Century HES80 User Manual

BANFF
Freestanding Electric Stove Model: HES80
Installation Instructions and
Homeowners Manual
CFM Home Products
2695 Meadowvale Blvd. • Mississauga, Ontario, Canada L5N 8A3
INSTALLER: DO NOT DISCARD THIS MANUAL - LEAVE FOR HOMEOWNER
S190006 6/04 Rev. 0
INSTALLER / CONSUMER
SAFETY INFORMATION
PLEASE READ THIS MANUAL
BEFORE INSTALLING AND
USING APPLIANCE
WARNING!
IF THE INFORMATION IN THIS
MANUAL IS NOT FOLLOWED
EXACTLY, AN ELECTRICAL SHOCK
OR FIRE MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL
INJURY OR LOSS OF LIFE.
FOR YOUR SAFETY
Service must be performed by a qual-
ified service agency.
DO NOT STORE OR USE
GASOLINE OR OTHER
FLAMMABLE VAPORS OR
LIQUIDS IN THE VICINITY OF
THIS OR ANY OTHER
APPLIANCE.
C US
2
S190006
Table of Contents
PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS
BEFORE USING THIS APPLIANCE
Thank you and congratulations on your purchase of a CFM Home Products stove.
IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these
instructions may result in a possible electric shock, fire hazard and will void the warranty.
Installation Instructions
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Locating Your Stove . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Stove Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Clearance to Combustibles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Hearth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Electrical Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Fan Kit Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Service Instructions
Replacing Light Bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Maintenance of Motors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Electrical Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Operating Instructions
On/Off Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Heater Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
3
S190006
Installation Instructions
General
1. Read all instructions before using this appliance.
2. This appliance is hot when in use. To avoid burns, do not let bare skin touch hot surfaces. If provided, use handles when moving this appliance. Keep combustible materials, such as furniture, pillows, bedding, papers, clothes and curtains at least 3 feet (914mm) from the front of this appliance.
3. CAUTION: Extreme caution is necessary when
any heater is used by or near children or invalids and whenever the heater is left operat­ing unattended.
4. If possible always unplug this appliance when not in use.
5. Do not operate any heater with a damaged cord or plug or after the appliance malfunctions, has been dropped or damaged in any manner.
6. Any repairs to this appliance should be carried out by a qualified service person.
7. Under no circumstances should this appliance be modified. Parts having to be removed for servicing must be replaced prior to operating this stove again.
8. Do not use outdoors.
9. This heater is not intended for use in bathrooms, laundry areas and similar indoor locations. Never locate this appliance where it may fall into a bathtub or other water container.
10.Do not run cord under carpeting. Do not cover cord with throw rugs, runners or the like. Arrange cord away from traffic areas and where it will not be tripped over.
11.To disconnect this appliance, turn controls to the off position, then remove plug from outlet.
12.Connect to properly grounded outlets only.
13.This appliance, when installed must be electrically grounded in accordance with local codes, with the current CSA C22.1 Canadian Electrical codes or for USA installations, follow local codes and the National Electric Code, ANSI/NFPANo. 70.
14.Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an electric shock, fire or damage the appliance.
15.To prevent possible fire, do not block air intakes or exhaust in any manner. Do not use on soft sur­faces, like a bed, where openings may become blocked.
16.This appliance has hot and arcing or sparking parts inside. Do not use it in areas where gasoline, paint or flammable liquids are used or stored. This appli­ance should not be used as a drying rack for cloth­ing, nor should Christmas stockings or decorations be hung on or near it.
17.Use this appliance only as described in this manual. Any other use not recommended by the manufac­turer may cause fire, electric shock or injury to per­sons.
18.Avoid the use of an extension cord because the extension cord may overheat and cause a risk of fire. However, if you have to use an extension cord, the cord shall be No. 14 AWG minimum size and rated not less than 1875 Watts. The extension cord must be a three wire cord with grounding type plug and cord connector. The extension cord shall not be more than 20 feet (6m) in length.
