Casio _EV-1000, XTV-10C Datasheet

CHASSIS : MODEL : EV-1000

10.4” TFT-LCD TV

SERVICE MANUAL

CONTENTS

Contents ................................................................................................................ 2

Safety Precautions ............................................................................................3

Specifications ..................................................................................................... 4

Control Descriptions ....................................................................................... 5-6

Adjustment...........................................................................................................7

Troubleshooting............................................................................... ...................8-9

Exploded View .................................................................................................. 10-11

Replacement Parts List ............................................................................... 12-16

Schematic Diagram ......................................………………………....................... 17

PCB Printings ............................................................................………………….. 18-21

2

SAFETY PRECAUTIONS

Important Safety Notice

Many electrical and mechanical parts in this chassis have special safety-related characteristics. These parts are identified by in the Schematic Diagram and Replacement Parts List. It is essential that these special safety parts should be replaced with the same components as recommended in this manual to prevent Shock, Fire, or other Hazards. Do not modify the original design without permission of manufacturer.

Leakage Current Hot Check (See below Figure)

Plug the AC cord directly into the AC outlet. Do not use a line Isolation Transformer during this check. Connect 1.5K/10watt resistor in parallel with a 0.15uF capacitor between a known good earth ground (Water Pipe, Conduit, etc.) and the exposed metallic parts. Measure the AC voltage across the resistor using AC voltmeter with 1000 ohms/volt or more sensitivity. Reverse plug of the AC cord into the AC outlet and repeat AC voltage measurements for each exposed metallic part. Any voltage measured must not exceed 0.75 volt RMS, which is, corresponds to 0.5mA. In case any measurement is out of the limits specified, there is possibility of shock hazard and the set must be checked and repaired before it is returned to the customer.

Leakage Current Hot Check circuit

3

SPECIFICATIONS

Note : Specifications and others are subject to change without notice for improvement.

1. Power requirement:

‥AC 110-240V, 50/60Hz (Cold SMPS)

/ DC 12V ADAPTOR

2. Tuning system: ‥FS, 181 Channel

3. Sound output: ‥1.0W+1.0W

4. Intermediate Frequency (IF):

‥Vision IF ; 45.75MHz ‥Color IF ; 42.17MHz ‥Sound IF ; 41.25MHz

5. Power consumption :

‥22W(3W-ST-BY at AC / 1W-ST-BY at DC)

6. Antenna input impedance :

‥VHF/UHF 75ohm , TIF (NTSC)

7. Voice coil impedance:

‥16ohm

Receiving system

No.

System

1 NTSC-3.58/4.5 O

TOTAL SYSTEM 1

8. OSD (On Screen Display) :

‥Window Type

9. External in/output: Headphone, AV In, Wired Remote

‥Audio-In ; 0.4Vrms, over 10Kohm ‥Video-In ; 1Vp-p,over 75ohm

10. Function:

‥CATV/Hyper band ‥Auto Program ‥Manual Program ‥Auto Sleep ‥Recall

Model No.

EV-1000

4

CONTROL DESCRIPTIONS

All the TV functions can be controlled with the remote controller. Some functions can also be adjusted with the buttons on the controls on the TV front panel. Remote controller Before you use the remote controller, please install the batteries.

POWER TV/VIDEO

DISPLAY

NUMBER KEY

SLEEP

1/2 digit

MENU

CLEAR VOICE

▼ Channel ▲

◀ Volume ▶

Stereo

MUTE

5

[Front/Side]

Speakers

◀ Volume ▶ up/down

CONTROL DESCRIPTIONS

LCD panel

Main power

Headphone out

Wired remote control IN

▼Programme▲ up/down

[Back/Rear]

15°/20°

POWER

IR receiver

MENU Remote control holder

Vents

TV/AV

Carrying handle

Cable storage

DC12V IN

6

AV IN

VIDEO L(MONO) R

ANTENNA

ADJUSTMENT

Safety Precautions

1. Never disconnect leads while the TV receiver is on.

2. Don't short any portion of circuits while power is on.

3. The adjustment must be done by the correct appliances. But this is changeable in view of productivity.

4. Unless otherwise noted, set the line voltage to 230Vac 10%, 50Hz ./ 110Vac, 60Hz

Test Equipment required

1. RF signal generator (with pattern generator)

2. Multi meter (volt meter)

3. Oscilloscope

4. LCD Color analyzer

RF AGC (Automatic Gain Control) Adjustment

Is not required. TIF (Tuner with IF) tuner is applied for EV-1000.

