Page 1
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
ESPECIFICAÇÃO TÉCNICA
EMITIDO POR: DAVID
EMITTED BY:
MODELO: A-350
MODEL :
CÓDIGO: 1005231204
CODE:
REV: DATA/
APROVADO POR: ROBERTO
APPROVED BY:
CONDIÇÕES PARA MEDIÇÃO:
MEASUREMENT CONDITION:
1- ALIMENTAÇÃO : 127 V
POWER SOURCE
AC / 60Hz
2- PONTOS DE MEDIÇÃO :
MEASUREMENT POINTS
AMPLIFICADOR : SAÍDA 8 OHMS
FULL RANGE-AMP : OUT 8 OHMS
3- NÍVEL PARA MEDIÇÃO :
MEASUREMENT LEVEL:
SAÍDA AJUSTADA PARA APROXIMADAMENTE 1W
SET OUTPUT TO ABOUT 1W
4- TODOS OS AJUSTES DE EQUALIZAÇÃO EM MODO FLAT
ALL ADJUST IN FLAT MODE
DATE : 21/07/2004
REV: OBSERVAÇÃO/REMARK:: DATA/DATE:
Com liberação de Manaus 12/08/04
CpQD
Page 2
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
AMPLIFICADOR
AMPLIFIER
ENTRADA: via CD ALIMENTAÇÃO : 127V
INPUT: via CD POWER SOURCE: 127VAC
SAÍDA: CARGAS 8 OHMS
OUTPUT: OUT LOAD 8 OHMS
N°
TEM
Í
ITEM
CONDIÇÕES
CONDITIONS
AC
VALOR TÍPICO
TYPI CAL VALUE
VALOR LIMITE
LIMIT VALUE
POTÊNCIA DE SAÍDA
1
POWER OUTPUT
DISTORÇÃO
2
DISTORTION
1KHz 0dB – medido em 127Vac
10% THD – measured in 127Vac
1KHz 0dBV, CARGA 1W
1W OUTPUT LOAD , FLAT
10+10 W
8,9+8,9 V
1,5%
9,5+9,5 W
8,7+8,7 V
3%
POTÊNCIA DE
3
CONSUMO
POWER CONSUMER
MODO STBY
STBY MODE
MEIO VOLUME - 1KHz 0dB
HALF VOLUM
VOLUME MÁXIMO - 1KHz 0dB
MINIMUM VOLUM
6W 10W
20W 30 W
57W 65W
CpQD
Page 3
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
RÁDIO FM
FM RADIO
NÍVEL PADRÃO DE ENTRADA
STANDARD INPUT LEVEL
60dB
ITEM
N°
ITEM
N°
FAIXA DE SINTONIA
1
TUNNING RANGER
SENSIBILIDADE
USUAL 30dB S/N
USABLE SENSITIVITY
2
REL. SINAL/RUÍDO
3
SIGNAL / NOISE
4 DISTORÇÃO
DISTORTION
REJEIÇÃO DE
5
IMAGEM
IMAGE REJECTION
RESPOSTA DE
FREQUÊNCIA
6
FREQUENCY RESPONSE
PARADA DO AUTO
SCAM
7
AUTO-STOP LEVEL
SEPARAÇÃO DE
CANAIS
8
CHANNEL SEPARATION
SENSIBILIDADE DO
9
INDICADOR ESTÉREO
STEREO INDICATION
SENSITIVITY
REJEIÇÃO DE FI
10
FI REJECTION
MODULAÇÃO
MODULATION
MONO: 1kHz, DESVIO: 75kHz
MONO: 1KHz, DEVIATION: 75kHz
ESTÉREO: L + R, 37,5kHz
STEREO: L + R , 37,5kHz
PILOTO: 7,5kHz
PILOT : 7,5kHz
CONDIÇÕES
CONDITION
MÍNIMO
MINIMUM
MÁXIMO
MAXIMUM
90,1MHz
98,1MHz
106,1MHz
98,1MHz
98,1MHz mono
estéreo
ANTENA
ANTENNA
DUMMY DA VI
ACOPLAGEM DIRETA
DIRECT COUPLING
PONTO DE MEDIÇÃO:
SAÍDA DO RÁDIO
MEASUREMENT POINTS: OUTPUT
RADIO
VALOR TÍPICO
TYPICAL VALUE
87,5 MHz 87,5 MHz
108,1 MHz 108,1 MHz
9 dB
9 dB
9 dB
50 dB
0,5 %
3,5%
106.1MHz 45 dB 25 dB
98.1MHz
1kHz
100 Hz
6 KHz
± 1 dB
-8 dB
90.1MHz 15 dB 21 dB
98,1MHz 15 dB 21 dB
106.1MHz 15 dB 21 dB
98,1MHz
98,1MHz
1KHz
ON
OFF
25 dB 20 dB
10 dB 15 dB
10 dB 15 dB
90,1MHz 50 dB 70 dB
IMPEDÂNCIA DE
ENTRADA
IMPEDANCE OF IMPUT
75 OHMS
VALOR LIMITE
LIMIT VALUE
12 dB
12 dB
12 dB
38 dB
1%
5%
±5 dB
-10 dB
ATUAÇÃO DO AFC
11
AFC ATUACTION
98,MHz
-3dB UP 300 kHz 450 kHz
-3dB DOWN 300 kHz 450 kHz
CpQD
Page 4
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
RÁDIO AM
AM RADIO
NÍVEL PADRÃO DE ENTRADA: 74dBµV, MODULAÇÃO 30% 400Hz, ANTENA LOOP
STANDARD INPUT LEVEL : 74dBµV, MODULATION: 30% 400Hz, ANTENNA LOOP
N°
ITEM
N°
ITEM
FAIXA DE SINTONIA
1
TUNNING RANGER
SENSIBILIDADE
USUAL 20dB S/N
USABLE SENSITIVITY
2
REL. SINAL/RUÍDO
3
SIGNAL / NOISE
REJEIÇÃO DE
4
IMAGEM
IMAGE REJECTION
AGC
5
AGC
DISTORÇÃO
6
DISTORTION
RESPOSTA DE
FREQUÊNCIA
7
FREQUENCY RESPONSE
PARADA DO AUTO
SCAN
AUTO SCAN STOP LEVEL
8
REJEIÇÃO DE FI
9
IF REJECTION
CONDIÇÕES
CONDITION
MÍNIMO
MINIMUM
MAXIMO
MAXIMUM
600kHz
1000kHz
1400kHz
1000Hz
1400kHz
1000kHz
1000kHz
1000kHz
400Hz
600kHz
1000kHz
1400kHz
600kHz
100Hz
3kHz
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
520 kHz 520 kHz
1650 kHz 1650 kHz
60 dB 72 dB
60 dB 72 dB
60 dB 72 dB
36 dB 28 dB
30 dB
≥25 dB
60 dB
≥50 dB
0,8%
± 3 dB
-5 dB
70 dB
70 dB
70 dB
>40dB
<3%
±5 dB
-8 dB
80 dB
80 dB
80 dB
>30dB
DECK REPRODUÇÃO
REPRODUCTION DECK
N°
ITEM
N°
ITEM
1 WOW & FLUTER
RESPOSTA EM
2
FREQUENCIA
FREQUENCY RESPONSE
SEPARAÇÃO DE
3
CANAIS
CHANNEL SEPARATION
RUÍDO TAPE PLAY
4
TAPE NOISE PLAY
CONDIÇÕES
CONDITION
W&F 0,1% 0,3%
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
MTT 111
MTT 117
MTT 117
( 1KHz = 0dB )
FREQ. 3 kHz
125Hz
6,3KHz
± 1 dB
± 1 dB ± 3 dB
3 kHz ± 3%
± 3 dB
MTT 141 30 dB 20 dB
VOLUME MÍNIMO
MINIMUM VOLUM
5 mV 10 mV
CpQD
Page 5
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
RELAÇÃO SINAL
5
RUÍDO
SIGNAL NOISE RELATION
DISTORÇÃO
6
DISTORTION
DIFERENÇA ENTRE
7
TAPES
LEVEL DIFFERENCE TAPES
DECK GRAVAÇÃO
WRITING DECK
N°
ITEM
N°
ITEM
RELAÇÃO SINAL
1
RUÍDO
SIGNAL NOISE RELATION
RESPOSTA EM
2
FREQUENCIA
FREQUENCY RESPONSE
SEPARAÇÃO DE
3
CANAIS L/R
CHANNEL SEPARATION
RUÍDO TAPE
4
REC/PLAY
TAPE NOISE REC/PLAY
DISTORÇÃO
5
DISTORTION
NÍVEL DE SAÍDA
6
REC/PLAY
OUTPUT REC/PLAY LEVEL
NÍVEL DE
7
APAGAMENTO
ERASE LEVEL
CD
CD
VOLUME MÁXIMO
MAXIMUM VOLUM
50 mV
100 mV
MTT 118 ( PLAY/STOP ) 30 dB 25 dB
MTT 118 1% 3 %
MTT 118 0,5dB 2dB
CONDIÇÕES
CONDITION
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
1kHz -10dB via CD 30 dB 25 dB
( 1KHz = 0dB )
125Hz
6,3KHz
±2 dB ±5 dB
±2 dB ±5 dB
1KHz - L/R 30 dB 25 dB
VOLUME MÍNIMO
MINIMUM VOLUM
VOLUME MÁXIMO
MAXIMUM VOLUM
1 mV 10 mV
50 mV 120 mV
MTT 118 1,5 % 3 %
MTT 118 1dB 3dB
MTT 118 30dB 25dB
N°
N°
2
ITEM
ITEM
RELAÇÃO SINAL
1
RUÍDO
SIGNAL NOISE RELATION
RESPOSTA EM
FREQUENCIA
FREQUENCY RESPONSE
SEPARAÇÃO DE
3
CANAIS L/R
CHANNEL SEPARATION
RUÍDO TAPE
4
REC/PLAY
TAPE NOISE REC/PLAY
DISTORÇÃO
5
DISTORTION
CONDIÇÕES
CONDITION
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
TNO 24 CD Yeds 18 60 dB 50 dB
TNO 04
TNO 09
( 1KHz = 0dB )
TNO 33/34 - CD Yeds 18
1KHz - L/R
VOLUME MÍNIMO
MINIMUM VOLUM
VOLUME MÁXIMO
MAXIMUM VOLUM
125Hz
6,3KHz
± 0,5 dB ± 3 dB
± 0,5 dB ± 3 dB
45 dB 40 dB
1 mV 10 mV
10 mV 50 mV
TNO 24 - CD Yeds 18 1 % 2 %
CpQD
Page 6
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
EQUALIZADOR
EQUALIZATOR
N°
ITEM
N°
ITEM
1 HI CUT ON VOL.10 – 10KHz -12dB
CONDIÇÕES
CONDITION
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
± 2 dB
CpQD
Page 7
ENCODERENCODER
VOLUMEVOLUME
E801E801
+5V+5V
++
C810C810
10uF/50V10uF/50V
BC856BBC856B BC856BBC856B BC856BBC856BBC856BBC856B
Q802Q802 Q803Q803 Q804Q804Q801Q801
DISPLAYDISPLAYDISPLAYDISPLAY
+5V+5V
D803D803
D804D804
AZULAZUL
OPC.OPC.
OPC.OPC.
180R180R
R854R854
R853R853
+5V+5V
R847R847
D801D801
D802D802
AZULAZUL
OPC.OPC.
180R180R
R851R851
OPC.OPC.
R852R852
R850R850
10K10K
10K10K
R849R849
R848R848
100R/1/2W100R/1/2W
100R/1/2W100R/1/2W
1K1K
R801R801
1K1K
R802R802
1K1K
R803R803
1K1K
R804R804
BC856BBC856B
Q805Q805
1K1K
AA
44
88
66
22
11
FF
EE
DD
BB
L1L1
GG
CC
L2L2
DPDP DPDP DPDP
1616 1313 33 55 1111 1515 771414
DS801DS801
R805R805
DIGIT 4DIGIT 4DIGIT 3DIGIT 3DIGIT 2DIGIT 2DIGIT 1DIGIT 1
L3L3
DPDP
1 - DIGIT 11 - DIGIT 1
2 - DIGIT 22 - DIGIT 2
3 - D3 - D
4 - L1,L2,L34 - L1,L2,L3
5 - E5 - E
6 - DIGIT 36 - DIGIT 3
7 - DP7 - DP
8 - DIGIT 48 - DIGIT 4
9 - NO CONNECTION9 - NO CONNECTION
10- NO PIN10- NO PIN
11- F11- F
12- NO PIN12- NO PIN
13- C,L313- C,L3
14- A,L114- A,L1
15- G15- G
16- B,L216- B,L2
Q814Q814
BC846BBC846B
LED_DISPLED_DISP
ENC_A2ENC_A2
ENC_A1ENC_A1
GNDGND
+5V+5V
CPCP CPCP
DD
STBSTB STBSTB
HI_CUTHI_CUT
TECL_BTECL_B
TECL_ATECL_A
REMREM
Q815Q815
BC846BBC846B
10n10n
10n10n
C812C812
C811C811
88 77 66 55 44 33 22 11
0101
0202
OPC.OPC.
OPC.OPC.
C808C808
OPC.OPC.
C807C807
C809C809
R855R855
1K1K
R856R856
10K10K
0303
VSSVSS
IC802IC802
QSQS
QSQS
(SMD)(SMD)40944094
0606
0707
DD
CPCP
0000
0505
STBSTB
E0E0
0404
VDDVDD
161615151414131312121111101099
C802C802
22n22n
0R0R
R814R814
BC846BBC846B
Q806Q806
R806R806
DD
0R0R
R815R815
BC846BBC846B
Q807Q807
10K10K
R807R807
+5V+5V+5V+5V
C801C801
22n22n
0R0R
R816R816
BC846BBC846B
Q808Q808
10K10K
R808R808
DD
CPCP
STBSTB
IC801IC801
E0E0
0404
VDDVDD
1616 1515 1414 1313 1212 1111 1010 99
0R0R
R817R817
BC846BBC846B
Q809Q809
10K10K
0000
0101
(SMD)(SMD)40944094
0505
0606
10K10K
R809R809
0202
0303
0707
QSQS
0R0R
R818R818
BC846BBC846B
Q810Q810
R810R810
8877665544332211
VSSVSS
QSQS
0R0R
R819R819
BC846BBC846B
Q811Q811
10K10K
R811R811
0R0R
R820R820
BC846BBC846B
Q812Q812
10K10K
R812R812
0R0R
R821R821
BC846BBC846B
Q813Q813
10K10K
10K10K
R813R813
SENSORSENSOR
REMOTOREMOTO
IR801IR801
332211
RPM6936/V4RPM6936/V4
R842R842
++
C806C806
47uF/25V47uF/25V
33R33R
+5V+5V
2K22K2
R831R831
SW808SW808
SKIP_RWSKIP_RW
1K1K 2K22K2
R841R841 R839R839
2K22K2
R840R840
NCNC
SW816SW816
2K22K2
R830R830
DISC3DISC3
SW807SW807
SW815SW815
OP/CLOSEOP/CLOSE
2K22K2 2K22K2
R829R829 R828R828
DISC2DISC2
SW806SW806
POWERPOWER
SW814SW814
+5V+5V
2K22K2
R827R827
DISC1DISC1
SW805SW805
FMFM
SW813SW813
2K22K2
R837R837
PL/PSPL/PS
SW804SW804
2K22K2
R836R836
AMAM
SW812SW812
2K22K2
R826R826
STOPSTOP
SW803SW803
2K22K2 2K22K2
R835R835 R834R834
TAPETAPE
SW811SW811
2K22K21K1K
R825R825R832R832
SW802SW802
HI-CUTHI-CUT
CDCD
SW810SW810
1K1K
R824R824
SW801SW801
SURROUNDSURROUND
1n1n
C804C804
1K1K2K22K2
R833R833R838R838
SW809SW809
SKIP_FFSKIP_FF
1n1n
C805C805
100K100K100K100K
R844R844R845R845
DES.DES.
