Cardinal Gates CP30 User Manual
CLEAR GATE - MODEL CP30
FOR OPENINGS 26.5” (67cm) - 41.5” (105cm)
ASSEMBLY INSTRUCTIONS
A
B
C
1
D
A
C or J
6 ”
E
1. Install hinge bracket
(A) to wall (stationary
side of gate) using
Phillips screw (C)
beginning 6 ” above
floor surface. (Use
ruler on left edge of
this sheet to measure
from floor).
OPTION: Long
screws (J) maybe be
used to attach gate to
stud through dry wall.
E
3
G
F
2
4
H
K
C or J
B
2. Install second
screw (C) in
top of hinge
bracket
securing it to
the wall.
I
J
OPTION
ONE-WAY
STOP BRACKET
L
2X
NOTE: THIS SIDE OF GATE HAS
THREE (3) HOLES - ONLY USE TOP AND
BOTTOM HOLES FOR THIS STEP
3. Insert eye bolts with nut and washer (E)
into top and bottom of hinge side gate
(side with three holes). Be sure nuts are
tight. Do not use middle hole for this step.
5
G
6
F
I
4. Hang gate by inserting hinge rod (B), through top
of mounted hinge bracket (A), through upper plastic
shoulder washer (F), through both eye bolts, through
lower plastic shoulder washer (F), and finally through
bottom of hinge bracket. To secure hinge, insert
key ring (I) through hole in end of hinge rod.
K
D
H
2X
LOOSEN AT TOP AND
BOTTOM OF GATE TO
ADJUST GATE WIDTH
5. Use Allen wrench (G) to unscrew
set screws on top and bottom of
gate to extend gate. LEAVE
SHIPPING TABS IN PL ACE NOT TO
MAR GATE FINISH. You will remove
shipping tabs during final tightening.
OPTION
ONE-WAY
STOP BRACKET
IF GATE IS INSTALLED AT TOP OF STAIRCASE:
Install one-way stop bracket (L) on one side of
wall mount latch if you wish to have gate open in
only one direction.
OPTION
ONE-WAY
STOP BRACKET
6. Mount latch assembly (K) to gate using 3/4” bolts with serrated
washers (D). Attach wall mount for latch assembly (H) up
into part (K) that is now secure on gate. Slide gate out to
mark holes for (K) on attaching wall. (*OPTIONAL ONE WAY
BRACKET INSTALLED HERE) Then attach the wall mount of
latch assembly to wall using Phillips head screws (C).
L
D
SEE REVERSE
FOR GATE
OPERATION
INSTRUCTIONS
GATE IS RECOMMENDED FOR CHILDREN UP TO 24 MONTHS.
GATE OPERATION
FOR OPENING:
When approaching
gate, if latch is to your
left, use right hand.
Depress flip latches
simultaneously with
thumb and index
finger while lifting
gate with remaining
fingers of hand.
REMEMBER: Latch to right, use left hand; latch to left, use right hand
FOR CLOSING:
Grasp gate in
middle. Lift
gate and align
latch pins with
bracket holes.
Drop in place.
There is no
need to close
gate using flip
latches.
GATE MAINTENANCE
To clean, rinse with lukewarm water, wash gently with mild soap or detergent and lukewarm water,
using a soft cloth or sponge. Rinse again. Dry with a soft cloth or sponge to prevent water spotting.
DO NOT SCRUB or use brushes or squeegees.
GATE CARE & REMINDERS
At CARDINAL GATES, INC., we design what we believe to be the very best, and most user
friendly gates available. Our gates are built to last many years with proper use and care. Here
are a few suggestions...
• Close gates gently - do not slam - to prevent damage to latch mechanism.
• When closing, be sure safety bracket on gate frame engages as depicted in instructions.
• For safety, always close gate when not in use. Children should not be allowed to swing on an
open gate as this can damage hinge mount.
• Keep allen wrench in a secure place. We suggest removing set screws when separ ating sections
for cleaning. Periodically check all screws, bolts, etc. for security and proper adjustment.
CARDINAL GATES, INC., offers many accessories such as extensions, stair kits, and other
safety products. Check with your dealer or call CARDINAL GATES, INC. at 1-800-318-3380.
We sincerely hope that you thoroughly enjoy many years of service from your CARDINAL GATE.
GATE WARRANTY
Your Cardinal Gate is warranted to be free of manufacturing defects for a period of one year
from the date of purchase when used in homes, and according to manufacturers instructions.
When used commercially, such as day care centers, the warranty is 90 days.
Cardinal Gates, lnc. will either repair or replace, at our option, any parts necessary to correct
defects in material or workmanship during the warranty period. The warranty disclaims liabilty
for incidental, special and consequential damages of any nature.
TO EXERCISE WARRANTY:
Ship your gate in a protective carton, freight prepaid to:
CARDINAL GATES, INC.
79 Amlajack Way
Newnan, GA 30265
You must include the following:
1. Proof of purchase (store receipt, etc.).
2. Brief note describing problem with gate.
3. Full return address along with phone number.
FOR FURTHER ASSISTANCE
Call 1-800-318-3380
79 Amlajack Way
Newnan, GA 30265
770-252-4200
www.cardinalgates.com
Loading...