic Engine / OSD

o Bitmap Operation

 ARGB/RGBA format
 Copy/Color expansion
 Logic Operation
 Copy with alpha blending (only 16/32 bit color mode)
 Source and destination area could be overlapped
 Color key for the transparence effect
 12 Raster Operation (ROP) rules

o Fill Rectangle

 Color fill
 Gradient fill

o Scaling

39

 Bicubic Algorithm

o 8/16/32-bit OSD Architecture
o 3 OSD Layers, each with 2 exclusive regions
o 5 levels of transparency with pixel or frame based operation (background, video, Plane3, Plane2,

Plane1)

Programmable width & height to meet LCD/TV's resolution exactly

o
o H Bicubic scaling up and V Bilinear scaling

 Audio Interface

o Built-in 5:1 audio ADC input mux (MAX. sampling rate 48KHz)
o Built-in 2 audio DAC output (MAX. sampling rate 48KHz)
o Built-in 3 I2S Output format for Power-Stage Amplifier
o S/PDIF output supported

 Audio Processor

o Dedicated DSP to decode compressed audio
o 16KB instruction, 48KB data cache
o Support ADPCM, MP3 decoder
o Support AC3(Optional) / HE-AAC(Optional) audio format
o Support Dolby2 Digital (Optional)/ WMA(Optional) audio format
o DTS3(Optional)/ DTS-LBR3(Optional)
o Automatic volume control
o Virtual surround

 High performance 24Kec 32-bit CPU

o Built-in Memory Management Unit
o 16KB instruction and 16KB data cache
o 128K L2 Cache

 Stand-by Controller

o Support VGA / IR / Keypad / CEC/DDCCI wake-up
o Built-in Turbo 8051 for stand-by application usage
o Built-in Low Voltage Reset for brown out
o Built-in EDID for saving system BOM cost
o System power control

 TV encoder with built-in video DAC

o Built-in 10-bit DAC for CVBS Analog Video output.
o Support HD resolution input with high quality scaling down engine
o Support TTX/ CC/ WSS/ VPS/ CGMS-A/Macrovision insertion

40

 Ethernet MAC

o Built-in 10/100 Ethernet MAC
o Compatible with IEEE 802.3
o Support RMII interface with front-end Ethernet PHY

 USB host/device controller with built in transceiver

o 2 USB host ports
o Compliant with USB Specification Revision 2.0
o Support high-speed, full-speed and low-speed devices
o Integrated USB 2.0 transceiver

 HDMI receiver

- Three HDMI Input ports(Port A is HDMI &MHL combo port)

- HDMI 1.4a Compliant

- Integrated HDCP 1.1 cipher engine for Content Protection

- Support High-Level CEC Command for Easy Link between CE equipments.

- Support Deep Color for more pixel depth information

- Support xvYCC for wide color gamut application

- 3D support

- Support Audio format including

- Support ARC (Audio Return Channel)

 MHL receiver

- CBUS

 2~8 -channel 32-192KHz

 DDC packet
 MSC(MHL Sideband Channel) packet
 Vendor-specific packet

- VBUS

 Memory controller

o NAND type flash

41

 RS Support
 RS Read Free Run
 4Bytes/512Byte ECC

 3D support

 Timing Fine Tune

o eMMC 4.41(Optional) type flash
o SPI NOR type flash

o 2D-to-3D real time conversion
o Support mandatory HDMI 1.4a 3D video format and timing

 3DFP
 3D SBS
 3DTB

o Support 100/120Hz shutter glasses half FHD 3D TV panel
o Line interleave for directly drive 60Hz PR 3D LCD
o Intermediate formats output support external 3D processor
o Support separate and programmable L/R sync pin
o Support Shutter glasses control signals

 L/R sync signal phase, polarity, duration programmable
 Samsung IR protocol support

 LZ77 Decompression engine

o 250 MByte/sec
o MAX search window buffer 512 byte
o MAX search length 18

 LED backlight

o PWM x 8
o PWM delay and duty is adjustable independently
o PWM delay is phase-locked to VS
o support PWM frequency = 1 x VS , 2 x VS frequency

 TCON

42

o support I2C/SPI LED-driver interface

o Support fail-safe mode function.
o Support Built-in 2-port 6-pair mini-LVDS output.
o Support Resolution: FHD(1920X1080) & HD(1366X768)
o Support over-driving function for improving LCD response time.

o Support data compression function for reducing frame data storage.
o Support gamma function that provides 12-bit full range programming.
o Support Built-in spread spectrum clock generator to lower the EMI issue.
o Support CABC(Content Adaptive Brightness Control) function
o Support mini-LVDS output Data-Skew control.
o Support 1 line, 2 line, 1+2 line, and frame inversion mode.
o support 8bit and 6 bit
o support 3D frame-sequential output and 2D output
o support 50Hz, 60Hz, 100Hz, 120Hz

 Miscellaneous

o Built-in UART controller
o LFBGA 21x21 - 576 balls

 Electrical and Physical Characteristics

o Single 12 MHz clock input crystal
o 1.15/1.5/2.5/3.3V power supply
o Power standby mode
o LFBGA-576

43

Novatek NT72567 Block Diagram

10. USB INTERFACE

Main Concept IC has integrated 2 USB 2.0 interface. One of them is used for Ethernet function, the other

one is used for USB connectivity for last user. Last user can play video, picture and audio files. Also digital

channels can be record to external storage device by this interface. All SW files can be updated with interface.

USB circuit has 3 main parts

o Integrated USB 2.0 Host interface of NT72567 (U112)
o Protection IC (U109) (optional*)
o Over Current Protection IC (U110) (optional*)

* The max current that can be supplied for USB loads does not cause a danger for main IC. So, these ICs are

used as optional.

44

11. DDR3 SDRAM K4B1G1646G 1GB G-DIE (U113)

The 1 GB DDR3 SDRAM G-die is organized as a 8Mbit x 16 I/Os x 8banks device. This synchronous

device achieves high speed double-data-rate transfer rates of up to 2133Mb/sec/pin (DDR3-2133) for general

applications. The chip is designed to comply with the following key DDR3 SDRAM features such as posted

CAS, Programmable CWL, Internal (Self) Calibration, On Die Termination using ODT pin and Asynchronous

Reset . All of the control and address inputs are synchronized with a pair of externally supplied differential

clocks. Inputs are latched at the cross point of differential clocks (CK rising and CK falling). All I/Os are

synchronized with a pair of bidirectional strobes (DQS and DQS) in a source synchronous fashion. The address

bus is used to convey row, column, and bank address information in a RAS/CAS multiplexing style. The DDR3

device operates with a single 1.5V ± 0.075V power supply and 1.5V ± 0.075V VDDQ. The 1 GB DDR3 G-die

device is available in 96ball FBGA(x16).

Features

• JEDEC standard 1.5V ± 0.075V Power Supply

• VDDQ = 1.5V ± 0.075V

• 400 MHz f

800MHz fCK for 1600Mb/sec/pin, 933MHz fCK for 1866Mb/sec/pin, 1066MHz fCK for 2133Mb/sec/pin

45

for 800Mb/sec/pin, 533MHz fCK for 1066Mb/sec/pin, 667MHz fCK for 1333Mb/sec/pin,

CK

• 8 Banks

• Programmable CAS Latency (posted CAS): 5,6,7,8,9,10,11,13,14

• Programmable Additive Latency: 0, CL-2 or CL-1 clock

• Programmable CAS Write Latency (CWL) = 5 (DDR3-800), 6 (DDR3-1066), 7 (DDR3-1333), 8

(DDR3-1600), 9(DDR3-1866) and 10(DDR3-2133)

• 8-bit pre-fetch

• Burst Length: 8 (Interleave without any limit, sequential with starting address “000” only), 4 with t

4 which does not allow seamless read or write [either on the fly using A12 or MRS]

• Bi-directional Differential Data-Strobe

• Internal (self) calibration: Internal self calibration through ZQ pin

• (RZQ: 240 ohm ± 1%)

• On Die Termination using ODT pin

• Average Refresh Period 7.8us at lower than TCASE 85°C, 3.9us at 85°C < T

CASE

 95 °C

• Support Industrial Temp (-40 ~ 85°C)

• Asynchronous Reset

• Package: 96 balls FBGA - x16

• All of Lead-Free products are compliant for RoHS

• All of products are Halogen-free

CCD

=

46

Pinning

47

12. SCALER AND LVDS SOCKETS

LVDS Sockets Block Diagram

13. PANEL SUPPLY SWITCH CIRCUIT

This switch is used to open and close panel supply of TCON. It is controlled by port of main µcontroller.

Also, with this circuit, the panel power sequences could be adjusted correctly. 2 panel supply options are

connected to the circuit. All of them are optional according to panels.

48

14. SPI FLASH MEMORY

49

A. 3V 64M-BIT SERIAL FLASH MEMORY WITH DUAL/QUAD SPI & QPI (U114)

General Description

Features

50

Block Diagram

51

Pinning

B. 3V 32M-BIT SERIAL FLASH MEMORY WITH DUAL/QUAD SPI & QPI (U115)

General Description

52

Features

53

Block Diagram

54

Pinning

15. CONNECTORS

A. SCART (SC100)

55

B. HDMI (CN115, CN116)

C. USB (CN112)

Pin Name Cable

color

1 VBUS Red 5 V

2 D- White

(gold*)

3 D+ Green Data+

4 GND Black

(blue*)

Description

Data 

Ground

56

D. VGA (CN117)

E. ETHERNET (CN114)

57

F. COMMON INTERFACE (CI) (CN106)

16. SERVICE MENU SETTINGS

In order to reach the service menu, first press “MENU” button, then press “4725” from the remote

controller keypad.

Following setting options be seen as below.

58

A. VIDEO SETTINGS

B. AUDIO SETTINGS

59

C. OPTIONS SETTINGS

OPTION 1

OPTION 2

60

OPTION 3

D. TUNNING SETTINGS

61

E. SOURCE SETTINGS

F. DIAGNOSTIC

62

G. USB OPERATIONS

USB Operations is used for updating panel, audio, video, etc. configuration parameters on the main

software. Necessary files should be copied in the USB stick root directory not in a file. In addition, the tool

called mksquashfs needs to be copied in the root directory. Below files can be updated;

 ptf.ptf
 PQF.bin
 PCF.pcf
 preset_list.sdx
 AQ.bin
 bornova_hwprofile.bin
 bornova_swprofile.bin
 logo.bin
 hdmiedid.bin
 vgaedid.bin
 PRODUCTION_CREDENTIALS.bin
 hdcpkey.bin

After making ready USB stick contents, plug the stick in to TV and run Usb Operations in one of the two ways,

via service menu or running test tool command of "USBOPERATIONS"

The update will be finished within couple of seconds. If everything goes well, you will get following messages

in bold format at the uart output,

>>> Update RO success <<<
...
>>> Update ROFIX success <<<

17. SOFTWARE UPDATE

Software update procedure can be done by following these steps below:

1. The format of the USB stick, which will be used in software update, should be in FAT32.

2. “bornova_usb_update.bin” and “bornova_usb_update.scr” files should be copied in the root directory.

3. Plug in USB stick to the TV when it is powered off.

4. Press and hold the “OK” button in the remote controller while the TV is turned off then turn on the TV.

When IR LED starts to blink, release the “OK” button and wait for installation. It may take several

minutes.

