CDA DV 990, 9Z6, 9Q6 User Manual

Customer Care Department • The Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY

T : 01949 862 012 F : 01949 862 003 E : [e-mail] W : www.cda.eu

9Q6 .. - DV 990 .. - 9Z6 ..
Built in Electric Double Ovens

Manual for Installation, Use and Maintenance

2

Important

This appliance is designed and manufactured solely for the cooking of domestic (household) food and
is not suitable for any non domestic application and therefore should not be used in a commercial
environment.

The appliance guarantee will be void if the appliance is used within a non domestic environment i.e. a semi
commercial, commercial or communal environment.

The CDA Group Ltd cannot be held responsible for injuries or losses caused by incorrect use or installation
of this product. Please note that CDA reserve the right to invalidate the guarantee supplied with this
product following incorrect installation or misuse of the appliance.

Appliance Information:

Please enter the details on the appliance rating plate below for reference, to assist CDA Customer Care in
the event of a fault with your appliance and to register your appliance for guarantee purposes.

Appliance Model

Serial Number

Declaration of CE Conformity

This double oven has been designed, constructed and marketed in compliance with:

- Safety requirements of EU Directive “Low Voltage” 2006/95/EC;

- Protection requirements of EU Directive “EMC” 2004/108/EC;

- Requirements of EU Directive 93/68/EEC.

Important Information for Correct Disposal of the Product in Accordance with
EC Directive 2002/96/EC.

At the end of its working life, the product must not be disposed of as urban
waste. It must be taken to a special local authority differentiated waste
collection centre or to a dealer providing this service.
Disposing of a household appliance separately avoids possible negative
consequences for the environment and health deriving from inappropriate
disposal and enables the constituent materials to be recovered to obtain
significant savings in energy and resources. As a reminder of the need to
dispose of household appliances separately, the product is marked with a
crossed-out wheeled dustbin.

3

Before Using for the First Time

– Read the instructions carefully before installing and using the appliance.
– After unpacking the appliance, check that it is not damaged. In case of doubt, do not use the appliance

and contact your supplier or a qualified engineer.

– Remove all the packing materials (i.e. plastic bags, polystyrene foam, etc.) and do not leave it around within

easy reach of children, as these may cause serious injuries. The packaging materials are recyclable.

– Do not attempt to modify the technical characteristics of the appliance, as it may become dangerous

to use.

– The appliance should be installed and all the electrical connections made by a qualified engineer in

compliance with local regulations in force and following the manufacturer's instructions.

Important Precautions and Recommendations
for Use of Electrical Appliances

Use of any electrical appliance implies the necessity to follow a series of fundamental rules. In particular:
– never touch the appliance with wet hands or feet;
– do not operate the appliance barefooted;
– do not allow children or disabled people to use the appliance without your supervision.

The manufacturer cannot be held responsible for any damages caused by improper, incorrect or
unreasonable use of the appliance.

Using the Double Oven for the First Time

You are advised to carry out the following operations:
– Assemble the interior of the top and the lower ovens as described under the heading “Cleaning and

maintenance”

– Switch the empty ovens ON at maximum temperature for about two hours to eliminate traces of grease

and smell from the components.

– Let the ovens cool down, switch off the electrical supply, then clean the inside of the ovens with a cloth

soaked in water and neutral detergent and dry thoroughly.

4

Important Safeguards and Recommendations

– Do not carry out any cleaning or maintenance without first disconnecting the appliance from the

electrical supply.
– During and after use of the double oven, certain parts will become very hot. Do not touch hot parts.
– After use always ensure that the controls are in the OFF position.
– Household appliances are not intended to be played with by children.
– Keep children away from the oven during use.
– Children, or persons with a disability which limits their ability to use the appliance, should have a

responsible person to instruct them in its use. The instructor should be satisfied that they can use the

appliance without danger to themselves or their surroundings.
– WARNING
When correctly installed, your product meets all safety requirements laid down for this type of product

category. However special care should be taken around the rear or the underneath of the appliance
as these areas are not designed or intended to be touched and may contain sharp or rough edges, that

may cause injury.
– Fire Risk! Do not store inflammable materials inside the ovens.
– Always use oven gloves when removing the shelves and food trays from the oven whilst hot.
– Clean the ovens regularly and do not allow fat or oils to build up in the oven base or trays. Remove

spillages as soon as they occur.

– Do not line the oven walls with aluminium foil. Do not place baking trays or the drip tray on the base

of the oven chambers.

– Always stand back from the double oven when opening the oven doors to allow steam and hot air to

escape before removing the food.

