Brinkmann 810-3070-s Owner's Manual

OWNER’S MANUAL / MANUAL DEL PROPIETARIO

ASSEMBLY AND OPERATING IN STRUC TIONS

INSTRUCCIONES DE ARMADO Y OPERACIÓN

SAVE THIS MANUAL FOR FUTURE REFERENCE

GUARDE ESTE MANUAL PARA REFERENCIA FUTURA

NOTICE TO INSTALLER:

LEAVE THESE INSTRUCTIONS WITH THE

GRILL OWNER FOR FUTURE REFERENCE .

AVISO PARA EL INSTALADOR:

ENTREGUE ESTAS INSTRUCCIONES AL

PROPIETARIO DE LA PARRILLA PARA

REFERENCIA FUTURA.

WARNING/ADVERTENCIA

HAZARDOUS EXPLOSION MAY RESULT IF THESE WARNINGS AND INSTRUCTIONS ARE

IGNORED. READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS IN THIS MANUAL

TO AVOID PERSONAL INJURY, INCLUDING DEATH OR PROPERTY DAMAGE.

SE PUEDE PRODUCIR UNA EXPLOSIÓN PELIGROSA SI SE HACE CASO OMISO A ESTAS ADVERTENCIAS E INSTRUCCIONES. LEA Y SIGA TODAS LAS ADVERTENCIAS E INSTRUCCIONES EN ESTE MANUAL PARA EVITAR LESIONES PERSONALES, INCLUSO

LA MUERTE, O LOS DAÑOS MATERIALES.

INS_810-3070-S_INSTR-Fire Pit _Grill 10/13/11 10:58 AM Page 1

WARNING

IMPORTANT SAFETY WARNINGS

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY

BEFORE ASSEMBLING AND OPERATING YOUR COOKER.

•

Only use this grill on a hard, level, noncombustible, stable surface (concrete, ground, etc.) capable of supporting the weight of the unit. DO NOT use on wooden or other surfaces that could burn.

•

FOR OUTDOOR USE ONLY. DO NOT operate grill indoors or in an enclosed area. In windy weather, place grill in an outdoor area that is protected from the wind.

•

Proper clearance of 10 feet between grill and combustible materials (bushes, trees, wooden decks, fences, buildings, etc.) or construction should be maintained at all times when grill is in use. DO NOT place grill under a roof overhang or other enclosed area.

•

Place a metal pan or pot under grill to catch any ashes or embers that may escape the grill.

• DO NOT use gasoline, kerosene or alcohol for lighting wood. Use of any of these or similar products will cause an explosion possibly leading to severe bodily injury.

• This is an attended product. DO NOT leave grill unattended while in use or while hot.

•

Never move grill when in use or when it contains hot coals or ashes.

•

Keep grill in an area where children and pets cannot come into contact with unit. Close supervision is necessary when the grill is in use or hot after use.

•

Never add charcoal lighting fluid to hot or even warm coals as flashback or explosion may occur causing severe burns.

• DO NOT store or use grill near gasoline or other flammable liquids, gases or where flammable vapors may be present.

•

To avoid personal injury, DO NOT wear loose clothing or allow hair to hang freely while tending to grill.

•

DO NOT burn any material other than wood or charcoal in grill as your fuel source.

• Always use oven mitts/gloves to protect your hands. Surfaces will be very HOT!

•

Safety pins should be used at all times. Insert safety pins in nearest holes directly under cooking grill.

•

Never leave hot coals and ashes in grill unattended. Remaining coals and ashes must be extinguished. Use caution to protect yourself and property. Carefully saturate coals completely with water. Allow coals and water to remain in grill 24 hours prior to disposing.

•

With garden hose, completely wet the surface beneath and around the grill to extinguish any ashes, coals or embers which may have fallen during use or cleaning.

•

Use caution when lifting or moving the grill to prevent strains and back injuries. Moving the grill may require the help of an additional person.

•

We advise that a fire extinguisher be on hand. Refer to your local authority to determine proper size and type of fire extinguisher.

• DO NOT use wood logs over 18 inches in length.

USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR OUTDOOR GAS GRILL. FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL

COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE.

SAVE THIS MANUAL FOR FUTURE REFERENCE.

