Camerons Products MSC-2769-SLD User Manual
MSC-2769-SLD CAMERON
OWNER'S MANUAL
ASSEMBLY INSTRUCTION,CARE,
MAINTENANCE & USER'S GUIDE
",,,",,,
CAUTION
This unit is designed to be used safely by up 6 children between the age of 2
to 8, with a maximum weight of 100 pounds(45.4kgs) each, simultaneously,
not to exceed a combined weight of 600 pounds(272.72kgs).
WARNING
Please read this instruction manual before you start with the assembly or use this swing set.
You must follow all safety instructions while using this equipment; be absolutely sure that the surface, on which
this swing set is set up on, is properly surfaced with fine sand, wood chips or double shredded bark mulch. Do
not use this swing set on hard pack soil, concrete or any kind of hard surface. Read all cautionary statement on
page 1 - page 4, before using this equipment. Save this instruction manual for future reference.
CUSTOMER SERVICE:
DO NOT RETURN TO THE STORE,
PLEASE CALL
1-866-884-0535
Monday-Friday, 8:00AM-5:00PM Eastern Time
www.Sportspowercustomerservice.com
Sportspower Ltd
Flat M, 3/Floor, Kaiser Estate Phase 3, 11 Hok Yuen Street,
Hunghom, Kowloon, HongKong
USER'S GUIDE
1 [CAUTION!
]READ BEFORE USING THIS EQUIPMENT I
GENERAL INSTRUCTION
• Read this manual and follow all instructions before using and assembling this unit.
• Observing the following statements and warnings reduces the likelihood of serious fatal injury.
• Recommending on-site adult supervision for children of all ages at all times.
• This unit is designed to be used safely by up to 6 children between the age of 2 to 8, with a maximum
weight of 100 pounds (45.4 kgs) each, simultaneously, not to exceed a combined weight of 600 pounds
(272.72 kgs).
_WARNIN_Lawn swings is designed for use by children over two years of age. Use by children under the
age of two can result in entrapment between the seat and back areas. NEVER place children in rearward
facing position or with legs between the seat and backrest because the child's body may pass through the
opening causing entrapment of the child's head.
_WARNIN_ This unit must be assembled and disassembled by a capable adult person.
We suggest that you get someone to help.
Children must not use the equipment until properly assembled and anchored.
Always locate the swing set on level groundY
_WA_'_IN_ Do not allow swing set near any obstruction or sharp object ! Place gym set on level ground, not
less than 6ft (1.8m) from any structures or obstacles such as fence, garage, shed house, overhanging
branches, laundry line, electrical wires.
If the seats of swing, glide or slide are wet, do not use this equipment.
If any bolts & nuts are missing, do not use this equipment!
_WARNIN_ A capable adult should supervise the use of this equipment at all times. Do not allow reckless
playing, such as jumping off swing, slide, or Glide ride.
• Provide proper surface material cover for this equipment prior to using this equipment. See page 3 of this
manual for more information.
_WA_'_IN_ Do not allow more than one child to play on the swing, trapeze bar or slide at any one time.
Children shall take turns using the slide.
If the child has any physical condition that may affect his/her ability to use this equipment, one
shall consult a physician, before allowing the child to use this equipment.
,_WARNIN_ Do not allow child over the weight limit to use this equipment. Adults should never ride on any
of the rides, swing, trapeze or slide.
_WARNIN_ Do not allow child to stand on the swing seats or glide ride.
_WA_'_IN_ Instruct children not to walk too close in front of, behind, or between moving items. Instruct
children to keep a safe distance away to avoid being struck by items in play.
_WA_'_IN_ Instruct children not to twist swing chains or ropes or loop them over the top support bar since
this mac reduce the strength of the chain or rope.
_WARNIN_ Instruct children to avoid swinging empty play items.
_ Teach children to sit in the center of the swing play items, with their full weight in the seats.
_WARNINq Instruct children not to use the equipment in any manner other than intended.
_WARNIN_ Instruct children not to get off equipment while it is in motion. Do not allow children to jump
from moving play items.
_WA_IN_ Parent to dress children appropriately while on and around this equipment (Examples would
include the use of well fitting shoes and the avoidance of ponchos, scarves, jewelry and other loose fitting
clothing t]1at is potentially hazardous while using equipment).
_[_ WA_ING Do not allow children to climb or play on equipment when it is wet.
_WA_ING Do not stand on the lawn swing when using this ride. One child per seat only!
_WA_ING Check the openings between rollers and sliding surfaces of roller slides for foreign materials
that could be potentially hazardous to users.
• Please verify that suspended climbing ropes, chain, or cable are secured at both ends, and verify that
suspended climbing ropes, chain, or cable cannot be looped back on itself.