63

This procedure finishes successfully with First Time Installation screen and then required selections will be

done

18. TROUBLESHOOTING

A. NO BACKLIGHT PROBLEM

Problem: TV is working, IR led is OFF but there is no picture and backlight on the panel.

Possible causes: BACKLIGHT_ON/OFF pin, DIMMING pin, backlight supply, STBY ON/OFF pin

Solution: BACKLIGHT_ON/OFF pin should be high in backlight open position. If it is low, please

check Q100 and panel cables.

DIMMING pin should be high or square wave in backlight open position. If it is low, please check S128 for

Novatek side and panel or power cables, connectors.

64

For W/ADAPTOR models, backlight power supply should be in panel specs. Please check CN102 and related

connectors for power supply cards.

STBY_ON/OFF should be low for standby on condition, please check R104.

B. CI MODULE PROBLEM

65

Problem: CI is not working when CI module inserted.

Possible causes: Supply, supply control pin, detect pins, mechanical positions (short circuit) of pins.

Solution: CI supply should be 5V when CI module inserted. If it is not 5V please check

CI_POWER_CTRL, this pin should be low.

Please check mechanical positions of CI module in case a short circuit.

Detect ports should be low. If it is not low, please check CI connector pins, CI module pins and

VCC_PCMCIA.

66

C. LED BLINKING PROBLEM

Problem: LED blinking, no other operation

Possible causes: A short circuit on Vcc voltages.

Solution: Protect pin should be logic high while the TV is in normal operation. When there is a short

circuit, protect pin will be logic low. If you detect logic low on protect pin, unplug the TV set and

control voltage points with a multimeter to find the shorted voltage to ground.

67

D. IR PROBLEM

Problem: IR or LED is not working.

Possible causes: No supply on the LED card.

Solution: Please check LED card supply.

68

E. KEYPAD OR TOUCHPAD PROBLEM

Problem: Keypad or Touchpad is not working.

Possible causes: No supply on the Keypad card.

Solution: Please check Keypad supply and KEYBOARD pin.

69

F. USB PROBLEMS

Problem: USB is not working or no USB Detection.

Possible causes: No supply on the USB Interface circuit.

Solution: Please check USB Supply, it should be nearly 5V.

G. NO SOUND PROBLEM AT MAIN SPEAKERS

Problem: No audio at main speaker outputs.

Possible causes

VDD_AUDIO_PWR. A problem in headphone connector or headphone detect circuit.

Solution: Please check supply voltages of VDD_AUDIO, 5V_VCC, 3V3_VCC, 12V_VCC and

VDD_AUDIO_PWR with a voltage-meter. Please check headphone connector and headphone detect

circuit (when headphone is connected, speakers are automatically muted). Measure voltage at

HP_DETECT pin, it should be 3.3v.

: No supply voltages on VDD_AUDIO, 5V_VCC, 3V3_VCC, 12V_VCC or

70

H. NO SOUND PROBLEM AT HEADPHONE

Problem: No audio at headphone output.

Possible causes: No supply voltages on 5V_VCC, 3V3_VCC or a problem in headphone connector or

headphone detect pin.

Solution: Please check supply voltages of 5V_VCC, 3V3_VCC with a voltage-meter. Please check

headphone connector and headphone detect pin when the headphone is plugged in. Measure voltage at

HP_DETECT pin, it should be low state (0V). A headphone sign should be seen in OSD screen when

volume up or down button is pressed in the remote controller.

71

İ. STANDBY ON/OFF PROBLEM

Problem: Device cannot boot, TV hangs in standby mode.

Possible causes: No power supply or a problem about software.

Solution: Please check 12V_VCC, 5V_VCC and 3V3_VCC with a voltage-meter. Try to update TV with latest

SW. Additionally it is good to check SW printouts via hyper-terminal (or TeraTerm). These printouts may give

a clue about the problem.

J. DVD PROBLEM

Problem: DVD is not working.

Possible causes

Solution

namely 12V_VCC.

: Please check that DVD source is selected in Service menu. Please check supply voltage of DVD

: A problem in Service menu or no DVD supply voltage.

72

K. NO SIGNAL PROBLEM

Problem: No signal in TV mode.

Possible causes: A problem in Service menu or no tuner supply voltage.

Solution: Please check tuner supply voltage; 3V3_TUN. Check tuner options are correctly set in Service menu.

Check AGC voltage at IF_AGC pin of tuner, it should be more than 2V.

73

1 2 3 4 5 6 7 8

AD9

USB_DP
USB_DM

USB_ETH_DP
USB_ETH_DM

PROTECT

R141

10k

DDR_RST#

R305

12k

A

AE19

STBC_GPIO0[BS6]

1k

R117

AA18

STBC_GPIO1[BS7]

Y17

STBC_GPIO2[BS8]

Y19

STBC_GPIO3[BS9]

AD19

STBC_GPIO4[BS15]

AC19

STBC_GPIO5

AC24

STBC_GPIO6[BS11]

AD25

STBC_GPIO7[BS12]

AA23

STBC_GPIO8[BS13]

AC25

STBC_GPIO9[BS14]

AB24

SAR_ADC0

AB25

SAR_ADC1

AA24

SAR_ADC2

AA25

SAR_ADC3

Y24

SAR_ADC4

W24

SAR_ADC5

Y23

SAR_ADC6

V23

SAR_ADC7

W23

SAR_ADC8

U112

NT72567

SPI_CS2

PANEL_VCC_ON/OFF

R395

10k

R497

3V3_STBY

3V3_STBY

KEYBOARD

B

SC_PIN8

DVD_WAKEUP

3V3_STBY

12V_VCC

10k
39k

R291

10k

R292

BACKLIGHT

AMP_MUTE

LED1

6

NAND/EMMC_D0
NAND/EMMC_D1
NAND/EMMC_D2
NAND/EMMC_D3
NAND/EMMC_D4
NAND/EMMC_D5
NAND/EMMC_D6
NAND/EMMC_D7

NAND_RE#
NAND_WE#
NAND_ALE

NAND_CLE
NAND_CE0#
NAND_CE1#

NAND_WP#
NAND_R/B#

SPI_DO[BS4]

SPI_CLK

SPI_CS[BS3]

SPI_HOLD[BS5]

SPI_WP#

C

VGA_SDA

VGA_SCL

IR_IN

RESETN

STBY_ON/OFF_NOT

3V3_STBY

D

3V3_STBY

47k

R274

10k

R8

R499
470k

U22

VGA_SDA

T23

VGA_SCL

AB19

STBC_IR

AA19

STBC_RSTN

Y18

PW_EN

AE20

STBC_RSTOUT[BS10]