INS_810-3070-S_INSTR-Fire Pit _Grill 10/13/11 10:58 AM Page 2

FOR COVERS, ACCESSORIES AND OTHER PRODUCTS, PLEASE VISIT US ONLINE AT:

ASSEMBLY & OPERATING INSTRUCTIONS

READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY

BEFORE ASSEMBLING OR OPERATING YOUR COOKER.

FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 1-800-527-0717.

PARTS LIST:

1 Spit Rod 1 Spit Holder Bracket 1 Spit Holder Stop Bracket 2 Spit Holder Supports 2 Cooking Grates 1 Charcoal Grate 1 Swing Hook 1 Swing Hook Holder

2 Cooking Grate Set Pins 2 Swing Hook Set Pins and

Cooking Grate Set Pins 1 Front Leg 1 Rear Leg 4 Retaining Rings 1 Ash Bowl 1 Ash Bowl Handle 1 Left Ash Bowl Bracket 1 Right Ash Bowl Bracket 2 Left / Right Legs 2 Handles 1 Warming Rack Bracket 1 Fire Bowl 1 Warming Rack 2 Spit Forks 1 Spit Rod Spring Handle

The following tool is required to assemble this Brinkmann Ranch Fire Pit & Grill:

• Phillips Head Screwdriver

CALIFORNIA PROPOSITION 65 WARNING

This product contains chemicals, including lead in the brass of certain component parts, that are known to the State of

California to cause cancer, and birth defects or other reproductive harm. Wash hands after handling. When used, this product

emits fuel combustion chemicals that are known to the State of California to cause cancer, and birth defects or other

reproductive harm. Follow all instructions in this manual and use only in well ventilated, outdoor area.

INS_810-3070-S_INSTR-Fire Pit _Grill 10/13/11 10:58 AM Page 3

Make sure you have all items listed under PARTS LIST and PARTS BAG CONTENTS before you begin the installation process.

PARTS BAG CONTAINS:

Qty. Qty.

PARTS BAG CONTENTS

16 M6 X 12 mm Bolts 4 M6 X 12 mm Wing Bolts 6 M6 Nuts 8 M6 X 12 mm Hex Head Bolts

1 M10 Flat Washer 1 M10 Cap Nut 4 M5 X 12 mm Bolts 1 Hex Nut Wrench

M6 X 12 mm Bolts

M6 X 12 mm

Wing Bolts

M6 Nuts

M5 X 12 mm Bolts

M6 X 12 Hex Head Bolts M10 Cap Nut

Hex Nut Wrench

M10 Flat Washer

INS_810-3070-S_INSTR-Fire Pit _Grill 10/13/11 10:58 AM Page 4

NOTE: Choose a good, cleared assembly

area and get a friend to help you put your grill together. Lay card board down to protect grill finish and assembly area.

Step 1

Place the fire bowl on platform, then attach legs to fire box using twelve M6 X 12 mm bolts as illustrated.

Step 2

Remove the platform after assembled legs, attach left and right ash bowl brackets to fire bowl using four M5 X 12 mm bolts as illustrated.

Rear Leg

Left/Right Leg

Rear Leg

Left/Right Leg

Left/Right LegLeft/Right Leg

Front Leg

Platform

Left Ash Bowl

Bracket

Right Ash Bowl

Bracket

M5 X 12 mm Bolts

Fire Bowl

M6 X 12 mm Bolts

INS_810-3070-S_INSTR-Fire Pit _Grill 10/13/11 10:58 AM Page 5

Step 3

Attach ash bowl handle into ash bowl using two M6 nuts as illustrated.

Step 4

Insert ash bowl into ash bowl rails as illustrated.

Step 5

Attach handle to fire box using four M6 X 12 mm bolts and four M6 nuts as illustrated.

Ash Bowl

M6 Nuts

M6 X 12 mm Bolts

M6 Nuts

Ash Bowl Handle

INS_810-3070-S_INSTR-Fire Pit _Grill 10/13/11 10:58 AM Page 6

Charcoal Grate

Step 6

Attach retaining rings to legs using eight M6 X 12 mm hex head bolts as illustrated.

Step 7

Insert charcoal grate as illustrated.

M6 X 12 mm Hex Head Bolts

Retaining Ring

INS_810-3070-S_INSTR-Fire Pit _Grill 10/13/11 10:58 AM Page 7

+ 15 hidden pages