19.SAVE THESE INSTRUCTIONS.
Locating Your Stove
Your new freestanding electric stove may be installed virtually anywhere in your home. However, when choosing a location for your new stove, ensure that the general instructions are followed. Also, for best effect, install the stove away from direct sunlight.
4
S190006
Stove Dimensions
14¹⁄₄"
(362 mm)
24¹⁄₄" (616 mm)
22¹⁄₂" (572 mm)
14¹⁄₄" (362 mm)
27⁷⁄₈"
(708 mm)
13¹⁄₂" (343 mm)
5
S190006
Clearance to Combustibles
Back . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2” (51 mm)
Sides . . . . . . . . . . . . . . . . . . . . . . . . . . . .6” (153 mm)
Floor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0” (0 mm)
Top . . . . . . . . . . . . . . . . . . . . . . . . . . . .24” (610 mm)
Hearth
A hearth is not mandatory, but is recommended for aesthetic purposes. We recommend a noncombustible hearth which does not obstruct heater openings.
Electric Specifications
Voltage . . . . . . . . . . . . . . . . . . . . . . . .120V AC/60Hz
Total Amps . . . . . . . . . . . . . . . . . . . . . . .12.20 Amps
Total Watts . . . . . . . . . . . . . . . . . . . . . . . .1460 Watts
Heater Ratings . . . . . . . . . . . . . . . . . . . .1300 Watts
Electrical Connection
A 15 Amp, 120 Volt, 60 Hz circuit with a properly grounded outlet is required. Preferably, the appliance will be on a dedicated circuit as other appliances on the same circuit may cause the circuit breaker to trip or the fuse to blow when the heater is in operation.
The unit comes standard with a 6’ (1.8m) long three wire cord, exiting from the rear of the stove. Plan the installation to avoid the use of an extension cord. If an extension cord must be used, it must be a minimum 14AWG, three wire with grounding type plug connector and rated not less than 1875 Watts. The cord shall not be more than 20’ (6m) in length.
WARNING: Electrical outlet wiring must comply with local building codes and other applicable regulations to reduce the risk of fire, electrical shock and injury to persons.
WARNING: Do not use this stove if any part of it has been under water. Immediately call a qualified service tech­nician to inspect the stove and replace any part of the electrical system.
Fan Kit Installation
When installed, the heater must be elec­trically connected and grounded in accor­dance with local codes, or in th absence of local codes, with ANSI/NFPA No. 70.
NOTE: 110/120 electric power is required to operate
blower (fan). Be sure to leave sufficient excess wire in case minor
adjustments are required. Any electrical re-wiring of this fan must be done by a
qualified electrician.
Turn off all power before installation.
CAUTION: Be careful not to touch or bend the flame
generator.
1. Remove panel from back of pedestal
2. Install the fan through the opening at the back of the pedestal. Place fan assembly as far forward as possible, inserting long flange through slot in front panel. (Fig. 1)
3. Use two screws provided to secure fan assembly to base of pedestal. (Fig. 2)
4. From front of unit, attach brass handle to front of fan assembly flange. (Fig. 3)
5. Plug in grounded service cord to a convenient wall receptacle.
6. Replace rear panel in pedestal.
Slot
ST824
Fig. 1 Insert flange through slot in front panel.
1WARNING: Disconnect power before attempting any maintenance or cleaning to reduce the risk of fire, electrical shock or personal injury.
Maintenance of Motors
The motors used on the fan and the flame generator assembly are prelubricated for extended bearing life and require no further lubrication. However, periodic cleaning/vacuuming of the fan/heater unit is recom­mended.
WARNING: Make sure the power is turned off before proceeding.
Service Instructions
Replacing Light Bulbs
This stove uses two clear 120 Volt, 60 Watt, E-12 socket base light bulbs (small base, chandelier candle­type). The 60 Watt bulbs are located under the log set/ember bed. For convenience, if one of the bulbs burns out, it may be a good idea to replace both of the light bulbs.
