Char-Griller 5050 User Manual

LP Gas & Charcoal Grill

Duo

model #5050

•

Chrome Plated Warming Racks

prop

pp j

ill Feat

cancer, birth defects or other reproductive harm are

Features:

•Porcelain Coated Cast Iron

•Stainless Steel Thermometers

Gas Grill Features:

OWNER’S MANUAL

•40,800 BTU

•Stainless Steel Tube Burners

•12,000 BTU Side Burner

•Cast Brass Side Burner

•Electronic Igniters

arcoal Gr

ures:

•Start charcoal with gas burner

•Adjustable Height Charcoal Grate

•Side Fire Box O

tional for Texas

Style Smoking

WARNING

For Outdoor Use Only (outside any enclosure)

SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE. IF YOU ARE ASSEMBLING THIS UNIT FOR SOMEONE ELSE, GIVE THIS MANUAL TO HIM OR HER TO SAVE FOR FUTURE REFERENCE.

FOR CUSTOMER SERVICE, CALL 912-638-4724

WARNING: Im maintenance could cause injury or property damage Read the installation, operation and maintenance instructions thoroughly before assembling or servicing this equipment. Failure to follow these instructions could result in fire or explosion that could cause property damage, personal injury or death.

DANGER: DO NOT use gas grill for indoor cooking or heating. TOXIC fumes can accumulate and cause asphyxiation. Do not use in or on boats or recreational vehicles.

PROP 65 WARNING: Chemicals known to the state of California to cause

created by the combustion of propane.

A propane gas cylinder is required for operation. This gas grill is not intended for commercial use.

er installation, adjustment, alteration, service or

If od

WARNING

DANGER

If you smell gas: Shut off gas to the appliance. Extinguish any open flame. Open Lid.

or continues, keep away from the appliance and immediately call your gas supplier or your fire department.

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other a

liance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

page 2

Table of Contents

Important Safety Information.………………………..page 4

pag

q, yp

Illustrated Parts List……………………………..…..page 6 – 8

Tools Required, Assembly Tips and Hardware List..…..

e 9

Assembly Instructions……………………………....page 10 – 18

Operating Grill

Connecting Gas Cylinder……………………….page 19

Checking for Leaks……………………………...page 19

Lighting Grill…...…………………………………page 20

Cleaning and Care………………………………page 21

Gas Grill Troubleshooting……………………………page 22 - 23

Grill Preparation………………………………………page 24

Recipes……………………………………………..….page 25 - 27

Accessories…………………………………………….page 28 - 29

page 3

Duo model # 5050 Owner’s Manual

death or serious injury may occur

(

() y

p( )

U.S. Department of Transportation (DOT) CFR 49 or the National Standard of Canada

tight

WARNING FOR YOUR SAFETY

1. DO NOT store or use gasoline or any other flammable vapors and liquids within 25 feet (8m) of this or any other appliance.

2. When cooking with oil/grease, do not allow the oil/grease to exceed 350˚F (177˚C). Do not store of use extra cooking oil in the vicinity of this or any other appliance.

3. An LP Cylinder not connected for use should be stored a minimum of 10 feet (3m) away from this or any other appliance. Never fill the cylinder beyond 80 percent full. If the above information not followed exactly, a fire causing

4. If you smell gas:

- Shut Off gas to the grill. - Extinguish any open flame.

- Open Lid. - If odor continues, immediately call your gas supplier or fire department.

For Your Safety

Stop! Call us first! Do Not return product to store. This grill has been made to high quality standards. If you have any questions not addressed in this manual or if you need parts please call our customer service department at 1912-638-4724

NOTE: The use and installation of this product must conform to local codes. In absence of local codes, use the National

Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code CSA B149.1, or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.

USA), Monday-Friday 9am-5pm (EST).

Minimum distance from sides and back of unit to walls or railings is 36 inches (914mm).

Do not use under overhead construction. This appliance not intended for commercial use. Do not locate this outdoor cooking appliance under overhead unprotected combustible surface. For Outdoor Use Only, If Store Indoors, Detach and Leave Cylinder Outdoors.

IMPORTANT NOTICE: read all instructions prior to assembly and use. Read and understand all warnings and precautions prior to operating your grill.

CAUTION

1. This grill is for use with propane gas only (propane gas cylinder not included).

2. Never attempt to attach this grill to the self-contained propane system of a camper trailer, motor home or house.

3. Never use charcoal or lighter fluid with the gas grill.

4. Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be constructed and marked in accordance with the specifications for propane gas cylinders of the

, CAN/CSA B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and Commission, as applicable. This grill is not intended to be used in or installed on recreation vehicles and/or boats..

