Brinkmann 810-7080-t Owner's Manual

OWNER’S MANUAL / MANUAL DEL PROPIETARIO

ASSEMBLY AND OPERATING INSTRUCTIONS

INSTRUCCIONES DE ARMADO Y OPERACIÓN

SAVE THIS MANUAL FOR FUTURE REFERENCE

GUARDE ESTE MANUAL PARA REFERENCIA FUTURA

NOTICE TO INSTALLER:

LEAVE THESE INSTRUCTIONS WITH THE GRILL OWNER FOR

FUTURE REFERENCE.

AVISO PARA EL

INSTALADOR:

ENTREGUE ESTAS

INSTRUCCIONES AL PROPIETARIO

DE LA PARRILLA PARA REFERENCIA FUTURA.

WARNING/ADVERTENCIA

HAZARDOUS EXPLOSION MAY RESULT IF THESE WARNINGS AND INSTRUCTIONS

ARE IGNORED. READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS IN THIS

MANUAL TO AVOID PERSONAL INJURY, INCLUDING DEATH OR PROPERTY DAMAGE.

SE PUEDE PRODUCIR UNA EXPLOSIÓN PELIGROSA SI SE HACE CASO OMISO A

ESTAS ADVERTENCIAS E INSTRUCCIONES. LEA Y SIGA TODAS LAS ADVERTENCIAS

E INSTRUCCIONES EN ESTE MANUAL PARA EVITAR LESIONES PERSONALES,

INCLUSO LA MUERTE, O LOS DAÑOS MATERIALES.

7085-K_Gour Elec_Eng-SP.qxd 11/1/07 2:28 PM Page 2

IMPORTANT SAFEGUARDS

WE WANT YOU TO ASSEMBLE AND USE YOUR SMOKER AS SAFELY AS POSSIBLE.

THE PURPOSE OF THIS SAFETY ALERT SYMBOL

IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR SMOKER.

WHEN YOU SEE THE SAFETY ALERT SYMBOL, PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS!

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY

BEFORE ASSEMBLING AND OPERATING YOUR SMOKER.

WARNING

• This smoker is to be used outdoors only. Do not operate this smoker indoors or in an enclosed area.

• Do not use this smoker in the rain or on wet surfaces. Do not immerse cord, plug or electric element in water or other liquids. Keep this smoker and all electrical appliances away from swimming pools, hot tubs, etc. Hazard of electrical shock if used on a wet surface, in the rain or if appliance has been exposed to moisture.

• For household use only. Do not use this product for other than its intended purpose.

• To prevent accidental electrical shock, this smoker should always be used on a GFCI (Ground Fault Circuit Interrupter) outlet or circuit.

• Always use a 3-wire grounded outlet wired for 120 volts which is GFCI protected at 15 or 20 amps. If in doubt, contact a qualified electrician. Do not operate this smoker with any other appliance or electrical device on the same circuit.

• The smoker is turned “ON” by plugging cord into electric outlet. There is no ON/OFF control switch. Before plugging unit into electric outlet, smoker should be completely set up with flavoring wood in place, liquid in water pan, meat on grills and dome lid on smoker. Always turn the unit “OFF” by unplugging cord from outlet when adding water and wood or when finished cooking.

• Do not use an extension cord unless absolutely necessary. If you must use one, the following care should be exercised: a. Use the shortest length possible. Use a 12/3 or 14/3 grounded-type extension cord with a rating of at least 15 amps. b. The cord should be marked with suffix letter “W-A” and with a tag stating “Suitable for Use with Outdoor Appliances.” c. Keep cord connection dry and off the ground. Appliance and/or extension cord should be placed in such a manner so it will not

be tripped over, tugged on by children or pets. Do not allow cord to touch hot surfaces.

• Do not operate this smoker if: a. The cord or plug is damaged. b. The electric element has been damaged in any manner. c. The smoker has malfunctioned. d. The smoker has been exposed to moisture or if grease and drippings were not cleaned from element after each use. Refer to

“Proper Care & Maintenance” section of this manual.

e. There is any damage to the smoker. (Return the smoker with prior return authorization number to The Brinkmann Corporation

for examination, repair or replacement.)

f. The GFCI circuit trips when the electric element is plugged into the electric outlet.

