Char-Broil Grill 2 Go 11401587, Grill2Go Ice, Grill 2 Go Quickset 11401587 Product Manual
Grill 2 Go Quickset
Product Guide
Model 11401587
IMPORTANT: Fill out the product record information below.
Serial Number
Date Purchased
See rating label on unit for serial number.
Estimated Assembly Time: 10 minutes
FOR OUTDOOR USE ONLY
CAUTION:
Read and follow all safety statements, assembly
instructions, and use and care directions before
attempting to assemble and cook.
INSTALLER/ASSEMBLER:
Leave this manual with consumer.
CONSUMER:
Keep this manual for future reference.
If you have questions or need assistance during assembly, please call .
To insure your satisfaction and for follow-up service, register your appliance online at www.charbroil.com/register
© 2010 Char-Broil, LLC Printed in China • Columbus, GA 31902 • • Assembly Instructions © 2010
WARNING:
Failure to follow all manufacturer’s instructions could
result in serious personal injury and/or property
damage.
CAUTION:
Some parts may contain sharp edges – especially as
noted in the manual! Wear protective gloves if
necessary.
1-888-430-7870
42804598 • 06-14-10
TABLE OF CONTENTS
Product Record Information .................1
For Your Safety ..........................2
Safety Symbols ..........................2
Installation Safety Precautions................3
Use and Care ..........................4-7
Food Safety.............................7
Limited Warranty.........................8
Troubleshooting........................9-11
Registration Card........................12
This instruction manual contains important
information necessary for the proper
assembly and safe use of the appliance.
Read and follow all warnings and
instructions before assembling and using
the appliance.
Safety Symbols
The symbols and boxes shown below explain what
each heading means. Read and follow all of the
messages found throughout the manual.
DANGER
DANGER
1. Never operate this appliance unattended.
2. Never operate this appliance within 10ft (3m) of
any structure, combustible material or other gas
cylinder.
3. Never operate this appliance within 25 ft (7.5 m)
of any flammable liquid.
4. If a fire should occur, keep away from the
appliance and immediately call your fire
department. Do not attempt to extinguish an oil
or grease fire with water.
Failure to follow these instructions could result in
fire, explosion or burn hazard, which could cause
property damage, personal injury or death.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the appliance
and immediately call your gas supplier or your
fire department.
Failure to follow these instructions could result in
fire or explosion, which could cause property
damage, personal injury or death.
DANGER: Indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
WARNING
WARNING: Indicates an potentially hazardous situation
which, if not avoided, could result in death or serious
injury.
CAUTION
CAUTION: Indicates a potentially hazardous situation or
unsafe practice which, if not avoided, may result in minor
or moderate injury.
CAUTION
For residential use only. Do not use for commercial
cooking.
WARNING
1. Do not store or use gasoline or other flammable
liquids or vapors in the vicinity of this or any other
appliance.
2. An LP cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
WARNING
Do not attempt to repair or alter the
hose/valve/regulator for any “assumed” defect. Any
modification to this assembly will void your warranty
and create the risk of a gas leak and fire. Use only
authorized replacement parts supplied by
manufacturer.
Page 2
INSTALLATION SAFETY PRECAUTIONS
Installation Safety Precautions
• Use grill, as purchased, only with LP (propane) gas and the
regulator/valve assembly supplied.
CAUTION
• This appliance is not for use in or on recreational vehicles
and/or boats.
• Grill installation must conform with local codes or, in the
absence of local codes,with the National Fuel Gas Code, ANSI
Z223.1/NFPA 54, Storage and Handling of Liquefied
Petroleum Gases, ANSI/NFPA 58; or Natural Gas and
Propane Installation Code, CSA B149.1; Propane Storage and
Handling, CSA B149.2; or the Standard for Recreational
Vehicles, ANSI A119.2/NFPA 1192; and Recreational Vehicle
Code, CSA Z240 RV Series, as applicable.
• All electrical accessories (such as rotisserie) must be
electrically grounded in accordance with local codes, or
National Electrical Code, ANSI / NFPA 70. Keep any
electrical cords and/or fuel supply hoses away from any hot
surfaces.
• This grill is safety certified for use in the United States and/or
Canada only. Do not modify for use in any other location.
Modification will result in a safety hazard.
?This appliance will be hot during and after use. Use insulated
oven mitts or gloves for protection from hot surfaces or
splatter from cooking liquids.
