Charmglow 720-0234 Owner's Manual

STAINLESS STEEL GAS GRILL

USE AND CARE GUIDE MODEL NO.: 720-0234

FOR OUTDOOR USE ONLY

PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE

DO NOT RETURN TO PLACE OF PURCHASE.

TABLE OF CONTENT

SECTION ONE

Importance………………………….….. 1 Precautions…………………………. . 2-3 Placement of the grill……………….…. 3

SECTION TWO Screw description………………………4 Assembly Instructions……………… 5-12 Propane tank assembly……………… ..13 Your gas grill is ready to use…………..14 Gas hook up……………………………15 Leak testing……………………….. 15-16 Installer final checklist………………. . 16 Operating Instructions………………. 17 Lighting Instructions………………. 17-18 Using the side burner……………….…. 19

SECTION THREE

Care and maintenance……………………..19 Care and maintenance of the side burner….20 Trouble shooting…………………………..20

SECTION FOUR

Exploded View……………………………21 Parts List…………………………………. 22 Grilling hints……………………………... 23 Grill cooking chart……………………. 24-26 Grill recipe suggestions………………. 27-29

SECTION FIVE

Limited Warranty………………………… 30

IMPORTANCE

* * * WARNING * * *

FOR YOUR SAFETY If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid

4. If odor continues, immediately call your gas supplier or your fire department.

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or

any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other

appliance.

PRECAUTIONS

WARNING Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual.

TESTED IN ACCORDANCE WITH ANIS Z21.58b-2002, CGA 1.6B-2002 STANDARD FOR OUTDOOR COOKING GAS APPLIANCES. THIS GRILL IS FOR OUTDOOR USE ONLY.

Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58 or CSA B149.1 Natural Gas and Propane Installation Code, and the National Electrical Code, ANSI/NFPA 70, or the Canadian Electrical Code, CSA C22.1.

CALIFORNIA PROPOSITION 65WARNING

The burning of gas fuel generates some byproducts, which are on the list of substances which are known by the State of California to cause cancer or reproductive harm. California law requires businesses to warn customers of potential exposure to such substances. To minimize exposure to these substances, always operate this unit according to the use and care manual, ensuring you provide good ventilation when cooking with gas.

SAFETY PRACTICES TO AVOID PERSONAL INJURY

When properly cared for, your 720-0234 (Charmglo w) Grill will give safe, reliable service for many years. However, extreme care must be used since the grill produces intense heat and that can increase accident potential. When using this appliance basic safety practices must be followed, including the following:

Read this Care and Use Manual carefully and completely before using your grill to reduce the risk of fire, burn hazard or other injury.

Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service should be referred to a qualified technician.

CHILDREN SHOULD NOT BE LEFT ALONE OR UNATTENDED IN AN AREA WHERE THE GRILL IS BEING USED. NEVER ALLOW THEM TO SIT, STAND OR PLAY ON OR AROUND THE GRILL AT ANY TIME.

DO NOT STORE ITEMS OF INTEREST TO CHILDREN AROUND OR BELOW THE GRILL OR IN THE CART. NEVER ALLOW CHILDREN TO CRAWL INSIDE OF THE CART.

Never let clothing, pot holders or other flammable materials come in contact with or too close to any grate, burner or hot surface until it has cooled. Fabric may ignite and result in personal injury.

For personal safety, wear proper apparel. Loose fitting garments or sleeves should never be worn while using this appliance. Some synthetic fabrics are highly flammable and should not be worn while cooking.

Only certain types of glass, heat-proof glass ceramic, earthenware, or other glazed utensils are suitable for grill use. Theses types of materials may break with sudden temperature changes. Use only on low or medium heat settings according to the manufacturer’s directions.

Do not heat unopened food containers as a build-up of pressure may cause the container to burst.

Use a covered hand when opening the grill lid. Never lean over an open grill.

WHEN LIGHTING A BURNER, ALWAYS PAY CLOSE ATTENTION TO WHAT YOU ARE DOING. BE CERTAIN YOU ARE TURNING THE IGNITER LABELED FOR THE BURNER YOU INTEND ON USING.

PRECAUTIONS

When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place or potholders. Do not let potholders touch hot portions of the grill rack.

Grease is flammable. Let hot grease cool before attempting to handle it. Avoid letting excess grease deposits collect in the grease tray at the bottom of the grill’s firebox. Clean often.

DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can severely upset

combustion air flow or trap excessive heat in the control area.

For proper lighting and performance of the burners keep the burner ports clean. It is necessary to clean them periodically for optimum performance. The burners will only operate in one position and must be mounted correctly for safe operation.

