Chad Valley 792/0987 Assembly & User Instructions

SWING AND GLIDE MULTIPLAY

Assembly & User Instructions -

Please keep for future reference

792/0987

Important -

Please read these instructions fully before assembly or use.

These instructions contain important information which will help you get the best from your

product and ensure safe and correct assembly, use and maintenance.

If you need help or have damaged or missing parts, call the

Customer Helpline:

Important

Limit: Age:3 - 8 years Maximum user: 5

(+44) 0330 0904 420

Max user weight: 45kg per seat Max combined weight: 180kg

Tips: It will take 2 adults around 30 minutes to assemble.

Contents

Warning

Parts

Assembly Instructions

Care and Maintenance

2-3

4-5

6-17

Warning

Important –Please read these instructions fully before assembly or use.

WARNING

Observing the following statements and warnings reduces the likelihood of serious injury.

● Warning! DO NOT allow use by children under the age of

36 months as small part(s) and long cord(s) may be choking and entanglement stangulation hazards.

● This unit is designed to be used by up to 5 children

between the age of 3 to 8, with a maximum weight of 45kg per seat. Combined weight not exceed of 180kg.

● Provide on-site adult supervision for children of all ages

at all times.

● It is recommended that the playground equipment be

located on level ground and anchored. Be certain that all anchoring devices (including concrete) are placed below the level of the playing surface and covered with protective soft material to prevent tripping.

● Teach children to sit in the centre of the swing play items,

with their full weight in the centre of the seats. DO NOT allow children to lean to the side when on play items or to collide with other playmates. DO NOT allow children to stand on the swing seat.

● Dress children appropriately while on and around this equipment. DO NOT allow children to wear ponchos,

scarves, jewelry,loose shoes, jackets or clothing with loose strings and/or clothing that might be potentially

hazardous whilst using this equipment.

● DO NOT let children use this equipment in any manner

other than intended.

● Anchor all play equipment. DO NOT install over concrete,

asphalt, gravel or any other hard surface which may cause injury should a fall occur. Swing set shall be placed over protective soft material such as sand bed, soft woodbark, grass lawn. The depth of sand and soft woodbark shall be a minimum of 183cm. The anchor shall be placed level with or under the ground in order to reduce tipping hazards.

● DO NOT let children use this equipment until it has been properly assembled and anchored. Place equipment on

level ground not less than 2M from any structures or obstacles such as fences, overhanging branches, laundry or electrical lines, garages, sheds or houses.

● Instruct children not to swing empty play items. They may strike other children, or the play equipment may come

back and strike you.

● Instruct children not to walk closely in front of, behind or in between moving play equipment. Instruct children to keep a

safe distance away to avoid being struck by the items in use.

● Instruct children not to twist chains or ropes, or loop them

over the support bar. This adds stress, reduces strength and may result in failure and cause injury.

● Instruct children not to get off play equipment whilst in

motion. DO NOT allow children to jump from moving play

equipment.

● Check all nuts and bolts twice monthly during the season and tighten as required. We recommend you

check the swing beam and hardware every two weeks. It is particularly important that this procedure be followed at the beginning of each season.

● Oil all metallic moving parts monthly during the usage

period.

● Check all nuts and bolts twice monthly during the

season to be certain they are in place. Replace when necessary. It is especially important to do this at the beginning of each new season.

● Check swing seats, ropes, cables and chains monthly

during usage season for evidence of deterioration. Replacement should be made of any swing seat that has developed cracks in the plastic seat or has exposed metal in the edges of the swing seat. If there are already exposed metal inserts on the edge of the seat, immediately remove the seats and chains to prevent serious injury. Ropes, cables and chains should be removed and replaced if excessive wear is found. Contact OUR SERVICE CENTER for replacement parts.

● Maintaining the Play set on a level location is very

important. As your children play, your Play set will slowly dig its way into soil, and it is very important that is settled evenly. Make sure the play set is level and true once each year or at the beginning of each play season.

● Toys shall be accompanied by maintenance

instructions drawing attention to the need of carrying out checks and maintenance of the main parts at regular intervals , if these checks are not carried out the toy could overturn and otherwise become a hazard. Whenever practical, the instructions shall also be affixed to the toy.

Maintenance Instructions

● DO NOT allow children to climb or play on the equipment

whilst wet (slips or falls may occur).

● DO NOT allow children to climb on or swing from

structural members (eg legs or top bar and chin bars). These are structural components ONLY and NOT play features.

● DO NOT allow children to swing play equipment more

than 60 degrees.

● After completion of assembly, ensure all the nuts and

bolts are tightened and in the correct position.

● Not suitable for hiring or commercial use.

● Never use the equipment in any manner other than

intended.

● Please retain these instructions for future reference.

● Warning! only for dometic use.

Safety Information

Important –Please read these instructions fully before assembly or use.

● Require at least 2 adults for assembly. Try to place in a

flat area of your yard to minimize ground preparation.

