Charmglow 720-0289 User Manual

Stainless Steel Gas Grill USE AND CARE GUIDE MODEL NO.: 720-0289

PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE

® ®

FOR OUTDOOR USE ONLY

K15Y06P-1

TABLE OF CONTENTS

SECTION ONE Safety Instructions…………………………2~6 Placement of the grill………………………6

SECTION TWO Side shelf Assembly………………………7

Side shelf handle Assembly………………..8 Battery assembly……………………………9 Condiment assembly……………………… 9 Propane Tank Assembly ……………….10

To Match light the Gill……………………...11

SECTION THREE Gas Precautions…………………………………13 Leak Testing……………………………..….14 Installer Final Check…………………..…...15

SECTION FOUR Operating Instructions……………………16

Lighting Instructions……………………....17

Lighting Illustration………………………..18

Read this Care and Use Manual carefully and completely before using your grill to reduce the risk of fire, burn hazard or other injury.

Hook-Up…………………………….…12

SECTION FIVE Using the side burner…………………… Care & Maintenance ………………. Trouble Shooting…………………………

SECTION SIX Exploded View…………………………….. Parts List ………………………………….. Grilling Hints……………………………….. Grill Cooking Chart ………………………. Grill Recipe Suggestion ………………….

SECTION SEVEN Limited Warranty ………………………….

19 19 20~22

23 24 25 26~27 28~29

K15Y06P-1

SAFETY INSTRUCTIONS

***** WARNING *****

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, immediately call your gas supplier or your fire de

artment.

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable vapors and

liquids in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in

the vicinity of this or any other appliance.

K15Y06P-1

SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS

WARNING

Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual.

INSECT WARNING!!! Spiders and insects can nest in the burners of this and any other grill, and cause the gas to flow improperly. This is a very dangerous condition, which can cause a fire to occur behind and beneath the valve panel, thereby damaging the grill and making it unsafe to operate. Inspect the grill twice a year.

LP Gas Cylinder must be fitted with Overfill Protection Device (OPD).

DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can severely upset combustion airflow or trap excessive heat in the control area.

Gas Installation Codes

A statement that the installation must conform with local codes or, in the absence of local codes, with wither the national fuel gas code, ANSIZ223.1/NFPA S4, natural gas and propane installation code, CSA B149.1, or propane storage and handling code, B149.2, or the standard for Recreational vehicles, ANSI A 119.2, and CSA Z240 RV series Recreational vehicle code, as applicable.

WARNING

a) DO NOT store a spare LP-gas cylinder under or near this appliance. b) NEVER fill the cylinder beyond 80% full. c) If the information in “a” and “b” is not followed exactly, a fire causing death or

serious injury may occur.

CAUTION: REMOVE THE

WARMING RACK WHEN USING THE ROTISSERIE BURNER. THE HIGH HEAT COMING FROM THE BURNER MAY CAUSE THE WARMING RACK TO BEND.

DO NOT LEAVE THE GRILL UNA TTENDED WHILE COOKING.

K15Y06P-1

SAFETY INSTRUCTIONS

RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS

WARNING: Always keep your face and body as far away from the burner as

possible when lighting.

WARNING: IMPORTANT!

BEFORE LIGHTING…

Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear , or abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is present. Only the pressure regulator and hose assembly supplied with the unit should be used. Never substitute regulators for those supplied with the grill. If a replacement is necessary, contact the factory for proper replacement.

Screw the regulator onto the tank. Leak check the hose and re gulator connections with a soap and water solution before operating the grill.

Keep a spray bottle of soapy water near the gas supply valve and check the connections before each use.

Do not attempt to light the grill if odor of gas is present. Call for service 1-800-913-8999.

K15Y06P-1

SAFETY INSTRUCTIONS

TESTED IN ACCORDANCE WITH ANSI Z21.58a • CSA 1.6a-2006 STANDARD FOR OUTDOOR COOKING GAS APPLIANCES. THIS GRILL IS FOR OUTDOOR USE ONLY.

Check your local building codes for the proper method of installation. In the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas and propane Installation Code. Electrical Code, ANSI/NF PA 70.

CALIFORNIA PROPOSITION 65-WARNING

The burning of gas fuel generates some byproducts, which are known by the State of California to cause cancer or reproductive harm. To minimize exposure to these substances, always operate this unit according to the use and care manual, ensuring you provide good ventilation when cooking with gas.

SAFETY PRACTICES TO AVOID PERSONAL INJURY

When properly cared for, your grill will give safe, reliable service for many years. However, extreme care must be used since the grill produces intense heat and that can increase accident potential. When using this appliance basic safety practices must be followed, including the following:

Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service should be referred to a qualified technician.

This outdoor cooking gas appliance is not intended to be installed in or on recreational vehicles and/or boats.

CHILDREN SHOULD NOT BE LEFT ALONE OR UNATTENDED IN AN AREA WHERE THE GRILL IS BEING USED. NEVER ALLOW THEM TO SIT, STAND OR PLAY ON OR AROUND THE GRILL AT ANY TIME.

