Brinkmann 805-2200-0, 805-2200-1 Owner's Manual
R
OWNER’S MANUAL
ASSEMBLY AND OPERATING INSTRUCTIONS
OUTDOOR BARBECUE GRILL & SMOKER
IMPORTANT SAFETY WARNINGS
WE WANT YOU TO ASSEMBLE AND USE YOUR SMOKER AS SAFELY AS POSSIBLE.
THE PURPOSE OF THIS SAFETY ALERT SYMBOL
IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR SMOKER.
WHEN YOU SEE THE SAFETY ALERT SYMBOL, PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS!
READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING AND OPERATING YOUR SMOKER.
WARNING
• Only use this product on a level, noncombustible, stable surface (concrete, ground, gravel, etc.). Do not use on
wooden surfaces.
• Always use a drip pan/ash guard under grill to protect surface from heat damage and/or discoloration and to catch
ashes, embers and drippings.
• Do not use unit on a surface that could burn. A drip pan/ash guard will not prevent fires from occurring on a combustible material.
• Proper clearance of 5 feet between the cooker and combustible construction should be maintained at all times
when this product is in use.
• For household use only. Do not use this product for other than its intended purpose.
• This product is to be used outdoors only. Do not operate this product indoors or inside any enclosed area.
• Do not leave product unattended when in use.
• Never move product when it is in use.
• Do not use gasoline, kerosene or alcohol for lighting charcoal. Use of any of these or similar products will cause
an explosion possibly leading to severe bodily injury.
• Do not store or use gasoline or other flammable liquids near the cooker.
• We recommend the use of a Charcoal Chimney Starter to avoid the dangers associated with charcoal lighting fluid.
If you choose to use charcoal lighting fluid, only use lighting fluid approved for lighting charcoal. Carefully read instructions on the charcoal lighting fluid and charcoal prior to use.
• If using charcoal lighting fluid, allow charcoal to burn until covered with a light ash (approximately 20 minutes).
This will allow charcoal lighting fluid to burn off. If charcoal lighting fluid does not completely burn off, fumes
could accumulate in cooker causing an explosion or flash fire when cooker door is opened.
• Do not use self-starting charcoal. Use only a high grade plain charcoal or charcoal/wood mixture.
• Never add charcoal lighting fluid to hot or even warm coals.
• Use caution when opening the door to avoid steam burns and flame flare-ups.
• Use caution when assembling and operating your smoker to avoid scrapes or cuts from sharp edges of metal
parts.
1
WARNING
29
• Do not allow children or pets to come in contact with the grill. Close supervision is necessary when grill is in use.
• Use caution when lifting or moving this product to prevent strains and back injuries.
• In windy weather, this product should be located in an outdoor area that is protected from the wind.
• Do not wear loose clothing or allow hair to hang freely while using this product.
• Use caution when reaching into or under the product. Always wear oven mitts/or gloves to protect your hands from burns.
Avoid touching hot surfaces.
• We advise that you have a fire extinguisher on hand. Refer to your local authority to determine proper size and type of fire
extinguisher.
• Accessory attachments not manufactured by The Brinkmann Corporation for this particular product are not recommended
and may lead to personal injury or property damage.
• Use extreme caution and follow instructions for adding charcoal, wood and water.
• When grilling, grease from the meat may drip into the charcoal and cause a grease fire. If a grease fire occurs, close and
latch the door to suffocate the flame. DO NOT USE WATER TO EXTINGUISH A GREASE FIRE.
• Never leave coals and ashes in smoker/grill unattended.
• Before cooker can be left unattended, coals and ashes must be removed from cooker. Use caution to protect yourself and
property. Place remaining coals and ashes in a noncombustible metal container and completely saturate with water. Allow
ashes and water to remain in metal container 24 hours prior to disposing.
• Extinguished coals and ashes should be placed a safe distance from all structures and combustible materials.
• Properly dispose of all packaging material.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR SMOKER.
FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL
COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
ASSEMBLY INSTRUCTIONS
READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY BEFORE
PROCEEDING WITH THE ASSEMBLY OF THIS SMOKER.
Inspect contents of the box to insure all parts are included and undamaged.
We recommend two people work together
when assembling this unit.
1
The following tools will be required for assembly of this Smoke’N Pit Smoke King:
• A Flathead Screwdriver
•A 7/16" Wrench
• An Adjustable Wrench
PARTS LIST:
1 Cooking chamber
1
3 Legs
2
3 Metal brackets for handles
3
6 Wooden handle halves
4
1 Chrome push-plug
5
1 Door latch
6
1 Porcelain coated charcoal pan
7
1 Porcelain coated water pan
8
3 15 2" chrome cooking grills
9
3 4-20 x 2 4" Bolts
4 4-20 x w" Bolts
6 4-20 x 2" Bolts
9 4-20 x 1 w" Bolts
21 4-20" Nuts
21 4" Lock washers
6 10-24 x 1" Bolts and nuts
(For handle halves)
6
3
2
2
9
5
3
4
8
7
3
Loading...