SVC Data Adjustment

NOTE: When the EEPROM has been replaced, the SVC data should be restored as the function of individual

specification.

1) Turn off Main Power switch on the side of the TV set.

2) Press VOLUME◀▶ and MENU keys on the front panel at the same time.

3) Keeping VOLUME ◀▶ and MENU pressed, turn on the Main Power switch on the side of the TV set.

4) Green LED lights and enters into SVC DATA1.

5) Press the MENU button to move to DATA2.

6) Adjust Language/Tu ning data in SVC DATA2.

7) Press the DISP button to save data.

8) Press the TV/VIDEO button to exit from SVC menu.

SVC Data Table

EV-1000 DATA 1

DATA 2 LANG 0/1 Language/Tuning

FP 50 FM Pre-scaler NP 89 NICAM Pre-scaler SP 55 SCART Pre-scaler S1VOL 105 AV1 out Pre-scaler S2VOL 105 AV2 out Pre scaler

REMARK Default data. No need to adjust.

0 : AMERICA 1 : JAPAN

7

TROUBLESHOOTING

No Raster or Maximum White

Maximum White?

Check P803 12V / On/Off: High / ADJ-BRI : 0V

Check Inverter CN2 / CN3 AC Vp.p ?

Replace LCD Module

No

Yes

No

Fasten P02 Connector

Check appropriate circuit. (Power supply & u-Com control

Replace Inverter

No Picture & Sound OK

Is OSD O.K?

No

Check IC01

-Pin13 (DCLK1)

-Pin15 (DVSYNC)

-Pin16 (DHSYNC) O.K ?

Yes

Check signals from IC01 to P02

-Pin 18~45

Yes

Check IC501 Pin28/35/36 O.K?

Yes

Check IC501 Video Inputs

-Pin42, 44

No

Check Vcc, X-tal & IIC of IC501

Check Vcc, X-tal and IIC of IC02

8

TROUBLESHOOTING

No Sound & Picture OK

Check IC601 Vcc / X-tal / IIC

No

Check IC601 Inputs ( Pin 53/ 54/56/57/67)

Yes

Check IC601 Outputs Pin27/28

Yes

Check IC605 Outputs(Pin2/5/ 16/19) Mute (Pin8 Low)

No

Check appropriate signal inputs from IC601 to signal source.

Check IC605 Vcc

9

REPLACEMENT PARTS LIST

C

The components identified by mark L is critical for safety. Replace only with part number specified.

For Capacitor & Resistors, the charactors at 2nd 3rd digit in the P/No. means as follows

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

IC

IC01 IC10 1 IC10 2 IC10 3 IC10 4 IC10 5 IC10 6 IC10 7 IC50 1 IC50 2 IC601 1ICMI3420G BS IC, MSP3420G -QA-B8 X601 IC60 2 IC60 3 IC60 5 IC801 1ICNS25 765AD IC, LM2576T-5 IC80 2 IC80 3 IC80 5 0 IC KE7 8 08 0 A D IC, KIA 78 0 8 A P C05 IC80 6 IC80 7 IC80 9 IC82 0

Q10 4 Q10 8 Q10 9 Q11 0 Q11 1 Q11 2 Q50 5 Q60 1 Q60 2 Q60 3 Q80 2 Q80 3 Q80 4 Q11 0 1 Q11 0 2

D8 0 2 D8 0 3 D8 0 5 ZD 101 1D Z S SHZ T 3 3 T A DIOD E , H Z T 3 3 C12 4 ZD 601 ZD 801 LD1 1 01 0 DLS Y RG124 A D LED, S LRG 124A C12 7

L80 2 L80 1 L41 0 L10 4 0 L ASS 2 2 0 HKT A CO IL ,2 2 UH AL0 4 T B 22 0 K C13 4 L10 3 0 L ASS 2 2 0 HKT A CO IL ,2 2 UH AL0 4 T B 22 0 K C40 3 L10 1 0 L ASS 2 2 0 HKT A CO IL ,2 2 UH AL0 4 T B 22 0 K C42 3