W17

POR_EN

W15

TEST_EN

W16

TEST_BYPASS

I2CM1_SCL
I2CM1_SDA
I2CM0_SCL
I2CM0_SDA

STBC_UART_0_RX

STBC_UART_0_TX

STBC_UART_1_RX

STBC_UART_1_TX

XTAL_OUT

XTAL_IN

SPI_DI

AC22
AC21
AB22
AB21
AA22
AA21

Y22
Y21

AE24
AD23
AE23
AE22
AB23
AD24
AC23
AD22

AA20

AD21

AB20

AC20

Y20

AD20

P19
R19
U21
U20

T19

U19

U24

U23

W25
V25

HP_MUTE

HP_DETECT

HDMI1_HPD_DET

AD_AMP_RESET

HDMI0_HPD_DET

LED2
ETH_RESET

R306

10k

SPI_D0

SPI_DI

SPI_CLK

SPI_CS

R318

10k

SPI_HOLD

1k

R317

SPI_WS

R289

4k7

RX_SC

TX_SC

R523

4k7

R502
100R

R503
100R

RESET_TUNER
R311

10k

3V3_STBY

3V3_STBY

3V3_STBY

3

1M

R290

27MHz

2

1 4

3V3_VCC

3V3_STBY

C268

22p

50V

X101

BACKLIGHT_DIM

DVD_IR_ON/OFF

12MHz 30068172

R329

100k

D112

1N4148

100nF diff. GND connections

RESETN

C449

2

100n

1

10V

SERIAL FLASH

TP244

TP2451TP246

1

TP250

U114

MX25L512

1

1

CS#

2

HOLD#

SO

3

WP#

4 5

U115

MX25L512

1

CS#

2

HOLD#

SO

3

WP#

4 5

VCC

SCLK

VCC

SCLK

8
7
6

SIGND

8
7
6

SIGND

TP305

1

1 2

100R
R312

1

TP247

1 2

100R
R322

TP243

1

3V3_STBY_SPI

C302

2

100n

1

10V

SPI_HOLD
SPI_CLK

1

TP242

C317

2

100n

1

10V

SPI_HOLD
SPI_CLK

Q119

3

2

R319

3V3_STBY_SPI

100k

1

BC858B

3V3_STBY

TP300

1

CN118

C301

2u2

1

6V3

2

1

C448
100n
10V

TP17

3V3_STBY_SPI

E

4k7

R300

SPI_CS
SPI_DI
SPI_WS

SPI_D0

3V3_STBY_SPI

4k7

R331

F

SPI_CS2

SPI_DI
SPI_WS

1

SPI_D0

50V

22p

C267

KEYBOARD_ONBOARD

F145

1k

TP298

TP299

TP18

1

1

TP19

1

2

3

4

5

EXT KEYPAD

F144

1

6

1k

1

2

1

R412

1 2

47R

1 2

C364
100n
10V

3V3_STBY

R441

47R

USB0_D+

AC9

USB0_D-

AD8

USB1_D+

AE8

USB1_D-

AB8

USB_REXT

Y10

GPE_25/USB0_PWEN

V10

GPE_26/USB1_PWEN

G14

GPB_0/PWM_0/TCON_CPV

E15

GPB_1/PWM_1/TCON_OE1

G13

GPB_2/PWM_2/TCON_OE2

D16

GPB_3/PWM_3/LED_SPI_EN

D15

GPB_4/PWM_4/LED_SPI_CLK

E14

GPB_5/PWM_5/LED_SPI_DI

F13

GPB_6/PWM_6/LED_SPI_DO

F12

GPB_7/3D_IR/3D_BT

E13

GPB_8/H_OUT/PWM_7

D13

GPB_9/LR0_DELAY/TCON_GPIO_2

E12

GPB_10/LR1_DELAY/TCON_GPIO_3

E22

I2SOUT_A_DATA/GPA_10

F24

I2SOUT_A_WS/GPA_11

F23

I2SOUT_A_BCLK/GPA_12

E23

I2SOUT_A_MCLK/GPA_13

Y5

GPE_14/CCIR_OUT_CLK

AA5

GPE_15/CCIR_OUT_D0

AB5

GPE_16/CCIR_OUT_D1

V6

GPE_17/CCIR_OUT_D2

W6

GPE_18/CCIR_OUT_D3

Y6

GPE_19/CCIR_OUT_D4

AA6

GPE_20/CCIR_OUT_D5

AB6

GPE_21/CCIR_OUT_D6

V7

GPE_22/CCIR_OUT_D7

F18

RMII_MDIO

F19

RMII_MDC

C22

RMII_RXD1

D22

RMII_RXD0

E19

RMII_CRS

F17

RMII_RX_ERR

D21

RMII_TX_D1

E20

RMII_TX_D0

E21

RMII_TX_EN

D20

RMII_REF_CLK

KEYBOARD

SYS_SCL

SYS_SDA

UARTA_TX

UARTA_RX

UARTB_TX

W10

UARTB_RX

UARTC_TX

UARTC_RX

I2C_MA_SDA

I2C_MA_SCL

I2C_MB_SDA

I2C_MB_SCL

U10

J25

J24

R20

T20

I2C_MC_SDA

8

U112

NT72567

I2C_MC_SCL

I2C_MD_SDA

I2C_MD_SCL

I2C_ME_SDA

I2C_ME_SCL

MIPS_TRST

MIPS_TCK

G18

G17

AA9

AA7

MIPS_TMS

MIPS_TDI

MIPS_TDO

AA8

MIPS_INT

ONBOARD KEYBOARD

TP269

1

D121

10k

R440

1

+ -

4

E2

TP336

3

SW100

G4

R437

1

TP338

C

G3

270R

T

G2

R431

2k7

2

G1

TP337

1

1

E1

V5

W5

W9

V9

U7

V8

U8

U9

Y8

Y9

Y7

C3V6

TP340

TP341

SYS_SDA

SYS_SCL

4k7

R471

4k7

R478

TP1

TP241

TP2

TP3

TP4

R498

47k

KEYBOARD_ONBOARD

5V_VCC

USB_EN

3V3_VCC

TUNER_SDA

TUNER_SCL

S2_T2_SDA

S2_T2_SCL

3V3_VCC

12

3V3_VCC

12

STBY_ON/OFF_NOT

10k

R442

LED2

USB INTERFACE

TP301

TP263

1

4

3

2

1

CN112

6V3
10u
C227

R268

4k7

BACKLIGHT

LED SOCKET

1

CN119

1

TP267

1

TP268

1

TP266

Q138
BC848B

3

2

10k

R457

1

BC858B

VESTEL

SCH NAME :
DRAWN BY :

03_GPIOs_SPI_CI
<YOUR NAME HERE>

1

C438

2

100n

1

10V

S173

1

IN

U110

2

GND

TPS2553-1

3

EN

3V3_VCC

R100

4k7

2

1 2

3V3_STBY

N.C.

R105
100R

R112

4k7

2

2

3

4

1 2

TP264

R443

470R

R455

220R

1 2

3

Q139

2

Q142

1

R456

220R

1 2

PROJECT NAME :

1

C402

1 2

27p

50V

6

IO4

5

VDD

AZ099-04S

IO3 IO2

OUT

ILIM

FAULT

4k7

R102

R101

1 2

100R

3

Q100
BC848B

1

4k7

R103

1 2

R104
100R

3

Q101
BC848B

1

5

1

F149

1k

R461

220R

R463

1 2

3

2

1

BC858B

220R

R462

1 2

5V_STBY

U109

6

5

4

TP265

Q137
BC848B

10k

IO1

GND

1

R265
560R
R267
470R

1

2

34

TP302

1

TP262

BACKLIGHT_ON/OFF

STBY_ON/OFF

5V_STBY

IR_IN

3

2

1

10k

R444

LED1

17mb55

87654321

3p9

50V

C457

2p2

USB_DP

USB_DM

3p9

50V

2p2

C458

A3

T. SHT:

9

01-07-2013_13:59

A

B

C

D

E

F

AX M

A

B

C

D

E

F

SC_L_OUT

SC_R_OUT

MAIN_L

MAIN_R

1k

F125

SAV_L_IN

SAV_R_IN

SC_AUD_L_IN

SC_AUD_R_IN

3V3_VCC

3V3_VCC

1 2 3 4 5 6 7 8

R250

3n3

50V

SC_LIN

SC_RIN

SAV_LIN

SAV_RIN

C209
3n3

C211

C217

6V3

2u2

F131

1k

50V

C216

100n

3n3

50V

C210

12

10V

R324

10k

R345

10k

R401

10k

R399

10k

3n3

50V

C214

2u2

C212

6V3

C328
100n
16V

C333
100n
16V

6V3

6V3

6V3

6V3

R256
470R
R255
470R
R258
470R
R257
470R

C215

100n

R323

R344

R402

R400

C213

10u

C218

10u

C225

10u

C226

10u

12

C223

C224

6V3

10V1210V

2u2

100n

4k7

470p

4k7

50V

470p

4k7 4k7

50V

C318
100n
16V

C334
100n
16V

B23

A24

B24

B25

C24

C25

D25

D24

C20

B20

A21

B21

B22

A23

C21

A22

SAV_LIN

470p

C304

50V

SAV_RIN

470p

C332

50V

SC_LIN

C370

SC_RIN

C368

100n
16V

3V3_VCC_ETH

ADIN_L0

ADIN_R0

ADIN_L1

ADIN_R1

ADIN_L2

ADIN_R2

ADIN_L3

ADIN_R3

DAOUT_L0

DAOUT_R0

DAOUT_L1

DAOUT_R1

AUD_VRM

AUD_VRP

AUD_VCM

AUD_VCMI

C325C324
100n
16V

I2S_OUT_A_DATA[BS_0]

I2S_OUT_A_WS[BS_1]

I2S_OUT_A_BCLK[BS_2]

3

U112

NT72567

TUNER_RF_AGC/GPA_16

TUNER_IF_AGC/GPA_15

RFAGC_VSYNC/GPA_14

1V8_VCC_ETH

C442 C443

1u
6V3

I2S_OUT_A_MCLK

I2SIN_DATA

I2SIN_WS
I2SIN_BCLK
I2SIN_MCLK

SPDIF_IN

SPDIF_OUT

SIF_IN+

SIF_IN-

DEMOD_D+

DEMOD_D-

100n
16V

D12
F11
E11
G12

H16
G16
H15
G15

W7

W8

H23

H24

H22

J23

F25

G24

G23

3V3_VCC_ETH

1k

R251

1k
R5

10k

1
2
3
4 5

CI_CD2#

DVD_SPDIF

SPDIF_OUT

R293
100R

100n

16V

16V

100n

3V3_VCC_ETH

3V3_VCC_ETH

1V8_VCC_ETH

R269

C238

C237

47R

8

R1

7

R2

6

R3
R4

15p

C247

1k2

R294

1V8_VCC_ETH

1V8_VCC_ETH

3V3_VCC_ETH

USB_ETH_DP

USB_ETH_DM

C335
100n
16V

3V3_VCC

3V3_VCC

50V

3V3_VCC

R298

10k

DIGITAL_IF_P

DIGITAL_IF_N

10k

R495

R494

12k

C327
100n
16V

I2S_DATA
I2S_WS
I2S_BCLK
I2S_MCLK

C283

2

100n

1

10V

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

1V8_VCC_ETH

IF_AGC_TUNER

VCCK4

V_BUS

V18F

VCC3R3

GND3R3

GND33A_PLL

GND33A_H

DP

DM

RREF

VCC33A_PLL

VCC33A_H

X2

X1

GND18A_PLL

VCC18A_PLL

C329

3

33p

HDMI1_ARC

48

GND4

VCC18A_1

1

R508

1M

X103

27MHz

50V

HDMI_0_CLKN
HDMI_0_CLKP
HDMI_0_RX0N
HDMI_0_RX0P
HDMI_0_RX1N
HDMI_0_RX1P
HDMI_0_RX2N
HDMI_0_RX2P

HDMI0_5V

HDMI_1_CLKN
HDMI_1_CLKP
HDMI_1_RX0N
HDMI_1_RX0P
HDMI_1_RX1N
HDMI_1_RX1P
HDMI_1_RX2N
HDMI_1_RX2P

HDMI1_5V

R334

47

TEST0

XTL25P

2

14
2

C336

R342

R341

R347

3V3_VCC_ETH

ETH_RESET

10k

44

45

46

TEST1

RESET_N

XTL25N

GND18A_1

5

4

3

50V

33p

AB13

AC10
AD10
AE10
AC11
AE11
AD11
AC12
AD12

43

TCLK_EN

Y15

AA14

AC13
AD13
AE13
AC14
AE14
AD14
AC15
AD15

Y16

42

TCLK_0

4k7

47R

4k7

3V3_VCC_ETH

VCC3IO_2

AX88772B

RSET_BG

VCC3A3SDGND18A_2

7

6

12k

R496

3V3_VCC_ETH

MHL_CBUS

RXA_CLK­RXA_CLK+
RXA_0­RXA_0+
RXA_1­RXA_1+
RXA_2­RXA_2+
PWR5V_A

HDMI_ARC

RXB_CLK­RXB_CLK+
RXB_0­RXB_0+
RXB_1­RXB_1+
RXB_2­RXB_2+
PWR5V_B

41

TCLK_1

U116

8

U112

NT72567

39

40

EECS

EEDIO

RXIP

RXIN

9

10

ETH_RXN

ETH_RXP

4

MHL_CD_SENSE

1V8_VCC_ETH

37

38

EECK

GND3

VCC18A_2

TXOP

12

11

ETH_TXP

1V8_VCC_ETH

RXC_CLK­RXC_CLK+

PWR5V_C

HDMIA_SDA
HDMIA_SCL
HDMIB_SDA
HDMIB_SCL
HDMIC_SDA
HDMIC_SCL

MHL_VBUS

EXT_RES

HDMI_CEC

35

36

VCCK3

TXON

14

13

ETH_TXN

RXC_0­RXC_0+
RXC_1­RXC_1+
RXC_2­RXC_2+

34

MFB0

GND18A

15

AC16
AD16
AE16
AC17
AE17
AD17
AC18
AD18
AA17

AB10
AA10
AA16
AA15
AB17
AB16

AB14

AA13

AB11

33

MFB1

MFB2

GND1

VCC3IO_1

16

3V3_VCC_ETH

Y14

MFB3

MFB4

MFB5

MFB6

MFB7

GPIO_0/PME

GPIO_1

GPIO_2

VCCK2

EXTWAKEUP_N

GND2

MFA3/PHY_N

VCCK1

MFA2/RMII_N

MFA1/MDIO

MFA0/MDC

HDMI_0_SDA
HDMI_0_SCL
HDMI_1_SDA
HDMI_1_SCL

R297
470R

CEC

32

31

30

29

28

27

26

25

24

23

22

21

20

19

18

17

HDMI0_HPD_DET

VDDC_3V3

R369

27k

D115

BA782

30065063 B0540W

HDMI1_ARC

HDMI1_HPD_DET

1V8_VCC_ETH

1V8_VCC_ETH

nLNKA_LED

nSPD_LED

HDMI0_5V

3V3_VCC

HDMI1_5V

6V3

1u

10k

C478

10k

3V3_VCC_ETH

HDMI_0_RX2P

HDMI_0_RX2N
HDMI_0_RX1P

HDMI_0_RX1N
HDMI_0_RX0P

HDMI_0_RX0N
HDMI_0_CLKP

HDMI_0_CLKN

R521

1k2

HDMI_1_RX2P

HDMI_1_RX2N
HDMI_1_RX1P

HDMI_1_RX1N
HDMI_1_RX0P

HDMI_1_RX0N
HDMI_1_CLKP

HDMI_1_CLKN

R512 R513
HDMI1_5V

R522

1k2

ETH_TXP

ETH_TXN

ETH_RXP

ETH_RXN

VESTEL

SCH NAME :
DRAWN BY :