PROJ.PROJ.
APRO.APRO.
P.A.P.A.ALT.ALT.
NOMENOME
THIAGOTHIAGO
ROBERTOROBERTO
TITULO:TITULO:
TITLE:TITLE:
06/05/0406/05/04THIAGOTHIAGO
06/05/0406/05/04
DISCRIMINACAODISCRIMINACAO DATADATAVISTOVISTO
ESQUEMA ELETRICO PCI FRONTAL ESQUEMA ELETRICO PCI FRONTAL
FRONTAL PCB ELECTRIC SCHEMATICFRONTAL PCB ELECTRIC SCHEMATIC
MAT.MAT.DATADATA
ACAB.ACAB.
ESC.ESC.
MOD.MOD.
A-350"B,C" - A-320"A,B"A-350"B,C" - A-320"A,B"06/05/0406/05/04
COD.COD.
PROJECAOPROJECAO
N.N.TOL.TOL.TOL.TOL.
A2A2
1.00.52338.011.00.52338.01
mmmmememdimensoesdimensoes
Page 8
+5V+5V
D601D601
BZX79C3V3BZX79C3V3
R605R605
10K10K
180R180R
+5V+5V
R606R606
+5V+5V
2K22K2
R647R647
ANT 75ohmANT 75ohm
GNDGND
AGCAGC
GNDGND
R126R126
R130R130
2K22K2
R140R140
330K330K
TU101TU101
CN101CN101
1K1K
1K1K
C123C123
C1C1
27p27p
R128R128
1K81K8
R2R2
0R0R
C608C608
(FM)(FM)(AM)(AM)
GNDGNDGNDGND
2SC2413K2SC2413K
10n10n
L1L1
47p47p
C607C607
R125R125
C122C122
Q104Q104
2SC4098T2SC4098T
C2C2
27p27p
100n100n
VCCVCC
OSCOSC
VTVT
IFIF
220R220R
10n10n
C3C3
27p27p
C4C4
100n100n
R648R648
STBSTB
DD
CPCP
ENC_A1ENC_A1
ENC_A2ENC_A2 ENC_A2ENC_A2
REMREM REMREM
11
22
33
44
47n47n
C143C143
ANT_FM"T"ANT_FM"T"
ANT_LOOPANT_LOOP
1:ANT1:ANT
2:GND2:GND
4:GND4:GND
3:AGC3:AGC
R608R608
1K1K
R641R641
C610C610
55
66
88
77
R127R127
3K33K3
R129R129
330R330R
KDV804CKDV804C
R1R1
18K18K
32,768KHz32,768KHz
47p47p
L2L2
D1D1
33K33K
R604R604
C641C641
R640R640
10M10M
X601X601
47p47p
R601R601
10K10K
10K10K
R602R602
R603R603
10K10K
Q601Q601
BC846BBC846B
Q602Q602
BC846BBC846B
22K22K
47p47p
47p47p
C626C626
C642C642
+5V+5V
MOTOR+MOTOR+
47p47p
VC101VC101
T102T102
ANT-AMANT-AM
R3R3
C144C144
10n10n
18p18p
R609R609
47p47p
C611C611
10p10p
55
66
C7C7
R4R4
100K100K
C609C609
11
33
22
44
6p6p
C5C5
C6C6
22n22n
22K22K
C121C121
100R100R
100R100R
100R100R
R610R610
10K10K
TP7TP7
C601C601
R633R633
R625R625
R632R632
ENC_A1ENC_A1
MOTOR+MOTOR+
OSC2OSC2
OSC1OSC1
VREGVREG
+5V+5V
PWMPWM
0R0R
D401D401
1N41481N4148
OPC.OPC.
C415C415 R414R414
8p28p2
++
C124C124
C138C138
10uF/50V10uF/50V
FSTFST
BF998RBF998R
100K100K
H-0300SH-0300S
TECL_BTECL_B
++
1uF/100V1uF/100V
1111
1010
TP6TP6
IRQ1IRQ1
TP5TP5
PWMPWM
++
C602C602
IRQ1IRQ1
99
99
PTB4/T1CH0PTB4/T1CH0
88
88
VSSVSS
77
77
OSC2OSC2
66
66
OSC1OSC1
55
55
VDDVDD
44
44
PTB5/T1CH1PTB5/T1CH1
33
33
VREGVREG
22
22
11
4444 4343 4242 4141 4040 3939 3838 3737 3636 3535
4444 4343 4242 4141 4040 3939 3838 3737 3636 3535 3434
22n22n
C605C605
47uF/25V47uF/25V
R639R639
10K10K
33n33n
C635C635
R413R413
470R470R
D101D101
SVC383SVC383
C117C117
47n47n
3636 3535 3434 3333 3232 3131 3030 2929 2828 2727 2626 2525 2424 2323 2222 2121 2020 1919
FMFM
RF INRF IN
AMAM
C634C634
22p22p
C120C120
R123R123
10K10K
47n47n
C115C115
RF OUTRF OUT
REGREGRF INRF IN
22n22n
C125C125
TP2TP2
1K1K
CECE
PTC1PTC1
PTA/ADC5PTA/ADC5
PTA4/ADC4PTA4/ADC4
PTA3/ADC3PTA3/ADC3
PTA2/ADC2PTA2/ADC2
PTA1/ADC1PTA1/ADC1
PTA0/ADC0PTA0/ADC0
PTD5/KBI5PTD5/KBI5
PB_1/2PB_1/2
R622R622
BB
2222212120201919181817171616151514141313
22222121202019191818171716161414 151513131212
PTC0/IRQ2PTC0/IRQ2
VREFLVREFL
PTD6/KBI6PTD6/KBI6
CDM_POSCDM_POS
1K1K
1K1K
R619R619
DD
CPCP
SDASDA
SCLSCL
PTB2/TxDPTB2/TxD
CGMXFCCGMXFC
PTB0/SDAPTB0/SDA
PTB1/SCLPTB1/SCL
PTB7/T2CH1PTB7/T2CH1
SURROUNDSURROUND
R614R614
1K1K
RSTRST
PTB3/RxDPTB3/RxD
PTB6/T2CH0PTB6/T2CH0
PTD0/KBI0PTD0/KBI0
STBYSTBY
R638R638
PTC7/SCRxDPTC7/SCRxD
PTD1/KBI1PTD1/KBI1
RECREC
1K1K
R629R629
MC68HC908AP32MC68HC908AP32
REC_SWREC_SW
1K1K
R607R607
DODO
CLCL
VREFHVREFH
PTD7/KBI7PTD7/KBI7
M_RPM_RP
R626R626
DIDI
PTC2/MISOPTC2/MISO
PTC3/MOSIPTC3/MOSI
PTD3/KBI3PTD3/KBI3
PTD4/KBI4PTD4/KBI4
M_PM_P
10R10R
R627R627
STBSTB
PTC4/PTC4/
SSSS
PTC5/SPSCKPTC5/SPSCK
PTC6/SCTxDPTC6/SCTxD
PTA7/ADC7PTA7/ADC7
PTA6/ADC6PTA6/ADC6
IC601IC601
PTD2/KBI2PTD2/KBI2
VDDAVDDA
VSSAVSSA
1K1K
10n10n
33K33K
47p47p
47p47p
C636C636
C615C615
C118C118
39p39p
C119C119
390p390p
100K100K
R124R124
R120R120
100R100R
FMFMGND2GND2
FMFM
GND1GND1MIXMIX
11
FI_AMFI_AM
T104T104
22
47p47p
47p47p
C606C606
C630C630
R121R121
5K65K6
100n100n
C116C116
47n47n
C114C114
AMAM
FMFMVcc2Vcc2
OSCOSC
OSCOSC
AMAM
Vcc1Vcc1IF INIF IN
66
4433
47p47p
C628C628
C627C627
T101T101
11
AM_OSCAM_OSC
OPC.OPC.
R119R119
AMAM
IF INIF IN
CF102CF102C139C139
SFU450BSFU450B
47p47p
44
6633
R131R131
220K220K
C620C620
47p47p
C623C623
47n47n
C113C113
IC101IC101
LV23002MLV23002M
FMFM
1uF/10V1uF/10V
C140C140
CF103CF103
SFE10.7MA5-ASFE10.7MA5-A
C141C141
22n22n
++
100R100R
D103D103
22n22n
C126C126
R5R5
L4L4
L5L5
BZX79C5V1BZX79C5V1
D2D2
C11C11
47uF/25V47uF/25V
100n100n
C127C127
6p6p
R9R9R16R16
680R680R1M1M
KDV804CKDV804C
2p2p
R18R18
100R100R
C9C9
33K33K
R7R7
10K10K
R11R11
C20C20
10p10p
3K93K9
R17R17
D3D3
KDV804CKDV804C
47p47p
C23C23
L7L7
22p22p
10K10K
R19R19
C22C22
C8C8
100n100n
SCLSCL
SDASDA
DODO
CLCL
DIDI
CECE
BB
++
22n22n
C631C631
C603C603
C633C633
C137C137
TECL_BTECL_B
TECL_ATECL_A
MUTEMUTE
STATUSSTATUS
RST_CDRST_CD
CAR_POSCAR_POS
22n22n
++
2,2uF/100V2,2uF/100V
AA
CAR-CAR-
CAR+CAR+
++
10uF/16V10uF/16V
C112C112
R113R113
R112R112
TP3/04TP3/04
+5V+5V
C604C604
100n100n
2323
2424
2424
2525
2525
2626
2626
2727
2727
2828
2828
2929
2929
3030
3030
3131
3131
3232
3232
3333
3333
R115R115
2K22K2
R117R117
1K1K
R116R116
P-COMPP-COMPP-DETP-DETIF INIF IN
FMFM
CF101CF101
3K33K3
R132R132
10uF/50V10uF/50V
TP8TP8
TP9TP9
Q103Q103
BC856BBC856B
10K10K
5K65K6
OPC.OPC.
++
C136C136
CDA10.7-MG46CDA10.7-MG46
R646R646
10R10R
R114R114
22uF/50V22uF/50V
R612R612
R613R613
R615R615
R621R621
R620R620
R611R611
R616R616
+5V+5V
R617R617
R630R630
R634R634
R635R635
R636R636
R637R637
R618R618
OPC.OPC.
C135C135
LOW CUTLOW CUT
C134C134
1n1n
C111C111
1uF/10V1uF/10V
AMAMAGCAGCPDPDA-INA-INA-OUTA-OUTBO1BO1BO2BO2
10R10R
10R10R
1K1K
10R10R
10R10R
0R0R
1K1K
1K1K
1K1K
10R10R
10R10R
1K1K
1K1K
1K1K
10K10K
R118R118
++
47uF/25V47uF/25V
C133C133
4,7uF/100V4,7uF/100V
++
DETDET
OUTOUT
47p47p
47p47p
C614C614
C617C617
33K33K
C619C619
TP1TP1 TP10TP10
GNDGND
R111R111
10R_1/2W10R_1/2W
100n100n
C110C110
3K33K3
R135R135
C109C109
MPXMPX
ININ
47p47p
C613C613
47p47p
47p47p
C637C637
C638C638
+5V+5V
CDM_POSCDM_POS
SURROUNDSURROUND
STBYSTBY
PB_1/2PB_1/2
M_RPM_RP
REC_SWREC_SW
RECREC
MOTOR+MOTOR+
560R560R
R110R110
C108C108
2n72n7
10p10p
C107C107
1uF/10V1uF/10V
1uF/10V1uF/10V
C142C142
TR1TR1
2SC2413K2SC2413K
L6L6
27p27p
C13C13
1n1n
C18C18
12p12p
C14C14
C15C15
R12R12
R15R15
220R220R
TR3TR3
2SC2413K2SC2413K
1K51K5
C21C21
R13R13
C17C17C19C19
2p2p27p27p
22p22p
R133R133
82R_1/2W82R_1/2W
7:IF7:IF
IFTIFT
100n100n
6:VCC6:VCC
33R33R
R14R14
100R100R
8:OSC8:OSC5:VT5:VT
TR2TR2
2SC2413K2SC2413K
PWMPWM
M_PM_P
CN701/CCN701/C
CN602CN602
+5V+5V+5V+5V
+5V+5V
+5V+5V
/TRAY+/TRAY+
TECL_ATECL_A
0K1
0K
1
10K10K
10K10K
R642R642
47p47p
C612C612
47p47p
47p47p
C639C639
C640C640
47p47p
47p47p
C622C622
C621C621
47p47p
47p47p
C632C632
C618C618
R645R645
R644R644
47p47p
C616C616
+5V+5V +5V+5V +5V+5V
10K10K
10K10K
R658R658
R660R660
R659R659
100n100n
C105C105
10K10K
STATUSSTATUS
R643R643
CECECECE
4K74K7
33
22
SCLSCLSCLSCL
SDASDA
CDRWCDRW
DODODODO
CLCLCLCL
DIDIDIDI
661155
44
CAR-CAR-
CAR+CAR+
RST_CDRST_CD
CAR-CAR-
CAR+CAR+
RST_CDRST_CD
99
88
77
55
88
66
77
11
CN603CN603
DECKDECK
SIMPLESSIMPLES
CAR_POSCAR_POS
99
88
66
55
1111
1010
GNDGND
+9VA+9VA
CAR_POSCAR_POS
CDM_POSCDM_POS
CDM_POSCDM_POS CDM_POSCDM_POS
+9V+9V
R109R109
1K1K
R104R104
C132C132
77
M_PM_P
M_RPM_RP
PB_1/2PB_1/2
PB_1/2PB_1/2 PB_1/2PB_1/2
REC_SWREC_SW
M_PM_P M_PM_P
M_RPM_RP M_RPM_RP
REC_SWREC_SW REC_SWREC_SW
100R100R
++
44443333222211
RECREC
R_OUTR_OUT
RECREC RECREC
R_OUTR_OUT R_OUTR_OUT
CN601CN601
DECKDECK
DUPLODUPLO
L_RECL_REC
R_RECR_REC
BB
L_RECL_REC
R_RECR_REC
L_OUTL_OUTL_OUTL_OUT L_OUTL_OUT
BB
AA
L_RECL_REC
R_RECR_REC
100uF/16V100uF/16V
100n100n
X101X101
75KHz75KHz
R108R108
4,7uF/100V4,7uF/100V
Q102Q102
BC846BBC846B
1K51K5
C128C128
++
R106R106
100K100K
C104C104
C130C130
1uF/10V1uF/10V
18n18n
D102D102
BZX79C3V3BZX79C3V3
10p10p
C106C106
R102R102
1K1K
15n15n
C102C102
MOTOR+MOTOR+
X-INX-INX-OUTX-OUTVDDVDD
1K1K
R103R103
R107R107
4,7uF/100V4,7uF/100V
Q101Q101
BC846BBC846B
1K51K5
C129C129
++
R105R105
100K100K
C131C131
1uF/10V1uF/10V
18n18n
DODOCLCLDIDICECEVSSVSSR-OUTR-OUTL-OUTL-OUTDETDET
181817171616151514141313121211111010998877665544332211
R134R134
10K_1/2W10K_1/2W
DODO
CLCL
DIDI
CECE
+9V+9V
R136R136
R137R137
R138R138
R139R139
10R10R
10R10R
10R10R
10R10R
C103C103
R101R101
1K1K
15n15n
C101C101
0V-OFF0V-OFF
MOTORMOTOR
5V-ON5V-ON
47K47K
R958R958
GNDMGNDM GNDMGNDM
22 11
opc.opc.