1. Turn off power to the unit by unplugging the power cord.
2. Let stove cool if it has been operating.
3. Remove rear access panel from back of pedestal to expose light bulbs.
6
S190006
Fan Assembly
ST818
Fig. 2 Secure fan assembly to base of pedestal.
Fig. 3 Attach brass handle to front of unit.
CAUTION: Be careful not to touch or bend the flame
generator.
4. Examine the bulbs to determine which bulb needs to be replaced.
5. Unscrew defective bulb(s).
6. Install new 60 Watt light bulb(s).
7. Replace rear access panel. Plug power cord into wall outlet.
WARNING: Do not exceed 60 watts per bulb. Use of higher rated bulbs may result in a fire, causing property damage or per­sonal injury.
7
S190006
Heater Control
The heater control acts to turn the heater on and off as well as setting the comfort level in the room. Turning the knob clockwise from the off position will place the heater into operation. The further the knob is rotated clockwise, the higher the set point temperature. turning the knob counterclockwise will lower the set point tem­perature. Turning it all the way counterclockwise will turn the heater function off.
Main On/Off Switch
The On/Off switch supplies power to all of the func­tions of the stove. It is located at the top rear of the unit.
WARNING: During any service of this appliance, the power to the unit must be turned off. It is not acceptable to use the “On/Off” switch to meet this requirement.
7
If repairing or replacing any electrical component or wiring, the original wire routing, color coding and securing locations must be followed.
Electrical Wiring Diagram
Any electrical repairs or rewiring of this unit should be carried out by a licensed electrician in accordance with national and local codes.
Operating Instructions
Heater Control
Flame Control
On/Off Switch
Fig. 4 HES80 controls.
SPEED CONTROL SWITCH
WIRE #7 WHITE
WIRE #8 WHITE
THERMOSTAT
BROWN WIRE
ORANGE WIRE
ORANGE/BROWN WIRE
SPEED CONTROL
+
REMOTE RECEIVER
WIRE#11 RED
WIRE#2 BLACK
HOT
-
WIRE#1 BLACK
SWITCH OFF/ON
WIRE#3 BLACK
WIRE#4 BLACK
WIRE#5 BLACK
RED WIRE
RED LINE OUTPUT
RED LINE INPUT
RED WIRE
BLUE WIRE
BLACK WIRE
WIRE #9 WHITE
BLACK WIRE
+
-
WHITE WIRE
BLACK WIRE
BLACK WIRE
HEATER MOTOR
MOTOR FLAME GENERATOR
WIRE #10 WHITE
WIRE#6 BLACK
HEATER
WHITE
BLACK
GREEN WIRE
l
o
8
S190006
1 YEAR WARRANTY
For Century Heating Electric Stove
BASIC WARRANTY: CFM Home Products (hereinafter referred to collectively as the "Company") warrants that your new Century Heating stove is free from manufacturing and material defects for a period of one year from date of installation, subject to the following conditions and limitations.
1. This electric stove must be installed and operated at all times in accordance with the Installation and Operating instructions furnished with the product. Any alteration, willful abuse, accident, or misuse of the product shall nullify this warranty.
2. This warranty is non-transferrable, and is made to the origi­nal owner, provided that the purchase was made through an authorized supplier of the Company.
3. This warranty is limited to the repair or replacement of part(s) found to be defective in material or workmanship, provided that such part(s) have been subjected to normal conditions of use and service, after said defect is confirmed by the Company's inspection.
4. This warranty does not cover the lightbulb(s) included
with the stove.
5. The Company may, at its discretion, fully discharge all obli­gations with respect to this warranty by refunding the wholesale price of the defective part(s).
6. Any installation, labour, construction, transportation, or other related costs/expenses arising from defective part(s), repair, replacement, or otherwise of same, will not be cov­ered by this warranty, nor shall the Company assume responsibility for same. Further, the Company will not be responsible for any incidental, indirect, or consequential damages, except as provided by law.
