Brinkmann Charcoal Grill User Manual [en, es]
OWNER’S MANUAL /
MANUAL DEL PROPIETARIO
ASSEMBLY AND OPERATING INSTRUCTIONS
INSTRUCCIONES DE ENSAMBLAJE Y OPERACIÓN
WARNING
READ AND FOLLOW ALL WARNINGS AND
INSTRUCTIONS IN THIS MANUAL TO AVOID
PERSONAL INJURY OR PROPERTY DAMAGE.
ADVERTENCIA
PARA EVITAR LESIONES PERSONALES Y
DAÑOS MATERIALES LEA Y OBEDEZCA TODAS
LAS ADVERTENCIAS E INSTRUCCIONES QUE
APARECEN EN ESTE MANUAL
Important Safety Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2–3
Parts List and Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4–12
Operating Grill and Lighting Instructions . . . . . . . . . . . . . . . . . . . . . . . . . 13–14
Regulating Heat and Adding Charcoal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
After-Use Safety and Proper Care & Maintenance . . . . . . . . . . . . . . . . . . . . 15
Warranty Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Back Cover
TABLE OF CONTENTS
DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
WARNING: Be alert to the possibility of serious bodily injury if the instructions are not followed. Be sure to read and
carefully follow all of the messages.
CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.
1
FOR COVERS, ACCESSORIES AND OTHER PRODUCTS, PLEASE VISIT US ONLINE AT:
www.brinkmann.net
FOR GRILL WARRANTY REPLACEMENT PARTS, PLEASE VISIT US AT:
www.grillpartsonline.com
2
IMPORTANT SAFETY WARNINGS
WE WANT YOU TO ASSEMBLE AND USE YOUR GRILL AS SAFELY AS POSSIBLE.
THE PURPOSE OF THIS SAFETY ALERT SYMBOL
IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR GRILL.
WHEN YOU SEE THE SAFETY ALERT SYMBOL, PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS!
READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING AND OPERATING YOUR GRILL.
• Only use this grill on a hard, level, non-combustible, stable surface (concrete, ground, etc.) capable of supporting the
weight of the grill. Never use on wooden or other surfaces that could burn.
• DO NOT use grill without charcoal ash cup in place. DO NOT attempt to remove charcoal ash cup while cup contains
hot coals.
• Proper clearance of 10 feet between the grill and combustible material (bushes, trees, wooden decks, fences,
buildings, etc.) or construction should be maintained at all times when grill is in use. Do not place grill under a roof
overhang or other enclosed area. Not adhering to these clearances will prevent proper ventilation and may increase the
risk of a fire and/or property damage, which could also result in personal injury.
• For outdoor use only. Do not operate grill indoors or in an enclosed area.
• For household use only. Do not use this grill for other than its intended purpose.
• We recommend the use of a Charcoal Chimney Starter to avoid the dangers associated with charcoal lighting fluid. If
you choose to use charcoal lighting fluid, only use lighting fluid approved for lighting charcoal. Carefully read manufacturer’s warnings and instructions on the charcoal lighting fluid and charcoal prior to the use of their product. Store
charcoal lighting fluid safely away from grill.
• When using charcoal lighting fluid, allow charcoal to burn with grill lid open until covered with a light ash
(approximately 20 minutes). This will allow charcoal lighting fluid to burn off. Failure to do this could trap fumes from
charcoal lighting fluid in grill and may result in a flash fire or explosion when lid is opened.
• Never use charcoal that has been pre-treated with lighter fluid. Use only a high grade plain charcoal or charcoal/wood
mixture.
• Do not use gasoline, kerosene or alcohol for lighting charcoal. Use of any of these or similar products could cause an
explosion possibly leading to severe bodily injury.
• Never add charcoal lighting fluid to hot or even warm coals as flashback may occur causing severe burns.
• Place grill in an area where children and pets cannot come into contact with unit. Close supervision is necessary when
grill is in use.
• Do not leave grill unattended when in use.
• When adding charcoal, use extreme caution and follow instructions in “Adding Charcoal During Cooking” section of this
manual.
• Do not store or use grill near gasoline or other flammable liquids, gases or where flammable vapors may be present.
• Use caution when adjusting charcoal grate height. Handle may be hot when in use.
Grill is hot when in use. To avoid burns:
• DO NOT attempt to move the grill.
• Wear protective gloves or oven mitts when adjusting cooking grill, ash cup or charcoal grate height.
• DO NOT touch any hot grill surfaces.
• DO NOT wear loose clothing or allow hair to come in contact with grill.
WARNING
3
• When grilling, grease from meat may drip into the charcoal and cause a grease fire. If this should happen close lid to
suffocate the flame. Do not use water to extinguish grease fires.
• Use caution since flames can flare-up when fresh air suddenly comes in contact with fire. When opening the lid, keep
hands, face and body a safe distance from hot steam and flame flare-ups.
• Never place more than 15 pounds on side tables. Do not lean on the side tables.
• Do not exceed a temperature of 400°F. Do not allow charcoal to rest on the walls of grill. Doing so will greatly reduce
the life of the metal and finish of your grill.
• Use caution when assembling and operating your grill to avoid scrapes or cuts from sharp edges of metal parts. Use
caution when reaching into or under grill.
• When opening lid, make sure it is pushed all the way open. If lid is not fully open, it could fall back to a closed position
and cause bodily injury.
• In windy weather, place grill in an outdoor area that is protected from the wind.
• Close lid to suffocate flame.
• Never leave coals and ashes in grill unattended. Before grill can be left unattended, remaining coals and ashes must be
removed from grill. Use caution to protect yourself and property. Carefully place remaining coals and ashes in a
non-combustible metal container and saturate completely with water. Allow coals and water to remain in metal
container 24 hours prior to disposing.