_WARNIN_ Instruct children not to attach items to the playground equipment that are not specifically
designed for use with the equipment such as but not limited to jump ropes, clothesline, pet leashes, cables
and chain as they may cause a strangulation hazard.
• It is recommended that the gym set be placed in concrete. Be certain that all anchoring devices ( including
concrete ) are placed below the level of the playing surface or below ground level to prevent tripping.
_WARNIN_ DO not allow children to lean to the side when riding on other rides, structural members on
collide with other playmates.
Do not install home playground equipment over concrete, asphalt, packed earth, grass, carpet, or
any other hard surface. A fall onto a hard surface can result in serious injury to the equipment user.
_WA_ING Do anchor all gyms.
_WA_ING If the swing set is set up on grounds with sandy soil condition, it must be anchored with
concrete footing (Concrete not included).
OPERATING INSTRUCTIONS
(WARNING THE BUYER)
Observing the following statements and warnings reduces the likelihood of serious or fatal injury.
This unit is designed to be used safely by up to 6 children between the age of 2 to 8, with a maximum
weight of 100 pounds (45.4 kgs) each, simultaneously, not to exceed a combined weight of 600 pounds
(272.7 kgs).
On-site adult supervision for children of all ages is recommended..
Instruct children not to walk close to, in front of, behind, or between moving items.
Instruct children not to twist swing chains or ropes or loop them over the top support bar since
this may reduce the strength of the chain or rope.
_ Instruct children to avoid swinging empty seats.
WARNING]
Teach children to sit in the center of the swings with their full weight on the seats,
Instruct children not to use the equipment in a manner other than intended,
Instruct children not to get off equipment while it is in motion.
_WA_IN_ Adult should dress children appropriately (examples would include the use of well-fitting shoes
and the avoidance of ponchos, scarfs, and other loose-fitting shoes and other loose-fitting clothing that is
potentially hazardous while using equipment).
_WA_IN_ Instruct children not to climb when the equipment is wet.
Please verify that suspended climbing ropes, chain, or cable are secured at both ends, and that
suspended climbing ropes, chain, or cable cannot be looped back on itself.
'_kWARNIN_ Instruct children not to attach items to the playground equipment that are not specifically
designed for use with the equipment, such as, but not limited to, jump ropes, clothesline, pet leashes,
cables and chain as they my cause a strangulation hazard.
Lawn swings, if applicable, are designed for use by children two years of age and older. The use by children
under the age of two can result in entrapment between the seat and back rest because the child's body may pass
through the opening, causing entrapment of the child's head. Such entrapment may result in strangulation.
NEVER place children in a rearward facing position or with legs between the seat and backrest.
_k WARNING Instruct children not to go down slide head first.
_WARNING Check slide bed for extreme heat before letting children use slide ( When exposed to direct
sunlight )
A /
AWARNIN_ Do not allow children to climb on swing from structural members (Legs, top bar and chin bar).
These are structural components only and NOT play features.
• If there is any cracked or damaged parts, do not use this equipment; call the 1-866-884-0535 number for
replacement part.
• Please save this instruction manual for future reference and review each season.
• Plastic components should be replaced every three years.
TIGHTENING NUTS & BOLTS
• At the start of assembling, do not tighten bolt/nut all the way, so to allow some possible adjustment, for
ease of installation.
• After all major components are assembled, go back over all bolts and nuts and properly tighten all of them
before using this product.
CARE & MAINTENACE INSTRUCTION
• Check all nuts and bolts twice monthly during the usage season for tightness and tighten as required. It
is particularly important that this procedure be followed at the beginning of each season.
• Oil all metallic moving parts monthly during the usage period.
• Sand rusted areas on metal tubing and repaint using a nonlead-based paint meeting the requirements of
Title 16 CFR Part 1303.
• Check swing seats, ropes, cables and chains monthly during usage season for evidence of deterioration.
Replacement should be made in accordance with manufacturer's instructions.
• Check all coverings for bolts and sharp edges twice monthly during usage season to be certain they are
in place. Replace when necessary. It is especially important to do this at the beginning of each new
season.
• Remove plastic swing seats slide and take indoors or do not use when temperature drops below 32
degrees F (0 degrees C).
Disposal Instructions
+ Please use with care to disassemble the unit, when it is no longer in operational condition. Wear
heavy duty working gloves!
+ Consumer may wish to recycle the steel tubing, please take the frame to your local recycling
center.
+ Be sure to completely disassemble the whole swing and slide sets, before disposal.
+ Do not leave partially disassembled equipment in area where accessible by children.
+ All plastic parts could be recycled, take it to your local recycling center.
+ All rusted parts, bolts shall be properly disposed of in trash bin. Do not reuse.