7. All other warranties - expressed or implied - with respect to the product, its components and accessories, or any obliga­tions/liabilities on the part of the Company are hereby expressly excluded.
8. The Company neither assumes, nor authorizes any third party to assume, on its behalf, any other liabilities with respect to the sale of this Norther Flame product.
9. The warranties as outlined within this document do not apply to non-CFM Home Products accessories used in con­junction with the installation of this product.
This warranty is void if:
a) The stove has been operated in atmospheres contami
nated by chlorine, fluorine or other damaging chemicals.
b) The stove is subjected to prolonged periods of damp
ness or condensation.
c) Any alteration, willful abuse, accident, or misuse of the
product.
IF WARRANTY SERVICE IS NEEDED . . .
1) Contact your supplier. Make sure you have your warranty, your sales receipt, and the model/serial number of your CFM Home Products product.
2) DO NOT ATTEMPT TO DO ANY SERVICE WORK YOUR-
SELF.
GARANTIE DE BASE: CFM Home Products (aux présentes nommée la "Société") garantit votre nouveau poêle électrique Northern Flame contre tous défauts de fabrication et de matières premières pour une période d'un an à compter de la date d'installa­tion, sujet aux conditions et limitations suivantes.
1. Le poêle electrique doit être installé par un entrepreneur de service autorisé et compétent. Il doit être installé et utilisé en tout temps selon les instructions d'installation et de fonc­tionnement fournies avec le produit. Toute altération, abus volontaire, accident ou mauvais usage du produit annulera cette garantie.
2. Cette garantie n'est pas transférable et est offerte à l'a­cheteur au détail d'origine, à condition que l'achat soit effec­tué par l'entremise d'un détaillant autorisé de la Société.
3. Cette garantie est limitée à la réparation ou au remplace­ment de(des) pièce(s) trouvée(s) défectueuse(s) en matières premières ou main-d'oeuvre, à condition que les­dites pièces aient été sujettes aux conditions normales d'usage et de service, après que ledit défaut a été confirmé par une inspection par la Société.
4. Cette Garantie ne couvre pas les ampoules inclus dans le poêle électrique.
5. La Société peut, à sa discrétion, se décharger entièrement de toutes obligations se rapportant à cette garantie en rem­boursant le prix de gros de la(des) pièce(s) défectueuse(s).
6. Tous les frais/dépenses d'installation, de main-d'oeuvre, de construction, de transport ou autres causés par une (des) pièce(s) défectueuse(s), une réparation, un remplacement ou autre, ne seront pas couverts sous cette garantie, et la Société n'assume aucune responsabilité pour ceux-ci. De plus, la Société ne pourra être tenue responsable pour tous dommages fortuits ou indirects sauf la ou prévu par la loi.
7. Toutes autres garanties, exprimées ou sous-entendues, en ce qui a trait au produit, ses composants et accessiores, ou toutes obligations/responsabilités de la part de la Société sont aux présentes expressment excluses.
8. La Société n'assume et n'autorise personne à assumer, en son nom, toutes responsabilités en ce qui a trait à la vente de ce produit Majestic Fireplaces.
9. Les garanties, telles que décrites dans ce document, ne s'appliquent accessoires non CFM Home Products utilisés conjointement pour l'installation de ce produit.
Cette garantie est nulle si:
a) Le poêle a été utilisé dans une atmosphère contaminée
par du chlore, du fluor ou tous autres produits chim iques.
b) Le poêle est assujetti à de longues périodes d'humidité
ou de condensation.
c) Toute altération, abus volontaire, accident ou mauvais
usage du produit annulera cette garantie.
SI UN SERVICE SOUS GARANTIE EST REQUIS . . .
1) Communiquez avec votre détaillant. Assurez-vous que vous avez votre garantie, votre reçu de caisse ainsi que le numéro de modèle/série de votre produit CFM Home Products.
2) NE TENTEZ PAS D'EFFECTUER DES REPARATIONS
VOUS-MEME.
Loading...