R955R955
Q953Q953
BC846BBC846B
C950C950
4K74K7
CN906CN906
++
BC327/25BC327/25
D952D952
opc.opc.
R956R956
++ --
MMI-6S9LMMI-6S9L
MM
SURROUNDSURROUND
SURROUNDSURROUND
RADIO_RRADIO_R
RADIO_LRADIO_L
+12V+12V
10K10K
Q952Q952
R950R950
C952C952
GNDMGNDMGNDMGNDM
CNTP9CNTP9
* = fixado ao dissipador* = fixado ao dissipador
HI_CUTHI_CUT
HI_CUTHI_CUT
C409C409
C411C411
++
10uF/50V10uF/50V
D402D402
R415R415
PWMPWM
470R470R
PWMPWM
HI_CUTHI_CUT
++
47uF/25V47uF/25V
C430C430
PWMPWM
STBYSTBYSTBYSTBY
L_RECL_REC
R_RECR_REC
++
BZX79C5V1BZX79C5V1
C412C412
++
10uF/50V10uF/50V
R409R409
4K74K7
+9V+9V
1K1K
R411R411
++
C413C413
47uF/25V47uF/25V
++
10uF/50V10uF/50V
C414C414
R410R410
4K74K7
C428C428
100p100p
R405R405
Q403Q403
BC856BBC856B
33K33K
R407R407
C410C410
100p100p
Q404Q404
BC856BBC856B
33K33K
R408R408
15R15R
SURROUNDSURROUND
R406R406
15R15R
MUTEMUTE
C422C422
R440R440
1K1K
++
2,2uF/100V2,2uF/100V
C418C418
10uF/50V10uF/50V
L_RECL_REC
RADIO_RRADIO_R
R_RECR_RECR_RECR_REC
L_RECL_REC
C421C421
2,2uF/100V2,2uF/100V
++
C427C427
R_RECR_REC
L_RECL_REC
C420C420
++
2,2uF/100V2,2uF/100V
10K10K
R444R444
R442R442
3M33M3
Q408Q408
BC846BBC846B
1K51K5
R438R438
100n100n
C402C402
C407C407
C408C408
5V-ON5V-ON
0V-OFF0V-OFF
2,2uF/100V2,2uF/100V
++
10n10n
C417C417
IC401IC401
40524052
++
+9V+9V
560R560R
R439R439
47uF/25V47uF/25V
C419C419
2,2uF/100V2,2uF/100V
++
470R470R
R403R403
220uF/25V220uF/25V
++
C405C405
100p100p
C403C403
22p22p
C406C406
100p100p
C404C404
22p22p
R435R435
22K22K
Q401Q401
BC856BBC856B
33K33K
R401R401
VR401VR401
470R470R
R404R404
220uF/25V220uF/25V
R436R436
22K22K
Q402Q402
BC856BBC856B
33K33K
R402R402
+9VA+9VA
BC846BBC846B
R433R433
3K93K9
R451R451
R301R301
1K1K
3K93K9
R452R452
R434R434
1616 1515 1414 1313 1212 1010 991111
VDDVDD
XX
X2X2
Y0Y0
YY
Y2Y2
R441R441
++
C429C429
L_RECL_REC
10K10K
R445R445
R437R437
BC846BBC846B
1K51K5
R443R443
3M33M3
Q407Q407
++
100n100n
C401C401
RADIO_LRADIO_L
Q405Q405
47K47K
R201R201
BC846BBC846B
R202R202
0R0R
Y3Y3
1K1K
2,2uF/100V2,2uF/100V
0R0R
22K22K
Q406Q406
47K47K
Y1Y1
2n72n7
C423C423
22
11
44
66
55
220R220R
++
2,2uF/100V2,2uF/100V
**
IC201IC201
LA4282LA4282
100uF/25V100uF/25V
C211C211
C426C426
++
C209C209
1111
1212
99
77
1010
8833
++
C212C212
10uF/50V10uF/50V
C207C207
2R2_1/2W2R2_1/2W
R207R207
R208R208
2R2_1/2W2R2_1/2W
C208C208
++
2200uF/50V2200uF/50V
C213C213
470uF/25V470uF/25V
220n/63V220n/63V
220n/63V220n/63V
++ ++
470uF/25V470uF/25V
C210C210
1K1K1K1K
R209R209R210R210
1N40041N4004
D201D201
C214C214
10n/100V10n/100V
1N40041N4004
D202D202
C215C215
10n/100V10n/100V
1N40041N4004
D203D203
C216C216
10n/100V10n/100V
1N40041N4004
D204D204
C217C217
10n/100V10n/100V
CN201CN201
(+L)(+L)(+R)(+R)
GNDGNDGNDGND
++
C201C201
10uF/50V10uF/50V
OPC.OPC.
R203R203
R303R303
100K100K
R302R302
22K22K
++
C301C301
C424C424
Q301Q301
BC846BBC846B
100K100K
22uF/50V22uF/50V
R304R304
2n72n7
R215R215
100p100p
C203C203
100p100p
C204C204
47K47K
R205R205
R206R206
R217R217
C205C205
100uF/16V100uF/16V
330R330R
330R330R
C206C206
100uF/16V100uF/16V
10K10K
++ ++
++
STBYSTBY
+5V+5V
C202C202
10uF/50V10uF/50V
OPC.OPC.
R204R204
R211R211
22K22K
0V-ON0V-ON
5V-OFF5V-OFF
BB
AA
R213R213
10K10K
R212R212
22K22K
Q202Q202
BC846BBC846B
R214R214
R216R216
10K10K
BC856BBC856B
Q203Q203
R220R220
BC846BBC846B
Q204Q204
10K10K
Q201Q201
BC846BBC846B
R218R218
10K10K
R219R219
47K47K
CD_RCD_R
+9VA+9VA
X0X0X1X1
X3X3
CONTROLCONTROL
UNITUNIT
100K100K
R422R422
R426R426
VSSVSSVEEVEE
8877665544332211
100K100K
R427R427
R425R425
CD_LCD_L
100K100K
100K100K
R428R428
++
100K100K
100K100K
R421R421
C416C416
4K74K7
R432R432
4K74K7
R431R431
47uF/25V47uF/25V
C425C425
++
2,2uF/100V2,2uF/100V
+12V+12V
IC502IC502
7805PL7805PL
ININ OUTOUT
GNDGND
D510D510
1N41481N4148
R417R417
8K28K2
R418R418
8K28K2
100K100K
D517D517
R420R420
ALIMENTACAOALIMENTACAO
1N41481N4148
100K100K
DO CDDO CD
22n22n
C512C512
R419R419
**
A_GNDA_GND
+5V+5V
GNDGND
+5VB+5VB
++
100uF/16V100uF/16V
C513C513
11
22
33
CN402CN402
LL
GNDGND CDCD
RR
CN507CN507
33
22
11
JC56JC56
D511D511
1N41481N4148
10K10K
R513R513
STBYSTBY
FS501FS501
GF501GF501
TF501TF501
GARRAGARRA
1A/250V1A/250V
120120
2020
100100
* = fixado ao dissipador* = fixado ao dissipador
+5V+5V
++
C511C511
100uF/10V100uF/10V
+12V+12V
+9VA+9VA
10V10V
Q506Q506
BC337/25BC337/25
R507R507
120R120R
120R120R
R509R509
++
C506C506
BZX79C10VBZX79C10V
D506D506
220uF/25V220uF/25V
R506R506
10K10K
Q505Q505
BC337/25BC337/25
D515D515
D516D516
1N41481N4148
1N41481N4148
22n22n
C509C509
A_GNDA_GND
++
10R10R
220uF/16V220uF/16V
C508C508
++
47uF/25V47uF/25V
STBYSTBY
+5V -> Stby Off+5V -> Stby Off
0V -> Stby On0V -> Stby On
22n22n
C510C510
**
C507C507
++
47uF/25V47uF/25V
13V13V
10K10K
R504R504
D505D505
R505R505
Q501Q501
KSD-1408-YKSD-1408-Y
R503R503
BZX79C13VBZX79C13V
47K47K
Q504Q504
IC501IC501
7805PL7805PL
GNDGND
Q503Q503
BC856BBC856B
10K10K
BC846BBC846B
**
ININOUTOUT
++
C505C505
2200uF/25V2200uF/25V
R501R501
220R/1/2W220R/1/2W
D501D501
D502D502
D503D503
D504D504
1N40041N4004
C501C501
10n/100V10n/100V
1N40041N4004
C502C502
10n/100V10n/100V
1N40041N4004
C503C503
10n/100V10n/100V
1N40041N4004
C504C504
10n/100V10n/100V
GF504GF504
OPC.OPC.
OPC.OPC.
FS502FS502
GF503GF503
OPC.OPC.
1212
1313
1010
1111
- ITEM DE SEGURANCA - ESTES COMPONENTES SO PODEM SER SUBSTITUIDOS POR - ITEM DE SEGURANCA - ESTES COMPONENTES SO PODEM SER SUBSTITUIDOS POR
ORIGINAIS DE FABRICAORIGINAIS DE FABRICA
DISCRIMINACAODISCRIMINACAO DATADATAVISTOVISTO
ESQUEMA ELETRICO PCI LATERALESQUEMA ELETRICO PCI LATERAL
LATERAL PCB ELECTRIC SCHEMATICLATERAL PCB ELECTRIC SCHEMATIC
DES.DES.
PROJ.PROJ.
P.A.P.A.ALT.ALT.
NOMENOME
THIAGOTHIAGO
THIAGOTHIAGO
TITULO:TITULO:
TITULO:TITULO:
TITLE:TITLE:
12/05/0412/05/04
12/05/0412/05/04
MAT.MAT.DATADATA
ACAB.ACAB.
ESC.ESC.
SW501SW501
220V220V
GF502GF502
GARRAGARRA
AC INAC IN
110V110V
N.N.TOL.TOL.TOL.TOL.
PROJECAOPROJECAO
A1A1
REDEREDE
11
22
mmmmememdimensoesdimensoes
VERIF.VERIF.
ROBERTOROBERTO
06/05/0406/05/04
MOD.MOD.
A-350"B,C" - A-320"A,B"A-350"B,C" - A-320"A,B"
COD.COD.
1.00.52338.021.00.52338.02
Page 9
TRAYTRAY
CARCAR
MM
M701M701
MM
M702M702
HOME_SWHOME_SW
CN703CN703
VAI PARA PICK-UPVAI PARA PICK-UP
PSC(-)PSC(-)
TRK(+)TRK(+)
TRK(-)TRK(-)
PSC(+)PSC(+)
PDPD
VRVR
LDLD
GNDGND
FF
PICK-UP SANSUNGPICK-UP SANSUNG
CC
BB
AA
DD
EE
VCCVCC
VCVC
TRAY-TRAY-
TRAY+TRAY+
CAR-CAR-
CAR+CAR+
SP+SP+
SP-SP-
SLD+SLD+
SLD-SLD-
GNDGND
CN702CN702
+6V+6V
IC702IC702
L701L701
C746C746
C701C701
R701R701
C702C702
24K24K
470uF/10V470uF/10V
C736C736
R736R736
A_GND1A_GND1
47n47n
22n22n
A_GND1A_GND1
++
47n47n
220uH220uH
GND1GND1
++
11
22
22
33
33
44
44
55
55
66
66
77
77
2929
88
99
1010
1111
1212
1313
1414
1R1R
+6V+6V
Q703Q703
BC337/25BC337/25
100R100R
3V33V3
R732R732
R724R724
R719R719
1K1K
R720R720
1K1K
R731R731
RESETRESET
RESETRESET
R721R721
C726C726
4K74K7
22n22n
R722R722
Q713Q713
BC856BBC856B
Q714Q714
BC856BBC856B
10K10K
CAR-CAR-
1K1K
CAR+CAR+
1K1K
3V33V3
4K74K7
R734R734
4K74K7
R735R735
LDLDLDLD
3V33V3
10R10R
R737R737
++
100n100n
C747C747
C705C705
47uF/25V47uF/25V
A_GND1A_GND1A_GND1A_GND1
Q712Q712
BC807/25BC807/25
C729C729
R727R727
Q708Q708
BC817/25BC817/25
++
22uF/50V22uF/50V
1K51K5
R730R730
11
22
33
44
55
66
77
88
99
1010
1616
1515
1414
1313
1212
1111
1010
99
88
77
66
55
44
33
22
11
CN702CN702
F-F-
T-T-
T+T+
F+F+
MONMON
R739R739
FF
BB
AA
DD
EE
A_GND1A_GND1 A_GND1A_GND1
C744C744
0R0R
A_GND1A_GND1
D702D702
SK-107SK-107
100n100n
100n100n
C706C706
C707C707
Q711Q711
BC807/25BC807/25
100n100n
1K51K5
Q707Q707
BC817/25BC817/25
++ ++ ++
22uF/50V22uF/50V 22uF/50V22uF/50V 22uF/50V22uF/50V
C743C743 C742C742 C741C741
D703D703
SK-107SK-107
+6V+6V
1K51K5
R729R729
Q710Q710 Q709Q709
BC807/25BC807/25 BC807/25BC807/25
100n100n
C728C728
R726R726R728R728
1K51K51K51K5
R725R725
Q706Q706
BC817/25BC817/25
1K51K5
Q705Q705
BC817/25BC817/25
R723R723
4K74K7
C727C727
22n22n
T-T-
F+F+
F-F-
T+T+
3V33V3
47uF/25V47uF/25V
C749C749
A_GND1A_GND1
BB
AA
CCCC
DD
FF
EE
X701X701
8,4672MHz8,4672MHz
C703C703C704C704
33p33p33p33p
A_GND1A_GND1
TZA1048TZA1048
VCCVCC
RADO-RADO-
FOCO+FOCO+
GNDGND
FOCO-FOCO-
RADO+RADO+
VCCVCC
VCCVCC
SLO+SLO+
SLO-SLO-
GNDGND
MOTO+MOTO+
MOTO-MOTO-
VCCVCC
11
22
33
44
55
66
77
88
99
1010
1111
1212
1313
1414
1515
1616
1717
1818
1919
2020
V3.30utV3.30ut
V3.3FBV3.3FB
V1.8OutV1.8Out
V1.8FBV1.8FB
EARTHEARTH
V1.65DutV1.65Dut
RESETRESET
CAR-CAR-
CAR+CAR+
TRAY+TRAY+
TRAY-TRAY-
8080 7979 7878 7777 7676 7575 7474 7373 7272 7171 7070 6969 6868 6767 6666 6565 6464 6363 6262 6161
POWERPOWER
LASERLASER
EXTFILTEREXTFILTER
MONITORMONITOR
SENSESENSE
VSSA1VSSA1
IREFIREF
VDDA1VDDA1
VREF_OUTVREF_OUT
D1D1
D2D2
D3D3
D4D4
R1R1
R2R2
CSLICECSLICE
VDDA2VDDA2
VSSA2VSSA2
OSCOUTOSCOUT
OSCINOSCIN
KDAC_GNDKDAC_GND
VSSA3VSSA3
MUTEMUTE
RADRAD
FODFOD
SLSL
VBiasVBias
GNDGND
Vo toVo to
BiasBias
MOTI1MOTI1
MOTI2MOTI2
C735C735
0,47uF/100V0,47uF/100V
R712R712
++
C734C734
220uF/10V220uF/10V
TEST3TEST3
TEST4TEST4
DAC_RPDAC_RP
DAC_RNDAC_RN
2828
2727
2626
2525
2424
2323
2222
3030
2121
2020
1919
1818
1717
1616
1515
10R10R
TEST2TEST2
DAC_VREFDAC_VREF
Q702Q702
BC337/25BC337/25
GND1GND1
++
TEST1TEST1
DAC_LNDAC_LN
C738C738
220uF/10V220uF/10V
C720C720
GND1GND1 GND1GND1
V5V5
DAC_LPDAC_LP
3V33V3
++
2n22n2
C719C719
V4V4
DAC_VPOSDAC_VPOS
1V81V8
+6V+6V
++
C740C740
47uF/25V47uF/25V
100n100n
Q701Q701
BC337/25BC337/25
++
C722C722
R716R716
R715R715
V2V2
BUF_IN_RBUF_IN_R
C712C712
47uF/25V47uF/25V
SAA7824SAA7824
1uF/10V1uF/10V
4K74K7
4K74K7
V1V1
IC701IC701
BUF_OUT_RBUF_OUT_R
2n22n2
GND1GND1GND1GND1 GND1GND1
VDDD3VDDD3
BUF_OUT_LBUF_OUT_L
C739C739
C721C721
2n22n2
100n100n
V3V3
BUF_VPOSBUF_VPOS
C725C725
GND1GND1
330p330p
C723C723
C724C724
2n22n2
3V33V3
120K120K
R718R718
120K120K
R717R717
GND1GND1
1V81V8
33K33K
4K74K7
4K74K7
R709R709
R710R710
R711R711
SLSL
FOFO
RARA
VSSD3VSSD3
MOTO2MOTO2
MOTO1MOTO1
BUF_GNDBUF_GND
BUF_IN_LBUF_IN_L
C713C713
A_GND2A_GND2 D_GNDD_GND
LKILLLKILL
1uF/10V1uF/10V
CDT_RDYCDT_RDY
RKILLRKILL
CDT_DATACDT_DATA
+6V+6V
10K10K
R714R714
R713R713
OPENOPEN
CLOSECLOSE
SW702SW702
CAR_POSCAR_POS
GNDGND
OPENOPEN
CLOSECLOSE
SW701SW701
CDM_POSCDM_POS
GNDGND
OPENOPEN
CLOSECLOSE
SW703SW703
TRAY_SWTRAY_SW
GNDGND
TRAY_SWTRAY_SW
C718C718
100n100n
D_GNDD_GND
6060
SBSYSBSY
VDDD2VDDD2
DOBMDOBM
VSSD2VSSD2
5959
SFSYSFSY
5858
SUBSUB
5757
RCKRCK
SLIDSLID
RESETRESET
CLK12CLK12
CLK16CLK16
SCLKSCLK
WCLKWCLK
DATADATA
SCLISCLI
WCLIWCLI
VDDD1VDDD1
RABRAB
SCLSCL
SDASDA
SDDSDD
40403939383837373636353534343333323231313030292928282727262625252424232322222121
5656
5555
5454
5353
5252
RESETRESET RESETRESET
5151
5050
4949
4848
4747
4646
4545
EFEF
4444
4343
4242
4141
STATUSSTATUS
VSSD1VSSD1
CFLAGCFLAG
CDT_CLKCDT_CLK
R703R703
SCLSCL
SDASDA
DGNDDGND
3V33V3
R702R702
C715C715
CN705CN705
GNDGND GNDGND
4K74K7
4K74K7
R706R706
R705R705
10R10R
C733C733
4,7uF/100V4,7uF/100V
++
++
100n100n
CN704CN704
33
22
11
44
3V33V3
4K74K7
OPC.OPC.