1ICMYTL005B S 1ICMY230M SBD 1ICSE24C16T S 0ICKE7427FTS 1ICSTLD33CT S 1ICFC2N700 TR IC, 2N7000TA 1ICFC2N700 TR IC, 2N7000TA 1ICFC2N700 TR IC, 2N7000TA 1ICMI3226EBS 1ICSTLD33CT S

1ICSTTS482TS IC, TS482IST -MiniS08 0ICKE7042FT S IC, KA7042 AF 1ICST7266DBS

1ICRO616 1FTS 0ICVI4925DTS IC, SI4925DY TP

0ICKE78L9FT S IC, KIA78L09F, IC 0ICKE78L5FT S IC, KIA78L05F, IC 1ICSTLD33CT S 1ICSTLD33CT S

TRANSISTOR 0TRKE3875STS 0TRKE3875STS 0TRKE1504STS KTA1504S Y 0TRKE3875STS 0TRKE1504STS KTA1504S Y 0TRKE3875STS 0TRKE3875STS 0TRKE1504STS KTA1504S Y 0TRKE1504STS KTA1504S Y 0TRKE3875STS 0TRKE3875STS 0TRKE3875STS 0TRKE3875STS 0TRKE3875STS 0TRKE3875STS

1DDSKEU1Z0TA Diode, axial EU1Z 0DSSCB340ATS DIODE,B340A 0DHKEKDS181S DIODE, KDS181

1DZSC5231BTS ZENER, 5.1V MMSZ5231BS 0DSSCB340ATS DIODE,B340A

0LRSM00100BD 0LRSM10100BD 0LASS120FKTA

IC, MTL 005 L804 0LBSS3580RTR CORE, BFD-3580R2F IC, MTV230MS L50 3 IC,S-24C16AFJ A-TB L50 1 IC KIA7427 L4 1 2 IC LD33C L41 1

L09 L05 L02

IC, VPX3226E L01 IC, L D33 C

X50 1 X10 1

IC, TDA7266D X01

IC, BA6161F C03

C04

C10 C14

IC, L D33 C C16 IC, L D33 C C17

C22 KTC38 7 5 S Y C23 KTC38 7 5 S Y C24

C25 KTC38 7 5 S Y C26

C27 KTC38 7 5 S Y C29 KTC38 7 5 S Y C30

C10 1

C10 2 KTC3875S Y C105 KTC3875S Y C106 KTC3875S Y C107 KTC3875S Y C108 0CESH471CMTR KTC3875S Y C109 KTC3875S Y C110

DIODE

COIL

CO IL, 1 MH SM C 1 0 3 C12 9 CO IL,1 0 0 UH S M C H1 0 0 C130 COIL,12UH AL02TB 120K C131

C11 1

C11 2

C12 2

C12 3 0 C E SH3 3 4 HMTR

C12 5

C12 6 0 C E SH1 0 0 HMTR

C12 8

0LBSS102DJTS 0LBSS601FJTS 0LBSS101DJTS 0LBSS101DJTS 0LBSS102DJTS 0LBSS601FJTS 0LBSS101DJTS 0LBSS601DJTS

0XTKI184320D 0XTKI202500D 0XTKI120000D 0XTKI143180D

0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS331DJTS CH IP CAP, 330PF 50V J 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS470DJTS CH IP CAP, 47PF 50V J 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS330DJTS CH IP CAP, 33PF 50V J 0CHSS330DJTS CH IP CAP, 33PF 50V J 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS200DJTS CH IP CAP, 20PF 50V J 0CHSS200DJTS CH IP CAP, 20PF 50V J 0CHSS331DJTS CH IP CAP, 330PF 50V J 0CESS101CMTR ELEC CAP, 100UF 16V M 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z

0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS222DKTS CHIP CAP, 2200PF 50V K 0CHSS222DKTS CHIP CAP, 2200PF 50V K 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CESS4R7HMTR ELEC CAP, 4.7UF 50V M

0CHSS470DJTS CH IP CAP, 47PF 50V J 0CHSS470DJTS CH IP CAP, 47PF 50V J

0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CESS221CMTR ELEC CAP, 220UF 16V M 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CESS3R3HMTR ELEC CAP, 3.3UF 50V M 0CHSS103DKTS CHIP CAP, 0.01UF 50V K 0CHSS104D ZTS CHIP CAP, 0.1UF 50V Z 0CHSS080DCTS CHIP CAP, 8PF 50V C 0CHSS080DCTS CHIP CAP, 8PF 50V C