CEC

HDMI_0_SCL
HDMI_0_SDA

HDMI0_5V

1k
R365
R363

1k

CEC

HDMI_1_SCL
HDMI_1_SDA

HDMI1_5V

1k
R338

10k

R343

C444
100n
16V

47R

47R

R326

R327

C312

1u
6V3

12

2

3

1

R328

Q126
BC848B

47R

R325

TP296

C447
100n
16V

Q132
BC848B

C445
100n
16V

47R

nSPD_LED

R520

nLNKA_LED

PROJECT NAME :

05_AUDIO_IO_HDMI_INPUTs
Ulas Dereli

R519

20k

20k

4k7

R346

4k7

R350

3V3_VCC

R354
470R

17mb55

47k

R340

1 2

5V_STBY

47k

R351

1 2

S152
R355

470R

3V3_VCC

S151

CN115

21
20

HDMI0

1
2
3
4
5
6
7
8

9
10
11
12
13
14
15
16
17
18
19

CN116

21
20

HDMI1

1

2

3

4

5

6

7

8

9
10
11
12
13
14
15
16
17
18
19

5V_STBY

CN114

1

TD+

2

TD-

3

TCT

4

RD+

5

RD-

6

RCT

7

NC1

8

NC2

9

GR+

10

GR-

11

YL+

12

YL-

13

SHLD1

14

SHLD2

24-06-2013_16:21

87654321

A

COMMONOPTIONAL

B

C

W/ARC

D

E

F

A3

T. SHT:

9

AX M

1 2 3 4 5 6 7 8

SCART

45

D119

A

21

20

19

18

17

16

15

14

13

B

SC100

12

11

SCART LT1

10

9

8

SAP CODE 30070522SAP CODE 30071149

7

6

5

4

3

C

2

1

CDA4C16GTH

1

TP306

1

TP319

1

TP307

1

TP308

1

TP309

1

TP310

1

TP311

1

TP312

1

TP313

1

TP314

1

TP318

1

TP315

SCART_AUD_R_IN

1

TP316

1

TP317

1

2

3

45

D

CDA4C16GTH

TP23

TP241TP251TP26

1

1

15

14

13

12

11

10

9

E

8

7

6

5

4

30R Ferrite Bead

3

2

1

1

TP20

1

TP21

CN117

F

1

TP22

6

F155 1k

F157 1k

7

8

R515
100R

1kF156

321

NUP4004M5

1

2

3

6

7

8

220p

PC INPUT

D117

R514
100R

C476

2

100n

1

10V

5

4

D114

3

45

6

50V

12

C371

75R

12

R403

SCART_AUD_L_IN

C367

50V

3n3

F140

1k

F146

1k

10k

R385

1 2

R387
100R
R388
100R

C477

2

100n

1

10V

12

75R

R376

2

7

R415

1 2

100R

50V
3n3
C381

10k

R390

1 2

12

75R

1

8

50V

R389

10k

1 2

R378

D118

CDA4C16GTH

1 2

C373

220p

50V

220p

12

75R

R408

50V

220p

12

C375

75R

R409

75R

R405

75R

R404

C369

3n3

10k

R386

1 2

12

75R

R380

12

75R

R407

50V

C374

12

12

12

TX_SC

12

RX_SC

R434

39k

F141

1k

F147

1k

SC_AUD_R_IN

SC_AUD_R_OUT

C363

2

100n

1

10V

R373
100R

VGA_VS

VGA_HS
R374
100R

VGA_B

VGA_G

VGA_R

C3V6

SC_CVBS_IN

C376

47p

50V

R391

47R

SC_R

SC_B

SC_AUD_L_IN

R429

1 2

100R

50V
3n3
C392

5V_STBY

VGA_SCL

VGA_SDA

D126

SC_FB

R406

220p

C372

R438

C3V6

D120

SC_CVBS_OUT

75R

12

50V

12

10k

SC_PIN8

SC_AUD_L_OUT

SC_R_OUT

JK100

SC_G

SC_AUD_R_OUT

C365

1u
6V3

JK103

30066835

TP322

SAV INPUT

R302

1 2

75R

F132

1k

F136

1k

C296

1 2

50V

220p

50V

C337

3n3

SAV_CVBS_IN

3n3

C315

SAV_L_IN

SAV_R_IN

50V

DVD_CVBS_IN

D111

YEL

WHT

RED

1

2

3

4

5

C5V6

1

TP27

1

TP320

1

TP28

1

TP321

1

TP29

INDIA OPTION

30064869

SC_CVBS_IN

4

YEL

SCART_AUD_L_IN

WHT

RED

3

2
1

SCART_AUD_R_IN

JK105

PRE-AMP for SCART AUDIO

R393
220k

220k

R394

C454

C385

100n

12

OUT1

U120

IN1-

TL062

IN1+

3

1

2

16V

VDD

OUT2

IN2-

IN2+VSS

R332

R333

1 2

1 2

R398

33k

1

2

3

4 5

12

16V

10u

8

7

6

4k7

C323

1 2

100n

10V

4k7

C322

V+

F139

60R

16V

100n

C316

R427

1 2

33k

C380

47p

50V

R414

75k

F133

60R

R330

1 2

100R

100p

50V

12V_VCC

C391

10u

10V

R413

1 2

20k

5V_VCC

C379

1u
6V3

SPDIF_OUT

R396

1 2

20k

2
3
1

1

C362

10u

10V

TP261

1

C306

1 2

V+

10V

100n

1 2

C307

50V

220p

C361
10u
10V

C366

47p

50V

R397

75k

V+

COAX SPDIF OUT

Q120

BC848B

R321
220R

R320

220R

1 2

VGA_R

VGA_G

VGA_B

SAV_CVBS_IN

SC_AUD_L_OUT

SC_L_OUT

C461

1 2

220p

12

100R

100R
R278
100R
R283
100R
R277
100R
R287

R281
100R

R282
100R

R276
100R

100R
R286

R272
100R

R271
100R

R273

VGA_HS
VGA_VS

12

12

12

12

10V

10V

50V

10V

10V

10V

10V

10V

10V

10V

470p

2

C254

12

100n

C255

12

100n

C248

C260

12

100n

C246

12

100n

C245

12

100n

C250

1

100n

C256

12

100n

C249

12

100n

C261

12

100n

M24

M25

M23

N25

T22
T21

N23

P23

R23

R25

K25

K24

L22

L24

N24

P24

R24

VGA_R

VGA_G

SOGIN1_STBC

VGA_B

VGA_HS_STBC
VGA_VS_STBC

YPBPR0_PR

YPBPR0_Y

SOGIN0_STBC

YPBPR0_PB

CVBS0

TUNER_CVBSIN

S_Y

NT72567

ADC0M

ADC1M

ADC2M

ADC3M

1

U112

VCOMP

FSADJ

TVDAC_OUT

CVBS_OUT

SCART1_R

SCART1_G

SOGIN2_STBC

SCART1_B

SCART0_Y

SCART0_FB

ADC1VMID
ADC3VMID

SCART VIDEO OUTPUT AMPLIFIER

12V_VCC

R416
220R

F142

1k

SC_CVBS_OUT

C382

BC858B

75R

16V

100n

Q133

1

2

3

R422R421
100R

Q134

BC848B

DVD INTERFACE

1

1

220p

IR_IN

1

50V

C112

TP259

CN101

1 2

3 4

5 6

7 8

9 10

1k

R139

1

50V

Q105

BC848B

2

S154

1 2

1

1

TP254

1 2

27p

3

DVD_SENSE

DVD_CVBS_IN

10V

1 2

C114

100n

DVD_SPDIF

R120

75R

R118

1 2

100R

12

TP257

4k7

R124

TP256

R116
100R

DVD_IR_ON/OFF

R119

75R

TP258

1

B18

A18

F Tolerance

C18

K23

P22

P21

R21

N22

L23

K22

L21
P20

R410

390R

3

1

100R

R417

TP253

1

TP255

DVD_IR

C111

R123

4k7

R420

2

R419

47n
16V

47n
16V

47n
16V

47n
16V

12

10V

10V

68k

33k

C244

C259

C386

10u

10V

R261

2k2

R266

75R

R264

75R

R254

100R

SCART_CVBS_OUT

C257

100R SC_R

C258

100R

C252

100R

C251

100R

SC_FB

12

100n

12

100n

SCART_CVBS_OUT

C113
10u
16V

NC

1 2

S111

12V_VCC

DVD_WAKEUP

DVD_IR

3V3_VCC

F Tolerance

R284

R285

R280

R279

SC_G

SC_B

SC_CVBS_IN

A

B

C

D

E

F

VESTEL

SCH NAME :
DRAWN BY :

02_PERIPHERALs
Ulas Dereli

PROJECT NAME :

