GPT1813G
Instruction Manual
Guide d’utilisation
1
Model/Modèle: 06695005
Portable Propane BBQ
Operators’ Manual p.2
Barbecue portatif au propane
Guide de I’utilisateur p.15
GPT1813G
Instruction Manual
Guide d’utilisation
2
Grill Operation 1-2-3
Before Grilling
Step 1 Keep your grill a safe distance away from your property.*
Step 2 Always perform a Leak Test on all connections. *
Step 3 Keep children away from the grill.
During Grilling
(To avoid tripping safety valves, please follow these instructions carefully.)
Step 1 First open lid and turn gas tank on slowly.
Step 2 This appliance will be hot during and after use. Use insulated oven mitts or gloves for
protection from hot surfaces or splatter from cooking liquids.
After Grilling
Step 1 Always burn grill for 10-15 minutes to burn off food residues after use.
Step 2 Wait until the grill is completely cooled before closing lid.
Step 3 Clean up grease build-up to avoid grease fire, and cover your grill to prevent rust.
* Please refer to the owner’s manual for details.
This instruction manual contains important information necessary for the proper assembly and safe use of the
appliance.
Read and follow all warnings and instructions before assembling and using the appliance.
Follow all warnings and instructions when using the appliance.
(Always keep this manual for convenient future reference).
WARNING
1. Do not store or use gasoli n e or
other flammable
liquids or vapour in
the vicinity of this or any other
appliance.
2.
An LP cylinder not connected for
use shall not be stored in the vi
cinity
of this or any other appliance.
3.
Use only 1-lb disposable propane
cylinders with this portable BBQ.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odour continues, keep away
from the appliance and
immediately call your gas
supplier or your fire
department.
DANGER
1. Never operate this appliance
unattended.
2. Never operate this appliance
within 10 ft (3 m) of any
structure, combustible material
or other gas cylinder.
3. Never operate this appliance
within 25 ft (7.5 m) of any
flammable liquid.
4. If a fire should occur, keep
away from the appliance an
immediately call your fire
department. Do not attempt to
extinguish an oil or grease fire
with water.
Failure to follow the instructions above could result in fire explosion or burn hazard which could cause property
damage, personal injury or death.
WARNING:
Imprope r installation,
adjustmen t, alteration, service
or maintenance can
cause
injury or
property damage.
Read the installation,
operation and maintenance
instructions thoroughly
before installing or
servicing
this equipment.
DANGER:
Failure to follow these
instructions could result
in fire or explosion that
could cause property
damage, personal
injury
or death.
DANGER:
DO NOT use gas grill
for
indoor cooking or
heating. TOXIC
fumes
can
accumulate and
cause asphyxiation.
DO NOT
use in or on
boats
or recreational
vehicles.
PROP 65 WARNING:
Chemicals known to
the
state of California
to
cause
many serious
diseases as cancer
are
created by
the
combustion of
propane.
WARNING:
FOR YOUR SAFETY:
For Outdoor Use Only (outside any enclosure).
GPT1813G
Instruction Manual
Guide d’utilisation
3
Table of Contents
For Your Safty ........................................................................................................3
Package Contents...................................................................................................5
Hardware
List..........................................................................................................6
Assembly Instructions........................................................................................6-9
Operating Your Grill
...............................................................................................9
Connecting Gas Cylinder.....................................................................................10
Checking
for
Leaks
...............................................................................................10
Lighting Your Grill
................................................................................................10
Excess Flow Safety Valve Reset Procedure
......................................................11
Care and Maintenance
..........................................................................................12
Tro ubleshooting....................................................................................................12
Replacement part list.............................................................................................13
Exploded view........................................................................................................14
Warranty Program..................................................................................................14
For Your Safety
Dear Valued Customer,
Congratulations on your new barbecue purchase! You’ve made the right choice. In this manual, you will find assembly
instructions, suggestions for
grilling and helpful hints, as well as guidelines for the safe operation , proper care and use of
your grill. Our expert staff strives to provide you with an easy-to-assemble product. Should you have any questi ons or
problems with this product, please call
our customer serv ice department at
1-855-630-5390, 7 A.M. – 4 P.M., EST,
Monday- Friday.
NOTE: The use and installation of this product must conform to local codes. In the absence of local codes, with either
the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58,
Natural Gas and Propane Installation Code, CSA B149.1, Propane Storage and Handling, CSA B149.2, or the Standard for
Recreational Vehicles, ANSI A119.2/NFPA 1192, and the Recreational Vehicle Code, CSA Z240 RV series, as applicable.
IMPORTANT NOTICE: READ ALL INSTRUCTIONS PRIOR TO ASSEM BL Y AND USE.
Safety First!
Read and understand all warnings and precautions prior to operating your grill.
WARNING
1.
Cylinders must be stored outdoors out of the reach of children and must not be stored in a building, garage or any other
enclosed area.
2.
