Cal Flame BBQ08852P User Manual
Installation / Assembly
Cabinet Cut-out Dimensions.........................4
Gas Requirements and Connection ...................5
Leak Testing Procedure.............................6
LP Gas ..........................................7
Natural Gas ......................................9
Installing Side Burner with a Grill ...................10
Save these instructions!
Copyright 2009-2010 LMS, Inc. All rights reserved. Duplication without written consent
is strictly prohibited.
Cal Flame® is a registered trademark.
Due to continuous improvement programs,
all models, operation, and/or specications
are subject to change without prior notice.
LTR50001082, Rev. B
5/26/11
250-407
California Proposition 65 Warning:
Chemicals known to the State of
California to cause cancer, birth
defects or other reproductive
harm are found in and/or created by the combustion of natural
gas, propane, butane and other
fuels. Always operate this unit as
described in the owner’s manual
and in well ventilated areas.
www. c a l s p a s .c o m
Safety Instructions
WARNING: Improper installation, adjustment, altera-
tion, service or maintenance can cause injury or property
damage. Read the installation, operating and maintenance
instructions thoroughly before installing or servicing this
equipment.
Placement and Location
C• al Flame side burners are designed for outdoor use only.
Never locate this appliance in an enclosed room, under a sealed •
overhead structure, or in any type of enclosed area such as a garage, shed, or breezeway. Keep clear of trees and shrubs.
Do not place a side burner under or near windows or vents that •
can be opened into your home.
Cal Flame side burners are not intended for installation in or on •
recreational vehicles or boats.
Maintain sufcient distance as to not overheat any overhead com-•
bustible material such as a patio cover.
The area surrounding your new side burner should be kept clean •
and free from ammable liquids and other combustible materials
such as mops, rags or brooms, as well as solvents, cleaning uids,
and gasoline.
Do not use the side burner or area surrounding the side burner •
as a storage area for ammable or plastic items. Do not store the
liquid propane (LP) cylinder in the vicinity of this or any other appliance when it is not being used.
1
Safety Instructions
Set-Up
We recommend that a licensed contractor install your Cal Flame •
side burner. Installation must conform to local codes, or in the
absence of local codes, with either the National Fuel Gas Code,
ANSI Z223.1 / NFPA54, Natural Gas and Propane Installation
Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2), as applicable.
To prevent re and smoke damage, remove all packaging material •
before operating side burner.
Before you start cooking, clean the entire side burner thoroughly •
with hot, soapy water. This is necessary to remove residual solvents, oil and grease used in the manufacturing process. The
grates should also be thoroughly cleaned in the same manner.
Cal Flame Side Burners
LTR50001082, Rev. B
2
www. c a l s p a s .c o m
Operation
Do not use side burner for oth• er than intended use.
In the event that a burner goes out, turn burner knobs to the •
full OFF position and let it air out. Do not attempt to use the side
burner until the gas has had time to dissipate.
Keep all electrical supply cords and the rotisserie motor cord away •
from the heated areas of the side burner.
Never use the side burner in windy conditions. If used in a consis-•
Safety Instructions
tently windy area a windbreak will be required. Always adhere to
the specied clearances listed in this manual.
Never line the side burner with aluminum foil.•
When the unit is not in use, be sure to turn off the gas at the •
source.
When handling LP gas line and connectors, do not allow them to •
come in contact with any metal surfaces of the cart or cabinet. Do
not drop LP connectors.
Do not use solid fuel such as charcoal briquettes.•
Never leave the side burner unattended when in use. When using •
pots and pans, boil-overs will cause smoking and greasy boil-overs
may ignite.
Always use the proper size pan. Select utensils with at bottoms •
large enough to cover the burner. The use of under-sized utensils
exposes the sides of the utensils to direct contact with a portion
of the ame. This can scorch utensils and hamper cleanup. Exces-
sive ames on large stainless steel pots can result in permanent
discoloration. For best results, we recommend commercial quality
aluminum pans and utensils.
Always position handles of utensils so they do not extend over ad-•
jacent work areas or cooking areas. This reduces the risk of burns,
ignition of ammable materials, and spillage due to accidental contact with the utensils.
Do not use water on grease res. Never pick up a aming pan. •
Turn the appliance off and smother the aming pan with a tighttting lid, a cookie sheet or a at tray. For aming grease outside
of the pan, smother it with baking soda or use a dry chemical or
foam-type re extinguisher.
Never allow clothing, pot holders or other ammable materials •
come in contact with or be close to any grate, burner or hot sur-
face until it has fully cooled. Never wear loose tting or hanging
Cal Flame Side Burners
LTR50001082, Rev. B
3
www. c a l s p a s .c o m
garments while using your side burner. Fabric may ignite and result
in personal injury.
Only use dry pot holders and do not use a towel or other bulky •
cloth in place of pot holders. Moist or damp pot holders used on
hot surfaces can cause burns.
Do not heat any unopened glass or metal container of food on •
the side burner. Pressure may build up and cause the container to
burst, possibly resulting in serious personal injury or damage to
the side burner.
Do not reach over your side burner when hot or in use.•
Maintenance and Repair
Spiders and other i• nsects can nest in the burners of the side burner
and block the gas and airow to the burner ports. This creates a
dangerous condition that can result in a re behind the valve pan-
el. Inspect and clean the burners periodically and follow the guidelines in the Cleaning and Maintenance section of this manual.
Unless specically recommended in this manual, do not repair or •
replace any part of the side burner. A qualied technician should
perform all service. Any repairs made by a non-L.M.S. approved
dealer technician will void your warranty.
Storage
When your side burner is not in use, turn off the gas at the supply •
cylinder.
Safety Instructions
Precautions Regarding Children
Never leave children unattended in the area where the side burner •
is being used. Close supervision of children is necessary when any
appliance is use near children.
Do not store items of interest to children in the side burner.•
Never allow children to sit or stand on any part of the side burner.•
Cal Flame Side Burners
LTR50001082, Rev. B
Loading...