Char-Broil Electric Patio Caddie 4654870 Assembly, Use & Care Manual
4654870
ASSEMBLY/USE & CARE
MANUAL
U
®
L
FOR OUTDOOR HOUSEHOLD USE ONLY. DO NOT
USE INDOORS OR FOR COMMERCIAL COOKING.
CAUTION:
instructions and use and care directions before attempting to
assemble and cook.
INSTALLER/ASSEMBLER:
consumer.
CONSUMER:
!
Failure to follow all manufacturer’s instructions could result in
serious personal injury and/or property damage.
!
CAUTION
Some parts may contain sharp edges — especially as noted in
the manual! Wear protective gloves if necessary.
If you have any questions or need assistance during
assembly, please call .
Visit us on the web at: www.charbroil.com
Read and follow all safety statements, assembly
Leave these instructions with
Keep this manual for future reference.
WARNING
1-800-241-7548
4654870 / 0–4165494 (02-02-05)
COLUMBUS, GA
© 2005 W. C. Bradley Co., All Rights Reserved
Printed in USA
Call Grill Service Center For Help And Parts
• If you need help or warranty parts call 1-800-241-7548.
Business hours: Open 24 hours – Seven days a week.
• To order non-warranty replacement parts or accessories (
cover, cleaners, paint
1-706-565-2121.
) call 1-800-993-2677 or send a FAX to
IMPORTANT SAFEGUARDS
grill
DANGER
IMPORTANT: Fill out the warranty information below.
Model Number
Serial Number
See rating label on grill for serial number.
Date Purchased
Safety Symbols
The symbols and boxes shown below explain what each heading
means. Read and follow all of the messages found throughout the
manual.
DANGER
DANGER: Indicates an imminently hazardous situation which, if not
avoided, will result in death or serious injury.
WARNING
WARNING: Be alert to the possibility of serious bodily injury if the
instructions are not followed. Be sure to read and carefully follow all of
the messages.
ELECTRIC SHOCK CAN KILL OR RESULT IN SERIOUS
INJURY
To prevent electrical shock:
• Use only with GFI (Ground Fault Interrupter) protected circuit.
• Do not use grill when raining.
• To prevent grill from being splashed or falling into water, do not
use grill within 10 feet of a pool, pond or other body of water.
• Keep grill and electric controller dry and out of rain at all times.
• When connecting controller to grill, plug electric controller into grill
first, make sure controller is set to OFF, then plug into outlet.
When unplugging, turn controller to OFF, disconnect from outlet,
then remove controller from grill.
• Unplug grill when not in use and before moving.
• Do not operate grill with an electric controller that has a damaged
cord, plug or metal probe. Call Char-Broil for a replacement
controller. The electric controller is made specifically for this grill.
• Never remove grounding plug or use with an adapter to two
prongs.
• Keep electric plugs off ground and dry.
• Never put controller, cord or heating element in water or any other
liquid.
• Do not allow cord to touch hot grill.
• Store controller indoors when not in use.
• Do not use water or other liquid spray to clean product without first
unplugging electric controller and removing heating element.
SAVE THESE INSTRUCTIONS
CAUTION
CAUTION: Indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate injury.
Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, CharDiamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, Faststart®, Flare Fighter®,
FlavorMaster®, Gas Grill Silouette and Design®, H2O Smoker®, Lava Flame®, MasterFlame®, MasterFlame Precision
Cooking System®, PowerSpark®, Quantum®, PrecisionFlame and Design®, Sierra® and TruFlame® are registered
Trademarks of the W.C. Bradley Company. Thermos® is a registered trademark of the Thermos Company and its
affiliates.
Artisan Collectiion by Char-Broil™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™,
Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking
Collection and Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™,
SmokerTents™, The Big Easy™.The Minute Grill™, The Edge™, The Tuscan Collection™, and The Urban Grill™ are
Trademarks of the W.C. Bradley Company. Universal Grill Parts and Design™ is a trademark of the Thermos Company
and its affiliates.
