Cardinal Gates door lock User Manual
MG15 Auto-Lock Gate
ASSEMBLY INSTRUCTIONS
A
B
C
1
6½
3
D
1. Install hinge
A
C
bracket (A) to wall
(stationary side of
gate) using Phillips
screw (C)
beginning 6½
above floor
surface.
(Use ruler on left
edge of this sheet
to measure from
floor)
D
F
E
G
H
2. Install second
2
C
B
I
screw (C) in
top of hinge
bracket
securing it to
the wall.
4
2X
REPEAT AT
BOTTOM OF
GATE
THIS SIDE OF GATE HAS THREE (3) HOLES
3. Insert eye bolts (D) into top and bottom
of hinge side gate (side with three holes).
Be sure nuts are tight.
5
F
2X
LOOSEN AT TOP AND
BOTTOM OF GATE TO
ADJUST GATE WIDTH
E
H
4. Hang gate by inserting hinge rod (B), through top
of mounted hinge bracket (A), through upper plastic
shoulder washer (E), through both eye bolts, through
lower plastic shoulder washer (E), and finally through
bottom of hinge bracket. To secure hinge, insert
key ring (H) through hole in end of hinge rod.
6
G
C
½
4X
MOUNT LATCH
ASSEMBLY WITH
SCREWS
5. Use Allen wrench (F) to unscrew set screws on
top and bottom of gate to extend gate to fill door
opening. ONLY LIGHTLY TIGHTEN AND LEAVE
SHIPPING TABS IN PLACE NOT TO MAR GATE
FINISH. You will remove shipping tabs during final
tightening.
OPTION
ONE-WAY
STOP BRACKET
Install one-way stop bracket (I) on one side of
latch if you wish to have gate open in only one
direction.
I
6. Hold latch assembly (G) against opposite
wall and extend gate until at least ½ of
safety bracket will interlock with flange
of latch. Mark position of latch assembly
screw holes with pencil. Swing gate out
of way and mount latch assembly to wall.
Check closure of gate and tighten set
screws from STEP 5 by removing shipping
tabs to secure gate width.
GATE IS RECOMMENDED FOR CHILDREN UP TO 24 MONTHS.
GATE MAINTENANCE
When used outdoors we suggest spraying hinge and latch parts with a marine corrosion inhibitor
by CRC or equivalent. This can be obtained normally at marinas or auto parts stores. Remove
set screws when separating frames for cleaning. A stainless steel hardware set is available. Please
call for information.
To clean, rinse with lukewarm water, wash gently with mild soap or detergent and lukewarm water,
using a soft cloth or sponge. Rinse again. Dry with a soft cloth or sponge to prevent water spotting.
DO NOT SCRUB or use brushes or squeegees.
GATE CARE & REMINDERS
At CARDINAL GATES, INC., we design what we believe to be the very best, and most user
friendly gates available. Our gates are built to last many years with proper use and care. Here
are a few suggestions...
Close gates gently - do not slam - to prevent damage to latch mechanism.
When closing, be sure safety bracket on gate frame engages as depicted in instructions.
For safety, always close gate when not in use. Children should not be allowed to swing on an
open gate as this can damage hinge mount.
Keep allen wrench in a secure place. We suggest removing set screws when separating sections
for cleaning. Periodically check all screws, bolts, etc. for security and proper adjustment.
CARDINAL GATES, INC., offers many accessories such as extensions, stair kits, and other
safety products. Check with your dealer or call CARDINAL GATES, INC. at 1-800-318-3380.
We sincerely hope that you thoroughly enjoy many years of service from your CARDINAL GATE.
GATE WARRANTY
Your Cardinal Gate is warranted to be free of manufacturing defects for a period of one year
from the date of purchase when used in homes, and according to manufacturers instructions.
When used commercially, such as day care centers, the warranty is 90 days.
Cardinal Gates, lnc. will either repair or replace, at our option, any parts necessary to correct
defects in material or workmanship during the warranty period. The warranty disclaims liabilty
for incidental, special and consequential damages of any nature.
TO EXERCISE WARRANTY:
Ship your gate in a protective carton, freight prepaid to:
CARDINAL GATES, INC.
15 St. Johns Circle
Newnan, GA 30265
You must include the following:
1. Proof of purchase (store receipt, etc.).
2. Brief note describing problem with gate.
3. Full return address along with phone number.
FOR FURTHER ASSISTANCE
Call 1-800-318-3380
15 St. Johns Circle
Newnan, GA 30265
770-252-4200
www.cardinalgates.com
Loading...