• For residential use only. Not intended for commercial use.
• Do not leave appliance unattended. Keep children and
pets away from appliance at all times.
Call Grill Service Center for Help and Parts
• If you need assistance with your product or warranty parts call
1-888-430-7870
8:00 A.M. To 6:00 P.M. EST Monday - Friday.
• To order non-warranty replacement parts or accessories
please visit us on the web at www.charbroil.com or call
1-888-430-7870
agents will be glad to assist you.
. Hours of Service Center Operation are
and one of our friendly and knowledgeable
• Do not leave appliance unattended. Keep children and
pets away from appliance at all times.
WARNING
CALIFORNIA PROPOSITION 65
1. Combustible by-products produced when using
this product contains chemicals known to the State
of California to cause cancer, birth defects, or
other reproductive harm.
2. This product contains chemicals, including lead
and lead compounds, known to the State of
California to cause cancer, birth defects or
other reproductive harm.
Wash your hands after handling this product.
Page 3
USE AND CARE
WARNING
For Safe Use of Your Grill and to Avoid Serious
Injury:
• Do not let children operate or play near grill.
• Keep grill area clear and free from materials that burn (i.e.
gasoline, propane, or any other flammable liquid or gas).
• Do not block holes in bottom or back of grill.
• Check burner flames regularly.
• Never use regulator from this grill with any other LP
appliance.
• When cooking, the appliance must be on a level surface in
an area clear of combustible material.
• Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch, covered
patio, or under an overhead structure of any kind.
• Do not use charcoal or ceramic briquets in a gas grill.
(Unless briquets are supplied with your grill.)
• This appliance is not intended for and should never be used
as a heater.
• Use grill at least 3 ft. from any wall or surface. Maintain
10 ft. clearance to objects that can catch fire or sources of
ignition such as pilot lights on water heaters, live electrical
appliances, etc..
A
3ft.(1m)minimum
10ft.recommended
LP (Liquefied Petroleum Gas)
• Is nontoxic, odorless and colorless when produced. For Your
Safety, LP gas has been given an odor (similar to rotten
cabbage) so that it can be smelled.
• LP gas is highly flammable and may ignite unexpectedly
when mixed with air.
Propane Cylinder Use (1 lb. Disposable)
• Use only cylinder marked “Propane Fuel”.
• Cylinder must be constructed and marked in accordance with
the specifications for LP-gas cylinders of the U.S. Department
of Transportation (DOT) or the National Standard of Canada,
CAN/CSA-B339, Cylinders, Spheres and Tubes for the
Transportation of Dangerous Goods.
• Size should be 4” diameter, 8” height, or 3” diameter, 10”
height.
• Save cylinder cap and reinstall when not in use.
• Cylinder supply system must be arranged for vapor
withdrawal. Gas cylinder must be upright in use.
Leak Testing (1 lb. Disposable)
• During leak test, keep grill away from open flames or sparks
and do not smoke. Grill must be leak tested outdoors in a well
ventilated area.
• Leak test must be repeated each time gas cylinder is replaced
or after storage.
Materials needed include clean paint brush and 50/50 soap and
water solution. Use mild soap and water. s Do not use
household cleaning agents. Damage to components can
result.
1. Be sure control knob on regulator is in "OFF" position.
2. Brush soapy solution onto connection between gas cylinder
and regulator at (A).
s If growing bubbles appear, there is a leak. Retighten
connection and repeat steps 1 and 2.
IMPORTANT!
• Apartment Dwellers:
Check with management to learn the requirements and fire
codes for using an LP gas grill in your apartment complex.
If allowed, use outside on the ground floor with a three (3)
foot clearance from walls or rails. Do not use on or under
balconies.
• NEVER attempt to light burner with lid closed. A
buildup of non-ignited gas inside a closed grill is
hazardous.
• Never operate grill with LP cylinder out of correct
position specified in assembly instructions.
Page 4
B
If you cannot stop a leak, remove
A
gas cylinder from regulator and
check for damaged threads, dirt
and debris on regulator and gas
cylinder. Also check to see if
anything is obstructing flow of gas
at regulator and gas cylinder
openings. Remove any obstruction
that may be found and repeat leak
test. If threads are damaged on
either regulator or gas cylinder,
replace. Order new parts by
giving the serial, model number
and name of items needed to the
Grill Service Centerat 1-800-241-
7548.
.
Loading...