Charmglow Stainless Steel Natural Gas Drop-In Sear Burner Owner's Manual

SEAR BURNER

Outdoor Gas Sear Burner / Hornilla para dorar a gas para uso al aire libre

WARNING / ADVERTENCIA

HAZARDOUS EXPLOSION MAY RESULT IF THESE WARNINGS AND INSTRUCTIONS

ARE IGNORED. READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS IN THIS

MANUAL TO AVOID PERSONAL INJURY, INCLUDING DEATH OR PROPERTY DAMAGE.

SE PUEDE PRODUCIR UNA EXPLOSIÓN PELIGROSA SI SE HACE CASO OMISO A

ESTAS ADVERTENCIAS E INSTRUCCIONES. LEA Y SIGA TODAS LAS ADVERTENCIAS

E INSTRUCCIONES EN ESTE MANUAL PARA EVITAR LESIONES PERSONALES,

INCLUSO LA MUERTE, O LOS DAÑOS MATERIALES.

SAVE THIS MANUAL FOR FUTURE REFERENCE

GUARDE ESTE MANUAL PARA REFERENCIA FUTURA

NOTICE TO INSTALLER:

LEAVE THESE INSTRUCTIONS

WITH THE SEAR BURNER OWNER

FOR FUTURE REFERENCE.

AVISO PARA EL

INSTALADOR:

ENTREGUE ESTAS

INSTRUCCIONES AL PROPIETARIO

DE LA HORNILLA PARA DORAR

COMO REFERENCIA FUTURA.

OWNER’S MANUAL / MANUAL DEL PROPIETARIO

ASSEMBLY AND OPERATING INSTRUCTIONS / INSTRUCCIONES DE ARMADO Y OPERACIÓN

Stainless Steel Natural Gas
Drop-In Sear Burner

Hornilla para Dorar a Gas Natural
Empotrable de Acero Inoxidable

1

WE WANT YOU TO ASSEMBLE AND USE YOUR SEAR BURNER AS SAFELY AS POSSIBLE.

THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO ATTRACT YOUR ATTENTION TO

POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR SEAR BURNER.

WHEN YOU SEE THE SAFETY ALERT SYMBOL

PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS!

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY

BEFORE ASSEMBLING AND OPERATING YOUR SEAR BURNER.

IMPORTANT SAFETY

WARNINGS

DANGER

IF YOU SMELL GAS:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, keep away from the appliance and immediately call your gas supplier or your
fire department.

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any
other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other
appliance.

• DO NOT store LP gas cylinders under or near this appliance.

• A fire causing death or serious injury may occur if the above is not followed exactly.

WARNING

DANGER

2

TABLE OF CONTENTS

DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

WARNING: Be alert to the possibility of serious bodily injury if the instructions are not followed. Be sure to read and

carefully follow all of the messages.

CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.

General Warnings. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Attachment and Safe Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Leak Testing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4–5

Pre-start Check List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Lighting Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6–7

Operating Sear Burner and Helpful Hints. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7–8

Proper Care and Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Transporting and Storage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Trouble Shooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Frequently Asked Questions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Parts List and Assembly Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11–13

Warranty Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Back Cover

3

WARNING

• Never use liquid propane gas (LP) in a unit designed for natural gas.

• Never use charcoal briquets or lighter fluid in a gas sear burner.

• Leak test all connections before first use, even if sear burner was purchased fully assembled

and after

each time the hose is connected to natural gas supply.

• Never check for leaks using a match or open flame.

CAUTION! Strong odors, colds, sinus congestion, etc. may prevent the detection of natural gas.

Use caution and common sense when testing for leaks.

• Charmglow Natural Gas Sear Burner is an accessory to the Charmglow Stainless Steel Natural Gas
Drop-In 4-Burner Grill. This Sear Burner is not designed to be used by itself.

• Always keep your gas sear burner free and clear of gasoline, paint thinner, or other flammable vapors
and liquids or combustible materials.

• Always check the sear burner prior to each use as indicated in the "Pre-Start Check List" section of this
manual.

• DO NOT obstruct the flow of combustion or ventilation air.

• Keep children and pets away from hot sear burner. DO NOT allow children to use or play near this sear
burner.

• DO NOT leave the sear burner unattended while in use.

• DO NOT allow the gas hose to come in contact with hot surfaces.

• DO NOT allow grease from drain hole to fall on hose.

• Keep any electrical supply cords away from water or heated surfaces.

• Keep a fire extinguisher on hand acceptable for use with gas products. Refer to your local authority
to determine proper size and type.

• For household use only. DO NOT use this sear burner for anything other than its intended purpose.

• DO NOT use while under the influence of drugs or alcohol.

• Sear burner is hot when in use. To avoid burns:

• DO NOT attempt to move the sear burner.

• Wear protective gloves or oven mitts.

• DO NOT touch any hot sear burner surfaces.

• DO NOT wear loose clothing or allow hair to come in contact with sear burner.

USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR GAS SEAR BURNER.

FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL

COULD RESULT IN SEVERE BODILY INJURY OR PROPERTY DAMAGE.

SAVE THIS MANUAL FOR FUTURE REFERENCE.

GENERAL WARNINGS

4

WARNING

• FOR OUTDOOR USE ONLY. DO NOT operate indoors or in an enclosed area such as a garage,
shed or breezeway.

• Use your sear burner OUTDOORS in a well ventilated space away from dwellings or other
buildings to prevent dangers associated with gas accumulation and toxic vapors. We recommend
your grill be situated at least 10 feet (3.1 m) from buildings.

• Maintain a minimum clearance of 36 inches (91 cm) between all sides of sear burner and walls or
other combustible material. DO NOT use sear burner under overhead unprotected combustible
construction.

• DO NOT use or install this sear burner in or on a recreational vehicle and/or boat.

FOLLOW THE INSTRUCTIONS FOR CONNECTING YOUR STAINLESS STEEL NATURAL
GAS DROP-IN 4-BURNER GRILL TO THE NATURAL GAS SOURCE.

These instructions are located in the 810-6835-0 Stainless Steel Natural Gas Drop-In 4-Burner Grill owner’s
manual

.

After main grill installation follow the instructions below for connecting your sear burner to the

Quick-Disconnect coupler.

• Never use your grill without leak testing all gas connections and hoses. See the section on

“Leak Testing” in this manual for proper procedures.

• Visually inspect the hose assembly prior to each use for evidence of damage, excess wear or

deterioration. If found, replace the assembly before using your grill. Only the Brinkmann
supplied replacement should be used.

WARNING

Connect the sear burner hose
fitting to the grill body hose by
inserting the fitting into the
quick-disconnect coupler.

LEAK TESTING:

To prevent fire or explosion hazard:

• DO NOT smoke or permit ignition sources in the area while conducting a leak test.

• Perform test OUTDOORS only in a well ventilated area.

• Never perform a leak test with a match or open flame.

• Never perform a leak test while the sear burner is in use or while sear burner is still hot.

DANGER

Quick-Disconnect Coupler

Sear Burner Hose Fitting

Push sleeve back to attach

Sleeve