17mb55

T. SHT:

24-06-2013_16:00

87654321

A3

9

AX M

TX_B_0_N
TX_B_0_P
TX_B_1_N
TX_B_1_P
TX_B_2_N
TX_B_2_P

TX_B_CLK_N

A

TX_B_CLK_P

TX_B_3_N
TX_B_3_P
TX_B_4_N
TX_B_4_P

CI_POWER_CTRL

USB_EN

B

5V_VCC

12V_VCC

C

1 2

1 2

1 2

PANEL_VCC_ON/OFF

1 2 3 4 5 6 7 8

S155

A7

MINI1_D0-

B7

MINI1_D0+

C7

LVO_0-/MINI1_D1-

B8

LVO_0+/MINI1_D1+

C8

LVO_1-/MINI1_D2-

B9

LVO_1+/MINI1_D2+

A9

LVO_2-/MINI1_CLK-

C9

LVO_2+/MINI1_CLK+

A10

LVO_CLK-/MINI1_D3-

B10

LVO_CLK+/MINI1_D3+

C10

LVO_3-/MINI1_D4-

B11

LVO_3+/MINI1_D4+

C11

LVO_4-/MINI1_D5-

B12

LVO_4+/MINI1_D5+

D19

GPH_0/TCON_CPV

F14

GPH_1/TCON_OE1

C19

GPH_2/TCON_OE2

E17

GPH_3/TCON_STV_D

E18

GPH_4/TCON_STV_U

B19

GPH_5/TCON_TP

F15

GPH_6/TCON_POL

F118

60R

F117

60R

F116

60R

R187

10k

100n

LVE_0-/MINI2_D0­LVE_0+/MINI2_D0+
LVE_1-/MINI2_D1­LVE_1+/MINI2_D1+
LVE_2-/MINI2_D2-

LVE_2+/MINI2_D2+
LVE_CLK-/MINI2_CLK­LVE_CLK+/MINI2_CLK+

LVE_3-/MINI2_D3-

LVE_3+/MINI2_D3+

LVE_4-/MINI2_D4-

LVE_4+/MINI2_D4+

2

U112

MINI2_D5­MINI2_D5+

NT72567

GPH_7/TCON_GPIO_0
GPH_8/TCON_GPIO_1

GPH_9/TCON_GPIO_2
GPH_10/TCON_GPIO_3
GPH_11/TCON_GPIO_4

PANEL SUPPLY SWITCH

5

6

C165

1u
16V

C158

10V

12

33k

R185

1 2

R196

1 2

47R

22k

R186

3

2

Q110

1

BC848B

2

1

1

3 4

2

A12
C12
A13
B13
C13
B14
C14
B15
A15
C15
A16
B16
C16
B17

A19
E16
F16
C17
D18

Q114

FDC642P

TP295

1

TX_A_0_N
TX_A_0_P
TX_A_1_N
TX_A_1_P
TX_A_2_N
TX_A_2_P
TX_A_CLK_N
TX_A_CLK_P
TX_A_3_N
TX_A_3_P
TX_A_4_N
TX_A_4_P

RESET_S2_T2

PANEL_VCC

S129

R216

33k

R210

1 2

10k

R221

33k

R220

1 2

10k

S134

R223

33k

R222

1 2

10k

S135

R225

33k

R226

1 2

10k

R175

1 2

12

BACKLIGHT_ON/OFFPANEL_VCC

10k

3D_EN

PANEL_VCC OP_PIN5

PANEL_VCC OP_PIN7

MEGA_DCR_IN

PANEL_VCC

MEGA_DCR_OUT

PANEL_VCC

R172

33k

PANEL_VCC OP_PIN10

PANEL_VCC OP_PIN11

PANEL_VCC OP_PIN27

3D_EN

OP_PIN8

OP_PIN9

PANEL_VCC

OPTIONS

CN107

1

R230

33k

R229

1 2

10k

R240

33k

R239

1 2

10k

R242

33k

R241

1 2

10k

S137
R245

33k

R248

1 2

10k

R253

33k

R249

1 2

10k

2

3

12

4

OP_PIN42PANEL_VCC

OP_PIN43

PANEL_VCC

OP_PIN11

5

6

1 2

7

S126

TX_B_4_N

TX_B_4_P

TX_A_4_N

TX_A_4_P

S130

1 2

8

1

CN110

1 2

9

OP_PIN8

S131

10

2

1 2

S156

1 2

S157

1 2

S158

1 2

PANEL_VCC

5. PAIR GND OPTION

51P FFC OPTIONS

TX_B_4_P

TX_B_4_N

TX_B_3_P

TX_B_3_N

TX_B_CLK_N

TX_B_CLK_P

OP_PIN43

OP_PIN42

TX_B_1_P

TX_B_2_N

TX_B_2_P

TX_B_0_N

TX_B_0_P

TX_B_1_N

OP_PIN27

TX_A_4_P

TX_A_4_N

TX_A_3_P

TX_A_3_N

TX_A_CLK_P

TX_A_CLK_N

5150494847464544434241403938373635343332313029282726252423222120191817161514131211

OP_PIN9

11

3

18

TX_A_2_P

19

11

TX_A_2_N

20

12

TX_A_1_P

TX_A_1_N

TX_A_0_P

21

22

23

24

25

13

14

15

16

17

18

TX_A_3_P

TX_A_3_N

12

13

14

4

5

6

7

15

8

TX_A_CLK_N

TX_A_CLK_P

16

17

9

10

TX_A_0_N

26

27

19

OP_PIN27

28

20

21

SINGLE LVDS FFC OPTIONS

TX_A_2_P

TX_A_2_N

TX_A_1_P

OP_PIN42

29

30

22

OP_PIN7

OP_PIN8

OP_PIN9

OP_PIN11

OP_PIN10

TX_A_1_N

TX_A_0_P

TX_A_0_N

987654321

10

LG BASED 30070519

OP_PIN43

23

24

25

26

OP_PIN5

27

TX_B_0_N

TP274

TX_B_0_P

TP275

TX_B_1_N

TP276

TX_B_1_P

TP277

TX_B_2_N

TP278

TX_B_2_P

TP279

TX_B_CLK_N

TP280

TX_B_CLK_P

TP281

TX_B_3_N

TP282

TX_B_3_P

TP283

CN109

PANEL_VCC

TX_A_0_N

TP284

TX_A_0_P

TP285

TX_A_1_N

TP286

TX_A_1_P

TP287

TX_A_2_N

TP288

TX_A_2_P

TP289

TX_A_CLK_N

TP290

TX_A_CLK_P

TP291

TX_A_3_N

TP292

TX_A_3_P

TP293

S136

28

29

30

OP_PIN9

PANEL_VCC

30

1

29

1

28

1

27

1

26

1

25

1

24

23

1

22

1

21

1

20

1

19

1

18

1

17

16

1

15

1

14

13

1

12

1

11

1

10

1

9

1

8

1

7

12

6

A

B

C

5

4

3

2

19" TO 22" DOUBLE LVDS FFC OPTIONS

1

CN111

D

CI_A0
CI_A1
CI_A2
CI_A3
CI_A4
CI_A5
CI_A6
CI_A7
CI_A8
CI_A9
CI_A10

CI_A12
CI_A13
CI_A14

R143 22R

R4

4 5

E

CI_D0
CI_D1
CI_D2
CI_D3
CI_D4
CI_D5
CI_D6
CI_D7

F

R3

3

R2

2

R1

1

R231 22R

R4

4 5

R3

3

R2

2

R1

1

R224

22R

6
7
8

6
7
8

CI_RESET
CI_CD1#
CI_CE1#
CI_IRQ#
CI_OE#
CI_WE#

CI_WAIT#
CI_IORD#
CI_IOWR#

G5
G4
G3
G2
H6
H5
H4
H3
H2
L4
J6
J5
K4
K5
K6

D5
D4
D3
D2
D1
E6
E5
E4

E3
E2
E1
F6
F3
F2
F1
G6
F5
F4

CI_A0/ALE0
CI_A1/ALE8
CI_A2
CI_A3
CI_A4
CI_A5
CI_A6
CI_A7
CI_A8
CI_A9
CI_A10
CI_A11
CI_A12
CI_A13
CI_A14

CI_AD0
CI_AD1
CI_AD2
CI_AD3
CI_AD4
CI_AD5
CI_AD6
CI_AD7

CI_RST#
CI_CD#
CI_CE#
CI_IOINT#
CI_HRD#
CI_HWR#
CI_REG#
CI_HWAIT#
CI_IORD#
CI_IOWR#

STSIN0_CLK/GPB_15
STSIN0_VALID/GPB_16
STSIN0_START/GPB_17

STSIN0_DATA/GPB_18

5

U112

NT72567

PTSIN1_ERROR

PTSIN1_CLK
PTSIN1_VALID
PTSIN1_START

PTSIN1_D0
PTSIN1_D1
PTSIN1_D2
PTSIN1_D3
PTSIN1_D4
PTSIN1_D5
PTSIN1_D6
PTSIN1_D7

DEMODOUT_ERROR

PTSOUT_CLK
PTSOUT_VALID
PTSOUT_START

PTSOUT_D0
PTSOUT_D1
PTSOUT_D2
PTSOUT_D3
PTSOUT_D4
PTSOUT_D5
PTSOUT_D6
PTSOUT_D7

F10
E10
D10

F9

E9
D9
F8
E8

F7
E7
D7
B6
A6
A4
A3
A2

B5
B4
B3
B2

B1
C6
C5
C4
C3
C2
C1
D6

DVD_SENSE
3D_EN

TSO_CLK
TSO_VAL
TSO_STRT

TSO_D0
TSO_D1
TSO_D2
TSO_D3
TSO_D4
TSO_D5
TSO_D6
TSO_D7

R180 22R

R197 22R

22RR181

22RR184

1

R1

2

R2

3

R3

4 5

R4

1

R1

2

R2

3

R3

4 5

R4

R183

22R

C462

15p

TSIN_CLK
TSIN_VAL
TSIN_STRT

8

TSIN_D0

7

TSIN_D1

6

TSIN_D2
TSIN_D3

8

TSIN_D4

7

TSIN_D5

6

TSIN_D6
TSIN_D7

50V

VCC_PCMCIA

R182

10k

VCC_PCMCIA

50V

15p

C151

CI_D3
CI_D4
CI_D5
CI_D6
CI_D7
CI_CE1#
CI_A10
CI_OE#
CI_A11CI_A11
CI_A9
CI_A8
CI_A13
CI_A14
CI_WE#
CI_IRQ#

TSIN_VAL
TSIN_CLK
CI_A12
CI_A7
CI_A6
CI_A5
CI_A4
CI_A3
CI_A2
CI_A1
CI_A0
CI_D0
CI_D1
CI_D2

CI INTERFACE

CN106

1

35

2

36

3

37

4

38

5

39

6

40

7

41

8

42

9

43
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32

10kVCC_PCMCIA

33
34

CI_IORD#

44

CI_IOWR#

45

TSIN_STRT

46

TSIN_D0

47

TSIN_D1

48

TSIN_D2

49

TSIN_D3

50

51

52

TSIN_D4

53

TSIN_D5

54

TSIN_D6

55

TSIN_D7

56

57

CI_RESET

58

CI_WAIT#

59

60

CI_REG#

61

62

63

64

65

66

67

68R136

R219

22R

R4

4 5

R3

3

R2

2

R1

R213

1

22R R205

10k

VCC_PCMCIA

R171

22R

R169 10k

22RR166
22RR162

R4

4 5

R3

3

R2

2

R1

1

R140

10k

CI_CD2#

CI_CD1#
TSO_D3
TSO_D4

6

TSO_D5

7

TSO_D6

8

TSO_D7

TSO_CLK

10kR170

TSO_VAL
TSO_STRT
TSO_D0
TSO_D1

6

TSO_D2CI_REG#

7
8

R150

22R

R232

10k

VCC_PCMCIA

15p

C144

VCC_PCMCIA

VCC_PCMCIA

VCC_PCMCIA

50V

12V_VCC

CI_POWER_CTRL

Q111

BSH103

5V_VCC VCC_PCMCIA

C162
100n
10V

C160
10u
6V3

R215

4k7

R207

4k7

1

10V

2

C174

100n

2

3

1

R201

10k

Q116
BC848B

2

1

C167
100n
10V

2

1

D

E

F

VESTEL

SCH NAME :
DRAWN BY :

07_USB_LVDS_OUT
<YOUR NAME HERE>

PROJECT NAME :

17mb55

T. SHT:

02-07-2013_09:26

87654321

A3

9

AX M

1 2 3 4 5 6 7 8

W/B2CABLE

12V_STBY

A

TP339

TP328

B

CN105

1

1

12

34

56

78

910

1112

1

TP330

DIMMING

1

TP331

BACKLIGHT_ON/OFF

1

TP332

STBY_ON/OFF_NOT

S124

S125

1

TP333

VDD_AUDIO_PWR

PIN11

CN121

1112

910

78

56

34

12

C

W/B2B

12V_STBY

DIMMING

BACKLIGHT_ON/OFF

STBY_ON/OFF_NOT

PIN11

12V_STBY

STBY_ON/OFF

F100

60R

S168

10k

R161

VFB_1

C137
1u
6V3

12

100n

16V

1

2

3

4

16V
10n
C135

C117

R160

1 2

EN

U101

VFB

TPS54528

VREG5

VSS

F108

60R

C122

C121

10u

10u

16V

16V

VIN

VBST

SSW

GND

12V_STBY

8

C116

7

100n

6

5

16V

4u7 6x6 olacak ÜA

D124

SK24

C453

10k

W/S2 W/T2

LDO2

U102

30068176

LM1117

IN OUT

VOUT

GND

C138

1234

10u
6V3

DC-DC 3

L10110u

3R3

R505

3n3

R151

100R

C123
10u

50V

N.C.

