Charmglow 730-0289 Owner's Manual

Stainless Steel Gas Grill
USE AND CARE GUIDE
MODEL NO.: 730-0289

®

®

FOR OUTDOOR USE ONLY

K15Y06N-1

PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE

TABLE OF CONTENTS

Safety Instructions ……………………..
Side shelf assembly………..………….
Side shelf handle assembly………..…
Battery Assembly ……………………..
Condiment assembly
Installation of Nature gas regulator…..
To Match Light the Grill …………..

Lighting Instructions…………………………

Lighting Illustrations…………………….

………………….

2~7
8
9
10
10
11
12
13
14

Operating Instructions………………….15
Cleaning & Maintenance………………16
Trouble Shooting …………………….17~18
Exploded View…………………………..19
Grill Parts List ……………………………20
Grilling Hints …………………………….21
Grill Cooking Chart ………………………22~24
Grill Recipe Suggestions………………..25~27
Limited Warranty …… ………………….28

READ THE FOLLOWING INSTRUCTIONS CAREFULLY AND BE SURE YOUR GRILL IS PROPERY
INSTALLED, ASSEMBLED AND MAINTAINED. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY
RESULT IN SERIOUS BODILY INJURY AND/OR PROPERTY DAMAGE. IF YOU HAVE QUESTIONS
CONCERNING ASSEMBLY OR OPERATION, CALL OUR SERVICE CENTER AT 1-800-913-8999,
MONDAY THROUGH FRIDAY 8:00AM-5:00PM, PACIFIC COAST TIME.

NOTE TO INSTALLER:

LEAVE THESE INSTRUCTIONS WITH THE CONSUMER AFTER INSTALLATION.

NOTE TO THE CONSUMER:

RETAIN THESE FOR FUTURE REFERENCE.

THIS OUTDOOR COOKING GAS APPLIANCE IS NOT INTENDED TO BE INSTALLED IN OR ON
RECREATIONAL VEHICLES AND/OR BOATS.

K15Y06N-1

1

SAFETY INSTRUCTIONS

***** WARNING *****

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, immediately call your gas supplier or your fire
department.

K15Y06N-1

2

SAFETY INSTRUCTIONS

WARNING

Do not try lighting this appliance without first reading the
“LIGHTING INSTRUCTIONS” section of this manual.

DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS
OR GRILL BOTTOM. This can severely upset combustion airflow

or trap excessive heat in the control area.

INSECT WARNING!!! Spiders and insects can nest in the
burners of this and any other grill, and cause the gas to
flow improperly. This is a very dangerous condition, which
can cause a fire to occur behind and beneath the valve
panel, thereby damaging the grill and making it unsafe to
operate. Inspect the grill twice a year.

WARNING
ELECTRICAL GROUNDING INSTRUCTIONS
This appliance (rotisserie motor) is equipped
with a plug and should be plugged directly into
a properly grounded receptacle. DO NOT cut or
remove the grounding prong from this plug.

Keep the rotisserie motor electric cord away from
the heated surfaces of the grill. When not in use
remove and store the motor in a dry location

RACK WHEN USING THE ROTISSERIE
BURNER. THE HIGH HEAT COMING
FROM THE BURNER MAY CAUSE THE
WARMING RACK TO BEND.

DO NOT LEAVE THE GRILL
UNATTENDED WHILE COOKING.

CAUTION: REMOVE THE WARMING

K15Y06N-1

3

SAFETY INSTRUCTIONS

WARNING: Always keep your face and body as far away from the burner as

possible when lighting.

WARNING: IMPORTANT!

BEFORE LIGHTING…

Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or
abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is present. Only the
pressure regulator and hose assembly supplied with the unit should be used. Never substitute
regulators for those supplied with the grill. If a replacement is necessary, contact the factory for
proper replacement.

Keep a spray bottle of soapy water near the gas
supply valve and check the connections before

Do not attempt to light the grill if odor of gas
is present. Call for service 1-800-913-8999.

ROTISSERIE DRIVE MOTOR

USE ONLY FOR OUTDOORS, DO NOT EXPOSE TO
RAIN.