"_ Do not let children play with any disassembled parts destined for disposal, such as chain, slide,
tubings, bolts, nuts, screws!
IMPORTANT
CONSUMER INFORMATION SHEET
The Consumer Product Safety Commission estimates that about 100,000 playground equipment-
related iniuries resulting from falls to the ground equipment treated annually in U.S. hospital emergency rooms. Iniuries
involving this hazard pattern tend to be among the most serious of all playground iniuries, And have the potential to be fatal,
particularly when the iniury is to the head.
The surface under and around playground equipment can be a major factor in determining the iniury-causing potential of a fall.
It is self evident that a fall onto a shock absorbing surface is less likely to cause a serious iniury than a fall onto a hard surface.
Playground equipment should never be placed on hard surfaces such as concrete or asphalt and while grass may appear to be
acceptable it may quickly turn to hard packed earth in areas of high traffic. Shredded bark mulch, wood chips fine sand or fine
gravel are considered to be acceptable shock absorbing surface when installed and maintained at a sufficient depth under and
around playground equipment.
Table below lists the maximum height from which a child would not be expected to sustain a life-threatening head iniury in a
fall onto four different loose-fill surfacing materials if they are installed and maintained at depths of 6, 9, and 12 in.
FALL HEIGHT IN FEET FROM WHICH
A LIFE THREATENING HEAD INJURY WOULD NOT BE EXPECTED
TYPE OF MATERIAL 6INCH DEPTH 9INCH DEPTH 12INCH DEPTH
Double shredded bark mulch 6 10 11
Wood Chips 6 7 12
Fine Sand 5 5 9
Fine Gravel 6 7 10
However, it should be recognized that all iniuries due to falls can not be prevented no matter what surfacing material is used.
We recommend that a shock absorbing material should extend a minimum of 6ft in all directions from the perimeter of
stationary equipment such as climbers and slides. However, Because children may deliberately jump from a moving swing.
The shock absorbing material should extend in the front and rear of a swing a minimum distance of 2 times the height of the
pivot point measured from a point directly beneath the pivot on the supporting structure.
This information is intended to assist in comparing the relative shock-absorbing properties of various materials. No particular
material is recommended over another. However, Each material is only effective when properly maintained. Materials should
be checked periodically and replenished to maintain correct depth as determined necessary for your equipment. The choice of
a material depends on the type and height of the playground equipment. The availability of the material in your area and its
cost.
Note: The maximum fall height for this product is 6 feet. The minimum ground clearance between the bottom of the
suspended plays and the playing or ground service must be 8 inches.
YOU MUST MAINTAIN A MINIMUM OF 8 INCHES OF GROUND CLEARANCE
This information has been extracted from the CPSC publication on" Playground Safety". You can obtain more information by
sending a postcard to the: Office of public Affairs, U.S. Consumer Product Safety Commission, Washington, D.C. 20207.
HARDWARE (ACTUAL SIZE BUT FOR REFERENCE ONLY )
Hardware used for main frame assembly
,:LB1) BOLT 5/16"x63 4PCS _), BOLT 5/16"x63 12PCS
/7
• :<........................i f
\
\
)
/
/
//
\5
LBy NYLON NUT 5/16"
16PCS
Hardware used for swing seats assembly
/
'/J2"_' ARC WASHER
'\ //
4PCS
Hardware used for trapeze assembly
_ ARC WASHER
28PCS
i 2_ LARGE WASHER
4PCS
,_ LARGE WASHER
4PCS
'\ .........................../
/F-_\
J6 NYLONNUT 5/16"
k. /
8PCS
\
\
/
/
ii
\ //
",2;; "- .........
i_S5) ARC WASHER
2PCS
NYLON NUT
2PCS
Bracket used for glide ride assembly
\
/
/
_N_ BOLT 5/16"x25 2PCS
Hardware used for glide ride assembly
_} BOLT 1/4"x34 4PCS
/'i i\ Y,
'.\.._ ../ ,
@, NYLON NUT 5/16"
2PCS
,<__ BOLT 1/4"x48 2PCS
_',_, BOLT 1/4"x34 4PCS
_ NYLONNUT 1/4"
10PCS
_i_' ARC WASHER
4PCS
,@ SCREW O5.5x16 4PCS
/
f
_ CAP BOLT 1/4"x14 2PCS
f--\
(N10) SPRING WASHER
\\ /'
10PCS
Hardware used for slide assembly
f
'\ j
(Z_ BOLT 1/4"x34
,_ SMALL WASHER
6PCS
@ SPRING WASHER
12PCS
14PC S
_X BOLT 1/4"x96 2PCS
/ \
_5_' NYLON NUT 1/4"
14PCS
_gl BOLT 1/4"x59 2PCS
\./
/
, __ SMALL ARC WASHER
4PCS
Loading...