6V3

R144
100R

C139
10u
6V3

33p

C136

R165
120k

C118
10u
6V3

100n

16V

0R

15pf

100n

TP36

1

C143

VFB_1

R168

22k

TP5

1

F103

C119

16V

F167

1V2_VCC

1V2_VCC2V5_VCC

60R

60R

5V_STBY

5V_STBY

5V_STBY

12V_VCC

STBY_ON/OFF_NOT

STBY_ON/OFF_NOT

6V3
10u
C175

R194

10k

STBY_ON/OFF

W/ADAPTOR

SW2

5

6

Q112

NTGS3446

1

3 4

2

12

R195

S100

S101

1 2

1k

Q113
BC848B

N.C.

R192

47R

100n

C164

16V

NC

MOSFET_CONTROL

R193

33k

12

TP6

6V3
10u
C170

5V_VCC

5V_VCC

C163

16V

100n

A

B

C

COMMON

DC-DC 1

16V

10n

C127

1

D

12V_VCC

F106

60R

100n

16V

C133

C125
10u
16V

SS

U103

2

IN

MP1498

3

SW

4

GND

VCC

EN/SYNC

BST

8

FB

100n

C134

7

16V

6

5

22R

R489

R2

22k

100K

R156

1 2

10k

100n

16V

10k

1 2

R487

C132

12V_VCC

L102

1u

N.C.

6V3
10u
C140

C2
15p
50V

33K

22k

120kR4R158

0R

TP32

R159

120k

1

6V3
10u
C141

75K

1V15_VCC

1V15_VCC

MOSFET_CONTROL

12V_STBY

R113

10k

50V
220n
C100

12

12

R106

12

R107

33k

1 2

33k

Q102
BC848B

SW1

R108

47R

5

6

1

3 4

2

12V_VCC

12V_VCC

Q103

FDC642P

5V_VCC

2V5_VCC

F164

60R

F128

60R

E

N.C.

5V_VCC

12V_VCC

F113

60R

F114

60R

100n

16V

C148

C147
10u
16V

C146
10u
16V

F

DC-DC 2

C145

10n

16V

1

SS

U104

2

IN

MP1498

3

4

SW

GND

EN/SYNC

VCC

BST

100n

16V

R1

22k

R177

1 2

10k

1 2

C153

10k

R486

12V_VCC

L103

1u

6V3
10u
C157

C1
15p
50V

R3

R174

6V3
10u
C156

47K

120k

0R

120k

22k

100n

16V

R179

2V5_VCC

TP33

1

F115

60R

C155

2V5_VCC

F119

60R

C178
10u
6V3

LDO3

U1

LM1117

IN OUT

VOUT

GND

1234

U105

LM1117

IN OUT

VOUT

GND

1234

N.C.

R209

N.C.

100R

R208
100R

C168
10u
6V3

TP35

3V3_VCC

1

3V3_VCC5V_VCC

100n

C169

16V

5V_STBY

8

FB

100n

C149

7

16V

6

5

R488

22R

0R

U126

LM1117

IN OUT

VOUT

GND

1234

U111

LM1117

IN OUT

VOUT

GND

C239

1234

10u
6V3

C191

1u
6V3

VESTEL

SCH NAME :
DRAWN BY :

LDO1

TP34

1V5_VCC

1

N.C.

100R

R263

R262
100R

0R

3V3_STBY

LDO4

1

OUT

IN

U107

2

GND

TLV0033

3 4

N/CEN

AP2120 3V3_STBY OPTION

5V_STBY

3V3_STBY

PROJECT NAME :

08_POWER
Ulas Dereli

Q1
BC848B

C220
10u
6V3

5

100n

C193

1u
6V3

16V

1V5_VCC

C221

C192

100n

50V

17mb55

TP31

1

3V3_STBY

T. SHT:

24-06-2013_16:22

87654321

D

E

F

A3

9

AX M

1 2 3 4 5 6 7 8

3V3_VCC_TUNER

24MHz

X104

27MHz

100R

1 2

17

18

XTAL_O

SCL

5

4

3V3_VCC_TUNER

C479

22p

50V

15

16

XOUT

XTAL_I

LDO_ADJ

SDA

VDD_IO

GND1

7

6

47p
C484

S2_IP

S2_IN

S2_QP

S2_QN

S2_DEMOD_CLK

VDD_L

ALIF_P

ALIF_N

DLIF_P

VDD_H1

DLIF_N

VDD_D

T2_DIGITAL_IF_P

T2_DIGITAL_IF_N

3V3_VCC_TUNER

21

VDD_H3

GPIO1

1

12

4k7

4k7

R313

S2_QP

S2_QN

S2_IN

S2_IP

27MHz

2

C480

22p

50V

R516

19

20

GND2

VDD_H2

U119

SI2158

GPIO2

AGC2

3

2

R308
100R
R307
100R

C295

27p
C297

X102

27p

S169

50V 50V
47p
C483

50V

50V

A

24

JK102

1

5 36789

270nH 180nH

L108

B

S159

1 2

5V_VCC

R339

1 2

4k7

1

IN

2

GND

TPS2553-1

3

EN

U118

OUT

ILIM

FAULT

6

5

4

C

3V3_VCC

D

I2C ADDR: 18

C465

F130

60R

3n3

50V

C286
10u

C314

2p2

C319

6V3

50V

PCB COIL

50V

3n3

CN113

E

50V

3n3

C466

F

3V3_VCC

I2C ADDR: C0

C350

47p

50V

2pF

12n

L106

C321

C294

16V

C342

100n

1n

10V

100n

680R
R353

F137

5.6nH

12n

C303

2p2

60R

50V

C320

C298

L109

C341
10u

1.8pF

100n 10V

12n

C343
180p
50V

6V3

L105

1n

50V50V

S2_AGC

C289

12n

TP334

1

1

10V

100n

C351

68p

50V

RESET_TUNER

T2_IF_AGC_TUNER

IF_AGC_TUNER

C345

47p

C347

100n 10V

4.7nH

TP335

C299

1

2

3

4

5

6

GND Connection Separate

LNB_OUT

R500

12

4k7

10V100n

C354

100n 10V

R7

GND1

RFIP

GND2

LOOP

GND3

ADD

2

1

C474
100p
50V

1 2

R392

1 2

100R

C359

12

4k7

24

PDN

AGC

7

C300
100n
10V

C344

1n2

50V
50V

180p

C352

C353

180p

50V

R382
100R

2

1

10V

C346

100n 10V

100n

TUNER_SCL

3V3_S2_TUN

100R

R310

22

23

VCC3

SCLK

RDA5815S

NC1

NC2

9

8

3V3_S2_TUN
C475
100p
50V

L107

12n

L110
12n

560nH

C357
100n
10V

TUNER_SCL

TUNER_SDA

3V3_VCC_TUNER

R309

50V

50V

20

NC4

BBQP

BBQN

BBIN

BBIP

DVDD

REFCLK

VCC1

11

3V3_S2_TUN

C356

2

100n

1

10V

3V3_VCC

C468

47p

47p

C467

19

VCC2

XTAL

12

2

1

FEF_AGC_FREEZE

C358
100n
10V

TUNER_SDA

100R

21

SDA

U125

NC3

10

560nH

22

23

24

25

26

27

28

18

17

16

15

14

13

RF_REF

RF_IP

RF_IN

RF_SHLD

ADDR

RSTB

AGC1

S160

1 2

R301

3V3_S2_TUN

C290

100n

C291

100n

C292

100n

100n

C293

100n

C441

S172

SH100

1

12

3R3

2R2

R381

30051799

BC858B
Q131

C348

1u
6V3

14

13

12

1

11

10

1

9

8

C349

R233

51R

R234

51R

R235

51R

R236

51R

S2_DEMOD_CLK

30010731

50V

C360

1n2

DIGITAL_IF_P

S146

S148

DIGITAL_IF_N

2

3V3_VCC_TUNER

2

1V8_VCC_TUNER

50V

1n2

10p

50V

10p

NC

50V

C184

C187

1V2_VCC_S2/T2

T2_IF_AGC_TUNER

T2_DIGITAL_IF_P

T2_DIGITAL_IF_N

3V3_VCC_S2/T2

NC

C189

10p

50V

C186

100n

NC

C190

S170

C471
2u2
6V3

10p

100n

1V8_VCC_TUNER

12V_VCC

NC

50V

C185

37

38

39

40

41

42

43

44

45

46

47

48

D125

C22V

LNB_OUT

L104

10u

C473

22p

50V

F154

60R

100n 10V

C439

S_ADC_IP

S_ADC_IN

S_ADC_QP

S_ADC_QN

TC_ADC_P

TC_ADC_N

NC

CLK_IN_OUT

SDA_MAST

SCL_MAST

GND5

VDD_VCORE4

R206

12

4k7

C180

2

100n

1

10V

FEF_AGC_FREEZE

C472

22p

50V

27MHz

36

VDD_VANA

MP_A

1

2

3

35

2

SK24

D110

14

GND2

MP_B

S161

1 2

X100

34

ADDR

GPIO_0

3

I2C ADDR: C8

12V_VCC

1N5819

D123

S162

16V
10u

S171

C434

31

32

33

XTAL_O

XTAL_I/CLK_IN

U106

SI2166

DISEQC_CMD

DISEQC_IN

6

5

4

I2C ADDR: 10

C196

100n

10u

16V

16V

D109

16V
10u
C455C456

RESET_S2_T2

R199

RESETB

DISEQC_OUT

DISEQC_OUT

50V
220n

1N5819

C198

D122

1N4001

16V
10u
C436

S2_AGC

3V3_VCC_S2/T2

12

4k7

R198

4k7

1 2

10V100n

1V2_VCC_S2/T2

28

29

30

MP_D

MP_C

VDD_VCORE1

VDD_VCORE2

GND3

VDD_VIO1

9

8

7

1V2_VCC_S2/T2

3V3_VCC_S2/T2

25V
2u2
C437

2

1

2

1

27

GND1

SCL_HOST

10

50V
47p
C470

C464
100n
10V

C450
100n
10V

26

TS_ERR/GPIO_1

SDA_HOST

11

25

TS_DATA[7]

TS_DATA[0]/TS_SER

TS_VAL

12

50V
47p
C469

220n

C197

12

13

14

15

16

3V3_VCC

1V2_VCC

R227
100R
R228
100R

VCC

VOUT

VUP

LNBH29EPTR

NC4

LX

NC1

1

TS_DATA[6]

TS_DATA[5]

VDD_VIO2

GND4

VDD_VCORE3

TS_DATA[4]

TS_DATA[3]

TS_DATA[2]

TS_DATA[1]

TS_CLK

TS_SYNC

VESTEL

SCH NAME :
DRAWN BY :

C199

10V

9

10

11

R243

NC3

U108

P-GND

3

2

F112

60R

C154
10u

F111

60R

24

23

22

21

20

19

18

17

16

15

14

13

1k2

R237

S2_T2_SDA

S2_T2_SCL

1k2

R238

BYP

GND

EXTM

NC2

4

10V100n

6V3

C152
10u

6V3

3V3_VCC_S2/T2

1V2_VCC_S2/T2

3V3_VCC_S2/T2

3V3_VCC_S2/T2

PROJECT NAME :

