Brinkmann 810-3795-0 Owner's Manual

OWNER’S MANUAL

WARNING

HAZARDOUS EXPLOSION MAY

RESULT IF THESE WARNINGS AND

INSTRUCTIONS ARE IGNORED. READ

AND FOLLOW ALL WARNINGS AND

INSTRUCTIONS IN THIS MANUAL TO

AVOID PERSONAL INJURY, INCLUDING

DEATH OR PROPERTY DAMAGE.

ASSEMBLY AND OPERATING INSTRUCTIONS

SAVE THIS MANUAL FOR FUTURE REFERENCE

NOTICE TO INSTALLER:

LEAVE THESE INSTRUCTIONS

WITH THE STOVE OWNER FOR

FUTURE REFERENCE.

WE WANT YOU TO ASSEMBLE AND USE YOUR STOVE AS SAFELY AS POSSIBLE.

THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO ATTRACT YOUR

ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR STOVE.

WHEN YOU SEE THE SAFETY ALERT SYMBOL

PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS!

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY

BEFORE ASSEMBLING AND OPERATING YOUR STOVE.

DANGER

IMPORTANT SAFETY

WARNINGS

FOR YOUR SAFETY:

IF YOU SMELL GAS:

• Shut off gas to the appliance at the LP cylinder and burners.

• Extinguish any open flame.

• If odor continues, leave the area and immediately call your gas supplier or your fire department.

FOR YOUR SAFETY:

• DO NOT store or use gasoline or other liquids with flammable vapors in the vicinity of this or any other appliance.

• An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance to avoid the possibility of explosion.

• Never store a spare LP cylinder under or near this stove.

• Never fill the cylinder beyond 80% full.

• A fire causing death or serious injury may occur if the above is not followed exactly.

WARNING

• Never use natural gas in a unit designed for liquid propane gas.

• Never use charcoal briquets or lighter fluid in a gas stove.

• Leak test all connections before first use, even if stove was purchased fully assembled and

after each tank refill.

• Never check for leaks using a match or open flame.

CAUTION! Strong odors, colds, sinus congestion, etc. may prevent the detection of

propane. Use caution and common sense when testing for leaks.

• Always keep gasoline, paint thinner, or other flammable liquids or combustible materials away from your gas stove.

• Always check the stove prior to each use as indicated in the “Pre-Start Check List” section of this manual.

• Keep children and pets away from hot stove. DO NOT allow children to use or play near this stove.

• Properly secure tank to support bracket as indicated in the “Installing the LP Gas Cylinder onto the Stove” section of this manual (page 5). This will stabilize stove while in use.

• DO NOT leave the stove unattended while in use.

• DO NOT allow the gas hose to come in contact with hot surfaces.

• Keep a fire extinguisher on hand acceptable for use with gas products. Refer to your local

authority to determine proper size and type.

• Never place more than 10 pounds on the side tables. DO NOT lean on the side tables.

• Never place more than 25 pounds on each of the cooking grills (50 lbs. total on grills).

• For household use only. DO NOT use this stove for anything other than its intended purpose.

• DO NOT use while under the influence of drugs or alcohol.

• Stove is hot when in use. To avoid burns:

• DO NOT attempt to move the stove.

• DO NOT exceed the weight capacity of the stove.

• Never put an empty pot over a lit burner.

• Use only small to medium size flat bottom cookware centered over the burners.

• Wear protective gloves or oven mitts.

• DO NOT touch any hot stove surfaces.

• DO NOT wear loose clothing or allow hair to come in contact with stove.

USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR GAS STOVE.

FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS

MANUAL COULD RESULT IN SEVERE BODILY INJURY OR PROPERTY DAMAGE.

SAVE THIS MANUAL FOR FUTURE REFERENCE.

CYLINDER SPECIFICATIONS:

When purchasing or exchanging a cylinder for your gas stove, it must be constructed and marked in accordance with the specifications for LP gas cylinders of the U.S. Department of Transpor tation (DOT) or the National Standard of Canada, CAN/CSA-B339 as applicable with a listed over-filling prevention device (OPD).

WARNING

LP GAS CYLINDER (NOT SUPPLIED WITH THIS STOVE)

The LP (Liquid Propane) gas cylinder specifically designed to be used with this stove must have a 20 lb. (9.1 kg) capacity incorporating a Type 1 cylinder valve and an over-filling protection device (OPD).

• DO NOT connect this stove to an existing #510 POL cylinder valve with Left Hand threads. The

Type 1 valve can be identified with the large external threads on the valve outlet.

• DO NOT connect to a propane cylinder exceeding this capacity.

• DO NOT connect to a cylinder that uses any other type of valve connection device.

• FOR OUTDOOR USE ONLY. DO NOT operate indoors or in an enclosed area such as a tent,

screened porch, garage, shed or breezeway.

• Use your stove OUTDOORS in a well ventilated space away from buildings, trees, fences or

other combustible materials or structures to prevent dangers associated with gas accumulation and toxic vapors. We recommend your stove be situated at least 10 feet (3 meters) from buildings.

• DO NOT use on wooden decks or surfaces that could burn.

• Maintain a minimum clearance of 36 inches (90 cm) between all sides of stove and walls or

other combustible material. Do not locate this appliance under overhead unprotected combustible surfaces.

• DO NOT install in or on a recreational vehicle and/or boat.

• DO NOT use on apartment complex patios or balconies.

INSTALLATION INFORMATION:

The installation of this appliance must be in accordance with:

All applicable local codes, or in the absence of local codes, either:

• National Fuel Gas Code,

• ANSI Z223.1 1988 or latest edition (USA)

• Natural Gas Installation Code: CAN/CGA B149.1 (Canada)

• Propane Installation Code: CAN/CGA B149.2 (Canada)

To check your local codes, see your local LP gas dealer or natural gas company.

This stove shall not be connected to a natural gas supply line.

The cylinder must also be equipped with:

• A shut-off valve terminating in a Type 1 gas cylinder valve outlet.

• A Type 1 valve that prevents gas flow until a positive seal is obtained.

• An arrangement for vapor withdrawal.

• A collar to protect the cylinder shut off valve.

• A safety relief device having direct communication with the vapor space of the cylinder.

• A listed over-filling prevention device (OPD).

• Turn off the cylinder valve when your stove is not in use.

• Handle the tank with care.

• Always secure the cylinder in an upright position.

• Never connect an unregulated LP gas cylinder to your stove.

• DO NOT expose LP cylinders to excessive heat or ignition sources.

• DO NOT store a spare cylinder under or near your stove.

• Allow only qualified LP gas dealers to fill or repair your LP gas cylinder.

• DO NOT allow the cylinder to be filled beyond 80% capacity.

• Read and follow all warnings and instructions that are on the cylinder and that accompany this

product.

• Never store a spare LP cylinder under or near your stove when in use. This could cause excess pressure to be expelled through the vapor relief valve resulting in fire, explosion, or severe personal injury including death.

NOTE: PROPANE GAS IS HEAVIER THAN AIR AND WILL COLLECT IN LOW AREAS.

PROPER VENTILATION IS EXTREMELY IMPORTANT.

• DO NOT insert any foreign objects into the valve outlet. Damage to the back-check could result. A damaged back-check can cause a leak, possibly resulting in explosion, fire, severe bodily harm, or death.

WARNING

DANGER

+ 11 hidden pages