• Extinguished coals and ashes should be placed a safe distance from all structures and combustible materials.
• With a garden hose, completely wet the surface beneath and around grill to extinguish any ashes, coals or embers
which may have fallen during the cooking or cleaning process.
• After each use, clean the grill thoroughly. Cover the grill to protect it from excessive rusting.
• Use caution when lifting or moving grill to prevent strains and back injuries.
• We advise that a fire extinguisher be on hand. Refer to your local authority to determine proper size and type of fire
extinguisher.
• Accessory attachments not manufactured by The Brinkmann Corporation for this particular product are not
recommended and may lead to personal injury or property damage.
• Store the grill out of reach of children and in a dry location when not in use.
• Do not attempt to service grill other than normal maintenance as explained in “After-Use Safety” and “Proper Care &
Maintenance” sections of this manual.
• Properly dispose of all packaging material.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR GRILL.
FAILURE TO ADHERE TO SAFETY WARNING AND GUIDELINES IN THIS MANUAL COULD RESULT
IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
WARNING
Qty.
Qty.
PARTS BAG CONTENTS
32 M5 X 12 Bolts
2 Cotter Pins
6 M6 X 12 Bolts
2 M5 Wing Nuts
9 M6 Washers
Make sure you have all items listed under PARTS LIST and PARTS CARD CONTENTS
before you begin the installation process.
PARTS CARD CONTAINS:
6 M6 Nuts
12 M5 Nuts
2 Hinge Pins
4 M5 X 35 Bolts
Hinge Pins
4
M5 X 12 Bolts
Cotter Pins
M6 Washers
M6 X 12 Bolts
M5 Wing Nuts
M6 Nuts
M5 Nuts
M5 X 35 Bolts
5
ASSEMBLY INSTRUCTIONS
READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING OR OPERATING YOUR GRILL.
WE RECOMMEND TWO PEOPLE WORK TOGETHER WHEN ASSEMBLING THIS UNIT.
The following provided tools are required to assemble this Grill:
• Flathead Screwdriver
• Hex Nut Wrench
PARTS LIST:
1 Right Side Table
1 Left Side Table Front Panel
1 Control Panel
1 Right Side Table Front Panel
1 Front Panel
1 Ash Cup
1 Axle with M10 Lock Nuts
2 Wheels
2 Hubcaps
4 Hood/Grill Body Hinges
1 Hood Handle
1 Thermometer
1 Hood
1 Warming Rack
1 Cooking Grill
1 Grill Body Assembly
1 Left Side Table
1 Left Leg Frame
1 Back Panel
1 Height Adjustment Knob
1 Right Leg Frame
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
21
20
6
1
3
6
9
8
7
15
13
11
12
14
20
19
16
4
5
10
17
18
21
(Proof of purchase will be required.)
Inspect contents of the box to ensure all parts are included and undamaged.
FOR COVERS, ACCESSORIES AND OTHER PRODUCTS, PLEASE VISIT US ONLINE AT:
www.brinkmann.net
FOR GRILL WARRANTY REPLACEMENT PARTS, PLEASE VISIT US AT:
www.grillpartsonline.com
2
GRATE
L
A
CO
CHAR
NT
TME
ADJUS
HT
EIG
H
,
E
C
N
A
T
IS
S
S
A
R
O
F
17
07
-
7
2
-5
0
0
8
L
L
A
C
m
o
.c
e
n
i
l
n
o
rts
pa
l
il
r
.g
w
w
w
OR
O
OUTD
OR
F
Y
L
N
O
SE
U
Choose a good, cleared assembly
area and get a friend to help you put
your grill together. Lay cardboard
down to protect grill finish and
assembly area.
CAUTION: Some parts may
contain sharp edges.
Wear protective gloves
if necessary.
Step 1
Assemble front panel, back panel,
right leg frame and left leg frame
using eight M5 X 12mm bolts as
illustrated.
Step 2
Remove the M10 lock nuts from
each end of the axle. Install the
wheels by inserting the wheel
axle through right side leg frame
axle holes. Insert wheels over
axle and secure wheels with M10
lock nuts. Then attach hubcaps to
wheels as shown.
Step 3
Attach right side table to right leg
frame using six M5 X 12mm bolts.
Repeat for left side table.
7
Step 4
Attach control panel to frame
assembly using four M5 X 35mm
bolts and M5 nuts as shown.
Step 5
Attach right side table front panel to
the right side table and control panel
using three M5 X 12mm bolts and
M5 nuts. Repeat for left side table
front panel.
8
CH
A
RC
OAL
G
RA
T
E
HE
IGH
T
A
DJU
S
TM
E
N
T
F
O
R
A
S
S
I
S
T
A
N
C
E
,
C
A
L
L
8
0
0
-
5
27
-
0
7
1
7
w
w
w
.
g
r
i
l
lp
a
r
t
s
o
n
li
n
e
.
c
o
m
F
OR OUTDOOR
USE ONLY
CH
A
RC
O
AL
G
RA
T
E
HE
I
GH
T
A
D
JU
S
TM
E
N
T
F
O
R
A
S
S
I
S
TA
N
C
E
,
C
A
L
L
8
0
0
-
5
27
-
0
7
1
7
w
w
w
.
g
r
i
llp
a
r
t
s
o
n
lin
e
.
c
o
m
F
OR
OUTDOOR
USE O
N
LY
Step 6
Attach grill body hinges to grill body
using two M6 X 12mm bolts, M6
washers and M6 nuts.
Step 7
Attach hood hinges to hood using
four M6 X 12mm bolts, M6 washers
and M6 nuts.
Step 8
Set grill hood on grill body, align the
hinge holes. Insert the hinge pins
through holes and secure hinge
pins with cotter pins.
9
Loading...