ISEL

SDA

SCL

ADDR

C435

C173

10V100n

C166

8

7

6

5

10V100n

R244
100R
R246
100R

DISEQC_OUT

10V100n

C183

10V100n

C188

6

7

8

R188

R189

6

7

8

R190

R191

R200

27k

C440

100n 10V

10V

C177

100n

R4

45

R3

3

R2

2

R1

1

47R

47R

R4

45

R3

3

R2

2

R1

1

47R

47R

50V

15p

C159

47R

17mb55

01_TUNER_S2_TUNER_DEMOD_LNBP
Ulas Dereli

S2_T2_SDA

S2_T2_SCL

3V3_VCC_S2/T2

C161

100n 10V

TSIN_D7

TSIN_D6

TSIN_D5

TSIN_D4

TSIN_D3

TSIN_D2

TSIN_D1

TSIN_D0

TSIN_CLK

TSIN_STRT

TSIN_VAL

1V2_VCC_S2/T2

T. SHT:

01-07-2013_13:39

87654321

A

B

C

D

E

F

A3

9

AX M

1 2 3 4 5 6 7 8

E24H1H12

H13J2J11

J12

J13

J14

J15

J16

K11

K12

K13

K14

A

GND124

J4

GND123

W4

GND122

W12

GND121

Y4

GND120

AA4

GND119

AB4

EFUSE

K17

LDO_BYPASS

C266

16V

W18

V20

VDD10_STBC

100n

GND0

GND1

GND2

GND3

GND4

GND5

GND6

GND7

GND8

GND9

GND11

GND10

GND13

GND12

GND15

GND14

K15

GND16

K16

GND17

K18

K19

GND19

GND18

L3L5L6L7L9

GND23

GND22

GND21

GND20

L10

L11

GND25

GND24

L12

L13

GND27

GND26

L14

L15

GND29

GND28

GND30

B

3V3_STBY

C264
100n
16V

F126

C

1V5_VCC

3V3_VCC

D

2V5_VCC

60R

F127

60R

F129

60R

F121

1k

F122

60R

C204
10u

C235
10u
6V3

C228
10u
6V3

C278
10u
6V3

C194
10u
6V3

E

VDDC_2V5

VDDC_2V5

F123

60R

F124

60R

C205 C206
100n
16V

C207
100n
16V

F

VDDC_1V5

2

1

C288
100n
10V

VDD33_NAND_STBC

W19

VDD33_STBC1

W21

VDD33_STBC0

W20

C234
10u
6V3

C242
100n
16V

C281
100n
16V

C195
100n
16V

C203
100n
16V

100n
16V

C208
100n
16V

C272

2

100n

1

10V

C233
100n
16V

C243
100n
16V

C269

16V

AVDD3V3_ADC3V3_VCC

1V5_VCC

C201
100n
16V6V3

AVDD2V5_ADC0

AVDD2V5_ADC1

C262

2

100n

1

10V

C232
100n
16V

C280
100n
16V

VDDC_2V5

C271

2

100n

1

10V

VDDC_1V5

F165

1k

C287

2

100n

1

10V

GND_APLL

GND_XTAL

GND_BIAS

R7

V24

C231
100n
16V

C279 C270
100n
16V

VDDC_2V5

VDDC_2V5

C263

2

100n

1

10V

GND_TVADC12

GND_TVADC11

N21

M21

C230
100n
16V

100n 100n
16V

C463
100n
16V

2

1

GND_TVADC10

GND_CLK1

Y3

M20

N20

C229
100n
16V

VDDC_3V3

VDDC_1V5_CLK

F159

60R

F160

60R

C253
100n
10V

GND_CLK0

GND_TVADC02

U6

K21

VDDC_1V151V15_VCC

C276

2

100n

1

10V

GND_TVADC01

GND_TVDAC

GND_AUD1

GND_AUD0

C23

D23

H14

K20

2V5_LVDS
C202
100n
16V

2V5_AUDIO
C200
100n
16V

DDR3 RAM

C277
100n
10V

2

1

C275
100n
10V

2

1

L16

L17

L18

GND33

GND32

GND31

GND_DEMOD

GND_LVDS1

G25

2

1

M4M5M6

L19

GND35

GND34

GND_LVDS0

H11

G11

DDR_MA0
DDR_MA1
DDR_MA2
DDR_MA3
DDR_MA4
DDR_MA5
DDR_MA6
DDR_MA7
DDR_MA8

DDR_MA9
DDR_MA10
DDR_MA11
DDR_MA12
DDR_MA13

DDR_BA0

DDR_BA1

DDR_BA2

DDR_WE#
DDR_CAS#
DDR_RAS#
DDR_MCKE

DDR_ODT

DDR_CLKA#

DDR_CLKA

DDR_CS#

C274
100n
10V

M10

GND38

GND37

GND36

GND_USB

GND_HDMI1

W11

C273

2

100n

1

10V

M11

M12

M13

GND41

GND40

GND39

GND_HDMI0

V14

W14

10k

R509

M14

M15

M16

GND44

GND43

GND42

VDD25_AUDAC

F21

AE5
AC3
AD7
AC8
AB3
AE7
AC2
AC7
AC1
AC6
AA2
AD2
AB2
AD5
AD1

AE4
AA3
AC5

AD4
AE2
AD3
AA1
AB7

Y1
Y2

AE3

AD6

C265
10u
6V3

M17

M18

GND45

MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
MA9
MA10
MA11
MA12
MA13
MA14

MBA0
MBA1
MBA2

MWE#
MCAS#
MRAS#
MCKE
MODT

MCLK#
MCLK

MCS

MRST

GND46

N3N4N5

M19

GND50

GND49

GND48

GND47

VDD25_AUADC

F22

2V5_AUDIO

U112

NT72567

C284
10u
6V3

N6

N10

N11

N12

GND54

GND53

GND52

GND51

VDD25_TVDAC

F20

DDR_DQL0
DDR_DQL1
DDR_DQL2
DDR_DQL3
DDR_DQL4
DDR_DQL5
DDR_DQL6
DDR_DQL7

DDR_DQU0
DDR_DQU1
DDR_DQU2
DDR_DQU3
DDR_DQU4
DDR_DQU5
DDR_DQU6
DDR_DQU7

7

DDR_DQSL

DDR_DQSL#

DDR_DQSU

DDR_DQSU#

DDR_DML
DDR_DMU

MVREF

N13

N14

N15

N16

N17

GND58

GND57

GND56

GND55

NT72567

U112

VDD25_BIAS

J18

2V5_LVDS

K2
V3
K3
V1
J3
W2
J1
W3

T2
M3
U3
L1
R1
M1
R2
M2

N2
P3
P2
P1

U2
L2

P4

C305
100n
16V

P5P6P7

N18

N19

GND63

GND62

GND61

GND60

GND59

9

VDD25_TVADC12

VDD25_TVADC11

VDD25_TVADC10

G19

H19

J19

AVDD2V5_ADC1

DDRA_DQL0
DDRA_DQL1
DDRA_DQL2
DDRA_DQL3
DDRA_DQL4
DDRA_DQL5
DDRA_DQL6
DDRA_DQL7

DDRA_DQU0
DDRA_DQU1
DDRA_DQU2
DDRA_DQU3
DDRA_DQU4
DDRA_DQU5
DDRA_DQU6
DDRA_DQU7

DDRA_DQSL
DDRA_DQSL#
DDRA_DQSU
DDRA_DQSU#

DDRA_DML
DDRA_DMU

1k

P10

P11

P12

P13

P14

GND68

GND67

GND66

GND65

GND64

VDD25_TVADC02

VDD25_TVADC01

G20

G21

AVDD2V5_ADC0

R314

1k

R315

R3R4R5

P15

P16

P17

P18

GND73

GND72

GND71

GND70

GND69

VDD33_TVADC0

VDD25_LVDS1

VDD25_LVDS0

H17

H18

H20

C236

2V5_LVDS

AVDD3V3_ADC

DDR_CLKA

DDR_CLKA#

VDDC_1V5

VDDC_1V5

DDR_RST#

S177

S174

S175

S176

GND75

GND74

16V

N.C.

R6

R11

R12

GND78

GND77

GND76

VDD11_DEMOD

G22

100n

1 2

VDDC_1V15

12

47R

R288

DDR_CS#

R13

R14

GND80

GND79

VDD33_IO1

AA12

S138

R518

4k7

R511

1k2

R15

R16

R17

R18

GND84

GND83

GND82

GND81

VDD33_IO0

Y12

R6

300R

T3T4T5

T6

GND88

GND87

GND86

GND85

VDD33_HDMI1

VDD33_HDMI0

VDD33_USB1

W13

Y13

AA11

DDR_MA0
DDR_MA1
DDR_MA2
DDR_MA3
DDR_MA4
DDR_MA5
DDR_MA6
DDR_MA7
DDR_MA8

DDR_MA9
DDR_MA10
DDR_MA11
DDR_MA12
DDR_MA13

DDR_BA0
DDR_BA1
DDR_BA2

DDR_CLKA

DDR_CLKA#

DDR_MCKE

DDR_RAS#
DDR_CAS#

DDR_WE#

1k

R510

T10

T11

T12

T13

GND92

GND91

GND90

GND89

VDD33_USB0

Y11

VDDC_3V3

N3
P7
P3
N2
P8
P2
R8
R2
T8
R3
L7
R7
N7
T3

J1
L1
M7
L9
T7
J9

M2
N8
M3

J7
K7

K9

L2

J3
K3
L3

T2
L8

R296

240R

T14

T15

T16

GND95

GND94

GND93

VDD25_MPLL

J17

2V5_LVDS

A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10/AP
A11
A12/BC
A13

NC1
NC2
NC3
NC4
NC5
NC6

BA0
BA1
BA2

CK_0
CK_1

CKE

CS

RAS
CAS
WE

RESET
ZQ

U1U4U5

T17

T18

GND99

GND98

GND97

GND96

VDD25_DLL

VDD_MMU10

T9

R10

VDDC_1V5

G7

D9

B2

VDD_1

VDD_2

VDD_3

VSS_1

VSS_2

B3

A9

V2

U11

GND102

GND101

GND100

VDD_MMU9

VDD_MMU8

VDD_MMU7

R9

T8

N1

K8

K2

VDD_4

VDD_5

VDD_6

U12

U13

U14

GND104

GND103

VDD_MMU6

VDD_MMU5

P8

P9

R8

R1

N9

VDD_7

VDD_8

U15

GND106

GND105

VDD_MMU4

VDD_MMU3

N9

R9

VDD_9

U16

U17

U18

GND108

GND107

VDD_MMU2

VDD_MMU1

M8

M9

N8

A8

A1

VDDQ_1

VDDQ_2

V4

GND110

GND109

VDD_MMU0

M7

D2

C9

C1

VDDQ_3

VDDQ_4

U113

H5TQ2G63BFR-PB

VSS_3

VSS_4

VSS_5

VSS_6

VSS_7

VSS_8

VSS_9

VSS_10

VSS_11

VSS_12

B1

T9

T1

P9

P1

M9

M1

J8

J2

G8

E1

VESTEL

SCH NAME :
DRAWN BY :