DO NOT STORE ITEMS OF INTEREST TO CHILDREN AROUND OR BELOW THE GRILL OR IN THE CART. NEVER ALLOW CHILDREN TO CRAWL INSIDE OF THE CART.

Never let clothing, pot holders or other flammable materials come in contact with or too close to any grate, burner or hot surface until it has cooled. Fabric may ignite and result in personal injury.

For personal safety , wear p roper appa rel. Loose fitting garments or sleeves should never be worn while using this appliance. Some synthetic fabrics are highly flammable and should not be worn while cooking.

Only certain types of glass, heatproof glass ceramic, earthenware, or other glazed utensils are suitable for grill use. Theses types of materials may break with sudden temperature changes. Use only on low or medium heat settings according to the manufacturer’s directions.

Do not heat unopened food containers as a build-up of pressure may cause the container to burst.

Use a covered hand when opening the grill lid. Never lean over an open grill.

WHEN LIGHTING A BURNER, ALWAYS PAY CLOSE ATTENTION TO WHAT YOU ARE DOING. BE CERTAIN YOU ARE TURNING THE IGNITER LABELED FOR THE BURNER YOU INTEND ON

USING.

K15Y06P-1

SAFETY INSTRUCTIONS

When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place of potholders. Do not let potholders touch hot portions of the grill rack.

Grease is flammable. Let hot grease cool before attempting to handle it. Avoid letting excess grease deposits collect in the grease tray at the bottom of the grill’s firebox. Clean often.

For proper lighting and performance of the burners keep the burner ports clean. It is necessary to clean them periodically for optimum performance. The burners will only operate in one position and must be mounted correctly for safe operation.

Clean the grill with caution. Avoid steam burns; do not use a wet sponge or cloth to clean the grill while it is hot. Some cleaners produce noxious fumes or can ignite if applied to a hot surface.

Be sure all grill controls are turned off and the grill is cool before using any type of aerosol cleaner on or around the grill. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal parts to corrode.

Do not use the grill for cooking excessively fatty meats or products, which promote flare-ups. Do not operate the grill

PLACEMENT OF THE GRILL

under unprotected combustible construction. Use only in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or other such enclosed areas. THIS UNIT IS FOR

OUTDOOR USE ONLY.

Keep the area surrounding the grill free from combustible materials, trash, or combustible fluids and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion and ventilation air. If the unit is stored indoors ensure that it is cool. If propane is used, the cylinder must be unhooked and the propane cylinder stored outside in a well-ventilated area, out of the reach of children.

DO NOT USE BRIQUETTES OF ANY KIND IN THE GRILL.

The 720-0289 Charmglow Grill is designed for optimum performance without the use of briquettes. Do not place briquettes on the radiant as this will block off the area for the grill burners to vent. Adding briquettes can damage ignition components and knobs, and void the warranty.

Keep the back of the cart free and clear from debris. Keep any electrical supply cord, or the rotisserie motor cord away from the heated areas of the grill.

Never use the grill in extremely windy conditions. If located in a consistently windy area (oceanfront, mountaintop, etc.) a windbreak will be required (see below). Always adhere to t he specified clearance.

NEVER USE A DENTED OR RUSTY PROPANE TANK

CLEARANCE To Non-Combustible Construction

A minimum of 3” clearance from the back of the grill to non-combustible construction is required for the lid to open fully. DO NOT INSTALL THIS UNIT INTO COMBUSTIBLE ENCLOSURES! MINIMUM CLEARANCE: 24”Clearance from all sides to combustible material.

LOCA TION

When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths and keeping any gas supply lines as short as possible. Locate the grill only in a well-ventilated area. Never locate the grill in a building, garage, breezeway, shed or other such enclosed areas. During heavy use, the grill will produce a lot of smoke. Lock the wheels after the grill is placed in a suitable position.

K15Y06P-1

SIDE SHELF ASSEMBLY

1. The screws used to attach the side shelf are already screwed into the left side burner And right side panel(see the figure below).loosen the screws from the left side burner And right side panel, install the side shelves and tighten screws as the figure show below. Attention: The left side shelf should be screwed from outside into inside with 4pcs screws, the right side shelf should be screwed:

a. the upper 2 screws to the right panel should be screwed from inside to outside

for side shelf.

b. the screws below them should be firmed from outside into inside.

K15Y06P-1

SIDE SHELF HANDLE ASSEM BLY

1. The screws used to attach the side shelf handle are already screwed into the side shelf handle(see the figure below).loosen the screws from the side shelf handle, align with the holes in the side shelf, and secure into the holes on the right side

shelf of the grill.

K15Y06P-1

BA TTER Y ASSEMBLY

In order to install the battery, remo ve the ignition button housing. Please keep the positive pole of the battery facing toward you. Insert the battery into the housing. Replace the ignition button housing after battery is installed.

CONDIMENT RACK ASSEMBLY

Assemble the condiment rack inside of the left door.

K15Y06P-1

+ 21 hidden pages