DH:Chip Diode DZ:Zener Diode DD:Rectifier Diode DS:Schottky Diode TR:Transistor

CORE

CORE,1000 OHM CIM10J102N CORE, 600 OHM CIM31J601 CORE, 100 OHM CIM21U101 CORE, 100 OHM CIM21U101 CORE,1000 OHM CIM10J102N CORE, 600 OHM CIM31J601 CORE, 100 OHM CIM21U101 CORE, 600 OHM CIM10J601N

CRYSTAL

CRYSTAL, 18.432MHZ 12PF CRYSTAL, 20.25MHZ 12PF CRYSTAL, 12MHZ 20PF CRYSTAL, 14.318MHZ 12PF

CAPACITOR

ELEC CAP, 470UF 16V M

ELEC CAP, 0.33UF 50V M

ELEC CAP, 10UF 50V M

LB: Bead Core LA:Inductor LR:Choke Coil XT:Crystal

The components identified by mark L is critical for safety. Replace only with part number specified.

For Capacitor & Resistors, the charactors at 2nd 3rd digit in the P/No. means as follows

CH:Chip Capacitor CE:Electrolytic Capacitor CB:Bipolar Capacitor CQ: Poly Capacitor CT:Tantal Capacitor

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION C424 C425 C426 C501 C502 C503 C504 C505 C506 C508 C509 C510 C511

0CHSS560DJTS CHIP CAP, 56PF 50V J 0CHSS471DJTS CHIP CAP, 470PF 50V J 0CHSS471DJTS CHIP CAP, 470PF 50V J 0CHSS224DZTS CHIP CAP, 0.22UF 50V Z 0CHSS684DZTC CHIP CAP, 0.68UF 50V Z 0CESS100CMTR ELEC CAP, 10UF 16V M 0CHSS473DKTS CHIP CAP, 0.047UF 50V K 0CHSS684DZTC CHIP CAP, 0.68UF 50V Z 0CHSS684DZTC CHIP CAP, 0.68UF 50V Z 0CHSS030DCTS CHIP CAP, 3PF 50V C 0CHSS030DCTS CHIP CAP, 3PF 50V C 0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CESS101CMTR ELEC CAP, 100UF 16V M C512 0CESH221AMTR C517 C601 C602 C603 C604 C605 C607 C608 C609 C612 C613 C614 C615 C616 C617 C618 C619 C620 C621 C622 C623 C624 C625 C626 C627 C628 C629 C630 C631 C632 C633 C634 C635 C636 C424 C425 C426 C501 C502 C503 C504 C505 C424

0CESS101CMTR ELEC CAP, 100UF 16V M

0CESS101CMTR ELEC CAP, 10

0CHSS103DKTS C HIP CAP, 0.01UF 50V K

0CHSS560DJTS CHIP CAP, 56PF 50V J

0CHSS020DCTS CHIP CAP, 2PF 50V C

0CHSS103DKTS C HIP CAP, 0.01UF 50V K

0CESS470CMTR ELEC CAP, 47UF 16V M

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CHSS152DKTS CHIP CAP, 1500PF 50V K

0CHSS222DKTS CHIP CAP, 2200PF 50V K

0CESS101CMTR ELEC CAP, 100UF 16V M

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CESS100CMTR ELEC CAP, 10UF 16V M

0CHSS332DKTS CHIP CAP, 3300PF 50V K

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CESS3R3HMTR ELEC CAP, 3.3UF 50V M

0CHSS224DZTS CHIP CAP, 0.22UF 50V Z

0CHSS222DKTS CHIP CAP, 2200PF 50V K

0CHSS224DZTS CHIP CAP, 0.22UF 50V Z

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CHSS472DKTS CHIP CAP, 4700PF 50V K