CAUTION: TO ENSURE CONTINUED PROTECTION
AGAINST RISK OF ELECTRIC SHOCK, CONNECT TO
PROPERLY GROUNDED OUTLETS ONLY, TO REDUCE
THE RISK OF ELECTRIC SHOCK, KEEP EXTENSION
CORD CONNECTION DRY AND OFF THE GROUND.

K15Y06N-1

4

SAFETY INSTRUCTIONS

TESTED IN ACCORDANCE WITH ANSI
Z21.58a • CSA 1.6a-2006 STANDARD FOR
OUTDOOR COOKING GAS APPLIANCES. THIS
GRILL IS FOR OUTDOOR USE ONLY.

Check your local building codes for the proper
method of installation. In the absence of local
codes, this unit should be installed in accordance
with the National Fuel Gas Code No. Z223.1-1988
and the National Electrical Code ANSI/NFPA No.
70-1990.

CALIFORNIA PROPOSITION 65-WARNING

The burning of gas fuel generates some
byproducts, which are on the list of substances,
which are known by the State of California to
cause cancer or reproductive harm. California law
requires businesses to warn customers of
potential exposure to such substances. To
minimize exposure to these substances, always
operate this unit according to the use and care
manual, ensuring you provide good ventilation
when cooking with gas.

SAFETY PRACTICES TO AVOID PERSONAL INJURY

When properly cared for, your grill will give safe,
reliable service for many years. However, extreme
care must be used since the grill produces intense
heat and that can increase accident potential. When
using this appliance basic safety practices must be
followed, including the following:

Do not repair or replace any part of the grill unless
specifically recommended in this manual. All other
service should be referred to a qualified technician.

CHILDREN SHOULD NOT BE LEFT ALONE OR
UNATTENDED IN AN AREA WHERE THE GRILL IS
BEING USED. NEVER ALLOW THEM TO SIT, STAND
OR PLAY ON OR AROUND THE GRILL AT ANY
TIME.

DO NOT STORE ITEMS OF INTEREST TO
CHILDREN AROUND OR BELOW THE GRILL OR IN
THE CART. NEVER ALLOW CHILDREN TO CRAWL
INSIDE OF THE CART.

Never let clothing, pot holders or other flammable
materials come in contact with or too close to any
grate, burner or hot surface until it has cooled. Fabric
may ignite and result in personal injury.

For personal safety, wear proper apparel. Loose fitting
garments or sleeves should never be worn while using
this appliance. Some synthetic fabrics are highly
flammable and should not be worn while cooking.

Only certain types of glass, heatproof glass ceramic,
earthenware, or other glazed utensils are suitable for
grill use. Theses types of materials may break with
sudden temperature changes. Use only on low or
medium heat settings according to the manufacturer’s
directions.

Do not heat unopened food containers as a build-up of
pressure may cause the container to burst.

Use a covered hand when opening the grill lid. Never
lean over an open grill.

WHEN LIGHTING A BURNER, ALWAYS PAY CLOSE
ATTENTION TO WHAT YOU ARE DOING. BE
CERTAIN YOU ARE TURNING THE IGNITER
LABELED FOR THE BURNER YOU INTEND ON
USING.

K15Y06N-1

5

SAFETY INSTRUCTIONS

When using the grill, do not touch the grill rack,
burner grate or immediate surroundings as these
areas become extremely hot and could cause
burns. Use only dry potholders. Moist or damp
potholders on hot surfaces may cause burns from
steam. Do not use a towel or bulky cloth in place
of potholders. Do not let potholders touch hot
portions of the grill rack.

Grease is flammable. Let hot grease cool before
attempting to handle it. Avoid letting excess
grease deposits collect in the grease tray at the
bottom of the grill’s firebox. Clean often.

For proper lighting and performance of the burners
keep the burner ports clean. It is necessary to
clean them periodically for optimum performance.
The burners will only operate in one position and
must be mounted correctly for safe operation.

Clean the grill with caution. Avoid steam burns; do
not use a wet sponge or cloth to clean the grill
while it is hot. Some cleaners produce noxious
fumes or can ignite if applied to a hot surface.