– Do not hang towels, dishcloths or other items on the double oven or its handles – as this could be a

fire hazard.

– Make sure that electrical cords connecting other appliances in the proximity cannot become entrapped

in the oven doors.

– Before disposing of an unwanted appliance, it is recommended that it is made inoperative and that all

potentially hazardous parts are made harmless.

– Important: This appliance has been designed for domestic use only. The appliance is NOT suitable for

use within a semi-commercial, commercial or communal environment.

– Safe food handling: leave food in the oven for as short a time as possible before and after cooking.

This is to avoid contamination by organisms which may cause food poisoning. Take particular care
during warmer weather.

– Do not operate your appliance by means of an external timer or separate remote-control system.

Note:

Your appliance has been fitted with a cooling fan to achieve optimum efficiency of the controls and to
ensure lower surface temperatures are maintained.
When the top oven is operating the cooling fan motor is always ON.
When only the lower main oven is operating the cooling fan motor switches ON/OFF depending on
temperature.
Depending on cooking temperatures and times, the cooling fan may run on even after appliance oven
has been switched off. The duration of this time is dependent on previous cooking temperature and
duration.

5

Top Oven Controls

4

3

43

1

2

2

1

4

3

2

1

Controls Description

1. Temperature knob

2. Cooking functions knob

3. Top oven power ON indicator lamp

4. Top oven temperature indicator lamp

9Q6..

Fig. 1a

DV 990..

9Z6..

Fig. 1b

Fig. 1c

6

Top Natural Convection Oven

General Features

This oven features 2 different thermostatic control functions to satisfy all cooking requirements, provided
by 3 heating elements:

– Upper element, 700 W

– Lower element, 1000 W

– Grill element, 2000 W

Note:

When using for the first time, you are advised to operate the oven at maximum temperature (thermostat
knob on the maximum position) for approximately one hour in the
in the mode in order to eliminate any traces of grease from the electrical elements.

Operating Principles

Heating and cooking in the natural convection oven are obtained:

a. by Normal Convection
The heat is produced by the upper and lower heating elements.

b. by Radiation
The heat is radiated by the infra red grill element.

mode and for another 15 minutes

Attention: the oven door becomes very hot during operation.
Keep children away.

7

How to Use the Top Oven

WARNING: The door is hot, use the handle.

ATTENTION - MOST IMPORTANT
Pay special attention not to touch the hot heating element inside the oven cavity.

Fig. 3Fig. 2

Thermostat Knob (Fig. 2)

To turn on the heating elements of the oven, set function selector knob to the required position and the
thermostat knob to the desired temperature.
To set the temperature, turn the thermostat control knob indicator mark to the required temperature.
The elements will turn on or off automatically which is determined by the thermostat.
The operation of the heating elements is signalled by a light placed on the control panel.

Function Selector Knob (Fig. 3)

Rotate the knob clockwise to set the oven for one of the following functions:

Oven Light

By turning the function selector knob to this setting, the oven light will illuminate in the oven cavity.
The oven light will operate on all selected functions.

8

Traditional Convection Cooking

The upper and lower heating elements come on. The heat is dispersed by
natural convection and the temperature must be set to between 50 °C and
250 °C with the thermostat knob.
The oven must be preheated before cooking.

Recommended for:

Food that requires the same degree of cooking both inside and out, for example roasts, spare pork ribs,
meringues etc.

Traditional Grilling

The infrared grill element comes on. The heat is dispersed by radiation.

Use with the oven door closed. The temperature can be regulated via the thermostat knob to between
50 °C and 225 °C.

For cooking hints, see the chapter “USE OF THE GRILL”.

Recommended for:

Intense grilling, browning, cooking au gratin and toasting etc.

It is recommended that you do not grill for longer than 30 minutes at any one time.

Caution: the oven door becomes very hot during operation. Keep children well out of reach.

Oven Cooking

Before introducing the food, preheat the oven to the desired temperature.
For a correct preheating operation, it is advisable to remove the tray from the oven and introduce it
together with the food, when the oven has reached the desired temperature.
Check the cooking time and turn off the oven 5 minutes before the theoretical time to recuperate the
stored heat.

Use of the Grill

– Preheat the oven for about 5 minutes with the door closed.
– Introduce the food to be cooked, positioning the rack as close to the grill as possible.
– The dripping pan should be placed under the rack to catch the cooking juices and fats.

• Grilling with the oven door closed.

• It is recommended that you do not grill for longer than 30 minutes at anyone time.

• Attention: the oven door becomes very hot during operation. Keep children away.

• The external parts of the oven become hot during operation. Keep children well out of

reach.