0CESS100CMTR ELEC CAP, 10UF 16V M

0CHSS103DKTS C HIP CAP, 0.01UF 50V K

0CHSS224DZTS CHIP CAP, 0.22UF 50V Z

0CHSS222DKTS CHIP CAP, 2200PF 50V K

0CHSS224DZTS CHIP CAP, 0.22UF 50V Z

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

ELEC CAP, 220UF 10V M

C648 0CESH471 CMTR C649 C650 C651 C652 C653

0CHSS103DKTS CHIP CAP, 0.01UF 50V K 0CHSS103DKTS CHIP CAP, 0.01UF 50V K 0CESS2R3HMTR ELEC CAP, 2.2UF 50V M 0CESS2R3HMTR ELEC CAP, 2.2UF 50V M

0CESS470CMTR ELEC CAP, 47UF 16V M C654 0CESH010 HMTR C661 C662 C663 C664 C665 C666 C667 C668 C801 C802 C803 C804

0CHSS224DZTS CHIP CAP, 0.22UF 50V Z

0CHSS222DKTS CHIP CAP, 2200PF 50V K

0CESS101CMTR ELEC CAP, 100UF 16V M

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CESS221CMTR ELEC CAP, 220UF 16V M

0CESS101EMTR ELEC CAP, 100UF 25V M C805 0CESH471 CMTR C806 0CESH471 CMTR C807 C808 C809 C810 C811 C812 C816 C820 C822 C1101 C1102 C1103 C1104

0CESS4R7HMTR ELEC CAP, 4.7UF 50V M

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CESS221CMTR ELEC CAP, 220UF 16V M

0CESS101CMTR ELEC CAP, 100UF 16V M

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CESS470CMTR ELEC CAP, 47UF 16V M

0CESS221CMTR ELEC CAP, 220UF 16V M

0CESS101CMTR ELEC CAP, 100UF 16V M

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

0CHSS331DJTS CHIP CAP, 330PF 50V J

0CHSS104DZTS CHIP CAP, 0.1UF 50V Z

RESISTOR R02 R03 R04 R05 R06 R07 R08 R09 R10 R11 R12 R14 R16 R19 R20 R21 R22 R23 R24 R25 R26 R32

0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS471DJTS CHIP RES 470 OHM 1/16W J 0RHSS471DJTS CHIP RES 470 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS000DJTS CHIP RES 0 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS000DJTS CHIP RES 0 OHM 1/16W J 0RHSS000DJTS CHIP RES 0 OHM 1/16W J 0RHSS750DJTS CHIP RES 75 OHM 1/16W J 0RHSS750DJTS CHIP RES 75 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS000DJTS CHIP RES 0 OHM 1/16W J

ELEC CAP, 470UF 16V M

ELEC CAP, 1UF 50V M

ELEC CAP, 470UF 16V M ELEC CAP, 470UF 16V M

The components identified by mark L is critical for safety. Replace only with part number specified.

For Capacitor & Resistors, the charactors at 2nd 3rd digit in the P/No. means as follows

CH:Chip Capacitor CE:Electrolytic Capacitor CB:Bipolar Capacitor CQ: Poly Capacitor CT:Tantal Capacitor

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION R103 R104 R106 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R125 R126 R127 R128 R129 R130 R131 R132 R134 R135 R138 R139 R140 R142 R143 R144 R145 R146 R147 R148 R149 R150 R151 R152 R153 R154 R155 R156 R160 R161 R162 R163 R164 R165 R166 R168 R169 R170 R171

0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS332DJTS CHIP RES 3.3K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS332DJTS CHIP RES 3.3K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS332DJTS CHIP RES 3.3K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS562DJTS CHIP RES 5.6K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS471DJTS CHIP RES 470 OHM 1/16W J 0RHSS470DJTS CHIP RES 47 OHM 1/16W J 0RHSS470DJTS CHIP RES 47 OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS223DJTS CHIP RES 22K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS680DJTS CHIP RES 68 OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS470DJTS CHIP RES 47 OHM 1/16W J 0RHSS470DJTS CHIP RES 47 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS470DJTS CHIP RES 47 OHM 1/16W J 0RHSS470DJTS CHIP RES 47 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J

R172 R173 R174 R175 R176 R177 R178 R179 R181 R182 R183 R184 R185 R186 R188 R189 R190 R191 R433 R434 R435 R436 R437 R438 R501 R505 R506 R507 R508 R509 R510 R511 R512 R513 R514 R532 R552 R553 R557 R601 R602 R603 R604 R605 R606 R607 R608 R609 R610 R611 R612 R613 R614 R615 R616 R617 R618