OPC.OPC.
R708R708
R707R707
D701D701
1N41481N4148
10n10n
C716C716
A_GND2A_GND2
C732C732
4,7uF/100V4,7uF/100V
A_GND2A_GND2
10n10n
C717C717
3V33V3
10K10K
GNDGND
10K10K
R733R733
+6V+6V
++
C748C748
C745C745
47uF/25V47uF/25V
A_GND2A_GND2
A_GND2A_GND2 GNDGND
100n100n
J703J703
OPC.OPC.
CN701CN701
+6V+6V
GNDGND
L_OUTL_OUT
A_GND2A_GND2
R_OUTR_OUT
STATUSSTATUS
SCLSCL
SDASDA
CAR-CAR-
CAR+CAR+
CAR_POSCAR_POS
CDM_POSCDM_POS
GND1GND1A_GND1A_GND1
DGNDDGNDGND1GND1
11
22
33
44
55
66
77
88
99
1010
1111
1212
1313
3V33V3
10R10R
R738R738
100n100n
C750C750
++
C730C730
3n33n3
C708C708
100uF/10V100uF/10V
++
3n33n3
C709C709
C731C731
3n33n3
C710C710
100uF/10V100uF/10V
A_GND2A_GND2
3n33n3
C711C711
DES.DES.
PROJ.PROJ.
VERIF.VERIF.
P.A.P.A.ALT.ALT.
NOMENOME
THIAGOTHIAGO
THIAGOTHIAGO
ROBERTOROBERTO
TITULO:TITULO:
TITLE:TITLE:
01/04/0401/04/04
01/04/0401/04/04
01/04/0401/04/04
ESQUEMA ELETRICO PCI CD 3 discosESQUEMA ELETRICO PCI CD 3 discos
COMPACT DISC 3 RECORD ELECTRIC SCHEMATICCOMPACT DISC 3 RECORD ELECTRIC SCHEMATIC
MAT.MAT.DATADATA
ACAB.ACAB.
ESC.ESC.
MOD.MOD.
DISCRIMINACAODISCRIMINACAO DATADATAVISTOVISTO
PHONIC CD 3 discosPHONIC CD 3 discos
GND1GND1GNDGND
COD.COD.
PROJECAOPROJECAO
N.N.TOL.TOL.TOL.TOL.
A2A2
1.00.52284.021.00.52284.02
mmmmememdimensoesdimensoes
Page 10
E-621MLE-621ML
S-201S-201
REC/PLAYREC/PLAY
HEADHEAD
Vrec=0,00035VVrec=0,00035V
Vbias=0,004VVbias=0,004V
Irec=35uAIrec=35uA
Ibias=400uAIbias=400uA
TP1TP1
22
11
33
55
TP2TP2
R915R915
10R10R
R916R916
10R10R
TP3TP3
TP4TP4
BC856BBC856B
Q901Q901
Q902Q902
1/2VCC1/2VCC
4,5V4,5V
BC856BBC856B
BC856BBC856B
Q907Q907
R917R917
470R470R
R918R918
470R470R
R919R919
10K10K
+9,3V+9,3V
R921R921
R920R920
10K10K
R922R922
10K10K
R946R946
10K10K
47K47K
BC856BBC856B
Q909Q909
Q910Q910
BC856BBC856B
C921C921
++
1uF/100V1uF/100V
C919C919
+9V+9V
C909C909
1n81n8
R925R925
R924R924
1n81n8
C908C908
C911C911
8n28n2
18K18K
330K330K
1K21K2
R929R929
R927R927
1/2VCC1/2VCC
390K390K
R931R931
(+)(+)
22n22n
1/2VCC1/2VCC
1/2VCC1/2VCC
330K330K
R926R926
8n28n2
C910C910
C917C917
1K21K2
18K18K
R928R928
R930R930
IC902IC902
390K390K
45584558
++
--
39R39R
R941R941
39R39R
R933R933
--
++
47R47R
R932R932
220uF/10V220uF/10V
R935R935
55667788
55667788
(-)(-)
44332211
44332211
220uF/10V220uF/10V
47R47R
R945R945
OPC.OPC.
1/2VCC1/2VCC
R944R944
OPC.OPC.
C918C918
++ ++
1/2VCC1/2VCC1/2VCC1/2VCC 1/2VCC1/2VCC
C913C913
OPC.OPC.
OPC.OPC.
C912C912
1/2VCC1/2VCC 1/2VCC1/2VCC
1K1K
R959R959
1n1n
100K100K
R961R961
R962R962
R960R960
C915C915
C916C916
100K100K
1K1K
1n1n
+9V+9V
L_OUTL_OUT
R_OUTR_OUT
L_RECL_REC
R_RECR_REC
REC_SWREC_SW
M_SWM_SW
+9V+9V
GNDGND
CN901CN901
11
22
33
44
55
66
77
88
ERASEERASE
HEADHEAD
22
11
Verase=0,035VVerase=0,035V
Ierase=35mAIerase=35mA
GND DOGND DO
R940R940
1R1R
PCIPCI
R954R954
C932C932
opc.opc.
C933C933
1/2VCC1/2VCC
2K22K233K33K
1/2VCC1/2VCC
0,7V0,7V
47K47K
3n33n3
BC846BBC846B
BC846BBC846B
Q911Q911
BC846BBC846B
T903T903
f=59.068Hzf=59.068Hz
OSC.BIASOSC.BIAS
11
plasticoplastico
Q915Q915
10K10K
R975R975
10K10K
R974R974
Q916Q916
0V0V
R923R923
10K10K
1/2VCC1/2VCC
++
C934C934
C920C920
9,4V9,4V
R943R943
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
+9V+9V
++
R942R942
47K47K
Q905Q905
BC817/25BC817/25
R987R987
1K1K
R939R939
1K1K
6n86n8
R989R989
1K21K2
R991R991
56K56K
C928C928
82p82p
R993R993
15K15K
R992R992
15K15K
C929C929
82p82p
R990R990
BC846BBC846B
Q906Q906
C926C926
C945C945
22n22n
55667788
55667788
44332211
44332211
2n72n7
C942C942
2n72n7
C943C943
2n72n7
C944C944
R983R983
1K1K
1K1K
++
--
R934R934
R979R979R980R980
BC846BBC846B
Q904Q904
Q903Q903
BC846BBC846B
2K22K26K86K8
--
++
45584558
18K18K
R936R936
18K18K
R937R937
6K86K8
R981R981
(-)(-)
C941C941
10n10n
4433
5522
66
++
opc.opc.
C940C940
C924C924
9,3V9,3V
12n12n
100n100n
+9V+9V
8R28R2
680R680R
R985R985
(+)(+)
IC903IC903
220uF/10V220uF/10V
1uF/100V1uF/100V
C951C951
opc.opc.
22K22K
++
opcopc
0V-ON0V-ON
0V-REC0V-REC
5V-PLAY5V-PLAY
P/R_SWP/R_SW
11 1122 22
CN902CN902
REC_SWREC_SW M_SWM_SW
5V-OFF5V-OFF
M_RPM_RP
CN903CN903
0V0V
Q908Q908
BC846BBC846B
TP6TP6TP5TP5
C930C930
470p470p
C931C931
470p470p
+9V+9V
R967R967R966R966
470R470R470R470R
R968R968
R978R978
68K68K
R977R977
68K68K
C922C922
C923C923
R973R973R969R969
22K22K
R971R971
2n22n2
2n22n2
22K22K
R970R970
R972R972
PCI DECKPCI DECK
33K33K
2K22K2
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
12n12n
C925C925
R988R988
1K21K2
C927C927
6n86n8
680R680R
R984R984
1K1K
R986R986
R982R982
2K22K2
R976R976
56K56K
THIAGOTHIAGO
C908.909 ERA 2n7 / C922.923 ERA 12n / ELIMINAR C912.913 68n E R944.945 68RC908.909 ERA 2n7 / C922.923 ERA 12n / ELIMINAR C912.913 68n E R944.945 68RAA
P.A.P.A.ALT.ALT.
TITULO:TITULO:
ESQUEMA ELETRICO PCI DECK SIMPLESESQUEMA ELETRICO PCI DECK SIMPLES
DISCRIMINACAODISCRIMINACAO
PROJECAOPROJECAO
17/09/0217/09/02C908.909 ERA 1nC908.909 ERA 1nBB
21/05/0221/05/02THIAGOTHIAGO
DATADATAVISTOVISTO
REFERENTE AO CJT. DECK MONT (1.02.52164.02)REFERENTE AO CJT. DECK MONT (1.02.52164.02)
mmmmememdimensoesdimensoes
DES.DES.
PROJ.PROJ.
APRO.APRO.
NOMENOME
THIAGOTHIAGO
TITLE:TITLE:
SIMPLE DECK PCB ELECTRIC SCHEMATICSIMPLE DECK PCB ELECTRIC SCHEMATIC
RELATIVE FOR THE CONJUNCT DECK MOUNTED (1.02.52164.02)RELATIVE FOR THE CONJUNCT DECK MOUNTED (1.02.52164.02)
MAT.MAT.DATADATA
01/08/0101/08/01ROBERTOROBERTO
ACAB.ACAB.
ESC.ESC.
01/08/0101/08/01
MOD.MOD.
DECK simplesDECK simples
COD.COD.
N.N.TOL.TOL.TOL.TOL.
