Chariot Carriers CHEETAH 2, CHEETAH 1 User Manual

Revised 10/23/03

www.chariotcarriers.com

51100461

CHEET

AH 1 - CHEET

AH 2 COUGAR 1 - COUGAR 2

OWNER’S MANUAL / GUIDE D’UTILISATION

X-COUNTRY SERIES

TTABLE OF CONTENTS

ABLE OF CONTENTS

General Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Carrier Maintenance, Care and Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Safety Guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Chariot Carrier CTS Ready Chassis Assembly

1.0 Folding and Unfolding the Carrier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

1.1 Wheel Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

1.2 Handlebar Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

1.3 Parking Brake Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

1.4 Suspension Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

1.5 Weather Cover Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

1.6 Rear Storage Compartments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

1.7 Child Placement and Seatbelts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

Parts Lists

Cheetah 1, Cheetah 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

Cougar 1, Cougar 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Strolling CTS Kit (wheels only)

2.0 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

2.1 Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

Jogging CTS Kit

3.0 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

3.1 Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Cycling CTS Kit

4.0 Reflectors and Flag Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

4.1 Attaching Your New Quick Release (QR) Skewer & Axle Mounted Hitch Cup to Your Bicycle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

4.2 Attaching Your Axle Mounted Hitch Cup to Your Bicycle if You Have a Solid Axle Style Hub . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

4.3 Hitch Arm Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

4.4 Attaching Your Carrier to the Hitch Cup on Your Bicycle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

X-Country Skiing CTS Kit

5.0 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15

5.1 Shoulder Harness Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15

Hiking CTS Kit

6.0 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

6.1 Shoulder Harness Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

French Instruction Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

Limited Lifetime Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35

CONGRA

TULA

TIONS

AND THANK

YOU FOR PURCHASING

YOU FOR PURCHASING AA

CHARIOT CARRIER!

Congratulations on choosing a X-Country series CTS Ready Chassis, the key component of the world’s premiere Child Transport System (CTS). Your new CTS carrier offers superior quality, safety features, and comfort. In addition, Chariot’s CTS Conversion Kits can provide you with the versatility to meet all of your child transportation needs. The CTS Conversion Kits available from your Chariot dealer are the following: 1. Jogging CTS Kit

2. Cycling CTS Kit 3. Strolling CTS Kit (wheels only) 4. Hiking CTS Kit 5. X-Country Skiing CTS Kit

IMPORTANT

Read all instructions before using your Chariot Carrier.

GENERAL

GENERALWW

ARNINGS

This manual contains many WARNINGS and CAUTIONS. Read and understand all of the WARNINGS and CAUTIONS. Failure to assemble and use this carrier correctly may lead to serious personal injury or death to you or your passengers.

• Do not install a car seat or any other seating device not approved by the manufacturer inside the carrier.

• Make no modifications to the carrier.

• The carrier may become unstable if a parcel bag or rack not approved by the manufacturer is attached to the carrier.

• Do not allow any of the child’s body, clothing, shoe laces, or toys to come in contact with moving parts.

• Never leave children unattended in the carrier.

• Failure to comply with the manufacturer’s instructions may lead to serious injury or death to you and to your passengers.

• Maximum capacity of the carrier is 75 lb (34 kg) for one child carriers and 100 lb (45 kg) for two child carriers. This includes the weight of the child/children and cargo. Do not use with children who exceed the weight limitations.

• Do not use cleaning solvents on the carrier. Clean only with mild soap and water.

• When used with only one passenger, the passenger should be seated in a center seating position.

• Passengers must always use seat belts.

• Maximum tire pressure is 30 – 35 psi.

• Care must be taken when folding and unfolding to prevent finger entrapment.

• Never use your carrier to go up or down stairs or on steep hills.

When carrier is used in Jogging or Strolling mode, please observe the following:

• Use wrist safety strap at all times.

• Always use parking brake when the carrier is stationary.

• Never in-line skate with your carrier.

• Maximum weight in the rear combined pockets is 2.2 lb (1 kg). The carrier may become unstable if the pocket is overloaded.

When carrier is used in Cycling mode, please observe the following:

• A reflector that complies with CPSC regulations shall be visible on the rear of the trailer and on the side of the wheels.

• Before each ride, ensure the attached carrier does not interfere with braking, pedaling, or steering of the bicycle.

• Never ride a bicycle at night without adequate lighting. Obey all local legal requirements for lighting.

• Ride with extreme caution, never exceed 25 km/h, and slow down to less than 10 km/h around corners and on rough roads.

• Use of a trailer changes the stability, braking requirements and riding characteristics of your bike.

• Always use flag for increased visibility.