0RHSS222DJTS CHIP RES 2.2K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS512DJTS CHIP RES 5.1K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS222DJTS CHIP RES 2.2K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS471DJTS CHIP RES 470 OHM 1/16W J 0RHSS750DJTS CHIP RES 75 OHM 1/16W J 0RHSS512DJTS CHIP RES 5.1K OHM 1/16W J 0RHSS474DJTS CHIP RES 470K OHM 1/16W J 0RHSS512DJTS CHIP RES 5.1K OHM 1/16W J 0RHSS474DJTS CHIP RES 470K OHM 1/16W J 0RHSS103DJTS CHIP RES 10K OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS000DJTS CHIP RES 0 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS220DJTS CHIP RES 22 OHM 1/16W J 0RHSS100DJTS CHIP RES 10 OHM 1/16W J 0RHSS112DJTS CHIP RES 1.1K OHM 1/16W J 0RHSS000DJTS CHIP RES 0 OHM 1/16W J 0RHSS151DJTS CHIP RES 150 OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS105DJTS CHIP RES 1M OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS100DJTS CHIP RES 10 OHM 1/16W J 0RHSS273DJTS CHIP RES 27K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS392DJTS CHIP RES 3.9K OHM 1/16W J 0RHSS392DJTS CHIP RES 3.9K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS102DJTS CHIP RES 1K OHM 1/16W J 0RHSS101DJTS CHIP RES 100 OHM 1/16W J 0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J

The components identified by mark L is critical for safety. Replace only with part number specified.

For Capacitor & Resistors, the charactors at 2nd 3rd digit in the P/No. means as follows

RH:Chip Resistor RD: Carbon Resistor RY: Array Resistor JA: Jack WAF: Pin Waf er

LOCA. NO PART NO D ESCRIPTION LOCA. NO PART NO DESCRIPTION R619 0RHSS 682D JTS R622 R624 R625

0RHSS000DJTS CHIP RES 0 OHM 1/16W J 0RHSS104DJTS CHIP RES 100K OHM 1/16W J

0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J R626 0RHSS 682D JTS R631 R632 R633 R634 R635 R636 R637 R638 R639 R640 R641 R642 R643 R644 R645 R648 R649 R661 R662 R801 R803 R804 R805 R806 R807 R808 R810 R815 R824

0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J

0RHSS102DJTS CHIP RES 1K OHM 1/16W J

0RHSS000EJTS CHIP RES 0 OHM 1/16W J

0RHSS473DJTS CHIP RES 47K OHM 1/16W J

0RHSS471DJTS CHIP RES 470 OHM 1/16W J

0RHSS102DJTS CHIP RES 1K OHM 1/16W J

0RHSS154DJTS CHIP RES 150K OHM 1/16W J

0RHSS683DJTS CHIP RES 68K OHM 1/16W J

0RHSS392DJTS CHIP RES 3.9K OHM 1/16W J

0RHSS104DJTS CHIP RES 100K OHM 1/16W J

0RHSS392DJTS CHIP RES 3.9K OHM 1/16W J

0RHSS102DJTS CHIP RES 1K OHM 1/16W J

0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J

0RHSS103DJTS CHIP RES 10K OHM 1/16W J

0RHSS102DJTS CHIP RES 1K OHM 1/16W J

0RHSS103DJTS CHIP RES 10K OHM 1/16W J

0RHSS104DJTS CHIP RES 100K OHM 1/16W J

0RHSS122DJTS CHIP RES 1.2K OHM 1/16W J

0RHSS103DJTS CHIP RES 10K OHM 1/16W J

0RHSS472DJTS CHIP RES 4.7K OHM 1/16W J

0RHSS000DJTS CHIP RES 0 OHM 1/16W J

0RHSS000EJTS CHIP RES 0 OHM 1/16W J R1101 0RHSS152DJTS R1102 0RHSS272DJTS R1103 0RHSS682DJTS R1104 0RHSS152DJTS R1105 0RHSS272DJTS R1106 0RHSS201DJTS R1107 0RHSS331DJTS L08 L07 L22 L21 L20 L19 L18 L17 L16 L15 L14 L13 L12 L11