Place the equipment not less than 2M from any

structure or obstruction such as a fence, garage, house, overhanging branches，laundry lines, or electrical wires.

●

It is a good idea to place your play set in an area that is

convenient for adults to watch children at play.

● The area that you choose should be policed for glass,

rocks or anything jagged or sharp that could endanger your children’s safety. The surface underneath your play system can cause or prevent injuries.

●

Shredded bark mulch, wood chips, fine sand of fine

gravel are considered to be acceptable shock-absorbing surfaces when installed and maintained at a sufficient depth under and around

playground equipment. However each material is only

effective when properly maintained. Material should be checked periodically and replenished to maintain correct depth as determined necessary for your

equipment. Otherwise serious injuries may occur from

a fall.

● Do not build your play set on top of surfacing material.

●

Please install this equipment facing away from the sun

to avoid causing dizziness whilst playing. The surface underneath your play system can cause or prevent injuries. We have additional suggestions in the suggested playground surfacing section.

Positioning Your Play Set

● Hardware: inspect for tightness.

● Swing hangers: check to insure correct installation.

Make sure that the bend of the swing hanger is positioned tightly against the stop washer and swing beam. The axis of the swing hanger bushing must be

perpendicular to the swing motion. If squeaking occurs

the nylon bushings can be sprayed with WD-40 or other house hold lubricant.

● The instructions and owner’s manual for your new play

set should be read in its entirety before assembly, to minimize problems and safety issues. We recommend reading the owner manual thoroughly after you have identified all of the parts for your play set.

● Check all coverings for bolts and sharp edges and replace when required.

●

DO NOT attach items to the playground equipment that

are not specifically designed for use with this

equipment, such as, but not limited to, jump ropes,

clotheslines, pet leashes, cables and chains as they may cause strangulation hazards.

● At the end of each play season, remove all plastic parts

and take indoors. DO NOT allow the use of plastic items when the temperature drops below 0 degree.

● Dispose of all packaging properly after the unit has

been assembled.

● This equipment is for family domestic use and is

intended for outdoor use only.

● Check all nuts and bolts for tightness and tighten when required.

●

Check swing seats, chains, and other means of

attachments for evidence of deterioration, replace

when required in accordance with the manufacturer’s

instructions.

●

Not suitable for children under 3 years because of

small part(s)-choking hazard.

● This unit must be assembled by adults, ensure bolts

and small components are kept out of reach of young children.

● Check all fixings regularly, tighten if necessary, and

that the suspension system is secure.

●

Check metal sections or components for signs of

corrosion.

● Discontinue use if weakening or breakage found.

●

Young children in play are unaware of potential

dangers and hazards, therefore responsible adults supervision is essential.

● Failure to comply with these precautions may result in

injury.

● Disassemble and store indoors during the winter.

Parts

call the Customer Helpline:

(+44) 0330 0904 420

1 Right Top Bar x 1pcs

2 Center Top Bar x 1pcs

3 Left Top Bar x 1pcs

4 Upper Leg x 4pcs

5 Lower Leg x 4pcs

6 Cross Bar x 1pcs

7 Target Cross Bar x 1pcs

8 Plastic cap x 4pcs

9 Swing Seat x 2pcs

14 Plastic Connector x 2pcs

12 Glider Lower Tube x 2pcs

11 Glider Upper Tube x 2pcs

10 Glider Bracket x 1pcs

15 Plastic Tube x 2pcs

16 Footrest x 2pcs

13 Glider Seat Tube x 2pcs

17 Plastic Connector x 4pcs

18 Plastic x 2pcs

19 Glider Seat x 2pcs

24 Anchor x 4pcs

20 Target Side Tube x 2pcs

21 Target Connector Tube x 1pcs

22 Target Connector Tube x 1pcs

23 Target Sheet x 1pcs

VIEW PRODUCT

Note: The quantities below are the correct amount to complete the assembly. In some cases more

×1 (4mm)

x4 (M8x114mm)

x6 (M8×50mm)

x4 (M6×36mm)

x2 (M6×34mm)

x4 (M8x61mm)

x2 (M6x60mm)

x2 (M8×20mm)x4 (M8×54mm)

x2 (M8×95mm)

x2 (M6×50mm) ×32 (Ø19×Ø8.5mm) ×12 (Ø19×Ø8.5mm)

×16 (Ø14×Ø6.5mm) ×22 (Ø8×Ø2mm) ×10 (Ø6×Ø1.5mm) ×22 (M8)

×10 (M6) ×1 (10&13mm) ×1 (6mm)

A B DC

FE G

I J K

O P

TQ R

Parts

Customer Helpline:

(+44) 0330 0904 420

VIEW PRODUCT

VIEW PRODUCT VIEW PRODUCT

VIEW PRODUCT

VIEW PRODUCT VIEW PRODUCT

VIEW PRODUCT

+ 13 hidden pages

Chad Valley 792/0987 Assembly & User Instructions

Specifications and Main Features

Frequently Asked Questions

User Manual