Protected under one or more of the following U.S. Patents: 4,598,692; 4,624,240; 4,747,391; 4,747,391;
4,817,583; 4,924,846; 4,989,579; 5,003,960; 5,076,256; 5,076,257; 5,090,398; 5,109,834; 5,224,676; 5,277,106;
5,421,319; 5,441,226; 5,452,707;5,458,309; 5,566,606; 5,579,755; 5,582,094; 5,613,486; 5,649,475; 5,706,797;
5,711,663; 5,765,543; 5,931,149; 5,996,573; 6,095,132; 6,135,104; 6,173,644; 6,279,566; 6,397,731;
6,418,923;6,439,222; 6,523,461; D282,619; D339,714; D341,292; D343,337; D358,059; D361,466; D364,535;
D372,637; D373,701; D377,735; D383,035; D397,910; D405,643; D405,643; D406,005; D406,009; D413,043;
D413,229; D413,229; D414,982; D415,388; D416,164; D416,441; D417,587; D422,516; D423,274; D423,876;
D428,303; D435,396; D463,004; D438,059; D438,060; D438,427; D439,110; D442,505; D443,179; D443,354;
D447,384; D447,385; D447,909; D448,610; D448,614; D448,615; D448,616; D448,975; D449,492; D451,759;
D456,202S; D460,313; D461,359 and D477,501. Canada: 87743; 87744; 92607; 92608 and 1,316,424. Other Patents
Pending. ©2005 W. C. Bradley Co., All Rights Reserved.
Thermsulate® is a registered trademark of ATD, Corp. Insulation bowl and application covered by U.S. Patents 5011743,
5111577, and other Patents pending.
2
WARNING
Do not use 16 or 18 gauge extension cords. Damage to household
wiring and/or fire could result.
DO NOT USE CHARCOAL.
A charcoal fire will result and the grill is
not designed for charcoal. The fire will create an unsafe condition and
damage the grill.
CAUTION
This grill is for residential use only. Do not use for commercial
cooking.
GENERAL SAFETY
1.
Do not touch hot surfaces with unprotected hands. Use
handles and knobs provided for operation.
2.
Never leave grill unattended when ON.
3.
Keep children away from grill both when hot and cold.
4.
Use long barbeque utensils for cooking.
5.
Allow grill to cool before moving, cleaning or storing.
6.
Do not cook under a roof.
7.
Keep grill 24” (2 feet) away from
walls and rails.
8.
For outdoor household
use only. Do not use
indoors or for commercial
24” OR 2FT.(.61 M)
24” OR 2FT.(.61 M)
cooking.
Use only ceramic briquettes
9.
similar to those provided
with the grill.
Do not use or store gasoline,
10.
kerosene, or other flammable liquids within 20 feet
of this grill when in use.
Store grill in weather protected area or under grill cover
11.
when not in use and electric controller indoors when not
in use.
Use only accessory attachments recommended by
12.
manufacturer.
It is the responsibility of the assembler/owner to
13.
assemble, install and maintain grill.
EXTENSION CORD USE AND SAFETY
• For best grill performance use of extension cord is
recommended.
If you must use an extension cord for your safety:
• Use only outdoor type with 3 prong grounding plug, rated for 15
amperes or more, approved by UL, marked with a W-A and a
tag stating “Suitable for Use with Outdoor Appliance”.
• Use the shortest length extension cord required. Do not connect
2 or more extension cords together. A 12 or 14 gauge extension
cord of 50 ft. or less is acceptable.
• Keep connections dry and off ground.
• Do not let cord hang over edge of table top or other items where
it can be pulled by children or tripped over.
not
Warranty
Char-Broil guarantees the Char-Broil® Electric Patio Caddie™
shall be free from defects in both material and workmanship under
normal and reasonable use (and correct assembly as assembled by
the consumer-purchaser) by the original purchaser, for outdoor
household use, for the following periods as specified herein:
(1) Porcelain top and bottom, legs, base - for five (5) years from
the date of purchase.
(2) Electrical control and heating element - for a period of three
(3) years from the date of purchase.
(3) All other parts including handles, wheels and temperature
gauge - for a period of one (1) year from the date of purchase.
If the product fails to operate due to manufacturing defect the
defective part will be repaired or replaced at Char-Broil’s option. The
product, along with proof of purchase, must be returned postage
prepaid.
If you wish to obtain performance of any obligation under this
limited warranty, you should write to:
/ P. O. Box 1240, Columbus, GA 31902-1240
Char-Broil may require reasonable proof of purchase and we
suggest you keep your receipt. In the state of California only, if
refinishing or replacement of the product is not commercially
practicable, the retailer selling this product or Char-Broil will refund the
purchase price paid for the product, less the amount directly
attributable to use by the original consumer-purchaser prior to
discovery of the nonconformity. In addition, in the state of California
only, you may take the product to the retail establishment from which it
was purchased or to any retail establishment selling this product in
order to obtain performance under this warranty.