0RHSS000EJTS CHIP RES 0 OHM 1/16W J

0RYSS101FJTS

CHIP RES 6.8K OHM 1/16W J

CHIP RES 1.5K OHM 1/16W J CHIP RES 2.7K OHM 1/16W J CHIP RES 6.8K OHM 1/16W J CHIP RES 1.5K OHM 1/16W J CHIP RES 2.7K OHM 1/16W J CHIP RES 200 OHM 1/16W J CHIP RES 330 OHM 1/16W J

RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS RES, 100 OHM RP164PJ101CS

PRE-AMP

PA1102 0PAVI48380AD PRE-AM P, TSOP 4838

SW1101 600-002A S/W, YTP-1141A SW1102 600-002A S/W, YTP-1141A SW1103 600-002A S/W, YTP-1141A SW1104 600-002A S/W, YTP-1141A SW1105 600-002A S/W, YTP-1141A SW1106 600-002A S/W, YTP-1141A SW1107 600-002A S/W, YTP-1141A SW1111 600-001C S/W, MSR1101(WK)

P02

WAFHI30050AS PIN WAFER, 05002HR-00 P102 WAFYH10200SD PIN WAFER, BMW 200- 10 P102-1 WA FYH10200AD PIN W AFER, BMH200-10R P103 WAFYH10200SD PIN WAFER, BMW 200- 10 P103-1 WA FYH10200AD PIN W AFER, BMH200-10R P104 WAFML07200AD PIN WAFER, 53015-0710 P105 WAFML08200AD PIN WAFER, 53015-0810 P1101 W A FM L07200AD PIN WAFER, 53015-0710 P1103 W A FM L08200AD PIN WAFER, 53015-0810 P1104 W A FYH02200A D PIN WAFER, SMA W 200 - 02 P601 P602

WAFYH02200SD PIN WAFER , SMW200-02

WAFYH03200SD PIN WAFER , SMW200-03 P803 WAFYH10125AS PIN WAFER, YH12505WR-10

J801 1JADM231000D JACK , DS 231-115 J402

0JAPK6054BBD J1102 1JAGEPJ20425 JACK, PJ-204B, 2.5PHIE J1101 1JAGEPJ32735 JACK, PJ-327, 3.5PHIN E

F801

P1111

1FHSW25H50TS FUSE, 25H5000G 5A 125V

CON02P200A0A CONNECT, 2P-30MM POW ER H1,H2 CONRING120A0 CONNECT, RING TYPE 120mm

TU101 0TULGH001FBD TUNER, TAFD-H 001F

SWITCH

PIN WAFER

JACK

JACK, PJ6054B 3P

FUSE

CONNECT

TUNER

NO

DR

No.

FRONT󰼿COVER

1

1-03-042

DECO󰼿COVER

2

F

3

REMOTE󰼿COVER

SPEAKER

4

SCREW󰼿TAPPING

5

CONTROL󰼿KNOB

6

POWER󰼿KNOB

7

POWER󰼿LED

8

9

CONTROL󰼿KEY

SCREW󰼿TAPPING

10

11

TFT󰼿LCD

12

SHIELD󰼿PANEL

SCREW󰼿MACHINE

13

MAIN󰼿BOARD

14

E

INVERTER

15

16

SCREW󰼿MACHINE

SHIELD󰼿PCB

17

SCREW󰼿MACHINE

18

19

SHIELD󰼿JACK

POWER󰼿SWITCH

20

REMOTE󰼿JACK

21

22

SCREW󰼿TAPPING

23

REAR󰼿COVER

24

SCREW󰼿TAPPING

D

1 2 3 4 5 6

DESCRIPTION

MATERIAL

ABS,󰼿t=2.0

ALUMINIUM

PC

-

BHT󰼿2.6*7

ABS-HB

PC

-

VHTTB󰼿3*10

-

EGI,󰼿t=0.6

BHTTC󰼿3*6

-

BHTTC󰼿3*6

EGI,󰼿t=0.6

BHTTC󰼿3*6

SPTH,󰼿t=0.3

-

VHTTB󰼿3*10

ABS,󰼿t=2.0

PTTB󰼿3*12

COLOR󰼿FINISH

SPRAY,󰼿GRAY

RED

-

SNI

CHROME󰼿증착

WHITE

-

SZN

PRIME󰼿VIEW

-

SZN(백색)

-

SZN(백색)

-

SZN(백색)