9

Lower Main Oven Controls

1

7

234

6 5

1

7

234

6 5

1

7

234

65

Controls Description

1. ON/OFF selection

2. Temperature and programmer functions regulation, Childlock selection

3. Programmer functions selection

4. Oven functions selection

5. Functions display

6. Clock/Programmer display

7. Temperature display

9Q6..

Fig. 4a

DV 990..

9Z6..

Fig. 4b

Fig. 4c

10

Lower Main Full Electronic Multifunction
Oven

General Features

This multifunction oven has 4 heating elements which allow you to choose between 9 cooking
programmes:

– Lower element 1300 W

– Upper element 1000 W

– Grill element 2000 W

– Circular element 2200 W

Note:

Before using your new oven, it is necessary to condition your oven.
Heat the oven on maximum for 60 minutes in the position
eliminate possible traces of grease on the heating elements.
Then heat the oven for another 15 minutes in the grill position as explained in the chapters VENTILATED
GRILL COOKING and GRILLING AND “AU GRATIN”.

IMPORTANT
Do not touch the hot heating elements inside the oven cavity.

Attention: the oven door becomes very hot during operation. Use the handle. Keep children
away.

and (for another 60 minutes) to

“Touch-control” keys

The “touch-control” keys shall be operated by the fingers (just by touching the key).
When using touch controls it is best to use the ball of your finger rather than the tip.

Fig. 5a

Fig. 5b

11

Operating Principles

Heating and cooking in the FULL ELECTRONIC MULTIFUNCTION oven
are obtained in the following ways:

a. by Normal convection

The heat is produced by the upper and lower heating elements.

b. by Semi-Forced Convection From The Bottom

The heat produced by the lower heating element is distributed throughout the oven by the fan.

c. by Radiation

The heat is radiated by the infrared grill element.

d. by Double Radiation

The heat is radiated by the infrared grill and the top heating elements.

e. by Radiation and Ventilation

The radiated heat from the infrared grill element is distributed throughout the oven by the fan.

f. by Semi-Forced Convection From The Bottom And Back

The food is defrosted by using the fan only function without heat.

g. by Forced Convection

The air inside the oven is warmed by a circular heating element at the back of the oven. Hot air is then

moved around the oven by a fan near the heating element. Food can be placed inside a cold oven
because it heats up quickly. The heat is evenly distributed throughout the oven allowing for different
dishes to be cooked simultaneously.

h. by Semi-Forced Convection

The heat produced by the upper and lower heating elements is distributed throughout the oven by the

fan.

i. by Ventilation

1. “

dEF

” food is defrosted by using the fan only.

2. By using “

is activated and this function can be used to keep food warm (for a limited amount of time).

l. by Fast Pre-heating (BOOSTER)

This special program allows (by a combination of the heating elements) a fast pre-heating of the oven

cavity.

dEF

” and setting the temperature (from 40° to 100°C maximum) the lower heating element

Attention: the oven door becomes very hot during operation.
Keep children away.

12

Lit = minute minder in operation

Flashing = countdown completed

by the minute minder

Lit = operation of heating elements

(cooking functions)

Flashing = semi-automatic or automatic

cooking completed

SYMBOL

SYMBOL

SYMBOL

ON/OFF

Programmer functions - Progressive selection
(each time the key is touched)

To increase the numbers

on the display

SYMBOL

SYMBOL

SYMBOL

SYMBOL

Lit = semi-automatic or automatic cooking

programmed

Flashing = semi-automatic or automatic

cooking completed

To decrease the numbers

on the display or to set

the alarm sound

DIGITS

- Oven switched on: Time of day and
selected function (alternating)

- Oven switched off: Time of day

OVEN SWITCHED OFF

Timer

OVEN SWITCHED ON

Oven light
options

Time of day

NORMAL

STAT U S

Automatic
switch off
options

Timer

Time of day and

selected function

(alternating)

NORMAL STATUS

Duration of a
cooking program

Stop time of a
cooking program

Setting time
of day

4

th

1

st

2

nd

3

rd

1

st

2

nd

3

rd

Using the Lower Main Oven - Electronic Display

Fig. 6

13

Electronic Controller Features

It performs the following functions:

– 24 hours clock with illuminated display.

– Timer (minute minder: up to 600 minutes - 10 hours).

– Programme for semi-automatic oven cooking (up to 600 minutes - 10 hours - of cooking time).

– Programme for automatic oven cooking (up to 600 minutes - 10 hours - of cooking time).

– Automatic switch off.

– “Childlock” safety (deactivation of the controller selections).

– Oven functions and temperature selection.

