Cal Flame Charcoal Grill Owner's Manual
LTR20091086, Rev. A
8/18/09
Installation / Assembly.............4
Cabinet Cut-out Dimensions .............4
Placing Grill in a Barbecue Island.........5
Using Your Grill ...................6
Lighting Instructions...................6
Grilling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Cleaning and Maintenance .......... 8
Stainless Steel Care and Cleaning .......10
Cleaning the Interior of Your Grill .......11
Covering Your Grill ...................12
Appendix .......................13
Charcoal Grill Warranty................13
Replacement Covers ..................15
Copyright 2009 LMS, Inc. All rights reserved. Duplication without written
consent is strictly prohibited.
Cal Flame™ is registered trademark.
Due to continuous improvement programs, all models, operation, and/or
specications are subject to change without prior notice.
LTR20091086, Rev. A
8/18/09
www. ca ls pa s. co m
Safety Instructions
WARNING: Improper installation, adjustment,
alteration, service or maintenance can cause injury or
property damage. Read the installation, operating and
maintenance instructions thoroughly before installing or
servicing this equipment.
Carbon Monoxide Hazard
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill
you.
Never use this appliance in an enclosed space such as a camper, tent,
car, or home.
Placement and Location
C• al Flame grills are designed for outdoor use only.
Never locate this appliance in an enclosed room, under a sealed •
overhead structure, or in any type of enclosed area such as a garage, shed, or breezeway. Keep clear of trees and shrubs.
Do not place this grill under or near windows or vents that can be •
opened into your home.
Cal Flame grills are not intended for installation in or on recre-•
ational vehicles or boats.
Maintain sufcient distance as to not overheat any overhead com-•
bustible material such as a patio cover.
The area surrounding your new grill should be kept clean and free •
from ammable liquids and other combustible materials such as
mops, rags or brooms, as well as solvents, cleaning uids, and
gasoline.
Do not use the grill, grill cabinet, or area surrounding the grill as a •
storage area for ammable or plastic items.
1
Safety Instructions
Charcoal Grill
LTR20091086, Rev. A
2
www. c a l s p a s . c o m
Set-Up
Before installing built in grills in enclosures, copy all pro• duct in-
formation such as model number and serial number and store
information in a safe place. This information is located on a plate
located behind the grill and is visible when the hood is lowered or
on the right side of the chassis. There is an area on the back cover
of this manual where you can write down this information.
To prevent re and smoke damage, remove all packaging material •
before operating grill.
Safety Instructions
Before you start cooking, clean the entire grill thoroughly with hot, •
soapy water. This is necessary to remove residual solvents, oil and
grease used in the manufacturing process. The grates should also
be thoroughly cleaned in the same manner.
Operation
Do not use grill for oth• er than intended use.
Never use the grill if the drip pan is not properly installed. Drip •
pan should be pushed all the way to the rack located just under the
grill. Fire can result from an improperly installed drip pan.
Keep all electrical supply cords away from the heated areas of the •
grill.
Never leave the grill unattended when in use.•
Do not use water on grease res.•
Never allow clothing, pot holders or other ammable materials to •
come in contact with or be close to any grate or hot surface until
it has fully cooled. Never wear loose tting or hanging garments
while using your grill. Fabric may ignite and result in personal in-
jury.
When using the grill, do not touch the grill rack or immediate sur-•
roundings as these areas become extremely hot and can cause
burns.
Only use dry pot holders and do not use a towel or other bulky •
cloth in place of pot holders. Moist or damp pot holders used on
hot surfaces can cause burns.
Do not heat any unopened glass or metal container of food on the •
grill. Pressure may build up and cause the container to burst, pos-
sibly resulting in serious personal injury or damage to the grill.
Do not reach over your grill or any other surfaces when hot or in •
use.
Charcoal Grill
LTR20091086, Rev. A
3
www. c a l s p a s . c o m
Maintenance and Repair
Unless specically recommended in this manual, do not repair or •
replace any part of the grill. A qualied technician should perform
all service. Any repairs made by a non-L.M.S. approved dealer
technician will void your warranty.
Precautions Regarding Children
Never leave children unattended in the area where the grill is being •
used. Close supervision of children is necessary when any appliance is use near children.
Do not store items of interest to children around or below the •
grill.
Never allow children to sit or stand on any part of the grill.•
Safety Instructions
Charcoal Grill
LTR20091086, Rev. A
4
www. c a l s p a s . c o m
WIDTH
DEPTH
HEIGHT
Installation / Assembly
Most cities and counties require permits for exterior construction and
electrical circuits. In addition, some communities have codes requiring
residential barriers such as fencing and/or self-closing gates on property to prevent unsupervised access to the property by children under
the age of ve. Your dealer can provide information on which permits
may be required and how to obtain them prior to the delivery of your
equipment.
We recommend the installation, adjustment and service of your new
grill be performed by L.M.S. qualied installers and service technicians
to ensure proper operation and prevent accidents.
When determining a suitable location, consider factors such as expo-
Installation / Assembly
sure to wind, proximity to trafc paths, and windows that open into
the home.
Cabinet Cut-out Dimensions
Your Cal Flame grill is designed for easy installation into a non-combustible enclosure. The supporting deck or counter must be at and
level.
The dimensions are for both the regular charcoal grill and the charcoal
grill with convection and light.
Width Depth Height
30 ¾” 22 ¼” 9 ¼”
Charcoal Grill
LTR20091086, Rev. A
Loading...