• Before the carrier can be used with the Cycling CTS Kit, children must be at least 1 year old and able to sit upright unassisted.

• Passengers must always wear a CPSC or CE approved bicycle helmet.

CARRIER MAINTENANCE, CARE

AND ST

ORAGE

A. Hitch Maintenance - Check that the hitch and back up straps are properly secured before every ride. Periodically check the hitch for

damage, cracks, etc. Replace at first sign of damage. Any damage/deterioration on any parts of your Chariot carrier should be repaired/replaced immediately to reduce the risk of personal injury.

B. Fabric/Shell Care - Your Chariot Carrier is manufactured from a tough, durable, water resistant fabric. Clean fabric with household soap

or mild detergent and warm water only. Wipe dry. Do not machine dry.

C. Wheels and Axles - Wheels should be serviced by a Chariot Dealer at least twice a year. Check wheels for loose spokes and axles for

proper security every time you use your Chariot carrier.

D. Hardware and Fasteners - Regularly inspect nuts and bolts to ensure they are tightened securely. E. Storage - Store your carrier in a dry, well-ventilated area. To avoid mildew, make sure carrier is dry before storing. Keep your carrier out of

the sun when not in use to reduce fading. Do not store the carrier attached to your bicycle.

Always inspect all parts every time you use your carrier!

SAFETY

GUIDELINES

Sixteen important rules for the safe use of your Chariot Carrier.

1. Read all instructions before use! Failure to read, understand and follow these instructions may result in an otherwise avoidable accident in

which you and/or your passengers could suffer serious injury or death.

2. The safe and proper use of this product is your responsibility! Take a practice bicycle ride, walk/run, hike, or cross-country ski with a

weighted carrier (weighted greater than your expected load with children and cargo) before using your carrier to ensure you can handle a loaded carrier in each activity. Be extremely careful on hills and try to avoid them if possible. In addition to safe bicycle practices, the rules listed below must be followed at all times.

3. Make sure your bicycle is in good working condition. We recommend a frequent safety check of your bike by a certified bicycle

mechanic.

4. Do not modify or alter carrier or bicycle. Ask your Chariot Dealer if you are not sure whether your bicycle is compatible with your

carrier.

5. When used as a bicycle trailer, children must be at least 1 year old and be able to sit upright alone. Consult your pediatrician

before carrying any child younger than one year.

6. Do not exceed the maximum carrier load of 75 lb (34 kg) for one child carriers and 100 lb (45 kg) for two child carriers. These capacities include the weight of child/children and cargo. Articles carried in the carrier should be well anchored to avoid shifting during

travel. Unstable loads and overloading make the carrier less stable and more difficult to control.

7. Always fasten shoulder harness, lap belt and crotch strap securely and tightly around children. Periodically check placement of shoulder straps, especially for a sleeping child. Make sure children cannot put fingers into the wheel spokes. Instruct children not to bounce, rock or lean.

8. Do not leave children unattended in the carrier.

9. To insure a smooth ride, keep tires inflated to the recommended pressure shown on the tire side wall. Check tire pressure before each use. Over inflating tires or use of high pressure tires can cause the carrier to overturn.

10. Use this carrier only with non-motorized bicycles capable of supporting the additional load of the carrier and child. Do not use

your carrier on electric bicycles, motorcycles, mopeds, automobiles or any other motor vehicle. Check the information supplied with your bike to verify compatibility or ask your dealer.

11. Do not use a kickstand or other parking device to support the bicycle with a trailer attached. Attaching a trailer can change the balance of the bicycle making kickstands ineffective. The bicycle can fall over, damaging it and the trailer.

12. Always use the high visibility flag supplied with the trailer. Do not assume you have the right-of-way. Do not pull your trailer in high traffic areas such as busy streets, highways or anyplace it may be unsafe to ride with children.

13. Always verify that the folding brackets are secure and hold the carrier in an upright position.

14. Avoid riding at night. Your ability to see and be seen is greatly reduced. If you must ride at night, use proper lighting and reflectors on

your bicycle and wear bright reflective clothing

15. Both cyclist and children must wear approved bicycle helmets. If your child is too small to properly wear the smallest size approved helmet, they should not ride in the carrier.

16. Always obey all traffic laws, and use proper hand signals.

WARNING! Bicycle trailers can tip over causing serious injury to passenger/rider. Hitting an obstacle with a wheel may cause the trailer to tip over at any speed!

CHARIOT CARRIER CTS READY

CHASSIS

ASSEMBL

ASSEMBLYY

Your Chariot Carrier is shipped 99% assembled. Initial assembly takes a few minutes. After that, folding and unfolding can be done in seconds.