A3A3
1.00.52164.161.00.52164.16
Page 11
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
ESPECIFICAÇÃO TÉCNICA
MODELO: A-320
MODEL :
CÓDIGO: 1.00.52338.04
CODE:
CONDIÇÕES PARA MEDIÇÃO:
MEASUREMENT CONDITION:
1- ALIMENTAÇÃO : 127 VAC / 60Hz
POWER SOURCE
2- PONTOS DE MEDIÇÃO :
MEASUREMENT POINTS
AMPLIFICADOR : SAÍDA 8 OHMS
FULL RANGE-AMP : OUT 8 OHMS
REV: A DATA/
EMITIDO POR: DAVID
EMITTED BY:
APROVADO POR: ROBERTO
APPROVED BY:
DATE : 22/10/2004
3- NÍVEL PARA MEDIÇÃO :
MEASUREMENT LEVEL:
SAÍDA AJUSTADA PARA APROXIMADAMENTE 1W
SET OUTPUT TO ABOUT 1W
4- TODOS OS AJUSTES DE EQUALIZAÇÃO EM MODO FLAT
ALL ADJUST IN FLAT MODE
REV: OBSERVAÇÃO/REMARK:: DATA/DATE:
A
Aprovação de Manaus 22/10/04
CpQD
Page 12
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
AMPLIFICADOR
AMPLIFIER
ENTRADA: via CD ALIMENTAÇÃO : 127V
INPUT: via CD POWER SOURCE: 127VAC
SAÍDA: CARGAS 8 OHMS
OUTPUT: OUT LOAD 8 OHMS
N°
TEM
Í
ITEM
POTÊNCIA DE SAÍDA
1
POWER OUTPUT
DISTORÇÃO
2
DISTORTION
DIFERENÇA ENTRE
3
CANAIS
CHANNEL DIFFERENCE
POTÊNCIA DE
CONSUMO
POWER CONSUMER
CONDIÇÕES
CONDITIONS
1KHz 0dB – medido em 127Vac
10% THD – measured in 127Vac
1KHz 0dB, CARGA 1W
1W OUTPUT LOAD , FLAT
1KHz 0dB, CARGA 1W
1W OUTPUT LOAD , FLAT
MODO STBY
STBY MODE
MEIO VOLUME - 1KHz 0dB
HALF VOLUM
VOLUME MÁXIMO - 1KHz 0dB
MINIMUM VOLUM
VALOR TÍPICO
TYPI CAL VALUE
AC
10+10 W
8,9+8,9 V
1,5% 3%
0dB
6W 8W
35W 45 W3
50W 60W
VALOR LIMITE
LIMIT VALUE
9,5+9,5 W
8,7+8,7 V
2dB
CpQD
Page 13
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
RÁDIO FM
FM RADIO
NÍVEL PADRÃO DE ENTRADA
STANDARD INPUT LEVEL
60dB
N°
N
ITEM
ITEM
°
FAIXA DE SINTONIA
1
TUNNING RANGER
SENSIBILIDADE
USUAL 30dB S/N
USABLE SENSITIVITY
REL. SINAL/RUÍDO
3
SIGNAL / NOISE
DISTORÇÃO
4
DISTORTION
MODULAÇÃO
MODULATION
MONO: 1kHz, DESVIO: 75kHz
MONO: 1KHz, DEVIATION: 75kHz
ESTÉREO: L + R, 37,5kHz
STEREO: L + R , 37,5kHz
PILOTO: 7,5kHz
PILOT : 7,5kHz
CONDIÇÕES
CONDITION
MÍNIMO
MINIMUM
MÁXIMO
MAXIMUM
ANTENA
ANTENNA
DUMMY DA VI
ACOPLAGEM DIRETA
DIRECT COUPLING
PONTO DE MEDIÇÃO:
SAÍDA DO RÁDIO
MEASUREMENT POINTS: OUTPUT
RADIO
VALOR TÍPICO
TYPICAL VALUE
87,5 MHz 87,5 MHz
108,1 MHz 108,1 MHz
IMPEDÂNCIA DE
ENTRADA
IMPEDANCE OF IMPUT
75 OHMS
VALOR LIMITE
LIMIT VALUE
90,1MHz 9 dB 12 dB
98,1MHz 9 dB 12 dB2
106,1MHz 9 dB 12 dB
98,1MHz
98,1MHz
Mono 0,5 1%
50 dB 40 dB
Estéreo 3,5% 5%
REJEIÇÃO DE
5
IMAGEM
IMAGE REJECTION
RESPOSTA DE
FREQUÊNCIA
6
FREQUENCY RESPONSE
PARADA DO AUTO
SCAM
AUTO-STOP LEVEL
SEPARAÇÃO DE
CANAIS
8
CHANNEL SEPARATION
SENSIBILIDADE DO
9
INDICADOR ESTÉREO
STEREO INDICATION
SENSITIVITY
REJEIÇÃO DE FI
10
FI REJECTION
ATUAÇÃO DO AFC
11
AFC ATUACTION
106.1MHz 45 dB 25 dB
98.1MHz
100 Hz
± 1 dB ±5 dB
1kHz
6 KHz -8 dB -10 dB
90.1MHz 15 dB 21 dB
98,1MHz 15 dB 21 dB7
106.1MHz 15 dB 21 dB
98,1MHz
98,1MHz
1KHz
ON
OFF
25 dB 20 dB
10 dB 15 dB
10 dB 15 dB
90,1MHz 50 dB 70 dB
-3dB UP 300 kHz 450 kHz
90,MHz
-3dB DOWN 300 kHz 450 kHz
CpQD
Page 14
ESPECIFICAÇÃOTÉCNICA
TECHNICAL SPECIFICATION
RÁDIO AM
AM RADIO
NÍVEL PADRÃO DE ENTRADA: 74dBµV, MODULAÇÃO 30% 400Hz, ANTENA LOOP
STANDARD INPUT LEVEL : 74dBµV, MODULATION: 30% 400Hz, ANTENNA LOOP
°
N
N
ITEM
°
ITEM
FAIXA DE SINTONIA
1
TUNNING RANGER
SENSIBILIDADE
USUAL 20dB S/N
USABLE SENSITIVITY
2
REL. SINAL/RUÍDO
3
SIGNAL / NOISE
REJEIÇÃO DE
4
IMAGEM
IMAGE REJECTION
AGC
5
AGC
DISTORÇÃO
6
DISTORTION
RESPOSTA DE
FREQUÊNCIA
7
FREQUENCY RESPONSE
PARADA DO AUTO
SCAN
AUTO SCAN STOP LEVEL
CONDIÇÕES
CONDITION
MÍNIMO
MINIMUM
MAXIMO
MAXIMUM
610kHz
1000kHz
1400kHz
1000Hz
1400kHz 30 dB
1000kHz 60 dB
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
520 kHz 520 kHz
1650 kHz 1650 kHz
65 dB 72 dB
65 dB 72 dB
65 dB 72 dB
36 dB 28 dB
≥25 dB
≥50 dB
1000kHz 0,8% <3%
1000kHz
100Hz
± 3 dB ±5 dB
400Hz
3kHz -1 dB -5 dB
600kHz 70 dB 80 dB
1000kHz 70 dB 80 dB8
REJEIÇÃO DE FI
9
IF REJECTION
DECK REPRODUÇÃO
REPRODUCTION DECK
°
N
ITEM
N
°
ITEM
1 WOW & FLUTER MTT 111
RESPOSTA EM
2
FREQUENCIA
FREQUENCY RESPONSE
SEPARAÇÃO DE
3
CANAIS
CHANNEL SEPARATION
RUÍDO TAPE PLAY
4
TAPE NOISE PLAY
CONDIÇÕES
CONDITION
MTT 117
MTT 117
( 1KHz = 0dB )
MTT 141 30 dB 20 dB
VOLUME MÍNIMO
MINIMUM VOLUM
VOLUME MÁXIMO
MAXIMUM VOLUM
1400kHz 70 dB 80 dB
600kHz
VALOR TÍPICO
TYPICAL VALUE
>40dB >30dB
VALOR LIMITE
LIMIT VALUE
W&F 0,1% 0,3%
FREQ. 3 kHz
125Hz
6,3KHz
± 1 dB ± 3 dB
± 1 dB ± 3 dB
3 kHz ± 3%
5 mV 10 mV
50 mV 100 mV
CpQD
Page 15
ESPECIFICAÇÃOTÉCNICA
RELAÇÃO SINAL
5
RUÍDO
SIGNAL NOISE RELATION
DISTORÇÃO
6
DISTORTION
DIFERENÇA ENTRE
7
TAPES
LEVEL DIFFERENCE TAPES
TECHNICAL SPECIFICATION
MTT 118 ( PLAY/STOP ) 30 dB 25 dB
MTT 118 1% 3 %
MTT 118 0,5dB 2dB
DECK GRAVAÇÃO
WRITING DECK
N
N
°
CD
CD
N
N
°
°
ITEM
ITEM
RELAÇÃO SINAL
1
RUÍDO
SIGNAL NOISE RELATION
RESPOSTA EM
2
FREQUENCIA
FREQUENCY RESPONSE
SEPARAÇÃO DE
3
CANAIS L/R
CHANNEL SEPARATION
DISTORÇÃO
4
DISTORTION
NÍVEL DE SAÍDA
5
REC/PLAY
OUTPUT REC/PLAY LEVEL
NÍVEL DE
6
APAGAMENTO
ERASE LEVEL
°
ITEM
ITEM
RELAÇÃO SINAL
1
RUÍDO
SIGNAL NOISE RELATION
RESPOSTA EM
2
FREQUENCIA
FREQUENCY RESPONSE
SEPARAÇÃO DE
3
CANAIS L/R
CHANNEL SEPARATION
RUÍDO TAPE
4
REC/PLAY
TAPE NOISE REC/PLAY
DISTORÇÃO
5
DISTORTION
CONDIÇÕES
CONDITION
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
1kHz -10dB via CD 30 dB 25 dB
( 1KHz = 0dB )
125Hz
6,3KHz
±2 dB ±5 dB
±2 dB ±5 dB
1KHz - L/R 30 dB 25 dB
MTT 118 1,5 % 3 %
MTT 118 1dB 3dB
MTT 118 30dB 25dB
CONDIÇÕES
CONDITION
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
TNO 24 CD Yeds 18 60 dB 50 dB
TNO 04
TNO 09
( 1KHz = 0dB )
TNO 33/34 - CD Yeds 18
1KHz - L/R
VOLUME MÍNIMO
MINIMUM VOLUM
VOLUME MÁXIMO
MAXIMUM VOLUM
125Hz
6,3KHz
± 0,5 dB ± 3 dB
± 0,5 dB ± 3 dB
45 dB 40 dB
1 mV 10 mV
10 mV 50 mV
TNO 24 - CD Yeds 18 1 % 2 %
EQUALIZADOR
EQUALIZATOR
°
N
ITEM
N
°
ITEM
CONDIÇÕES
CONDITION
1 HI CUT ON VOL.10 – 10KHz -12dB
VALOR TÍPICO
TYPICAL VALUE
VALOR LIMITE
LIMIT VALUE
± 2 dB
CpQD
Page 16
ROTEIRO DE CALIBRAÇÃO
ALIGMENT CALIBRATION
ROTEIRO DE CALIBRAÇÃO
EMITIDO POR: David
EMITTED BY:
ALIGMENT CALIBRATION
MODELO: A-320
MODEL:
CÓDIGO: 1.00.52338.03
CODE:
REV.
PA
DESCRIÇÃO
APROVADO POR: Roberto
APPROVED BY:
DATA/ DATE : 20/08/2004
DATA
OBSERVAÇÕES / NOTAS
OBSERVATIONS / NOTES
- Rádio Front End Box.
CpQD
Page 17
ROTEIRO DE CALIBRAÇÃO
ALIGMENT CALIBRATION
Obs.: Este roteiro tem caráter orientativo, podendo alguns itens sofrer adaptações pela Enga
de Fábrica para melhor adequar ao processo produtivo.
FAIXA FM
Sintonize em 87,5 MHz, e verifique se há 1,4V (aproximadamente) na tensão de sintonia
(terminal 28 do IC101 com resistor de 10K em série com o voltímetro).
Sintonize em 108,1 MHz
, e verifique se a tensão de sintonia é de aproximadamente 7,0 V.
FI-FM
Conecte um gerador de varredura de FM na entrada de FM.
Sintonize o rádio em 98,1 MHz.
Verifique o formato da curva “S”, no pino 23 do IC.101, se necessário aprimorar a curva S, ajustar
a bobina com núcleo parafusado (bobina FI) do front end .
FAIXA AM
Sintonize em 520 kHz, ajuste a bobina OSC-AM (T.101) para obter ~ 1,2 V na tensão de
sintonia.
Sintonize em 1650 kHz
, e verifique se a tensão de sintonia seja ~ 6,5 V.
Os valores de tensão podem ser ligeiramente mudados para facilitar a produção.
FI-AM
Ajuste um gerador de AM para 1000 kHz com 30% de modulação em 400 Hz.
Sintonize o rádio em 1000 kHz
.
Deve ser usado um sinal de RF muito baixo.
Caso tenha ruídos indesejáveis, esta freqüência pode ser deslocada para + ou para -, junto com
a freqüência do gerador.
Ajuste a bobina de FI-AM (T.104) para obter o máximo sinal detectado.
TRACKING-AM
Irradie uma varredura de AM para a antena de ferrite .
Sintonize em 600 kHz
Sintonize em 1400 kHz
e ajuste a bobina ANT-AM (T.102) para obter máximo sinal na saída.
e ajuste VC.101 para obter máximo sinal na saída.
Refaça o ajuste três vezes para obter o melhor ponto de ajuste .
CpQD
Page 18
ROTEIRO DE CALIBRAÇÃO
(
)
O gerador do sinal de FM deve ser conectado na entrada de FM através do DUMMY DA-V.
O gerador do sinal de AM deve ser irradiado por uma antena LOOP e captado pela própria
antena de ferrite do aparelho.
Tanto na calibração de FM como de AM a ferramenta utilizada para calibrar as bobinas deve ser
de material não magnético.
ALIGMENT CALIBRATION
OBSERVAÇÕES
4510
60
50 : 75
OSC. BIAS
Oscilador BIAS:
1- Conecte um VTVM nos pontos TP5 e TP6.
2- A saída do VTVM deve ser ligada a um freqüêncímetro.
3- Coloque uma fita com a trava de gravação intacta.
4- Selecione a função AUX sem sinal na entrada.
5- Ajuste T903 para obter 59.068 Hz +/- 20Hz no freqüêncímetro.
6- Verifique se no VTVM está um sinal de 0,035V.
Azimuth:
1- Conecte nas saídas R e L do circuito deck nos canais 1 e 2 do VTVM.
2-A saída do VTVM deve ser ligada a um osciloscópio.
3- Coloque uma fita padrão de ajuste de azimuth (MTT-114).
4- Ajuste o parafuso esquerdo da cabeça rec-play (para deck simples ou deck1, quando o
conjunto for deck duplo/lógico), de modo que o sinal dos canais R e L fiquem em fase no
osciloscópio e em maior amplitude possível.
5- Repetir o item 4 para a cabeça play.
CpQD
Page 19
Page 20
ENCODERENCODER
VOLUMEVOLUME
E801E801
+5V+5V
++
C810C810
10uF/50V10uF/50V
BC856BBC856B BC856BBC856B BC856BBC856BBC856BBC856B
Q802Q802 Q803Q803 Q804Q804Q801Q801
DISPLAYDISPLAYDISPLAYDISPLAY
+5V+5V
D803D803
D804D804
AZULAZUL
OPC.OPC.
OPC.OPC.
180R180R
R854R854
R853R853
+5V+5V
R847R847
D801D801
D802D802
AZULAZUL
OPC.OPC.
180R180R
R851R851
OPC.OPC.
R852R852
R850R850
10K10K
10K10K
R849R849
R848R848
100R/1/2W100R/1/2W
100R/1/2W100R/1/2W
1K1K
R801R801
1K1K
R802R802
1K1K
R803R803
1K1K
R804R804
BC856BBC856B
Q805Q805
1K1K
AA
44
88
66
22
11
FF
EE
DD
BB
L1L1
GG
CC
L2L2
DPDP DPDP DPDP
1616 1313 33 55 1111 1515 771414
DS801DS801
R805R805
DIGIT 4DIGIT 4DIGIT 3DIGIT 3DIGIT 2DIGIT 2DIGIT 1DIGIT 1
L3L3
DPDP
1 - DIGIT 11 - DIGIT 1
2 - DIGIT 22 - DIGIT 2
3 - D3 - D
4 - L1,L2,L34 - L1,L2,L3
5 - E5 - E
6 - DIGIT 36 - DIGIT 3
7 - DP7 - DP
8 - DIGIT 48 - DIGIT 4
9 - NO CONNECTION9 - NO CONNECTION
10- NO PIN10- NO PIN
11- F11- F
12- NO PIN12- NO PIN
13- C,L313- C,L3
14- A,L114- A,L1
15- G15- G
16- B,L216- B,L2
Q814Q814
BC846BBC846B
LED_DISPLED_DISP
ENC_A2ENC_A2
ENC_A1ENC_A1
GNDGND
+5V+5V
CPCP CPCP
DD
STBSTB STBSTB
TECL_BTECL_B
TECL_ATECL_A
IRIR
Q815Q815
BC846BBC846B
10n10n
10n10n
C812C812
C811C811
88 77 66 55 44 33 22 11
0101
0202
OPC.OPC.
