CAPKOLD WJ100-REF-A User Manual

CapKold Cook-Chill Production Systems

Cook Tanks & Chillers

Air Cooled Remote
Refrigeration Package

r WJ100-REF-A [For 100 Gal. WaterJet]

General Description:

Remote Refrigeration Package shall be a Model WJ100-REF-A self­contained air cooled unit consisting of a compressor, condenser coils,
two or more cooling fans and electrical control and safety subsystems;
contained in a corrosion resistant galvanized housing. Unit shall be
designed and sized to provide adequate water chilling capacity for the
WJ100 WaterJet Chiller and will come evacuated and nitrogen charged,
for use with R-22 refrigerant. Unit shall be suitable for exterior roof or
ground level installation.

Standard Features:

• Winterized for cold weather operation

• Semi-hermetic compressor

• Sealed high efficiency compressor, with crankcase heater

(Temperature limit - 20º F minimum)

• Compressor and condenser coils evacuated and nitrogen

charged. For use with R-22 refrigerant only

• Air cooled condensing unit and matching evaporator.

• Welded Pump-Down Receiver Tank with pressure relief valve

• Suction accumulator with factory installed refrigerant filter/dryer

with replaceable core

• Compressor Receiver Valves factory mounted.

• Compressor and control cabinet fully enclosed with corrosion

resistant galvanized panels

Control Package:

• Main Power Disconnect

• Head pressure control for all climate ambient

temperature operation

• Fuse/panel protection system

• Both Receiver Outlet & Liquid Outlet sight glasses

• Defrost heater contactors

• High/Low pressure control

• Flood type head pressure control

Remote Refrigeration Package: Air Cooled

Additional WaterJet Capabilities:

r For Water Cooled Package see CapKold spec. CK-84

Notes:

• WaterJet Remote Refrigeration Package is designed for outdoor

installation on a ground level pad or rooftop location. Contact
CapKold for any refrigeration piping run over 100 feet or
installation at any elevation higher than 10 feet above the WJ100

unit. Professional consultant and/or mechanical contractor

must determine suitability of installation site and provide for all
necessary site preparations.

• Refrigerant piping and electrical control wiring between the

WaterJet Tank unit and exterior mounted Refrigeration Package
must be installed by a licensed refrigeration contractor in
accordance with all applicable plumbing and electrical codes,
good practice and the detailed installation instructions provided
with both system components.

1055 Mendell Davis Drive, Jackson, MS 39272
888-994-7636, unifiedbrands.net

Please reference our website for the most
updated product information and specifications.

Groen CapKold Cook Tanks & Chillers, Page 23

CK-83 160664A

Revised 08/06

CK-83 WaterJet

160665 REV A

CAPKOLD

1055 Mendell Davis Drive, Jackson, MS 39272, 888-994-7636, unifiedbrands.net

© 2009 Unified Brands. All Rights Reserved. DOVER® and the DOVER® Logo are registered
trademarks in the United States [and various other countries] of Unified Brands, a
wholly-owned subsidiary of Dover Corporation.