5. Do not attempt to move the grill while it is lit.

6. Do not use the grill unless it is completely assembled and all parts are securely fastened and ened.

page 4

7. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible

filled

ill

severely

7.Do not use the grill in high winds

materials, gasoline and other flammable vapors and liquids.

8. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to avoid burns,

unless you are wearing protective gear (BBQ mittens, pot holders, etc.)

9. Do not alter this grill in any manner.

10. Clean and inspect the hose before each use. If there is evidence of abrasion, wear, cuts, or

leaks, the hose must be replaced prior to operating the appliance. The replacement hose assembly will be that which is specified by the manufacturer.

• Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

•

ever keep a

container in a hot car or car trunk. Heat w

cause the gas pressure to

increase, which may open the relief valve and allow gas to escape.

• Keep the grill’s valve compartment, burners and circulating air passages clean. Inspect the grill

before each use.

WARNING

1. This grill is for outside use only, and should not be used in a building, garage or any other

enclosed area.

2. The use of alcohol, prescription or non-prescription drugs may impair the operator’s ability to

properly assemble or safely operate the grill.

3. Always open grill lid slowly and carefully as heat and steam trapped within the grill can burn you

4. Always place your grill on a hard, level surface far away from combustibles. An asphalt or

blacktop surface may not be acceptable for this purpose.

5. Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.

6. Do not place this grill on any type of tabletop surface.

DANGER

Liquid propane (LP) gas is flammable and hazardous if handled improperly. Know its characteristics

before using any propane product.

• Propane Characteristics: Flammable, explosive under pressure, heavier than air and settles in pools and low areas.

• In its natural state, propane has no odor. For your safety, an odorant has been added.

• Contact with propane can cause freeze burns to skin.

• This grill is shipped from the factory for propane gas use only.

• Never use a propane cylinder with a damaged body, valve, collar or footing.

• Dented or rusted propane cylinders may be hazardous and should be checked by your propane gas supplier.

page 5

ILLUSTRATED PARTS LIST:

10. CHARCOAL HOOD…1PC

11. CHARCOAL BODY….1PC

1. GAS GRILL HOOD…....1PC 2. GAS GRILL BODY……...1PC 3. GAS CHIMNEY……..2PCS

4. THERMOMETER……2 PCS 5. HOOD HANDLE……..2 SETS 6.WARMING.RACK…..2PCS

7. BURNER (with shorter wire)..2PCS 8. BURNER (with longer wire)…1PC 9. FLAME SHIELD…..3PCS

12.CHARCOAL CHIMNEY...1PC

page 6

13.FIRE GRATE HANGER..2PCS 14. FIRE GRATE/ASH PAN..1PC

PANEL / HOSE & VALVE….1SET

15. SIDE DAMPER…....1PC

16.SIDE HANDLE………...1PC

19. SIDE BURNER / CONTROL

17.CONDIMENT BASKET….1PC

18. POT STAND.…………1PC

20. ‘S’ HOOK……..…….3PCS 21. GREASE TRAY……2PCS

22. CATCH PAN……..…..1PC 23. LEG CROSS BAR….2PCS 24. LEFT LEG..…….…..2PCS

page 7

25. RIGHT LEG……..…2PCS 26. LEG BRACE….…….2PCS 27. BOTTOM SHELF……1PC

28. BASE…………………1PC 29. WHEEL……………..2PCS 30. AXEL………………….1PC

31. AXEL CAP………....2PCS 32. COOKING GRATE...6PCS 33. GRATE HOOK….....1PC

o to next page for the Hardware List and Assembly Tips.

page 8

Assembly: Requires 2 people. Get another person to help.

parts from fitting together. All Hex Nuts should be on the inside of the grill unless stated

HARDWARE:

¼-20 HEX NUT

PCS

Tools Needed NOTE

otherwise. Unpack all contents in a well cleared and padded area. Estimated Assembly Time: 45 minutes

STOP! Do Not Return to Store. If you are missing parts or need assistance please email us at

info@chargriller.com or call 912-638-4724. Do not attempt assembly if you are missing parts.

: Do Not tighten any bolts unless instructed to do so. Tightening too soon may prohibit

: Pliers, Phillips Head Screwdriver and a 7/16” Nut Driver.

¼-20x 1 ½” BOLT……8 PCS

¼-20x1/2” BOLT….... 43 PCS

SCREW……………….3 PCS

¼” FLAT WASHER…10 PCS

……..

¼” LOCK WASHER…35 PCS

HINGE PINS………..2 PCS

HAIR COTTER PIN….3 PCS

CENTER HINGE PIN…1 PC

page 9

+ 20 hidden pages

Char-Griller 5050 User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual