Page 1
Model DH5000 Operation/Cleaning Guide
OPERATION
1
Detergent
Check chemical levels
in containers.
5
1 5 0
WASH
150°F
Rinse-aid
2
POWER WASH
ON STANDARD
EXTENDED
Close hood & select wash
mode (Standard or Extended).
6
3
POWER WASH
ON
OFF/DRAIN EXTENDED
STANDARD
CYCLE
Press power switch to ON
position, machine fills.
7
POWER WASH
ON
CYCLE
OFF/DRAIN
EXTENDED
4
30
20
10
0
40
PSI
50
60
Check pressure gauge &
make sure reading is 20-22 PSI.
8
1 8 0
RINSE
180°F
Wait 10 minutes for the display
to indicate 150°F/66°C.
9
POWER WASH
ON
CYCLE
OFF/DRAIN
When the green cycle goes out,
remove the dish rack of clean wares.
EXTENDED
Prescrap & load wares into dish
racks. Wash one rack at a time.
AUTOMATIC
DRAIN CYCLE
The dishwasher can be drained
automatically at the end of normal
wash cycle or whenever the
dishwasher is idle.
TO DRAIN
THE DISHWASHER
Load the dish rack & close the hood.
The green cycle light illuminates &
the timed cycle starts automatically.
10
POWER WASH
ON
OFF/DRAIN EXTENDED
Push the power switch to the OFF/DRAIN
position. The cyle light will not come on.
STANDARD
CYCLE
The final rinse water temperature
display must indicate a minimum of
180°F/82°C during the final rinse.
11
Drain
Valve
Form No.115073_0
The automatic drain valve opens
for 10 minutes to drain the machine.
Page 2
Model DH5000 Operation/Cleaning Guide
CLEANING
Every 2 hours and at the end of the day
1
POWER WASH
ON
OFF/DRAIN EXTENDED
Push the power switch to the
OFF/DRAIN position to drain.
STANDARD
CYCLE
2
Spray the interior of the machine
with fresh clean water.
65
3
4
DO NOT spray the exterior of
the machine with water.
7 8
Remove the upper & lower
spray arms and flush clean.
Remove the scrap screens from
the machine.
9
Clean the round drain screen
& flush the bottom of the tank.
Remove the scrap screen support
filler plate.
10
POWER WASH
ON
OFF/DRAIN EXTENDED
Push the power switch ON & immediately
to the OFF/DRAIN position to drain.
STANDARD
CYCLE
Remove the pump suction screen. Back flush the screens and plate
in a remote sink. DO NOT strike
the screens against hard objects.
11 12
DRY
OPEN
OVERNIGHT
Wipe the exterior with mild detergent
and dry with soft cloth.
Reassemble machine and leave
hood open to aid in overnight drying.
Form No.115073_0
Loading...