• Proper clearance of 5 feet between the smoker and combustible construction should be maintained at all times when this product is in use.

• In windy weather, this product should be located in an outdoor area that is protected from the wind.

• Do not leave smoker unattended when in use.

• Do not place smoker on or near a gas or electric burner, or a heated oven.

• Do not store or use smoker near gasoline or other flammable liquids, gases or where flammable vapors may be present.

• Use smoker only on a hard, level, noncombustible, stable surface (concrete, ground, etc.). Never use smoker on wooden or other surfaces that could burn.

• A drip pan/ash guard will not prevent fires from occurring on a wooden or other combustible surface. A drip pan/ash guard is designed for use with a smoker for easy clean up of drippings that can cause discoloration of surface and to catch falling ashes and embers.

• Smoker should be placed in an area where children and pets cannot come into contact with unit. Close supervision is necessary when this smoker is in use.

7085-K_Gour Elec_Eng-SP.qxd 11/1/07 2:28 PM Page 3

WARNING

• Use caution when reaching into or under smoker. Always wear oven mitts/gloves to protect your hands from burns. Avoid touching hot surfaces.

• Base pan should never be touched or moved while smoker is in operation or if still hot.

• The side door is for viewing purposes and adding water to water pan ONLY. Never add wood or any other material through the side door. When opening door, stand back and use caution to avoid burns from steam, flame flare-ups or splashes from hot water.

• Do not wear loose clothing or allow hair to hang freely when operating smoker.

• Always wear shoes when operating smoker.

• When in operation, smoker contains hot liquid in water pan. Extreme caution should be used at all times. Do not move smoker when water pan contains hot liquids. Tilting or other slight movement could cause hot liquid to spill from water pan causing serious bodily injury.

• When lifting the dome lid, keep hands, face and body safe from hot steam or possible flame flare-ups. Always lift the dome lid off the smoker by tilting the dome lid toward you to allow hot steam to escape away from your face. Should a flame flare-up occur, replace dome lid and unplug smoker to smother flame. Do not use water to extinguish flames.

• Use extreme caution when adding liquid to water pan being careful not to spill any liquid onto electric element. Always unplug smoker before adding water. Follow instructions in “Adding Water During Cooking" section of this manual.

• Water pan should always be used when smoking. Do not allow liquid in water pan to completely evaporate. Check water pan every 2 hours and add water if level is low (a sizzling sound may indicate a need for water). Follow instructions in “Adding Water During Cooking” section of this manual.

• Use a sufficient amount of flavoring wood to avoid having to remove smoker body from base pan during the cooking process. This will limit the danger of spilling hot liquid from the water pan which could cause serious bodily injury.

• Use caution when assembling or operating your smoker to avoid cuts or scrapes from sharp edges of metal parts.

• Never add charcoal, lighter fluid, fuel or material of any kind, other than flavoring wood to the base pan where the electric element and lava rocks are housed. Place wood chunks on lava rocks away from the electric element.

• Unplug the smoker from electric outlet when not in use. Allow smoker to cool completely before cleaning. Make sure embers are completely extinguished. Dispose of remaining embers and ashes in a noncombustible container. Do not allow ashes to build up in smoker.

• Do not use the smoker if the electric element has been exposed to moisture, grease and drippings, or if there is excessive ash buildup on the lava rock. Do not clean electric element with a water spray or the like. Failure to adhere to this safety warning could result in the electric element shorting out and in some cases, exploding. Clean the Electric element and lava rocks as instructed in the “Proper Care and Maintenance” section of this manual.

• Store the smoker indoors in a dry location when not in use–out of the reach of children.

• Accessory attachments not manufactured by The Brinkmann Corporation for this smoker are not recommended and may lead to personal injury or property damage.

• Use caution when lifting or moving smoker to prevent strains and back injuries.

• We advise that you have a fire extinguisher designed for use with electrical appliances on hand. Refer to your local authority to determine proper size and type of fire extinguisher.

• Do not attempt to service smoker other than normal maintenance as explained in “After-Use Safety and Proper Care & Maintenance” sections of this manual. Repairs should be performed by The Brinkmann Corporation only.

• Properly dispose of all packaging material.

USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR SMOKER.

FAILURE TO ADHERE TO SAFETY WARNING AND GUIDELINES IN THIS MANUAL COULD RESULT

IN BODILY INJURY OR PROPERTY DAMAGE.

SAVE THESE INSTRUCTIONS

7085-K_Gour Elec_Eng-SP.qxd 11/1/07 2:28 PM Page 4

Tools required to assemble your Gourmet Electric Smoker and Grill:

• Flathead Screwdriver

• Pliers

PARTS LIST:

1 Dome Lid

1 Smoker Body

2152" Chrome Cooking Grills

1 Porcelain Water Pan

1 Base Pan

1 Lava Rock Pan

1 Electric Element

1 Door with Latch

1 Door Hinge

3 Metal Brackets for Handles

6 Wooden Handle Halves

3 Upper Support Brackets (Single Clip)

3 Lower Support Brackets (V Clip)

1 Bag Lava Rocks

12 10-24 x s" Screws and Square Nuts

6 6-32 x 4" Screws and Nuts (for Door)

6 8-32 x w" Screws and Nuts (for Handles)

Wood Chunk (sample)

ASSEMBLY INSTRUCTIONS

READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY

BEFORE ASSEMBLING OR OPERATING YOUR SMOKER.

FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 800-527-0717.

(Proof of purchase will be required.)

Inspect contents of the box to ensure all parts are included and undamaged.

7085-K_Gour Elec_Eng-SP.qxd 11/1/07 2:28 PM Page 5

STEP 1

a. Attach wooden handle halves to metal brackets using 8-32 x w"

screws and nuts as illustrated.

b. Attach two handle assemblies to side of smoker body using

10-24 x s" screws and square nuts as illustrated.

c. Attach the three lower support brackets (V-clips) to inside of smoker

body through the three 4" holes that are located about halfway down the smoker body (lower level). Mount each bracket with notched side facing up using 10-24 x s" screws and square nuts. Tighten screws securely.

d. Attach the three upper support brackets (single clips) to inside of

smoker body through the three 4" holes located near the top edge. Mount each bracket with notched side facing up using 10-24 x s" screws and square nuts. Tighten screws securely.

STEP 2

a. Attach hinge to inside of smoker body as illustrated. Use

6-32 x 4" screws and nuts to attach hinge to smoker body. NOTE: Attach the hinge so pin is facing out of smoker as illustrated.

b. Attach door to hinge using the remaining 6-32 x 4" screws and nuts.

Pin Facing Out

Upper support bracket

with notched side

facing up.

Lower support bracket

(V-clip) with notched

side facing up.

7085-K_Gour Elec_Eng-SP.qxd 11/1/07 2:28 PM Page 6

STEP 3

a. Place lava rock pan inside base pan and align the hole in the side of

each pan.

b. Working from the inside of the lava rock pan, feed the cord of the

electric element through the aligned holes until the back plate of the electric element is resting against the wall of the lava rock pan. Empty the entire bag of lava rocks into the pan and spread evenly.

c. Lift the electric element up and position it on top of lava rocks. Keep the

back plate of the electric element flush against wall of lava rock pan.

STEP 4

a. Place water pan inside smoker body on top of lower support brackets.

Position water pan so the rim is resting securely on notched out step of all three support brackets. Place smoker body on base pan.

b. Place a cooking grill on the lower support brackets directly above

water pan.

c. Place a cooking grill on the upper support brackets so the outer rim is

resting securely on notched out step of all three support brackets.

STEP 5

a. Attach the handle assembly on top of dome lid using 10-24 x s"

screws and square nuts.

b. Place dome lid on upper support brackets of smoker body.

NOTE: The dome lid is not designed to fit snugly in the smoker body.

The gap between dome lid and smoker body allows proper air draft.

YOUR GOURMET ELECTRIC SMOKER IS NOW COMPLETELY ASSEMBLED.

Before first use and after cleaning, apply a light coat of vegetable oil or vegetable cooking spray to the interior surface of the dome lid, smoker body, cooking grills and water pan. This simple process will help reduce interior rusting. DO NOT apply oil to the base pan or electric element.

READ ALL SAFETY WARNINGS AND OPERATING INSTRUCTIONS

PRIOR TO USING YOUR SMOKER.

7085-K_Gour Elec_Eng-SP.qxd 11/1/07 2:28 PM Page 7

OPERATING INSTRUCTIONS

PLACE THE SMOKER OUTDOORS ON A HARD, LEVEL, NON-COMBUSTIBLE SURFACE

AWAY FROM ROOF OVERHANG OR ANY COMBUSTIBLE MATERIAL. NEVER USE ON WOODEN OR OTHER SURFACES THAT

COULD BURN. PLACE THE SMOKER AWAY FROM OPEN WINDOWS OR DOORS TO PREVENT SMOKE FROM ENTERING YOUR

HOUSE. IN WINDY WEATHER, PLACE THE SMOKER IN AN OUTDOOR AREA THAT IS PROTECTED FROM THE WIND.

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY

BEFORE OPERATING YOUR SMOKER.

1. remove dome lid and smoker body from base pan.

2. Place flavoring wood on lava rock near the electric element. Refer to “Flavoring Wood” section for recommended amount of flavoring wood to use.

NOTE: Do not place the flavoring wood directly on the electric element.

This could cause flame flare-up and failure of the electric element.

3. Place empty water pan inside smoker body on the lower support brackets. Position water pan so rim is resting securely on notched out step of all three support brackets.

1" (2.5 cm)

FOLLOW THESE STEPS BEFORE PLUGGING SMOKER INTO ELECTRIC OUTLET.

Prior to first use, cure your smoker to minimize damage to the exterior finish as well as rid the smoker of paint odor that can impart unnatural flavors to the first meal prepared. Cure your smoker periodically throughout the year to protect against rust.

1. Remove water pan from smoker and leave out during curing process. Lightly coat all interior surfaces of the smoker, dome lid and cooking grill’s with vegetable oil or vegetable oil spray. Do not coat lava rock pan, lava rock or electric element.

NOTE: Do not use flavoring wood while curing your smoker.

2. With the dome lid on smoker, plug the smoker into electric outlet.

WARNING: Always use a 3-wire grounded outlet wired for 120-volts

which is GFCI protected at 15 or 20 amps. If in doubt, contact a qualified electrician. Do not operate this smoker with any other appliance or electrical device on the same circuit.

3. Cure smoker for three hours, then unplug smoker from electric outlet. Allow smoker to cool completely. It is important that the exterior of the smoker is not scraped or rubbed during the curing and cooling process.

IMPORTANT: To protect your smoker from excessive rust, the unit must

be cured periodically and covered at all times when not in use. A smoker cover may be ordered directly from Brinkmann by calling 1-800-468-5252.

Curing Your Smoker

7085-K_Gour Elec_Eng-SP.qxd 11/1/07 2:28 PM Page 8

BRINKMANN

DALLAS, TX 75244

CAUTION: Before each use, check handles and support brackets to make

sure they are securely fastened.

4. Place the smoker body on base pan, making sure the water pan is still in place.

5. Carefully, fill water pan with warm water or marinade to 1" below the rim. A full pan holds 4 quarts of water and will last for approximately 2-3 hours. Do not overfill or allow water to overflow from water pan.

WARNING: Do not spill water or liquid onto electric element.

6. Place a cooking grill on the lower support brackets directly above the water pan.

7. Place food on the cooking grill in a single layer with space between each piece. This will allow smoke and moist heat to circulate evenly around all pieces.

8. Place the other cooking grill on the upper support brackets. Make sure the rim is resting securely on notched out step of all three support brackets. Place food on the cooking grill.

9. With the dome lid on smoker, plug the smoker into electric outlet.

WARNING: Always use a 3-wire grounded outlet wired for 120-volts

which is GFCI protected at 15 or 20 amps. If in doubt, contact a qualified electrician. Do not operate this smoker with any other appliance or electrical device on the same circuit.

10. Allow food to cook. After 2-3 hours of cooking, check water level and add water if level is low. Follow instructions in the “Adding Water During Cooking” section of this manual.

11. Always use a meat thermometer to ensure food is fully cooked before removing from smoker.

12. After cooking, always unplug the smoker from electric outlet. Allow smoker to cool completely, then follow instructions in the “After-Use Safety and Proper Care & Maintenance” sections of this manual.

7085-K_Gour Elec_Eng-SP.qxd 11/1/07 2:28 PM Page 9

180

POULTRY

LAMB

BEEF WELL PORK

VEAL

140

HAM

BEEF MED.

BEEF RARE

COOKED HAM

+ 16 hidden pages