니켈도금

-

SZN

SPRAY,󰼿WHITE

SNI

Q'ty

1

2

1

3

1

4

1

6

1

7

1

2

1

4

TORQUE(Kgf.cm)

풀󰼿림

1.88

6.5

6

4

6.5

조󰼿임

-

3󰾝4

6󰾝7

13

2󰾝3

3󰾝4

12

11

16

14

24

23

18

17

87

F

E

D

1

15

C

2

B

A

기󰼿󰼿󰼿󰼿󰼿󰼿사󰼿󰼿󰼿󰼿󰼿󰼿󰼿DESCRIPTION

위치

기호 SYM

ZONE REVISED

변󰼿경󰼿REVISIONS

1

변경자

변경일 승󰼿󰼿󰼿인

DATE

APPROVED

2

9

3

5

4

6

3 4 5

10

C

19

22 21 20

B

TITLE

SET󰼿ASS'Y

DRAWING󰼿NO.

1-03-042

SCALE

N/S

INJECTION󰼿MAKER

SHEETS

8

A

1/1

87

6

MATERIAL

THIC

처리

UNIT

MODEL

EV-1000

MOLD󰼿MAKER

DR󰼿DATE

2003.07.08.

ENGR

김󰼿명󰼿일

CHK

APPD

mm

APPD

7

NO

DR

No.

1

1-03-039

2

F

3

4

5

6

7

8

9

10

11

12

13

14

E

15

16

17

1 2 3 4 5 6 7 8

DESCRIPTION

HANDLE󰼿FRONT

HINGE󰼿ASS'Y

SCREW󰼿TAPPING

HANDLE󰼿REAR

SCREW󰼿TAPPING

STAND󰼿TOP

STAND󰼿BOTTOM

SCREW󰼿TAPPING

SUPPORT󰼿BRKT

RUBBER󰼿FOOT

SCREW󰼿TAPPING

SCREW󰼿MACHINE

STAND󰼿FRONT

SCREW󰼿TAPPING

STAND󰼿REAR

SCREW󰼿TAPPING

STAND󰼿COVER

MATERIAL

ABS,󰼿t=2.0

PTTBW󰼿3*6

ABS,󰼿t=2.0

PTTB󰼿2.6*7

ABS,󰼿t=2.0󰼿

ABS,󰼿t=2.0

PTTB󰼿3*10

󰼿EGI,󰼿t=2.0

NBR,万15*万3*4T

PTTB󰼿3*10

PBR󰼿4*8

ABS,󰼿t=2.0

PBTB󰼿3*10

ABS,󰼿t=2.0

PSTB󰼿3*8󰼿

ABS,󰼿t=2.0

COLOR󰼿FINISH

SPRAY,󰼿WHITE

SZN

SPRAY,󰼿WHITE

SNI

SPRAY,󰼿WHITE

SZN

백색󰼿아연도금

BLACK

SNI

SZN

SPRAY,󰼿GRAY

SZN

SPRAY,󰼿GRAY

SBN

SPRAY,󰼿GRAY

Q'ty

1

4

1

3

2

1

2

1

4

2

1

413

TORQUE(Kgf.cm)

풀󰼿림

3

2

3

10

3

조󰼿임

6󰾝7

5󰾝6

6󰾝7

1

3

4

5

2

6󰾝7

5

15

6

6󰾝7

7

8

9

F

E

D

A

D

C

완제품

10

C

13

C

11

15

12

14

16

B

17

B

MOLD󰼿MAKER

MATERIAL

THIC

B

A

기󰼿󰼿󰼿󰼿󰼿󰼿사󰼿󰼿󰼿󰼿󰼿󰼿󰼿DESCRIPTION

위치

기호

SYM

ZONE

변󰼿경󰼿REVISIONS

1

변경일 DATE

변경자

REVISED

승󰼿󰼿󰼿인

APPROVED

2

3 4

5 6

처리

UNIT

MODEL

EV-1000

DR󰼿DATE

2003.07.08.

ENGR

김󰼿명󰼿일

CHK

APPD

mm

APPD

7

TITLE

STAND󰼿ASS'Y

DRAWING󰼿NO.

1-03-039

SCALE

N/S

INJECTION󰼿MAKER

SHEETS

8

A

1/1

PCB󰼿TOP

PCB󰼿BOTTOM

PCB TOP PATTERN

PCB BOTTOM PATTERN