OPC.OPC.
C808C808
OPC.OPC.
C807C807
C809C809
0303
VSSVSS
IC802IC802
QSQS
QSQS
(SMD)(SMD)40944094
0606
0707
DD
CPCP
0000
0505
STBSTB
E0E0
0404
VDDVDD
161615151414131312121111101099
C802C802
22n22n
0R0R
R814R814
BC846BBC846B
Q806Q806
R806R806
DD
0R0R
R815R815
BC846BBC846B
Q807Q807
10K10K
R807R807
+5V+5V+5V+5V
C801C801
22n22n
0R0R
R816R816
BC846BBC846B
Q808Q808
10K10K
R808R808
DD
CPCP
STBSTB
IC801IC801
E0E0
0404
VDDVDD
1616 1515 1414 1313 1212 1111 1010 99
0R0R
R817R817
BC846BBC846B
Q809Q809
10K10K
0000
0101
(SMD)(SMD)40944094
0505
0606
10K10K
R809R809
0202
0303
0707
QSQS
0R0R
R818R818
BC846BBC846B
Q810Q810
R810R810
8877665544332211
VSSVSS
QSQS
0R0R
R819R819
BC846BBC846B
Q811Q811
10K10K
R811R811
0R0R
R820R820
BC846BBC846B
Q812Q812
10K10K
R812R812
0R0R
R821R821
BC846BBC846B
Q813Q813
10K10K
10K10K
R813R813
SENSORSENSOR
REMOTOREMOTO
IR801IR801
332211
RPM6936/V4RPM6936/V4
R842R842
++
C806C806
47uF/25V47uF/25V
33R33R
+5V+5V
2K22K2
R831R831
SW808SW808
SKIP_RWSKIP_RW
1K1K 2K22K2
R841R841 R839R839
2K22K2
R840R840
NCNC
SW816SW816
2K22K2
R830R830
DISC3DISC3
SW807SW807
SW815SW815
OP/CLOSEOP/CLOSE
2K22K2 2K22K2
R829R829 R828R828
DISC2DISC2
SW806SW806
POWERPOWER
SW814SW814
+5V+5V
2K22K2
R827R827
DISC1DISC1
SW805SW805
FMFM
SW813SW813
2K22K2
R837R837
PL/PSPL/PS
SW804SW804
2K22K2
R836R836
AMAM
SW812SW812
2K22K2
R826R826
STOPSTOP
SW803SW803
2K22K2 2K22K2
R835R835 R834R834
TAPETAPE
SW811SW811
2K22K21K1K
R825R825R832R832
SW802SW802
HI-CUTHI-CUT
CDCD
SW810SW810
1K1K
R824R824
SW801SW801
SURROUNDSURROUND
1n1n
C804C804
1K1K2K22K2
R833R833R838R838
SW809SW809
SKIP_FFSKIP_FF
1n1n
C805C805
100K100K100K100K
R844R844R845R845
BB ACRESCENTAR MODELO MD-K300C/D/E/F / A-350ACRESCENTAR MODELO MD-K300C/D/E/F / A-350 20/01/0420/01/04
ACRESCENTAR MODELO MD-K300BACRESCENTAR MODELO MD-K300BAA
DISCRIMINACAODISCRIMINACAO DATADATAVISTOVISTO
ESQUEMA ELETRICO PCI FRONTAL ESQUEMA ELETRICO PCI FRONTAL
FRONTAL PCB ELECTRIC SCHEMATICFRONTAL PCB ELECTRIC SCHEMATIC
N.N.TOL.TOL.TOL.TOL.
MD-K300A/B/C/D/E/F / A-350MD-K300A/B/C/D/E/F / A-350
COD.COD.
DES.DES.
PROJ.PROJ.
APRO.APRO.
P.A.P.A.ALT.ALT.
NOMENOME
THIAGOTHIAGO
THIAGOTHIAGO
ROBERTOROBERTO
TITULO:TITULO:
TITLE:TITLE:
24/02/0324/02/03
24/02/0324/02/03
08/04/0308/04/03
MAT.MAT.DATADATA
ACAB.ACAB.
ESC.ESC.
MOD.MOD.
THIAGOTHIAGO
PROJECAOPROJECAO
A2A2
1.00.52250.021.00.52250.02
08/05/0308/05/03THIAGOTHIAGO
mmmmememdimensoesdimensoes
Page 21
CN614CN614
CN701/CCN701/C
998877665544332211
CNTP9CNTP9
IRIR
ENC_A1ENC_A1
ENC_A2ENC_A2
TECL_BTECL_B
TECL_ATECL_A
+5V+5V
GNDGND
+5V+5V
R620R620
10R10R
SCLSCL
SDASDA
TP9TP9
CDRWCDRW
47p47p
47p47p
C618C618
C616C616
STATUSSTATUS
+5V+5V
+5V+5V+5V+5V
10K10K
R612R612
R622R622
++
C611C611
100n100n
C610C610
10uF/50V10uF/50V
10K10K
10K10K
R623R623
47p47p
47p47p
C637C637
C615C615
C614C614
CAR-CAR-
RST_CDRST_CD
47p47p
C632C632
+5V+5V
R619R619
CAR+CAR+
Y3Y3
C407C407
C408C408
5V-ON5V-ON
0V-OFF0V-OFF
Y1Y1
++
++
X0X0X1X1
C405C405
100p100p
C403C403
22p22p
C406C406
100p100p
C404C404
22p22p
220uF/25V220uF/25V
220uF/25V220uF/25V
X3X3
470R470R
R403R403
Q401Q401
BC856BBC856B
33K33K
R401R401
470R470R
R404R404
Q402Q402
BC856BBC856B
33K33K
R402R402
CONTROLCONTROL
UNITUNIT
R435R435
22K22K
VR401VR401
1K1K
R436R436
22K22K
AA
BB
VSSVSSVEEVEE
8877665544332211
Q405Q405
BC846BBC846B
47K47K
R433R433
2n72n7
C423C423
22
11
44
66
55
220R220R
IC201IC201
LA4282LA4282
100uF/25V100uF/25V
++
C211C211
**
C209C209
1111
1212
99
77
1010
8833
++
C212C212
10uF/50V10uF/50V
470uF/25V470uF/25V
C207C207
220n/63V220n/63V
2R22R2
R207R207
R208R208
2R22R2
220n/63V220n/63V
C208C208
++ ++
470uF/25V470uF/25V
++
2200uF/50V2200uF/50V
C213C213
R209R209R210R210
C210C210
D201D201
C214C214
D202D202
C215C215
D203D203
C216C216
D204D204
C217C217
R201R201
0R0R
R203R203
3K93K9
R451R451
R302R302
++
22K22K
R301R301
C301C301
3K93K9
R452R452
BC846BBC846B
R434R434
22uF/50V22uF/50V
Q406Q406
47K47K
C424C424
R202R202
0R0R
R204R204
+5V+5V
STBYSTBY
R422R422
R425R425
OPC.OPC.
22K22K
CD_RCD_R
100K100K
100K100K
CD_LCD_L
10uF/50V10uF/50V
R303R303
100K100K
BC846BBC846B
2n72n7
OPC.OPC.
0V-ON0V-ON
5V-OFF5V-OFF
R426R426
R427R427
++
C201C201
Q301Q301
++
C202C202
10uF/50V10uF/50V
R211R211
22K22K
100K100K
R428R428
100K100K
R421R421
C205C205
Q203Q203
R205R205
R206R206
R217R217
R218R218
10K10K
100uF/16V100uF/16V
330R330R
330R330R
C206C206
100uF/16V100uF/16V
10K10K
R219R219
++ ++
BC846BBC846B
R220R220
Q204Q204
10K10K
100p100p
C203C203
100p100p
R213R213
10K10K
R212R212
22K22K
47uF/25V47uF/25V
R215R215
+9VA+9VA
R432R432
R431R431
47K47K
Q202Q202
BC846BBC846B
R214R214
4K74K7
4K74K7
C204C204
R216R216
10K10K
47K47K
2,2uF/100V2,2uF/100V
2,2uF/100V2,2uF/100V
C426C426
++
C425C425
++
BC856BBC856B
Q201Q201
BC846BBC846B
100K100K
R304R304
100K100K
++
100K100K
C416C416
CDM_POSCDM_POS
CAR_POSCAR_POS
HI_CUTHI_CUT
C409C409
C411C411
10uF/50V10uF/50V
OSC1OSC1
PTD0/SSPTD0/SS
PTC6PTC6
PTC5PTC5
PTC4PTC4
PTC3PTC3
PTC2PTC2
PTC1PTC1
PTCOPTCO
D401D401
1N41481N4148
R413R413
470R470R
PWMPWM
OPC.OPC.
10uF/50V10uF/50V
R440R440
5K65K6
C418C418
R441R441
5K65K6
D402D402
R415R415
470R470R
HI_CUTHI_CUT
++ ++
++
10uF/50V10uF/50V
L_RECL_REC
R647R647
10K10K
R607R607
1K1K
R640R640
1K1K
R608R608
1K1K
R628R628
1K1K
1111
1010
99
88
77
66
55
44
33
22
11
TP5TP5
++
C604C604
47uF/25V47uF/25V
R611R611
1K1K
R624R624
1K1K
R621R621
10R10R
R629R629
1K1K
R649R649
1K1K
R648R648
1K1K
R606R606
1K1K
R605R605
1K1K
R604R604
1K1K
R603R603
1K1K
+5V+5V
TP1TP1 TP10TP10
GNDGND
IRQIRQ
RSTRST
44444343424241414040393938383737363635353434
HI_CUTHI_CUT
MUTEMUTE
SURROUNDSURROUND SURROUNDSURROUND
STBYSTBY
RECREC
47p47p
47p47p
47p47p
C623C623
C617C617
R601R601
10M10M
C636C636
C613C613
47p47p
47p47p
C619C619
C624C624
X601X601
32,768KHz32,768KHz
C601C601
33p33p
C612C612
TP6TP6
REC_SWREC_SW
M_RPM_RP
M_PM_P
PB_1/2PB_1/2
BB
AA
CECE
DIDI
CLCL
DODO
47p47p
C620C620
R602R602
10K10K
10n10n
C609C609
MOTORMOTOR
RADIO_RRADIO_R
RADIO_LRADIO_L
C602C602
33p33p
33n33n
C605C605
+5V+5V
DODO
CLCL
DIDI
CECE
47p47p
47p47p
C640C640
TP3TP3
TP2TP2
TP8TP8
AA
47p47p
47p47p
47p47p
47p47p
47p47p
C639C639
2,2uF/100V2,2uF/100V
2,2uF/100V2,2uF/100V
TP7TP7
C626C626
C625C625
++
Q602Q602
C606C606
BC846BBC846B
1uF/100V1uF/100V
C428C428
C429C429
47p47p
C627C627
R613R613
10K10K
R614R614
10K10K
Q601Q601
BC846BBC846B
47p47p
C628C628
C622C622
+5V+5V
10K10K
R615R615
D601D601
BZX79C3V3BZX79C3V3
R617R617
10K10K
22K22K
R616R616
180R180R
R618R618
DODO
CECE
CLCL
DIDI
M_PM_PM_PM_P
PB_1/2PB_1/2PB_1/2PB_1/2
RECRECRECREC
M_RPM_RPM_RPM_RP
REC_SWREC_SWREC_SWREC_SW
R_OUTR_OUTR_OUTR_OUT
++
++
STBYSTBYSTBYSTBYSTBYSTBY
++
47uF/25V47uF/25V
C430C430
BB
RADIO_RRADIO_R
R414R414
0R0R
C415C415
+5V+5V
R631R631
1K1K
R625R625
1K1K
R626R626
10R10R
R634R634
1K1K
R609R609
0R0R
R635R635
1K1K
R627R627
10R10R
R633R633
1K1K
47p47p
47p47p
47p47p
C631C631
C630C630
CDM_POSCDM_POS
LED_DISPLED_DISPLED_DISPLED_DISP
STBSTB
++
C607C607
100n100n
10uF/50V10uF/50V
C608C608
2222 2121 2020 1919 1818 1717 1616 14141515 1313 1212
VddVdd
1K1K
47p47p
IC601IC601
R638R638
C635C635
VssVss
PTD2/MOSIPTD2/MOSI
PTD3/SPSCKPTD3/SPSCK
PTA7/KBO7PTA7/KBO7
VssaVssa
VddsVdds
1K1K
PTD1/MISOPTD1/MISO
PTE1/RxDPTE1/RxD
PTE0/TxDPTE0/TxD
OSC2OSC2
CBMXFCCBMXFC
330K330K
R639R639
TP4TP4
C603C603
100n100n
47p47p
2323
PTB0/AD0PTB0/AD0
PTD7/T2CH1PTD7/T2CH1
PTD6/T2CHOPTD6/T2CHO
PTD5/TACH1PTD5/TACH1
PTB1/AD1PTB1/AD1
PTB2/AD2PTB2/AD2
1K1K
R636R636
47p47p
C633C633
PTD4/T1CHOPTD4/T1CHO
MC68HC908GP32MC68HC908GP32
PTA6/KBO6PTA6/KBO6
PTA5/KBO5PTA5/KBO5
1K1K
R637R637
47p47p
C634C634
2424
PTB3/AD3PTB3/AD3
2525
PTB4/AD4PTB4/AD4
2626
PTB5/AD5PTB5/AD5
2727
PTB6/AD6PTB6/AD6
2828
PTB7/AD7PTB7/AD7
2929
3030
Vssad/Vref1Vssad/Vref1 PTA1/KBD1PTA1/KBD1
3131
3232
3333
PTA2/KBO2PTA2/KBO2
R632R632
DDDD
CPCPCPCP
47p47p
C629C629
PTA0/KBD0PTA0/KBD0Vddad/VrefhVddad/Vrefh
PTA3/KBO3PTA3/KBO3
PTA4/JBO5PTA4/JBO5
1K1K
22K22K
R643R643
R610R610
47p47p
C638C638
C621C621
10K10K
C412C412
+9V+9V
R439R439
BZX79C5V1BZX79C5V1
IC401IC401
C417C417
40524052
R409R409
4K74K7
+9V+9V
1K1K
R411R411
++
C413C413
47uF/25V47uF/25V
++
10uF/50V10uF/50V
C414C414
R410R410
4K74K7
+9VA+9VA
10n10n
VDDVDD
560R560R
100p100p
R405R405
15R15R
R406R406
15R15R
MUTEMUTE
R407R407
R408R408
Q403Q403
BC856BBC856B
33K33K
C410C410
100p100p
Q404Q404
BC856BBC856B
33K33K
1616 1515 1414 1313 1212 1010 991111
XX
X2X2
Y0Y0
YY
Y2Y2
* = fixado ao dissipador* = fixado ao dissipador
1K1K1K1K
1N40041N4004
10n/100V10n/100V
1N40041N4004
10n/100V10n/100V
1N40041N4004
10n/100V10n/100V
1N40041N4004
10n/100V10n/100V
R419R419
CN201CN201
(+L)(+L)(+R)(+R)
GNDGNDGNDGND
R417R417
8K28K2
R418R418
8K28K2
100K100K
100K100K
R420R420
A_GNDA_GND
11
22
33
CN402CN402
LL
GNDGND CDCD
RR
+9VA+9VA
MOTORMOTOR
10K10K
R444R444
Q408Q408
BC846BBC846B
1K51K5
R438R438
2,2uF/100V2,2uF/100V
2,2uF/100V2,2uF/100V
C422C422
++
++ ++++
C420C420
+5V+5V
GNDGND
PB_1/2PB_1/2
M_PM_P
M_RPM_RP
REC_SWREC_SW
RECREC
R_OUTR_OUT
L_OUTL_OUT
R_RECR_REC
L_RECL_REC
CN601CN601
R630R630
R642R642
R641R641
10K10K
10K10K
10K10K
DODO
10K10K
R113R113
CLCL
1818 1717 1616 1515 1414 1313 1212 1111 1010 99 88 77 66 55 44 33 22 11
DODO CLCL DIDI CECE VSSVSS R-OUTR-OUT L-OUTL-OUT DETDET
CECE
DIDI
RADIO_LRADIO_L
RADIO_RRADIO_R
++
47n47n
++
C124C124
C126C126
1uF/100V1uF/100V
22n22n
C128C128
22n22n
C129C129
C127C127
CF104CF104
CDA10.7-MG46CDA10.7-MG46
FMFM
++
0,47uF/100V0,47uF/100V
3K33K3
R110R110
P-COMPP-COMP P-DETP-DET IF INIF IN
C125C125
1uF/100V1uF/100V
LV23000MLV23000M
IC101IC101
++
SFE10.7MA5-ASFE10.7MA5-A
FMFM
CF103CF103
IF INIF IN
AMAM
SFU450BSFU450B
100uF/16V100uF/16V
CF102CF102 C123C123
Vcc1Vcc1 IF INIF IN
T104T104
FI_AMFI_AM
33
22
GND1GND1 MIXMIX
FMFM
C122C122
47n47n
REGREG RF INRF IN
AMAM
C121C121
++
22uF/50V22uF/50V
44
33
22
11
OPC.OPC.
