Brinkmann 810-5500-0 Owner's Manual
OWNER’S MANUAL
ASSEMBLY AND OPERATING INSTRUCTIONS
WARNING
READ AND FOLLOW ALL WARNINGS
AND INSTRUCTIONS IN THIS MANUAL
TO AVOID PERSONAL INJURY OR
PROPERTY DAMAGE.
Heavy-Duty Charcoal/Wood Smoker Grill
IMPORTANT SAFETY WARNINGS
WE WANT YOU TO ASSEMBLE AND USE YOUR SMOKER AS SAFELY AS POSSIBLE.
THE PURPOSE OF THIS SAFETY ALERT SYMBOL
IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR SMOKER.
WHEN YOU SEE THE SAFETY ALERT SYMBOL, PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS!
READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING AND OPERATING YOUR SMOKER.
WARNING
• Only use this smoker on a hard, level, non-combustible, stable surface (concrete, ground, etc.) capable of supporting the weight of
the smoker. Never use on wooden or other surfaces that could burn.
• DO NOT use smoker without ash pan in place. DO NOT attempt to remove ash pan while tray contains hot coals.
• Proper clearance of 10 feet between the smoker and combustible material (bushes, trees, wooden decks, fences, buildings, etc.) or
construction should be maintained at all times when smoker is in use. Do not place smoker under a roof overhang or other enclosed area.
• FOR OUTDOOR USE ONLY. Do not operate smoker indoors or in an enclosed area.
• For household use only. Do not use this smoker for other than its intended purpose.
• We recommend the use of a Charcoal Chimney Starter to avoid the dangers associated with charcoal lighting fluid. If you choose to
use charcoal lighting fluid, only use lighting fluid approved for lighting charcoal. Carefully read manufacturer’s warnings and
instructions on the charcoal lighting fluid and charcoal prior to the use of their product. Store charcoal lighting fluid safely away
from smoker.
• When using charcoal lighting fluid, allow charcoal to burn with smoker box door open until covered with a light ash (approximately
20 minutes). This will allow charcoal lighting fluid to burn off. Failure to do this could trap fumes from charcoal lighting fluid in
smoker and may result in a flash fire or explosion when smoker box door is opened.
• Never use charcoal that has been pre-treated with lighter fluid. Use only a high grade plain charcoal or charcoal/wood mixture.
• Do not use gasoline, kerosene or alcohol for lighting charcoal. Use of any of these or similar products could cause an explosion
possibly leading to severe bodily injury.
• Never add charcoal lighting fluid to hot or even warm coals as flashback may occur causing severe burns.
• Place smoker in an area where children and pets cannot come into contact with unit. Close supervision is necessary when
smoker is in use.
• Do not leave smoker unattended when in use.
• When adding charcoal and/or wood, use extreme caution and follow instructions in “Adding Charcoal/Wood During Cooking”
section of this manual.
• To avoid overturning/spilling pan of hot liquid, never pull water pan bracket out more than 4”. Refer to the illustration in “Adding
Water During Cooking” section of this manual.
• Do not store or use smoker near gasoline or other flammable liquids, gases or where flammable vapors may be present.
1
WARNING
• Smoker is hot when in use. To avoid burns:
• DO NOT attempt to move the smoker.
• Lock the wheels so the unit does not accidentally move.
• Wear protective gloves or oven mitts.
• DO NOT touch any hot smoker surfaces.
• DO NOT wear loose clothing or allow hair to come in contact with smoker.
• Use caution since flames can flare-up when fresh air suddenly comes in contact with fire. When opening the door, keep hands,
face and body a safe distance from hot steam and flame flare-ups.
• Do not allow charcoal and/or wood to rest on the walls of smoker. Doing so will greatly reduce the life of the metal and finish of
you smoker.
• Use caution when assembling and operating your smoker to avoid scrapes or cuts from possible sharp edges of metal parts. Use
caution when reaching into or under smoker.
• In windy weather, place smoker in an outdoor area that is protected from the wind.
• Never leave coals and ashes in smoker unattended. Before smoker can be left unattended, remaining coals and ashes must be
removed from smoker. Use caution to protect yourself and property. Carefully place remaining coals and ashes in a noncombustible metal container and saturate completely with water. Allow coals and water to remain in metal container 24 hours
prior to disposing.
• Extinguished coals and ashes should be placed a safe distance from all structures and combustible and flammable materials.
• With a garden hose, completely wet the surface beneath and around smoker to extinguish any ashes, coals or embers which may
have fallen during the cooking or cleaning process.
• After each use and the smoker has cooled completely, clean the smoker thoroughly and reapply a light coat of oil to interior to
prevent rusting. Cover the smoker to protect it from excessive rusting.
• Use caution when lifting or moving smoker to prevent strains and back injuries. Moving smoker may require the help of an
additional person.
• We advise that a fire extinguisher be on hand. Refer to your local authority to determine proper size and type of fire extinguisher.
• Accessory attachments not manufactured by The Brinkmann Corporation for this particular product are not recommended and
may lead to personal injury or property damage.
• Store the smoker out of reach of children and in a dry location when not in use.
• Do not attempt to service smoker other than normal maintenance as explained in “After-Use Safety” and “Proper Care &
Maintenance” sections of this manual. Repairs should be performed by The Brinkmann Corporation only.
• Properly dispose of all packaging material.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR SMOKER.
FAILURE TO ADHERE TO SAFETY WARNING AND GUIDELINES IN THIS MANUAL COULD RESULT
IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
2
ASSEMBLY INSTRUCTIONS
READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING OR OPERATING YOUR SMOKER.
FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 1-800-527-0717.
(Proof of purchase will be required.)
Inspect contents of the box to ensure all parts are included and undamaged.
We recommend two people work together
when assembling this unit.
The following tool is required to assemble
this Vertical Smoker:
• Adjustable Wrench
PARTS LIST - VERTICAL SMOKER:
1 Smoker box with legs
1
3 Cooking grills
2
1 Water pan
3
1 Water pan bracket
4
1 Charcoal pan
5
1 Charcoal pan bracket
6
1 Chimney
7
1 Door handle with spring, washer
8
and cotter pin
9
1 Temperature gauge
10
4 Locking casters
11
1 Ash pan
1
2
3
4
5
6
7
8
9
10
11
3
Choose a good, cleared assembly area and get a
friend to help you put your smoker together.
Carefully remove all components from Smoker Box.
Lay cardboard down to protect smoker finish and
assembly area.
Step 1
Attach the smoker box handle by inserting the
handle through the hole in smoker box door.
Place the handle spring and washer onto the
handle. Compress the spring and washer to the
door and insert the cotter pin to secure.
WARNING: Use caution when lifting or moving
smoker to prevent strains and back
injuries. Moving smoker may require
the help of an additional person.
NOTE: With the help of a friend, turn the smoker
box with legs upside down. Make sure door
is securely latched to avoid injury.
Step 2
Attach a locking caster to the bottom of each
leg. Screw into holes and tighten with an
adjustable wrench.
Smoker Box
Handle
Smoker Box
Door
Cotter Pin
Spring
Washer
Locking Caster
Smoker Box Leg
50
700
100
600
200
500
300
400
4
Loading...