Stand at the back of the carrier body. Grab the upper frame and pull up until it stops.

CAUTION: Pull back on the lower bars from under the pivot brackets to avoid pinching your fingers.

1.1 Wheel Assembly

Pull back on both the right and left lower backtube bars until they “snap” all the way back over center and the auto-lock disks engage.

WARNING: Ensure that folding brackets are correctly locked before using carrier. Failure to do so could cause the carrier to collapse.

To collapse the carrier, pull the release disks and then push both the right and left lower backtube bars forward until the carrier is completely collapsed.

CAUTION: Do not attempt to collapse carrier without first pulling the release disks.

1. Depress the rubber cap on the wheel hub with your thumb and fully insert the clevis axle into the hollow axle. Once fully inserted and

secured, you should hear a “click” sound. Important: To ensure the axle system is engaged properly, test by trying to pull the wheel outwards after installing. The wheel should be locked in its installed position. If not, do not use and take your carrier to your Chariot Dealer for servicing.

2. Repeat all steps for the other wheel.

CLEVIS AXLE

HOLLOW AXLE

1.0 Folding and Unfolding the Carrier

NOTE: Any reference to orientation (left or right) is from the passengers point of view while in the carrier.

1.3 Parking Brake Instructions

1.4 Suspension Adjustments (Cougar 1 and 2 models only) NOTE: To determine the weight, you must

combine the weight of the passengers and cargo. To adjust simply loosen knob, slide bracket to desired weight range, and tighten knob.

NOTE: The bracket should be moved to the location next to the weights noted (not on top of the position).

If the suspension is making a hard "knocking" sound, it means the weight setting is too low and you need to slide the bracket further towards the rear. Typically, the suspension on both sides should be set to the same position/range, however it is possible to have them set to different positions if a lighter child is on one side and a heavier child on the other.

1.2 Handlebar Instructions

Depress both spring buttons and insert the handlebars fully into the sleeves. Both spring

buttons must “pop” out of the holes located on the inner side of the sleeves to secure the handlebar in place.

To adjust handle bar height, simply remove the handlebar by depressing the spring buttons and pulling the handle bar out of the aluminum sleeve. Rotate the handlebars 180o, and re-insert the handlebars into the aluminum sleeves.

Insert both ends of the handlebar into the aluminum sleeves located at the upper rear section of the carrier.

WARNING: Failure to properly install the handlebars or use the wrist safety strap could cause the carrier to become separated from you resulting in serious injury.

The parking brake is located at the center of the rear axle under the rear storage bag.

Note the 4 positions outlined in table where 1 represents the lightest load and 4 represents the heaviest load.

All Cougar models come with adjustable suspension. Four adjustment ranges are suggested, but it can be used in any position. The weight ranges suggested are based on the carrier being used for cycling. The setting could be softer or stiffer for strolling/jogging. Experimenting may be required.

Disengage the parking brake by lifting the plunger upwards.

Engage the parking brake by pressing the plunger down on the brake housing.

432

1.5 Weather Cover Features

WARNING: Failure to use the weather cover could expose your child to flying rocks, insects, and other debris.

1.6 Rear Storage Compartments

Fasten the front corners of the weather cover to the Velcro tabs located on the front lower corners of the frame.

Attach the loops from the back corner of the weather cover over the aluminum sleeves located at the upper rear section of the carrier.

During cooler temperatures use the rain cover to keep your child warmer. If this is too warm or you are worried about ventilation, open one or both of the small triangular side vents (for Cougar models). For more ventilation, roll up the rain cover and secure it by looping the elastic loops around its ends. If it is bright outside or the sun is bothering your child, use the back panel as a sunscreen. To do so, remove the weather cover, flip the back panel over the front of the carrier, secure it to the Velcro tabs located on the upper frame, and re-install the weather cover.

Your Chariot carrier comes with two separate rear storage bags. The first is the rear cargo mesh storage area located directly behind the seat. The second storage area is located on the lower backside of the carrier. The maximum capacity for both storage compartments is

2.2 lb (1 kg).

RAIN COVER

TRIANGULAR SIDE VENT

ELASTIC LOOP

BACK PANEL

Note: Your Chariot Carrier has climate control features designed to regulate your child’s temperature. Periodically monitor your child to ensure that he/she is comfortable in terms of temperature.

1.7 Child Placement and Seatbelts WARNING: Failure to properly attach seatbelts could result in serious injury or death to occupants in the event of an accident.

TWO CHILDREN (Cheetah 2 )

1. Unclip both shoulder harnesses from the side release buckles

and unthread them from the O-rings.