C133C133
T102T102
AM_ANTAM_ANT
CN601CN601
1111
1010
99
88
77
66
55
44
33
22
11
44
66
AMAM
R442R442
3M33M3
R_RECR_REC
C402C402
++
C427C427
47uF/25V47uF/25V
10K10K
100n100n
R445R445
Q407Q407
BC846BBC846B
1K51K5
R437R437
2,2uF/100V2,2uF/100V
C419C419
R443R443
3M33M3
L_RECL_REC
L_OUTL_OUT
100n100n
C401C401
ALIMENTACAOALIMENTACAO
DO CDDO CD
IC502IC502
7805PL7805PL
2,2uF/100V2,2uF/100V
C421C421
PARA MD-K300"D,E"PARA MD-K300"D,E"
USAR KIA 7806USAR KIA 7806
OU 7805 + D510,511OU 7805 + D510,511
+12V+12V
ININ OUTOUT
JC56JC56
**
GNDGND
D510D510
D511D511
D517D517
1N41481N4148
1N41481N4148
C512C512
1N41481N4148
+5V+5V
GNDGND
+5VB+5VB
++
22n22n
100uF/16V100uF/16V
C513C513
CN507CN507
33
22
11
X-INX-IN X-OUTX-OUT VDDVDD
10p10p
C120C120
C132C132
BZX79C3V3BZX79C3V3
D105D105
+9VA+9VA
47n47n
X101X101
75KHz75KHz
C131C131
R112R112
680R680R
10K10K
R513R513
ININ
OUTOUT
DETDET
LOW CUTLOW CUT
AMAM AGCAGC PDPD A-INA-IN A-OUTA-OUT BO1BO1 BO2BO2
++
0R0R
R109R109
C115C115
390p390p
C117C117
100n100n
C116C116
R106R106
1K1K
R105R105
8K28K2
47n47n
C114C114
4K74K7
R108R108
22uF/50V22uF/50V
10K10K
R107R107
0,47uF/100V0,47uF/100V
C113C113
++
C112C112
47n47n
AM_OSCAM_OSC
66 33
44
MPXMPX
C118C118
++
4,7uF/100V4,7uF/100V
10p10p
C119C119
R111R111
++
330R330R
100uF/16V100uF/16V
Q101Q101
BC846BBC846B
47n47n
C130C130
D104D104
BZX79C5V6BZX79C5V6
T101T101
OSCOSC
OSCOSC
AMAM
FMFM Vcc2Vcc2
C111C111
47n47n
OSC_FMOSC_FM
C109C109
C104C104
C105C105
22p22p
R114R114
220R220R
39p39p
390p390p
470p470p
C108C108
L102L102
11
D103D103
C134C134
R102R102
RF OUTRF OUT
FMFM GND2GND2
SVC201-SPASVC201-SPA
33K33K
R104R104
47n47n
100K100K
RF INRF IN
FMFM
363635353434333332323131303029292828272726262525242423232222212120201919
CF101CF101
GFMB5GFMB5
C110C110
47n47n
10p10p
OPC.OPC.
C107C107
L101L101
RF_FMRF_FM
33K33K
R101R101
C102C102
47n47n
SVC383SVC383
D101D101
15p15p
C103C103
VC102VC102
C106C106
D102D102
+9VA+9VA
SVC201-SPASVC201-SPA
1n1n
33K33K
R103R103
VC101VC101
10p10p
OPC.OPC.
C101C101
10K10K
R115R115
R116R116
10K10K
1n1n
C136C136
C135C135
BC846BBC846B
1n1n
CN101CN101
Q102Q102
GNDGND
11
FMFM
22
47K47K
R958R958
GNDMGNDM GNDMGNDM
22 11
++ --
MMI-6S9LMMI-6S9L
MM
0V-OFF0V-OFF
5V-ON5V-ON
opc.opc.
R955R955
Q953Q953
BC846BBC846B
C950C950
4K74K7
++
CN906CN906
MOTORMOTOR
BC327/25BC327/25
D952D952
opc.opc.
R956R956
10K10K
Q952Q952
+12V+12V
R950R950
C952C952
GNDMGNDMGNDMGNDM
+5V+5V
++
+12V+12V
+9VA+9VA
Q505Q505
BC337/25BC337/25
D515D515
D516D516
1N41481N4148
1N41481N4148
C509C509
A_GNDA_GND
22n22n
10V10V
++
220uF/16V220uF/16V
C508C508
C507C507
220R220R
R507R507
BZX79C10VBZX79C10V
D506D506
10R10R
100uF/10V100uF/10V
++
47uF/25V47uF/25V
C511C511
22n22n
C510C510
**
13V13V
++
C506C506
220uF/25V220uF/25V
10K10K
++
47uF/25V47uF/25V
+5V -> Stby Off+5V -> Stby Off
0V -> Stby On0V -> Stby On
STBYSTBY
R504R504
D505D505
R506R506
10K10K
R505R505
Q501Q501
KSD-1408-YKSD-1408-Y
R503R503
BZX79C13VBZX79C13V
47K47K
Q504Q504
IC501IC501
7805PL7805PL
GNDGND
Q503Q503
BC856BBC856B
10K10K
BC846BBC846B
**
ININOUTOUT
++
C505C505
2200uF/25V2200uF/25V
R501R501
220R/1/2W220R/1/2W
D501D501
D502D502
D503D503
D504D504
1N40041N4004
C501C501
10n/100V10n/100V
1N40041N4004
C502C502
10n/100V10n/100V
1N40041N4004
C503C503
10n/100V10n/100V
1N40041N4004
C504C504
10n/100V10n/100V
GF504GF504
OPC.OPC.
OPC.OPC.
FS502FS502
GF503GF503
OPC.OPC.
TF501TF501
1212
1313
1010
1111
- ITEM DE SEGURANCA - ESTES COMPONENTES SO PODEM SER SUBSTITUIDOS POR - ITEM DE SEGURANCA - ESTES COMPONENTES SO PODEM SER SUBSTITUIDOS POR
ORIGINAIS DE FABRICAORIGINAIS DE FABRICA
BB 28/11/0328/11/03THIAGOTHIAGO
P.A.P.A.ALT.ALT.
NOMENOME
DES.DES.
THIAGOTHIAGO
ACRESCENTAR D510 e D511 1N4148 / JC56 JUMPER / SERIES D,E - A-350ACRESCENTAR D510 e D511 1N4148 / JC56 JUMPER / SERIES D,E - A-350
ELIMINAR R412 / ACRESCENTAR R451 e R452 3K9 - VR401 TRIMPOT 1K - SERIE C ELIMINAR R412 / ACRESCENTAR R451 e R452 3K9 - VR401 TRIMPOT 1K - SERIE C 30/09/0330/09/03THIAGOTHIAGOAA
DISCRIMINACAODISCRIMINACAO DATADATAVISTOVISTO
TITULO:TITULO:
TITULO:TITULO:
TITLE:TITLE:
ESQUEMA ELETRICO PCI LATERALESQUEMA ELETRICO PCI LATERAL
LATERAL PCB ELECTRIC SCHEMATICLATERAL PCB ELECTRIC SCHEMATIC
MAT.MAT.DATADATA
24/02/0324/02/03
ACAB.ACAB.
GARRAGARRA
100100
GF501GF501
1A/250V1A/250V
120120
2020
* = fixado ao dissipador* = fixado ao dissipador
SW501SW501
220V220V
GF502GF502
GARRAGARRA
FS501FS501
AC INAC IN
110V110V
PROJECAOPROJECAO
REDEREDE
11
22
mmmmememdimensoesdimensoes
PROJ.PROJ.
VERIF.VERIF.
THIAGOTHIAGO
ROBERTOROBERTO
30/09/0330/09/03
30/09/0330/09/03
ESC.ESC.
MOD.MOD.
MD-K300 "B,C,D,E" / A-350MD-K300 "B,C,D,E" / A-350
COD.COD.
N.N.TOL.TOL.TOL.TOL.
A1A1
1.00.52250.081.00.52250.08
Page 22
CARCAR
TRAYTRAY
MM
M702M702
MM
M701M701
VAI PARA PICK-UPVAI PARA PICK-UP
PARA USO DE CD TOPOPARA USO DE CD TOPO
USAR CN703 2 VIAS (1 e 2)USAR CN703 2 VIAS (1 e 2)
PARA USO CD 3 DISCOSPARA USO CD 3 DISCOS
USAR CN703 6 VIASUSAR CN703 6 VIAS
CN703CN703
CAR-CAR-
CAR+CAR+
TRAY-TRAY-
TRAY+TRAY+
TRAY_SWTRAY_SW
CN702CN702
CN702CN702
GNDGND
+6V+6V
IC702IC702
L701L701
220uH220uH
11
T-T-
F+F+
opc. nao montar para uso do CD TOPOopc. nao montar para uso do CD TOPO
+6V+6V
Q703Q703
BC337/25BC337/25
100R100R
R724R724
R719R719
1K1K
R720R720
1K1K
DGNDDGND
R731R731
RESETRESET
4K74K7
Q714Q714
BC856BBC856B
C726C726
22n22n
SW704SW704
Q713Q713
BC856BBC856B
OPENOPEN
M704M704
R721R721
R722R722
SP1SP1
MM
SP2SP2
RESETRESET
1K1K
1K1K
CLOSECLOSE
Q712Q712
BC807/25BC807/25
C729C729
R727R727
Q708Q708
BC817/25BC817/25
++
22uF/50V22uF/50V
1K51K5
R730R730
66
55
44
33
22
11
1616
1515
1414
1313
1212
1111
1010
99
88
77
66
55
44
33
22
11
F-F-
T-T-
T+T+
F+F+
MONMON
FF
BB
AA
DD
EE
A_GND1A_GND1 A_GND1A_GND1
C707C707
A_GND1A_GND1
100n100n
C744C744
D702D702
SK-107SK-107
100n100n
C706C706
Q711Q711
BC807/25BC807/25
100n100n
1K51K5
Q707Q707
BC817/25BC817/25
++ ++ ++
22uF/50V22uF/50V 22uF/50V22uF/50V 22uF/50V22uF/50V
C743C743 C742C742 C741C741
D703D703
SK-107SK-107
+6V+6V
1K51K5
R729R729
Q710Q710 Q709Q709
BC807/25BC807/25 BC807/25BC807/25
100n100n
C728C728
R726R726R728R728
1K51K51K51K5
R725R725
Q706Q706
BC817/25BC817/25
1K51K5
Q705Q705
BC817/25BC817/25
R723R723
4K74K7
C727C727
22n22n
++
--
CAR-CAR-
CAR+CAR+
3V33V3
3V33V3
0R0R
J2J2
J4J4
OPC.OPC.
J3J3
OPC.OPC.