The use of alcohol, prescriptio n or non-prescription drugs may impair an individual’s ability to properly
assemble or safely operate this appliance.
3.
Always open the grill lid carefully and slowly as heat and steam trapped within the grill could cause severe burns.
4.
Always place your grill on a hard and level surface far away from combustible materials and structures. An
asphalt or blacktop surface may not be acceptable for this purpose.
5.
Do not leave a lit grill unattended.
6. Keep children a nd pet s away from the grill at all times.
7.
Do not use the grill in high winds.
GPT1813G
Instruction Manual
Guide d’utilisation
4
8. This grill must be used with
1-lb disposable propane cylinders only.
9. Do not attempt to attach this grill to the self-contained propane system of a camper, trailer, motor home or house.
1 0 .
Do not use charcoal or lighter fluid.
11. Do
not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be constructed and
marked
in
accordance with the specifications for
LP-gas cylinder of the US Department of Transportation (DOT) or the
Standard for Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods, CAN/CSA-B339.
12. This outdoor gas appliance is not intended to be installed in or on recreation vehicl es and/or boats.
13. Do
not attempt to move the grill while it is lit.
14. Do
not use the grill unless it is COMPLETELY
assembled and all parts are securely fastened and tightened.
15. Keep combustible items and surfaces at least 50 inches (127 cm) away
from the grill at all times. DO NOT use this gas
grill
or any gas product under any overhead enclosure or near any unprotected combustible constructions.
16. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible ma terials,
gasoline and other flammable vapours and liquids.
17. Do not attempt to use or assemble with miss ing or damaged parts. Contact customer service fo r replacement part.
18.
Storage of an appliance indoor is permissible only if the cylinder is disconnected and removed from the appliance.
19.
This appliance is not intended for and should never be used as a heater.
Safe Locations For Use Of This Outdoor Grill
DANGER
Never use this outdoor grill inside any building, garage, shed or breezeway, or inside any boat, traile r o r recrea tiona l
vehicle to prevent a possible fire and to prevent the possibility of carbon monoxide poisoning or asphyxiation.
WARNINGS
Do not use this appliance under overhead combustible surface or covered area (e.g., awnings, umbrellas, porches or
gazeboes).
Always confirm that this grill is not positioned under the overhang of a house, a garage
or other structure before lighting it. An overhang will serve to deflect flare-ups and
radiated heat into the structure itself, which could result in a fire.
Always confirm that this grill is positioned more than 50 inches (127 cm) away
from any combustible materials or surface before lighting it, and that no gasoline
or other volatile substances are stored in the vicinity of this grill.
(see diagram to right). The temperature of a grease fire or of the radiated heat
might otherwise be sufficient to ignite nearby combustible or volatile substances.
Always locate this grill where there will be ample combustion and ventilation air. Do not obstruct the flow of combustion and
ventilation air, but never position it in the direct path of a strong wind.
Never allow the grill to operate while unattended to prevent uncontrolled grease fires from erupting.
Never attempt to move this grill while it is in operation or while it is still hot to prevent possible personal injury.
Never store or use gasoline or other flammable or volatile substances in the vicinity of this grill or in the vicinity of any other
heat-generating appliance because of the danger of starting a fire.
Always confirm that the installation of this grill conforms with the requirements of all local codes or, in the absence of
applicable local codes,
with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied
Petroleum Gases, ANSI/NFPA 58, Natural Gas and Propane Installation Code, CSA B149.1, Propane Storage and
Handling, CSA B149.2, or the Standard for Recreational Vehicles, ANSI A119.2/NFPA 1192, and the Recreational Vehicle
Code, CSA Z240 RV series, as applicable.
DANGER – Gas Safety
Liquid propane (LP) gas is flammable and hazardous if handled improperly. Become aware of its characteristics before
using any propane product.
•
Propane Characteristics: Flammable, explosive under pressure, heavier than air and settles in pools in low areas.
• In its natural state, propane has no odour. For your safety, an odorant h as been added.
• Contact with propane could cause freeze burns the skin.
•
This grill
has been designed to be used with
propane gas use only.
• Never use a propane cylinder with a damaged body, valve, collar or footing.
• Dented or rusted propane cylinders may be hazardous and should be checked by your propane gas supplier.
CAUTION
It is essential to keep the grill’s valve compartment, burners and circulating air passag es cl ean .
Inspect the grill before each use
.
Step 1. Inspect all connections and make certain they are secure.
Step 2. Check and clean the burner venturi tubes for insects and insect nests by removing the burner and inserting a
bottle brush cleaner into each tube to make sure the passage is clear.
*** A clogged tube can lead to a fire beneath the grill. ***
Step 3. Ensure that the valve nozzle is pointing straight and completely inserted into the venturi tube.
GENERAL INFORMATION
1. A
1-lb disposable
propane gas cylinder
is
required for operation.
2. This gas grill is NOT intended for commercial u
se.