2. Seat children in carrier.

3. Place the center crotch strap between children’s legs and

adjust so O-rings are centered on children’s lower chest.

4. Thread the shoulder harnesses through the backside of the O-

rings, clip into buckles over the children’s right shoulder and tighten by pulling the loose strap ends from over the children’s left shoulder.

5. Fasten lap belt buckles and tighten snugly.

ONE CHILD IN DOUBLE CARRIER (Cheetah 2)

1. Seat child in center seating position.

2. Place the center crotch strap between child’s legs and adjust

so O-ring is centered on child’s lower chest.

3. Thread right hand shoulder harness through the back side of the

O-ring, clip into buckle over the child’s left shoulder, and tighten by pulling the loose strap end from over the child’s right shoulder.

4. Fasten lap belt buckle and tighten snugly.

ONE CHILD SINGLE CARRIER (Cheetah 1)

1. Seat child in carrier.

2. Place the crotch strap between child’s legs and adjust so

O-ring is centered on child’s lower chest.

3. Thread right hand shoulder harness through the back side of the

O-ring, clip into buckle over the child’s left shoulder, and tighten by pulling the loose strap end from over the child’s right shoulder.

4. Fasten lap belt buckle and tighten snugly.

WARNING: Always adjust shoulder harness and crotch strap so they meet at child’s lower chest. Adjusting harnesses and buckles near your children’s neck could cause serious injury or death.

WARNING: Failure to seat single child in the center position on a double child carrier could cause the carrier to tip over causing injury or death.

CENTRE O-RING AT LOWER CHEST

RIGHT HAND

SHOULDER HARNESS

TWO CHILDREN (Cougar 2)

All Cougar models come with a padded shoulder harness. Shoulder harness length can be adjusted by removing the shoulder harness straps from either one or both of the adjustment loops. The harness is adjusted to the middle position on the small child and the long position on the larger child as in the diagram. The third and final arrangement is achieved by removing the straps from both adjustment loops.

1. Lift shoulder harnesses and Velcro to upper seat frame, so that harnesses do not

interfere with seating the children.

2. Seat children in carrier, place outer crotch straps between legs of children and

adjust so buckles are centered on children’s lower chests.

3. Place shoulder harnesses over children’s head and slide ladder locks downwards

to fit the harnesses snugly over their shoulders.

4. Secure the bottom of the harnesses with the buckles on the crotch strap.

5. Pull the loose strap ends from over the children’s shoulders to

snugly secure the top of the harnesses.

6. Fasten lap belt buckles and tighten snugly.

ONE CHILD IN DOUBLE CARRIER (Cougar 2)

1. Remove both shoulder harnesses from ladder lock buckles.

2. Install one shoulder harness in the center seat using the two center ladder

locks. (See diagram at right). Thread the shoulder harness straps up through the ladder locks, pull over and towards yourself, then thread straps back down through the ladder locks.

3. Seat child in center seating position, place the center crotch strap between

child’s legs and adjust so buckle is centered on child’s lower chest.

4. Place shoulder harnesses over children’s head and slide ladder locks downwards

to fit the harnesses snugly over their shoulders.

5. Secure the bottom of the harnesses with the buckle on the crotch strap.

6. Pull the loose strap ends from over the child’s shoulders to snugly secure the

top of the harness.

7. Fasten lap belt buckle and tighten snugly.

ONE CHILD SINGLE CARRIER (Cougar 1)

1. Lift shoulder harness and Velcro to upper seat frame so that harness does not

interfere with seating the child.

2. Seat child in carrier, place crotch strap between the legs of the child and adjust

so that the buckle is centered on child’s lower chest.

3. Place shoulder harness over child’s head and slide ladder locks downwards to

fit the harness snugly over the child’s shoulders.

4. Secure the bottom of the harness with the buckle on the crotch strap.

5. Pull the loose strap ends from over the child’s shoulders to snugly secure the

top of the harness.

6. Fasten lap belt buckle and tighten snugly.

ADJUSTMENT LOOPS

WARNING: Failure to properly attach seatbelts could result in serious injury or death to occupants in the event of an accident.

WARNING: Always adjust shoulder harness and crotch strap so they meet at child’s lower chest. Adjusting harnesses and buckles near your child’s neck could cause serious injury or death.

WARNING: Failure to seat single child in the center position on a double child carrier could cause the carrier to tip.