– Each setting is automatically processed about 4 seconds after the last selection.

IMPORTANT NOTE: The first time the oven is used or after a power failure the clock is automatically set
to 12:00 (“

WARNING: The oven can be used but it is preferable to set the time of the day.

12:00

” appears on the clock/programmer display).

Setting Time of Day

The controller is provided with an electronic clock with illuminated figures showing the hour and
minutes.

IMPORTANT: The time of day can be set only when the oven is turned off (“stand-by”
condition).

To set the time:
– Select “

hour

” on the clock/programmer display by using the key “ ”.

– While the hour is flashing touch “ ” and “ ” keys to set the time.

14

Turning the Oven On and Off

To turn the oven ON:

– Touch the key “

– You can now operate your oven. The time of the day appears on the clock/programmer display (followed

by the programme number “

To turn the oven OFF:

– Touch the key “

– The oven is turned off (“stand-by” condition) and the time of the day appears on the clock/programmer

display.

– 3 beeps indicate that the oven has been turned off.

To select the volume of the beeps, touch the “
condition).

WARNING - IMPORTANT NOTE

Do not turn the oven off if you have set it for automatic or semi-automatic cooking. This
operation will cancel the programmed cooking.

Only the timer (minute minder) operates in the “stand-by” condition.

” and hold until “On” appears on the clock/programmer display.

Pr01, Pr02,

” and hold until “

...”).

OFF

” appears on the clock/programmer display.

” key when the oven is turned off (”stand-by”

Oven Automatic Switch Off

– If you do not use your oven within 3 minutes, it automatically switches back to stand-by.
– When the oven is operating a cooking function it automatically switches back to stand-by after 10

hours.

– It is possible to remove the automatic switch off feature by selecting “

with the oven switched off) on the clock/programmer display and then touching the “ ” or “ ” key
to set “

OFF

”.
To reactivate the automatic switch off feature repeat the same procedure and set to “On”.
It is factory setted for “
activated after a power failure.

A_SO - On

” (automatic switch off ON) and this option is also automatically

A_SO

” (by using the key “ ”

15

Childlock Safety

To activate the Childlock option touch the “ ” and “ ” keys
simultaneously and hold until the clock/programmer display
shows “

n--0

” and then “On”.
Then the time of the day appears again (followed by the selected
programme number “
temperature display shows “ ”.
When the Childlock option has been selected it is only possible to
turn off the oven (stand-by mode) and operate the timer (minute
minder).
In this setting it is not possible to change the oven cooking
programme (cooking function, temperature) and the time
selected for a semi-automatic or automatic cooking: if touching
the relative keys “
If the oven is turned off (stand-by mode) it is only possible to
operate the timer.
To deactivate the “Childlock” option touch the “ ” and “ ”
keys simultaneously and hold until the clock/programmer display
shows “

n--0

Then the time of the day appears again (followed by the selected
programme number “
the temperature display the “ ” symbol goes out.

IMPORTANT: If the oven has been switched OFF (stand-by mode) with the Childlock option
selected it is possible to turn ON the oven only after having deactivated the Childlock.

Pr01, Pr02, ...

n--0

” and then “

Pr01, Pr02, ...

” when the oven is ON). The

” appears on the central display.

OFF

”.

” when the oven is ON). On

Fig. 7

Using The Timer (Minute Minder)

You can use the timer at any time, even when the oven is not in use or switched off (stand-by mode). The
timer does not turn the oven off. Remember to turn off the oven manually. The timer can be set for up
to 600 minutes (10 hours).

To set the timer:
– Select “

bELL

” on the clock/programmer display by using the key “ ” and then, with “----” flashing on

the central display, touch “ ” and “ ” keys and set the time in minutes.
– To reset the time touch the “ ” or “ ” key.
– Then the time of the day appears again on the clock/programmer display (followed by the selected

programme number “
– To check the countdown select “

time is indicated (for a few seconds) in minutes.
– When the time is up, the timer will beep. Touch any key (except the “ ” key) to turn it off.

NOTE:
The timer also operates if the oven, after selection, is turned OFF (stand-by mode). The timer
can also be set in the stand-by mode (OFF).

Pr01, Pr02, ...

bELL

” when the oven is ON) and the countdown starts immediately.

” on the clock/programmer display by using the key “ ”; the

16

Oven Cooking Function

When selection a cooking function the
relative programme number and the
symbol are activated.

Set Oven Function Key

Decreasing

Set Oven Function Key

Increasing

Setting

Setting

Clock/

Programmer

Display

Functions

Display

Using the Lower Main Oven
Selecting the Cooking Functions

Fig. 8