Cambro UPCHBD16002, UPCHT800, UPCHTD1600, UPCH400, UPCHW4002 User Manual

OWNER’S

MANUAL

This owner’s manual applies to all of the following product models:

Ultra Pan Carrier® H-Series

UPCH400
UPCH4002
UPCHW400
UPCHW4002

Ultra Camcart

UPCH800
UPCH8002
UPCHT800
UPCHT8002
UPCH1600
UPCH16002
UPCHT1600
UPCHT16002
UPCHTR1600
UPCHTR16002

®

H-Series

®

CAMBRO

ULTRA PAN CARRIER

ULTRA CAMCART

ELECTRIC HOT HOLDING

®

H-SERIES

®

H-SERIES

AND HEATED REPLACEMENT DOORS

UPCH400

UPCH800

Heated Replacement Doors ONLY
For Replacement
Or Retrofit Non-Electric Ultra Pan Carriers or Ultra Camcarts

Ultra Pan Carrier

UPCHD400
UPCHD4002

Ultra Camcart® H-Series

TOP DOORS

UPCHTD800, UPCHTD8002
UPCHTD1600, UPCHTD16002

BOTTOM DOORS

UPCHBD800, UPCHBD8002
UPCHBD1600, UPCHBD16002

Note: All models ending in “2” indicate 220V.
All instructions in this manual refer to both
110V and 220V models.

®

H-Series

UPCH1600

Table of Contents

I. Introduction .......................................................................................................................................................................................................... 2

II. Safety Instructions and Warnings ........................................................................................................................................................................ 2

III. Assembly and Exploded Views .............................................................................................................................................................................. 2

IV. Operating Instructions .......................................................................................................................................................................................... 3

V. Care & Maintenance ..........................................................................................................................................................................................3-4

VI. Electric Heated Door Kit Installation..................................................................................................................................................................4-5

(For replacement or to retrofit non-electric UPC400 Ultra Pan Carriers® and UPC800 or UPC1600 Ultra Camcarts®)

VII. Troubleshooting Guide .......................................................................................................................................................................................... 5

VIII. Replacement Parts ............................................................................................................................................................................................... 6

IX. Warranty and Service ........................................................................................................................................................................................... 6

I. Introduction

Congratulations on the purchase of your new Cambro Electric Hot Holding Ultra Pan Carrier or Ultra Camcart. This Owner’s Manual provides you with a step-by-step guide
to operating and maintaining your new insulated transporter. If you have any further questions, please contact your Cambro Sales Representative, visit www.cambro.com or
call our Customer Service Department at 800 833 3003 (International customers please call 714-848-1555).

II. Safety Instructions

IMPORTANT: Read all instructions prior to use and save for future reference.

• Follow all warnings marked on unit.

• Use only type of power supply (voltage, phase, frequency) indicated on the heater unit label.

• Do not use if power cord is frayed or damaged.

• Connect unit to properly grounded power source.

• Use only manufacturer authorized power cord and replacement parts.

• Warning! Do not use this equipment in wet or damp conditions.

• Warning! Unplug unit prior to cleaning or service.

• Warning! Remove power cord from heater prior to cleaning. Clean with damp cloth only.

• Warning! Do not submerge heater in water and never spray water on or near it.

• Warning! Unplug the power cord before removing the heater from the door.

• Warning! Only Cambro Authorized Service Agent or qualified foodservice equipment technician should open the inner cover of the heater for servicing.

• During normal operation, check the heater thumbscrews for tightness at least once a week.

• Any operating problems not identified and corrected by instructions in this manual should be referred to qualified service personnel

(electrician or foodservice equipment technician).

NOTE: For service please contact Cambro at 800-854-7631 X4118. Units under warranty should be serviced by Cambro Authorized Service Agent Only.

III. Assembly and Exploded Product Views

All UPCH400, UPCH800 and UPCH1600 products are factory assembled for your convenience. No assembly is required.

NOTE: Remove packing tape, tags or documents from inside compartments before operating.

Nylon
Washer
5ea.

Door Hinge

Knuckle

Heater

Hinge Pin

Thumb Screw

Hinge Pin

Door Latch

AC Inlet

Thermometer

Socket

Thermometer

AC Inlet
Opening

Digital
Thermometer

UPCH1600
Door

UPCH1600 Heater
110V or 220V Door

UPCH400 Diagram UPCH1600 Door Diagram

Nylon
Thumbscrew
5ea.

White
Door

Gasket

2