50 inches
50 inches
GPT1813G
Instruction Manual
Guide d’utilisation
5
Package Contents
Part Description QTY Part Description QTY Part Description QTY
A
Lid handle 1 pc
F
Heat plate 1 pc
K
Right handle 1 pc
B
Lid 1 pc G Burner 1 pc L Body assembly 1 pc
C
Upper hinge 2 pcs
H
Regulator 1 pc M Left leg 1 pc
D
Lower hinge 2 pcs
I
Heat plate support 2 pcs
N
Right leg 1 pc
E
Cooking grid 1 pc
J
Left handle 1 pc
O
Grease cup 1 pc
GPT1813G
Instruction Manual
Guide d’utilisation
6
Hardware listed above is not scaled to exact size.
(A screwdriver is required on assembly and is included for your convenience).
Assembly Instructions
Remove all contents from the carton packaging. Make sure all parts
are present before
attempting assembly. Once the grill is f ully
assembled, go back and check to make certain all the bolts are
secure. Tighten again
using the screwdriv er provided if necessary.
Estimated Assembly
Time: 20 minutes.
AA: 1 PC
BB: 14 PCS
CC: 14 PCS
Wrench
M5 × 10 Bolt
M5 Lock Washer
DD: 14 PCS
EE: 14 PCS
FF: 1 PCS
Flat Washer
M5 Nut
M6 x 7 Bolt
GG: 7 PCS
HH: 7 PCS
II: 6 PCS
M6 Lock Washer
Flat Washer
M6 Nut
JJ: 1 PC KK: 2 PCS LL: 2 PCS
Screw Driver
R Pin
Lid Pin
Hardware Contents
Step 1
a) Align the holes on the right back side of body assembly (L) with the
holes on the lower hinge (D).
b) Insert one bolt (BB) into the pre-drilled hole, tighten with one flat
washer (DD
) one lock washer (CC) and one nut (EE)
c) Repeat the procedure for the left back side of body assembly.
d) Go back and tighten all the bolts using the screwdriver
provided.
GPT1813G
Instruction Manual
Guide d’utilisation
7
Step 2
a) Insert the venturi side of the burner (G) through the hole on
the right side of body.
b) Align the pre-drilled hole under the burner with the hole on
the bottom of body.
c) Insert one flat washer (HH
), one lock washer (GG) and one
bolt (FF) into the pre-drilled hole.
d) Tighten the bolt using the screwdriver provided.
e) Screw the regulator valve (H) into the threaded venturi tube
of the burner.
Step 4
a) Align the holes on the lower right front side and lower
right back side of the body assembly with the holes on
the right leg (N).
b) Insert one bolt (BB) into each pre-drilled hole and
tighten it with one flat washer (DD), one lock washer
(CC) and one nut (EE).
c) Repeat the procedure for the left leg (M).
d) Go back and tighten all the bolts using the screwdriver
provided.
Insert the ignition cable into the electrode
underneath the firebox.
Step 3
a) Align the holes on the left side of the firebox with
the holes on the heat plate support (I).
b) Insert the bolts on left handle (J) into each
pre-drilled hole and tighten with
one flat washer
(HH), one lock washer (GG), and one nut (II) in
sequence.
c) Repeat the procedure for the right handle (K)
and another heat plate support (I) with the right
side of the firebox.
d) Go back and tighten all the nuts using the
wrench provided.
e) Insert the ignition cable into the electrode
underneath the firebox. (See the figure on
the right).
GPT1813G
Instruction Manual
Guide d’utilisation
8
Step 5
a) Place the heat plate (F)
on the heat plate support.
b) Place the cooking grid (E)
over the heat plate and make
certain the cooking grid is clipped with the fastener.
Step 6
a) Insert the grease cup (O) into the two guides underneath the
grill and push forward until it is in place.
Step 7
a) Insert the pre-attached bolts on the lid
handle (A) into the holes on the front of the
lid and seal with one flat washer (HH), one
spring washer (GG), and one nut (II).
b) Align the holes on the back side of lid with
the holes on the upper hinge (C).
c) Insert one bolt (BB) into each pre-drilled
hole and seal with one flat washer (DD), one
spring washer (CC) and one nut (EE)
d) Go back and tighten all the bolts using the
screwdriver provided.
GPT1813G
Instruction Manual
Guide d’utilisation
9
Operating the Grill
CAUTION:
Use only the regulator provided. If a
replacement is necessary, call our customer service center. The use of
unauthorized parts
can create an unsafe condition and environment.
Right Side
Left Side
Fully Assembled View
Step 8
a) Align the holes on the upper hinges
on the back of the lid with the holes
of the lower hinges on the back of the
body.
b) Insert one lid pin (LL) into each hole.
c) Insert one R pin (KK)
into the hole on
the front of the lid pin.
Step 9
a) Screw the gas cylinder clockwise into the thread underneath
the regulator valve until it is in place.
b) Make certain the connection is secure and conduct the leak
test on page 10.
Loading...