V11

V12

V13

V15

V16

V17

V18

V19

GND118

GND117

GND116

GND115

GND114

GND113

GND112

GND111

VDD_CORE15
VDD_CORE14
VDD_CORE13
VDD_CORE12
VDD_CORE11
VDD_CORE10

VDD15_LDO

N7

F1

E9

VDDQ_5

VDDQ_6

VDDQ_7

VSSQ_1

VSSQ_2

VSSQ_3

D1

B9

VDD_CORE9
VDD_CORE8
VDD_CORE7
VDD_CORE6
VDD_CORE5
VDD_CORE4
VDD_CORE3
VDD_CORE2
VDD_CORE1
VDD_CORE0

VDD15_CLK

T7

VDDC_1V5_CLK

H9

H2

VDDQ_8

VDDQ_9

VSSQ_4

VSSQ_5

E2

D8

VDD10_DDR

L8

VDDC_1V15

VDDC_1V5

VREF_DQ
VREF_CA

DQL0
DQL1
DQL2
DQL3
DQL4
DQL5
DQL6
DQL7

DQU0
DQU1
DQU2
DQU3
DQU4
DQU5
DQU6
DQU7

DQSL_0
DQSL_1

DQSU_1
DQSU_0

DML
DMU

ODT

VSSQ_6

VSSQ_7

VSSQ_8

G9

G1

F9

E8

K10

K9
K8
K7

J10

J9
J8
J7

H10

H9
H8
H7

G10

G9
G8
G7

H1
M8

E3
F7
F2
F8
H3
H8
G2
H7

D7
C3
C8
C2
A7
A2
B8
A3

F3
G3

B7
C7

E7
D3

K1

VSSQ_9

PROJECT NAME :

04_RAM_MAIN_POWER
<YOUR NAME HERE>

VDDC_1V15

VDDC_1V5

DDRA_DQL0
DDRA_DQL1
DDRA_DQL2
DDRA_DQL3
DDRA_DQL4
DDRA_DQL5
DDRA_DQL6
DDRA_DQL7

DDRA_DQU0
DDRA_DQU1
DDRA_DQU2
DDRA_DQU3
DDRA_DQU4
DDRA_DQU5
DDRA_DQU6
DDRA_DQU7

DDRA_DQSL
DDRA_DQSL#

DDRA_DQSU#
DDRA_DQSU

DDRA_DML
DDRA_DMU

DDR_ODT

17mb55

1k

1k

R275

C240
100n

1k

C285
100n
16V

R270

1k

16V

T. SHT:

01-07-2013_15:30

87654321

A

B

C

R295

R299

D

E

F

A3

9

AX M

1 2 3 4 5 6 7 8

A

B

1

2

3

4

5

6

CN102

A

B

DIMMING

C

12V_STBY

C

BACKLIGHT_ON/OFF

S2

S1

5

6

5

6

Q127

FDC642P

1

3 4

2

D

Q121

FDC642P

1

3 4

2

5

6

W_ADAPTER

JK101

E

ADAPTER SOCKET

TP8

Q123

5

4

3

2

TP11

TP10

TP9

FDC642P

1

3 4

2

1

PL100

PL101

PL103

PL102

F

12V_STBY

R358

1 2

R359

R368

5k6

220R

BACKLIGHT_DIM

MEGA_DCR_IN

R360

R361

22k

1k5

10k

R316

1 2

1k

C338

220n

Q122

10V

BC848B

MEGA_DCR_OUT

S132

NC

S128

BC848B

NC

TP297

Q124

S127

3 4

S4

S3

R211

1 2

4k7

C181

1 2

220p

50V

5

6

Q125

FDC642P

TP12

1

2

!

FS100

7A/32VDC

DIMMING CIRCUIT

3V3_VCC

1k

R202

1 2

S153

3

2

Q115
BC848B

1

1k

R490

1 2

12V_STBY

R203

1 2

4k7

C171

1 2

220p

50V

R204

1 2

4k7

C172

1 2

220p

50V

PROTECT

TP7

1

C131

2

100n

1

10V

1

Q117

2

BC858B

3

R217

12

1k

R218

12

1k

3

2

1

Q118
BC848B

C179

1u
6V3

R212
100R

DIMMING

Q109

3

2

1

BC848B

BC858B

1 2

SHORT CCT PROTECTION

3V3_STBY

R145

12

10k

1

Q108

R163

10k

R152

R146

1 2

2

10k

3

10k

1 2

VDDC_1V15

BAW56

2V5_VCC

1V2_VCC

BAW56

1V5_VCC

VESTEL

SCH NAME :
DRAWN BY :

D105

D1

R153

12

33k

R154

1 2

4k7

BAW56

R164

10k

R167

3k9

D108

5V_VCC

D107

BAW56

R148

Q107

1 2

3

1

BC848B

10k

2

R137
100R

2

3V3_VCC

3

BC858B
Q106

1

R142

1 2

10k

10k

1 2

R147

R138

PROJECT NAME :

09_POWER1_CONVERTER
<YOUR NAME HERE>

47k

VDD_AUDIO_PWR

12V_VCC

R131

1 2

10k

6k8

R130

3V3_VCC

17mb55

3V3_VCC

T. SHT:

24-06-2013_16:02

87654321

D

E

F

A3

9

AX M

1 2 3 4 5 6 7 8

AUDIO AMP for 16" to 24"

A

6V3

1u

MAIN_L

R458

C393

220n

L_AUDIO_N_OUT

4k7

10V

INP

GNDA

A2

A1

VDD_AUDIO

U123 PT2333

OUTN

VDDA

VDD1

GNDB

B3

B2

B1

A3

C397

2

100n

1

10V

C1

R459

C416

INN

4k7

SDB

C2

AMP_EN

10V

220n

MAIN_R MAIN_L

OUTP

C3

L_AUDIO_P_OUT

C377

HP_AMP_R

R418

15k

C383
180p

50V

HP_EN

R423

33k

R424

12

R439

1 2

10k

C395

HP_MAIN_INR

C389

50V47p

1u

6V3

1

INR_P

2

INR_N

3

OUTR

U121

4

GND

DRV632

5

MUTE

6

VSS

7

CN

C396

1u
6V3

INL_P

INL_N

OUTL

UVP

GND1

VDD

14

13

12

11

10

9

8

CP

HEADPHONE AMP

HP_MAIN_INL

C388

C390

47p 50V

R430

47k

C415

100n

50V

R433

3k3

47k47k

33k

R425

C399
10u

6V3

R491

50V

12

1 2

1k

R432

180p

R426R428

15k

3V3_VCC_AD

F148

60R

12V_VCC8k2

6V3

1u

C384

HP_AMP_L

3V3_VCC

COMMON SUPPLY FOR HEADPHONE

HP_AMP_L

HP_AMP_R

B

VDD_AUDIO_

U122 PT2333

INP

GNDA

OUTN

VDDA

VDD1

GNDB

INN

SDB

OUTP

C3

C2

C1

B3

B2

B1

A3

A2

R447

4k7

A1

VDD_AUDIO

I2S_BCLK
I2S_MCLK

C398
10V
100n

C401

15p

2

1

50V

10V

4k7

R446

220n

4k7

AMP_EN

C406

R517

C482

100n

50V

R_AUDIO_P_OUT

C481

100n

50V

3V3_VCC_AD

3V3_VCC_AD

C407

MAIN_R

C

220n

10V
R_AUDIO_N_OUT

12V_VCC

VDD_AUDIO_PWR

5V_VCC

F107

60R

F104 C129

60R

F110

60R

F166

60R

C394

100u

35V

100n

50V

2A Fuse or 1206 Jumper

C130

100n

50V

FS101

7A/32VDC

VDD_AUDIO

POP NOISE CIRCUIT

AMP_MUTE

HEADPHONE OUTPUT

F161

1k

F162

1k

AMP_EN

R466

1 2

10k

C452
10n
16V

2

3

1

C451
10n
16V

BC848B
Q140

F143

1k

F138

1k

NC

HP_DETECT

10k

R411

1 2

VDD_AUDIO_

3V3_VCC

10k

R454

C420
100n
16V

3V3_VCC

TP230

R384

12V_VCC

1 2

10k

R501
100R

1

BC848B

Q141

3

2

1

TP229

C378
10n
16V

S150

1 2

S149

1 2

C355
10n
16V

D116

R467

10k

TP51

1

1

C5V6

NC

16V

10u

C433

TP52

4k7

R383

Q145

BC858B

12

1

1

R485

R484

R481

1 2

10k

47k

1

3

100k

1

2

6

3

4

5

7

3V3_VCC

2

JK104

R483

R482

A

B

1k

C

100k

10k

25

26

27

28

29

30

31

32

33

34

35

3

NC9

NC10

PD#

ERROR#

2

R474

VDD_AUDIO

36

NC11

VDDRA

GNDR

VDDRB

VDDLB

GNDL

VDDLA

NC12

1

37

38

VDD_AUDIO

39

RA

RB

LB

LA

40

41

42

43

44

45

46

47

48

R_AUDIO_P_OUT

R_AUDIO_N_OUT

VDD_AUDIO

L_AUDIO_N_OUT

L_AUDIO_P_OUT

VDD_AUDIO

AMP_EN

100n

50V

C425C414

100n

50V

C408

100n

50V

R_AUDIO_P_OUT

R_AUDIO_N_OUT

L_AUDIO_P_OUT

L_AUDIO_N_OUT

C430

R468

C413

R445

18R

18R

330p

R451

330p

R469

C431

18R

18R

330p

L114

330p

22u

F151

L111

22u

C405

L112

22u

NC

220R
220R

F153

22u

L113

F152

220R

220R

F150

50V

50V

50V

50V

HP_MUTE

1n

C421

50V

1u

C422

1n

C412

50V

1n

C424

50V

1n

C427

50V

C400

C428

C423

1u

NC

1u

1u

C403
220n
50V

C404
220n
50V

HP_EN

R479

1 2

10k

TP131TP14

1

TP151TP16

3

2

1

CN120

1

2

3

4

1

VESTEL

SCH NAME :
DRAWN BY :

BC848B
Q143

D

HP_MAIN_INL

HP_AMP_L

R453

20k

R452

10k3V3_VCC_AD

HP_EN

R504

47k

3V3_VCC_AD

C417

1u

6V3

R460

1 2

10k

E

HP_AMP_R

HP_MAIN_INR

3V3_VCC_AD

AD_AMP_RESET

SYS_SCL

SYS_SDA

24

LINN

23

LOUT

22

UVP

21

PGND

20

PVDD

19

6V3
1u
C418

CP

18

CN

17

PVSS

16

EN

15

SGND

14

ROUT

13

RINN

R470

10k
R477 1k
100R
R476
100R
R475
100R

NC4

RESET#

12

NC5

SCL

11

SA0

SDA

10

BCLK

MCLK

U124

AD87587

MONO

LRCIR

9

8

I2S_WS

DGND

DEF

7

DVDD

NC3

6

NC6

NC2

5

NC7

NC1

4

NC8

SDATA

I2S_DATA

F

R473

BC848B

C432
100n
16V

3

1

Q144

2

R480

10k

PROJECT NAME :

06_AUDIO_AMP_HP_AMP
<YOUR NAME HERE>

12

17mb55

T. SHT:

24-06-2013_16:22

87654321

D

E

F

A3

9

AX M