This warranty does not include the cost on any inconvenience or
property damage due to failure of the product and does not cover
damage due to misuse, abuse, accident, damage arising out of
transportation of the product, or damage incurred through commercial
use of the product. This express warranty is the sole warranty given by
the manufacturer and is in lieu of all other warranties, express or
implied, including implied warranty of merchantability or fitness for a
particular purpose. Neither CharBroil dealers nor the retail
establishment selling this product has any authority to make any
warranties or to promise remedies in addition to or inconsistent with
those stated above. Char-Broil’s maximum liability, in any event, shall
not exceed the purchase price of the product paid by the original
consumer-purchaser. Some states do not allow the exclusion or
limitation of incidental or consequential damages. So the above
limitations or exclusions may not apply to you. This warranty gives you
specific legal rights and may also have other rights which vary from
state to state.
Char-Broil, Consumer Warranty
GROUND FAULT INTERRUPTER
•Since 1971 the National Electric Code (NEC) has required
Ground Fault Interrupter devices on all outdoor circuits.
• If your residence was built before 1971, check with a qualified
electrician to determine if a Ground Fault Interrupter protector
exists.
• Do not use this appliance if the circuit does not have GFI
protection.
• Do not plug this appliance into an indoor circuit.
WARNING
Use care when operating your grill. Be sure you read and
understand all the information and safeguards in this manual
before
operating this grill.
3
Parts List
Key Qty. Description Part #
A.......1 .......Base .......................................................................4154381
P
N
J
E
B
O
O
C
B.......1 .......Cooking Grate ........................................................4152860
C ......1.......Element Assembly..................................................4159277
D ......1.......Grill Bottom.............................................................4509581
E.......1 .......Grill Lid ...................................................................4509582
F.......1 .......Control Leg w/Slot..................................................4302497
G ......1 .......Leg .........................................................................4302534
H ......1.......Leg w/Logo.............................................................4525611
I........1.......Briquette Grate.......................................................4156128
J .......1 .......Top Insulation Bowl ................................................4152826
K.......1 .......Bottom Insulation Bowl...........................................4152827
L.......1.......Controller................................................................4150235
M......1.......Leg Handle.............................................................4150357
N ......1.......Temperature Gauge w/Wing Nut............................4157142
O ......3 .......Lid Hangers............................................................4154245
P.......1 .......Lid Handle ..............................................................4154399
Q ......1 .......Grease Cup............................................................5156609
R ......1.......Grease Clip ............................................................5156610
- -......1 .......Briquette Bag..........................................................4158125
- -......1 .......Hardware, Misc ......................................................4253860
- - 1.......Hardware, Elec. #10...............................................4254040
M
O
I
L
D
R
K
Q
H
F
G
A
4
Necessary tools for assembly of your grill include a
1
1
Items to Assemble
1 Grill Lid
1 Lid Handle
2 Machine Screws
2 Lock Nuts
Phillips screwdriver, adjustable wrench or pliers.
(A 3/8” nut driver would be ideal).
Nylon insert
Qty: 2
Items to Assemble
1 Temperature Gauge
2
1 Top Insulation Bowl
1 Flat Washer
1 Wing Nut
A Place temperature gauge. Hold it in place as you turn lid upside down.
B Note: Be sure hole in top insulation bowl is aligned with temperature
gauge. Attach wing nut “DO NOT TIGHTEN” until after Step 3.
Qty: 1
Qty: 1
A
Place handle on lid.
Important:
unable to tighten these items once the insulation bowl is attached.
3
A
Place lid hanger bracket on upper lip of insulation
bowl. Adjust insulation bowl as necessary to align.
B Tighten wing nut.
Tighten both nuts securely at this time. You will be
A
Items to Assemble
3 Lid Hangers
3 Self-tap Screws
Note:
Lower end of lid hanger
A
bracket must rest on upper
lip of insulation bowl.
Qty: 2
Qty: 3
A
B
Items to Assemble
1 Grill Bottom
4
1 Bottom Insulation Bowl
A inwards and upwards
Fold flaps (90 degrees) so they are horizontal
B
Align rectangular slots
C Push insulation bowl tabs down and under to temporarily hold bowl in
place while you work.
A
Repeat for all three holes
B
C
5
Loading...