Clean the grill with caution. Avoid steam burns; do not use a wet sponge or cloth to clean the grill while it is hot. Some cleaners produce noxious fumes or can ignite if applied to a hot surface.

INSECT WARNING!!! Spiders and insects can nest in the burners of this and any other grill, and cause the gas to flow improperly. This is a very dangerous condition which can cause a fire to occur behind the value panel, thereby damaging the grill and making it unsafe to operate. Inspect the grill twice a year.

Be sure all grill controls are turned off and the grill is cool before using any type of aerosol cleaner on or

around the grill. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal parts to corrode.

Do not use the grill for cooking excessively fatty meats or products which promote flare-ups. Do not operate the grill under unprotected combustible construction. Use only in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or other such enclosed areas.

THIS UNIT IS FOR OUTDOOR USE ONLY.

Keep the area surrounding the grill free from combustible materials, trash, or combustible fluids and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion and ventilation air. If the unit is stored indoors ensure that it is cool. If propane is used, the cylinder must be unhooked and the propane cylinder stored outside in a well ventilated area, out of the reach of children.

DO NOT USE BRIQUETTES OF ANY KIND IN THE GRILL.

The 720-0234 (Charmglow) Grill is designed for optimum performance without the use of briquettes. Do not place briquettes on the radiant as this will block off the area for the grill burners to vent. Adding briquettes can damage ignition components and knobs, and void the warranty.

Never use the grill in extremely windy conditions. If located in a consistently windy area (oceanfront, mountaintop, etc.) a windbreak will be required (see below). Always adhere to the specified clearance.

NEVER USE A DENTED OR RUSTY PROPANE TANK

PLACEMENT OF THE GRILL

CLEARANCE To Non-Combustible Construction

A minimum of 24” clearance from the back of the grill to non-combustible construction is required for the lid to open fully.

DO NOT INSTALL THIS UNIT INTO COMBUSTIBLE ENCLOSURES!

LOCATION

When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths and keeping any gas supply lines as short as possible. Locate the grill only in a well-ventilated area. Never locate the grill in a building, garage, breezeway, shed or other such enclosed areas without an approved ventilation system. During heavy use, the grill will produce a lot of smoke. Lock the wheels after the grill is placed in a suitable position according to the sticker located beneath the right door.

Screw description

Item

Descr i pt i on( SCALE 1: 1)

Specification Quantity

cr ossed r ound head scr ew

cr oss ed r ound head scr ew

1/4× 42mm

1/4× 12mm

5/32× 10mm

8pcs

24pcs

8pcs

cr oss ed f l at head scr ew

5/32× 12mm

4pcs

hexagonal s cr ew

5/32× 5mm

1pcs

wa s h er

1/4

32pcs

wa s he r

5/32

14pcs

cr ossed r ound head scr ew

5/32× 6mm

2pcs

cr ossed r ound head scr ew

5/32× 12mm

6pcs

ASSEMBLY INSTRUCTIONS

PLEASE READ THE INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP.

Attention: Please lock the caster during the process of installation of the grill.

TOOLS REQUIRED: Philips head screwdriver(not provide),monkey wrench(not provide)

Step 1:

. Assemble two regular casters to the right side panel and caster with brakes on the left side panel as shown figure below..

Step 2: : Assemble bottom panel to side panels with four (4) pcs 1/4*42 mm screws as shown figure below

Step 3: Assemble the back panel to the two side panels. with two (2)pcs 1/4*12mm screws and four (4) pcs 5 /32*12 as shown figure below.

Step 4: Assemble the front cart flame and back cart flame to the front side and back side of the side panel with eight (8)

screws . Attention: The front cart flame should be screwed from outside into inside with four(4) pcs 1/4*42

screws, and the back cart flame should be screwed from inside into outside with four(4) pcs 1/4*12 screws.

Step 5: Insert fix piece of door shaft into the square pipe at left and right side as shown figure

below, screw four(4)pcs 5/32*12 screws. Attention: Do not screw too tight.

Step 6:

Assembly the door in the fix piece of door shaft from bottom as shown figure and tighten

the screws.

Step 7:

First assemble the door handle to the door with the eight (8) pcs 5/32*10 screws as shown figure

below, then put the condiment rack inside of the left door as shown figure below.

Step8

: Remove the head unit of grill from carton. Insert the upper portion of the grill onto the cart from

the top. Caution!! The firebox is heavy, and we recommend two or more people to lift up

firebox.

+ 22 hidden pages