Part # Part Quantity

A 40100135 Upper Frame – Left . . . . . . . . . . . . . . . . . . . . .1

B 40100136 Upper Frame – Right . . . . . . . . . . . . . . . . . . .1

C 41100222 Lower Frame . . . . . . . . . . . . . . . . . . . . . . . . .2

D 41101290 Lower Frame Bracket . . . . . . . . . . . . . . . . . . .2

E 40100425 Back Frame – Left . . . . . . . . . . . . . . . . . . . . .1

F 40100426 Back Frame – Right . . . . . . . . . . . . . . . . . . . .1

G 40100722 Back Tube . . . . . . . . . . . . . . . . . . . . . . . . . . .2

H 40100626 Seat Frame . . . . . . . . . . . . . . . . . . . . . . . . . . .1

I 40101514 Wheel Arm Attachment Bracket - Left . . . . . . .1

J 40101515 Wheel Arm Attachment Bracket - Right . . . . . .1

K 40101281 Back Bracket – Left . . . . . . . . . . . . . . . . .1 Set

L 40101282 Back Bracket – Right . . . . . . . . . . . . . . . .1 Set

M 40200106 Shoulder Harness . . . . . . . . . . . . . . . . . . . . . .1

N 50101733 Plastic Wheel . . . . . . . . . . . . . . . . . . . . . . . . .2

O 50101305 Clevis Axle . . . . . . . . . . . . . . . . . . . . . . . . . . .2

P 31100406/7 Weather Cover . . . . . . . . . . . . . . . . . . . . . . . .1

Q 30100409/8 Fabric Body . . . . . . . . . . . . . . . . . . . . . . . . . .1

R 41103032 Axle Adapter . . . . . . . . . . . . . . . . . . . . . . . . . .2

T 40101311 Handlebar . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

U 40202011 Wrist Safety Strap . . . . . . . . . . . . . . . . . . . . . .1

V 40101740 Parking Brake Assembly with Axle . . . . . . . . . .1

W 33100403/4 Storage Pouch (not shown) . . . . . . . . . . . . . . .1

X 41101929 Parking Brake Hub (not shown) . . . . . . . . . . . .2

PPARTS LIST

ARTS LIST

Cheetah 1

PPARTS LIST

ARTS LIST

Cheetah 2

Part # Part Quantity

A 40100133 Upper Frame – Left . . . . . . . . . . . . . . . . . . . . .1

B 40100134 Upper Frame – Right . . . . . . . . . . . . . . . . . . . .1

C 41100222 Lower Frame . . . . . . . . . . . . . . . . . . . . . . . . . .2

D 41101290 Lower Frame Bracket . . . . . . . . . . . . . . . . . . . .2

E 40100425 Back Frame – Left . . . . . . . . . . . . . . . . . . . . . .1

F 40100426 Back Frame – Right . . . . . . . . . . . . . . . . . . . . .1

G 40100722 Back Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

H 40100624 Seat Frame . . . . . . . . . . . . . . . . . . . . . . . . . . .1

I 40101514 Wheel Arm Attachment Bracket – Left . . . . . . .1

J 40101515 Wheel Arm Attachment Bracket – Right . . . . . .1

K 40101281 Back Bracket – Left . . . . . . . . . . . . . . . . . .1 Set

L 40101282 Back Bracket – Right . . . . . . . . . . . . . . . . .1 Set

M 40200106 Shoulder Harness . . . . . . . . . . . . . . . . . . . . . .2

N 50101733 Plastic Wheel . . . . . . . . . . . . . . . . . . . . . . . . . .2

O 50101305 Clevis Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

P 31100801/2 Weather Cover . . . . . . . . . . . . . . . . . . . . . . . .1

Q 30100803/4 Fabric Body . . . . . . . . . . . . . . . . . . . . . . . . . . .1

R 41103032 Axle Adapter . . . . . . . . . . . . . . . . . . . . . . . . . .2

S 40100625 Lower Seat Bar . . . . . . . . . . . . . . . . . . . . . . . .1

T 40101329 Handlebar . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

U 40202011 Wrist Safety Strap . . . . . . . . . . . . . . . . . . . . . .1

V 40101741 Parking Brake Assembly with Axle . . . . . . . . . .1

W 33100803/4 Storage Pouch (not shown) . . . . . . . . . . . . . . .1

X 41101929 Parking Brake Hub (not shown) . . . . . . . . . . . .2

PPARTS LIST

ARTS LIST

Cougar 1

PPARTS LIST

ARTS LIST

Cougar 2

Part # Part Quantity

A 40100135 Upper Frame – Left . . . . . . . . . . . . . . . . . . . . .1

B 40100136 Upper Frame – Right . . . . . . . . . . . . . . . . . . .1

C 41100224 Lower Frame . . . . . . . . . . . . . . . . . . . . . . . . .2