0R0R
J1J1
R735R735
4K74K7
R734R734
4K74K7
10K10K
R732R732
HOME_SWHOME_SW
LDLDLDLD
3V33V3
10R10R
R737R737
++
100n100n
C747C747
C705C705
47uF/25V47uF/25V
A_GND1A_GND1A_GND1A_GND1
F-F-
T+T+
M703M703
TR2TR2
X701X701
8,4672MHz8,4672MHz
A_GND1A_GND1
TR1TR1
MM
--
++
470uF/10V470uF/10V
TRAY+TRAY+ TRAY+TRAY+
TRAY-TRAY- TRAY-TRAY-
3V33V3
C746C746
47uF/25V47uF/25V
A_GND1A_GND1
C701C701
R701R701
24K24K
C749C749
47n47n
A_GND1A_GND1
BB
AA
CCCC
DD
FF
EE
C702C702
C703C703C704C704
33p33p33p33p
C736C736
R736R736
22n22n
A_GND1A_GND1
++
47n47n
GND1GND1
++
22
22
33
33
44
44
55
55
66
66
77
77
2929
88
99
1010
1111
1212
1313
1414
1R1R
TZA1048TZA1048
VCCVCC
RADO-RADO-
FOCO+FOCO+
GNDGND
FOCO-FOCO-
RADO+RADO+
VCCVCC
VCCVCC
SLO+SLO+
SLO-SLO-
GNDGND
MOTO+MOTO+
MOTO-MOTO-
VCCVCC
11
22
33
44
55
66
77
88
99
1010
1111
1212
1313
1414
1515
1616
1717
1818
1919
2020
V3.30utV3.30ut
V3.3FBV3.3FB
V1.8OutV1.8Out
V1.8FBV1.8FB
EARTHEARTH
V1.65DutV1.65Dut
RESETRESET
CAR-CAR-
CAR+CAR+
8080 7979 7878 7777 7676 7575 7474 7373 7272 7171 7070 6969 6868 6767 6666 6565 6464 6363 6262 6161
POWERPOWER
LASERLASER
EXTFILTEREXTFILTER
MONITORMONITOR
SENSESENSE
VSSA1VSSA1
IREFIREF
VDDA1VDDA1
VREF_OUTVREF_OUT
D1D1
D2D2
D3D3
D4D4
R1R1
R2R2
CSLICECSLICE
VDDA2VDDA2
VSSA2VSSA2
OSCOUTOSCOUT
OSCINOSCIN
KDAC_GNDKDAC_GND
VSSA3VSSA3
MUTEMUTE
RADRAD
FODFOD
SLSL
VBiasVBias
GNDGND
Vo toVo to
BiasBias
MOTI1MOTI1
MOTI2MOTI2
C735C735
0,47uF/100V0,47uF/100V
R712R712
++
C734C734
220uF/10V220uF/10V
TEST3TEST3
TEST4TEST4
DAC_RPDAC_RP
DAC_RNDAC_RN
2828
2727
2626
2525
2424
2323
2222
3030
2121
2020
1919
1818
1717
1616
1515
10R10R
TEST2TEST2
DAC_VREFDAC_VREF
Q702Q702
BC337/25BC337/25
GND1GND1
++
TEST1TEST1
DAC_LNDAC_LN
C738C738
220uF/10V220uF/10V
C720C720
GND1GND1 GND1GND1
V5V5
DAC_LPDAC_LP
3V33V3
++
2n22n2
C719C719
V4V4
DAC_VPOSDAC_VPOS
1V81V8
+6V+6V
++
C740C740
47uF/25V47uF/25V
100n100n
Q701Q701
BC337/25BC337/25
++
C722C722
R716R716
R715R715
V2V2
BUF_IN_RBUF_IN_R
C712C712
47uF/25V47uF/25V
0R0R
P/ USO CD 3 DISCOSP/ USO CD 3 DISCOS
SAA7824SAA7824
470n470n
4K74K7
4K74K7
V1V1
IC701IC701
BUF_OUT_RBUF_OUT_R
2n22n2
GND1GND1GND1GND1 GND1GND1
VDDD3VDDD3
BUF_OUT_LBUF_OUT_L
C739C739
C721C721
2n22n2
J701J701
100n100n
V3V3
BUF_VPOSBUF_VPOS
C725C725
GND1GND1
330p330p
C723C723
C724C724
2n22n2
3V33V3
120K120K
R718R718
120K120K
R717R717
GND1GND1
1V81V8
33K33K
4K74K7
4K74K7
R710R710
R711R711
VSSD3VSSD3
MOTO2MOTO2
MOTO1MOTO1
BUF_GNDBUF_GND
BUF_IN_LBUF_IN_L
C713C713
A_GND2A_GND2 D_GNDD_GND
LKILLLKILL
470n470n
R709R709
SLSL
FOFO
RARA
CDT_RDYCDT_RDY
RKILLRKILL
CDT_DATACDT_DATA
+6V+6V
10K10K
R714R714
P/ USO CD 3 DISCOSP/ USO CD 3 DISCOS
OPENOPEN
CLOSECLOSE
SW702SW702
CAR_POSCAR_POS
GNDGND
OPENOPEN
CLOSECLOSE
SW701SW701
CDM_POSCDM_POS
GNDGND
OPENOPEN
CLOSECLOSE
SW703SW703
TRAY_SWTRAY_SW
GNDGND
usado para CD 3 DISCOS usado para CD 3 DISCOS
TRAY_SWTRAY_SW
C718C718
100n100n
D_GNDD_GND
6060
SBSYSBSY
VDDD2VDDD2
DOBMDOBM
VSSD2VSSD2
5959
SFSYSFSY
5858
SUBSUB
5757
RCKRCK
SLIDSLID
RESETRESET
CLK12CLK12
CLK16CLK16
SCLKSCLK
WCLKWCLK
DATADATA
SCLISCLI
WCLIWCLI
VDDD1VDDD1
RABRAB
SCLSCL
SDASDA
SDDSDD
40403939383837373636353534343333323231313030292928282727262625252424232322222121
5656
5555
5454
5353
5252
RESETRESET RESETRESET
5151
5050
4949
4848
4747
4646
4545
EFEF
4444
4343
4242
4141
STATUSSTATUS
VSSD1VSSD1
CFLAGCFLAG
CDT_CLKCDT_CLK
R703R703
SCLSCL
SDASDA
DGNDDGND
3V33V3
R702R702
C715C715
CN705CN705
GNDGND GNDGND
4K74K7
4K74K7
R706R706
R705R705
10R10R
47uF/25V47uF/25V
C733C733
++
++
100n100n
CN704CN704
33
22
11
44
3V33V3
4K74K7
OPC.OPC.
OPC.OPC.
R708R708
R707R707
10n10n
C716C716
A_GND2A_GND2
A_GND2A_GND2
47uF/25V47uF/25V
C732C732
R713R713
J704J704
OPC.OPC.
P/ USO CD TOPOP/ USO CD TOPO
D701D701
1N41481N4148
10n10n
C717C717
3V33V3
10K10K
P/ USO CD 3 DISCOSP/ USO CD 3 DISCOS
GNDGND
+6V+6V
C745C745
R733R733
++
47uF/25V47uF/25V
A_GND2A_GND2
A_GND2A_GND2
10K10K
CN701CN701
100n100n
C748C748
J703J703
OPC.OPC.
USAR CN701 10 VIAS (1 AO 10)USAR CN701 10 VIAS (1 AO 10)
GNDGND
GND1GND1A_GND1A_GND1
DGNDDGNDGND1GND1
+6V+6V
GNDGND
L_OUTL_OUT
A_GND2A_GND2
R_OUTR_OUT
STATUSSTATUS
SCLSCL
SDASDA
CAR-CAR-
CAR+CAR+
CAR_POSCAR_POS
CDM_POSCDM_POS
PARA USO DE CD TOPOPARA USO DE CD TOPO
PARA USO CD 3 DISCOSPARA USO CD 3 DISCOS
USAR CN701 13 VIASUSAR CN701 13 VIAS
11
22
33
44
55
66
77
88
99
1010
1111
1212
1313
3V33V3
10R10R
R738R738
100n100n
C750C750
++
C730C730
3n33n3
C708C708
100uF/10V100uF/10V
++
3n33n3
C709C709
C731C731
3n33n3
C710C710
100uF/10V100uF/10V
A_GND2A_GND2
3n33n3
C711C711
DES.DES.
PROJ.PROJ.
VERIF.VERIF.
P.A.P.A.ALT.ALT.
NOMENOME
THIAGOTHIAGO
THIAGOTHIAGO
ROBERTOROBERTO
TITULO:TITULO:
04/08/0304/08/03
19/11/0319/11/03
19/11/0319/11/03
MAT.MAT.DATADATA
ACAB.ACAB.
ESC.ESC.
MOD.MOD.
DISCRIMINACAODISCRIMINACAO DATADATAVISTOVISTO
ESQUEMA ELETRICO PCI CD 3 e 1 discoESQUEMA ELETRICO PCI CD 3 e 1 disco
PHONIC P/ PICK-UP DA-12PHONIC P/ PICK-UP DA-12
PHONIC CD 3 e 1 discoPHONIC CD 3 e 1 disco
GND1GND1GNDGND
COD.COD.
PROJECAOPROJECAO
N.N.TOL.TOL.TOL.TOL.
A2A2
1.00.52284.011.00.52284.01
mmmmememdimensoesdimensoes
Page 23
S-201S-201
PLAYPLAY
HEADHEAD
CAB.PLAYCAB.PLAY
11
22
CN902CN902
22R22R
47R47R
R913R913
(-)(-)
44332211
100uF/16V100uF/16V
100uF/16V100uF/16V
++
C905C905
47R47R
1/2VCC1/2VCC
C906C906
++
1/2VCC1/2VCC
22n22n
C907C907
1/2VCC1/2VCC
+9VA+9VA
8n28n2
330K330K
C903C903
R901R901
1n81n8
C901C901
RRLL33
C902C902
1n81n8
C904C904
330K330K
R902R902
1K21K2
R905R905
R903R903
1/2VCC1/2VCC
1K21K2
8n28n2
R904R904
R906R906
4K74K7
18K18K
R907R907
88 77 66 55
(+)(+)
100n100n
C954C954
18K18K
4K74K7
R908R908
R910R910
390K390K
R909R909
R911R911
--
++
IC901IC901
45584558
++
--
22R22R
390K390K
R912R912
R914R914
Q914Q914
BC846BBC846B
+12V+12V
R963R963
10K10K
0V-PLAY0V-PLAY
5V-R/P5V-R/P
R964R964
R965R965
22K22K
47K47K
PB_1/2PB_1/2
E-621MLE-621ML
S-201S-201
HEADHEAD
REC/PLAYREC/PLAY
ERASEERASE
HEADHEAD
CAB.R/PCAB.R/P
CAB_APGCAB_APG
11
22
33
44
CN904CN904
22
11
CN905CN905
JG01JG01
Vrec=0,00035VVrec=0,00035V
Vbias=0,004VVbias=0,004V
Irec=35uAIrec=35uA
Ibias=400uAIbias=400uA
TP1TP1
R915R915
10R10R
R916R916
10R10R
TP2TP2
R940R940
1R1R
Verase=0,035VVerase=0,035V
Ierase=35mAIerase=35mA
GND DOGND DO
PCIPCI
R962R962 R961R961
++
1uF/100V1uF/100V
5V-OFF5V-OFF
0V-ON0V-ON
0V-ON0V-ON
++
1uF/100V1uF/100V
C915C915
C916C916
100K100K 100K100K
R960R960
C921C921
1n1n
1n1n
1K1K
R959R959
TP11TP11
RECREC
1K1K
TP12TP12TP9TP9
GNDGND
+9VA+9VA
TP10TP10
TP8TP8
RESISTORESRESISTORES
DE PULL-UPDE PULL-UP
ESTAO JUNTOESTAO JUNTO
AO MICROAO MICRO
665544332211
CN903CN903
CN907CN907
CN908CN908
PLAYPLAYREC/PLAYREC/PLAY
PB_1/2PB_1/2
M_PM_P
M_RPM_RP
REC_SWREC_SW
RECREC
R_OUTR_OUT
L_OUTL_OUT
R_RECR_REC
L_RECL_REC
TP7TP7
CN901CN901
1111
1010
99
88
77
66
55
44
33
22
11
CN901CN901
BC856BBC856B
Q912Q912
47K47K
C951C951
R942R942
22K22K
C913C913
OPC.OPC.
OPC.OPC.
C912C912
opc.opc.
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC
1/2VCC1/2VCC1/2VCC1/2VCC
R947R947
1/2VCC1/2VCC
C914C914
10n10n
47K47K 47K47K
R948R948 R949R949
1/2VCC1/2VCC
47K47K
R946R946
Q913Q913
RECREC
C920C920
BC856BBC856B
M_RPM_RP
5V-OFF5V-OFF
M_PM_P
5V-PLAY5V-PLAY
P/R_SWP/R_SW
0V-REC0V-REC
OPC. PARA CJT. DECK LOGICO 1.02.52202.45OPC. PARA CJT. DECK LOGICO 1.02.52202.45
39R39R
47R47R
R939R939
R987R987
1K1K
R986R986
1K1K
R935R935
(-)(-)
44332211
100uF/16V100uF/16V
1K1K
BC846BBC846B
Q906Q906
6n86n8
R991R991
56K56K
C928C928
82p82p
C929C929
R990R990R968R968
56K56K18K18K
6n86n8
C919C919
47R47R
C918C918
R989R989
1K21K2
R993R993
8K28K2
R992R992
8K28K2
R988R988
1K21K2
++ ++
C926C926
82p82p
100uF/16V100uF/16V
R945R945
OPC.OPC.
1/2VCC1/2VCC
R944R944
OPC.OPC.
++
R943R943
C927C927
+9VA+9VA
47K47K
1/2VCC1/2VCC
BC856BBC856B
TP3TP3
TP4TP4
TP6TP6TP5TP5
BC856BBC856B
Q901Q901
Q902Q902
BC856BBC856B
C930C930
470p470p
C931C931
470p470p
+9VA+9VA
R966R966 R967R967
Q907Q907
R917R917
470R470R
R918R918
470R470R
R919R919
10K10K
Q908Q908
BC846BBC846B
R978R978
47K47K
R977R977
47K47K
R969R969 R973R973
18K18K 2K22K2
470R470R 470R470R
2n22n2 2n22n2
C923C923 C922C922
+9V+9V
C909C909
R923R923
10K10K
1n81n8
R925R925
R924R924
1n81n8
C908C908
4433
5522
66
++
opc.opc.
1/2VCC1/2VCC
10K10K
R921R921
47K47K
R920R920
47K47K
R954R954
C932C932
opc.opc.
C933C933
3n33n3
1/2VCC1/2VCC
BC846BBC846B
22K22K
R971R971
R922R922
10K10K
R994R994
10K10K
plasticoplastico
BC856BBC856B
BC856BBC856B
Q910Q910
Q911Q911
BC846BBC846B
f=59.068Hzf=59.068Hz
OSC.BIASOSC.BIAS
11
Q915Q915
10K10K
R975R975
Q909Q909
T903T903
8n28n2
330K330K
C911C911
330K330K
C910C910
C940C940
1K21K2
R927R927
R929R929R928R928
1/2VCC1/2VCC
1K21K2
8n28n2
R926R926
C945C945
22n22n
C941C941
10n10n
8R28R2
R934R934
100n100n
680R680R
12n12n
R985R985
C924C924
+9VA+9VA
88 77 66 55
(+)(+)
++
1/2VCC1/2VCC
10K10K
BC846BBC846B
R974R974
Q916Q916
22K22K
R970R970
R972R972
2K22K2
220uF/10V220uF/10V
C934C934
C925C925
12n12n
12n12n
C953C953
680R680R
R984R984
100n100n
2K22K2
R976R976
18K18K18K18K
++
--
+9VA+9VA
R931R931
88 77 66 55
(+)(+)
100n100n
C917C917
Q904Q904
BC846BBC846B
BC846BBC846B
R979R979
IC903IC903
R980R980
Q905Q905
BC817/25BC817/25
Q903Q903
2K22K2
45584558
6K86K8
IC902IC902
++
--
390K390K
R941R941
R930R930
18K18K
R936R936
18K18K
R937R937
6K86K8
R981R981
--
++
(-)(-)
390K390K
45584558
39R39R
44332211
--
++
2n72n7
C942C942
2n72n7
C943C943
2n72n7
C944C944
R982R982
R933R933
R932R932
R983R983
1K1K
1K1K
DES.DES.
PROJ.PROJ.
VERIF.VERIF.
P.A.P.A.ALT.ALT.
NOMENOME
THIAGOTHIAGO
THIAGOTHIAGO
ROBERTOROBERTO
TITULO:TITULO:
TITLE:TITLE:
20/05/0320/05/03
20/05/0320/05/03
20/05/0320/05/03
DISCRIMINACAODISCRIMINACAO DATADATAVISTOVISTO
ESQUEMA ELETRICO PCI DECK DUPLOESQUEMA ELETRICO PCI DECK DUPLO
DOUBLE DECK PCB ELECTRIC SCHEMATICDOUBLE DECK PCB ELECTRIC SCHEMATIC
MAT.MAT.DATADATA
ACAB.ACAB.
ESC.ESC.
MOD.MOD.
MD-K300 / A-350 DECK duploMD-K300 / A-350 DECK duplo
COD.COD.
THIAGOTHIAGO 18/02/0418/02/04ACRESCENTAR SERIES A,B,C,D,E,F / A-350ACRESCENTAR SERIES A,B,C,D,E,F / A-350AA
PROJECAOPROJECAO
N.N.TOL.TOL.TOL.TOL.
A2A2
1.00.52250.091.00.52250.09
mmmmememdimensoesdimensoes
Loading...