Be sure all grill controls are turned off and the grill
is cool before using any type of aerosol cleaner on
or around the grill. The chemical that produces the
spraying action could, in the presence of heat,
ignite or cause metal parts to corrode.

Do not use the grill for cooking excessively fatty
meats or products, which promote flare-ups. Do
not operate the grill under unprotected

combustible construction. Use only in well ventilated
areas. Do not use in buildings, garages, sheds,
breezeways or other such enclosed areas. THIS
UNIT IS FOR OUTDOOR USE ONLY.

Keep the area surrounding the grill free from
combustible materials, trash, or combustible fluids
and vapors such as gasoline or charcoal lighter
fluid. Do not obstruct the flow of combustion and
ventilation air. If the unit is stored indoors ensure
that it is cool.

DO NOT USE BRIQUETTES OF ANY KIND IN THE
GRILL.

The 730-0289 Charmglow Grill is designed for
optimum performance without the use of briquettes.
Do not place briquettes on the radiant as this will
block off the area for the grill burners to vent.
Adding briquettes can damage ignition components
and knobs, and void the warranty.

Keep the back of the cart free and clear from debris.
Keep any electrical supply cord, or the rotisserie
motor cord away from the heated areas of the grill.

Never use the grill in extremely windy conditions. If
located in a consistently windy area (oceanfront,
mountaintop, etc.) a windbreak will be required (see
below). Always adhere to the specified clearance.

K15Y06N-1

6

SAFETY INSTRUCTIONS

CHECKING FOR GAS LEAKS

Never test for leaks with a flame. Prior to first use
and at the beginning of each new season, you must
check for gas leaks.

Follow these steps:

1.Make soap solution by mixing one part liquid
detergent and one part water.

2.Turn off heat control valves, and then turn on gas
at source.

NATURAL GAS SAFETY

Your natural gas is designed to operate on
natural gas grill only, at a pressure of 4” water
column(1/4 psig or 1.75 kpa) regulated at the
pre-set supplied regulator. Check with your gas
utility for local gas pressure and with your local
municipality for building code requirements. If
your residential gas utility line pressure has not
been regulated to 7” W.C. contact your local gas
utility or gas grill dealer for professional
assistance.

Check with your gas utility or with local building
codes for instructions to install gas supply line,
or call a licensed and knowledgeable installer.

It is recommended that an “ON-OFF” shut off
valve be installed at the gas supply source;
outdoors after the gas line piping exits outside
the wall and before the quick-disconnect. In a
branch fuel line, it should be installed before the

3. Apply the soap solution to all gas connections.
Bubbles will appear in the soap solution if
connections are not properly sealed. Tighten or
repair as necessary.

4. If you have a gas leak that you cannot repair,
turn off the gas at the source, disconnect the
fuel line from grill and immediately call your

grill dealer or gas supplier for professional
assistance.

gas line piping enters the ground indoors in an
accessible location near the supply line.

Pipe sealing compound or pipe thread tape of
the type resistant to the action of natural gas
must be used on all male pipe threads when
making the connection.

Disconnect your gas grill from its fuel source
when the gas supply lines are being tested at
high pressures by the gas company. This
appliance and its individual shut off valve must
be disconnected from the gas supply piping
system during any pressure testing of that
system at pressure in excess of ½ psi (3.5 kpa).

Turn off your gas grill when the gas supply is
being tested at low pressures by the gas
company. This appliance must be isolated from
the gas supply piping system by closing its
individual manual shut off valve during any
pressure testing of the gas supply piping system
at pressures equal or less than ½ psi (3.5kpa).

K15Y06N-1

SIDE SHELF ASSEMBLY

1. The screws used to attach the side shelf are already screwed into the left side burner
And right side panel(see the figure below).loosen the screws from the left side burner
And right side panel, install the side shelves and tighten screws as the figure shown
below.

Attention: The left side shelf should be screwed from outside into inside with 4pcs

screws, the right side shelf should be screwed:

a. the upper 2 screws to the right panel should be screwed from inside to outside

for side shelf.

b. the screws below them should be firmed from outside into inside.

8

K15Y06N-1