Bradley SS-3, SS-3/AST/WH97TAS Installation Instructions Manual
IMPORTANT
Read this entire installation manual
to ensure proper installation, then
file these instructions with the
owner or maintenance department.
Flush all the water supply lines
before making connections.
Wall anchors used must have a
minimum pull-out rating of 1,000
lbs.
Product warranties may be found
under "Product Information" on our
web site at www.bradleycorp.com..
SS-3/AST/WH97TAS
Express® Lavatory
System SS-Series
*Complies with Texas Accessibility
Standards (TAS) for Juvenile Height
applications.
Table of Contents
Pre-Installation Information . . . . . . . . . . . . . . . .2
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
Installation Instructions . . . . . . . . . . . . . . . . 5-11
Cleaning and Maintenance . . . . . . . . . . . . . . . .12
Soap Dispenser Maintenance . . . . . . . . . . .13-14
Check Valve Troubleshooting . . . . . . . . . . . . . .14
Assembly of Components . . . . . . . . . . . . . .15-16
Metering Air Valve Maintenance . . . . . . . . . . .17
Metering Air Valve Troubleshooting . . . . . .17-18
Vernatherm™ Thermostatic Mixing Valve . . . .19
P.O. Box 309, Menomonee Falls, WI 53052-0309
TEL. 1-800-BRADLEY FAX 262-251-5817
http://www.bradleycorp.com
215-1240 Rev. E; EN 08-805
© 2008 Bradley Corporation
Page 1 of 19 4/24/08
Installation
Instructions
OBSOLETE
Express® Lavatory System SS-Series
SS-3/AST/WH97TAS Installation - Obsolete
2
4/24/08 Bradley Corporation • 215-1240 Rev. E; EN 08-805
Pre-Installation Information
Texas Accessibility Standards compliant:
The SS-3/AST/WH97TAS Express® Lavatory System meets Texas Accessibility standards
(TAS) for barrier-free clearances, reaches and controls. Always check local codes and ordinances
for compliance.
Pushbutton and air valve
Each sprayhead is controlled by a pushbutton air valve, enabling each user to activate a single flow
of water. Air valves use 0.5 gpm for a ten-second duration, meeting the ANSI/ASHRAE/IES
90A-1980 Standard.
Supplies required for installation:
• (10) 3/8" wall anchors, bolts and washers to mount frame and bowl to wall
(minimum pull-out rating of 1,000 lbs.)
• 1/2" NPT hot and cold supply piping
• 1-1/2" NPT drain piping
Express® Lavatory System SS-Series
Installation - Obsolete SS-3/AST/WH97TAS
3
Bradley Corporation • 215-1240 Rev. E; EN 08-805 4/24/08
SS-3/AST/WH97TAS Express® Lavatory System Dimensions
Dimensions continue . . .
Express® Lavatory System SS-Series
SS-3/AST/WH97TAS Installation - Obsolete
4
4/24/08 Bradley Corporation • 215-1240 Rev. E; EN 08-805
Dimensions continued . . .
Juvenile Height
SS-3/AST/WH97TAS
Grades Pre-K thru 5 or 6
Juvenile Height
SS-3/AST/WH97TAS
Grades 6 thru 8 or 9
Express® Lavatory System SS-Series
Installation - Obsolete SS-3/AST/WH97TAS
5
Bradley Corporation • 215-1240 Rev. E; EN 08-805 4/24/08
Installation Instructions
Step 1: Rough in
Note: See Figure 1a (below) and Figures 1b and 2 (on page 6) when roughing in the Express®.
IMPORTANT: Flush the supply lines before making connections. Debris in supply
lines will cause the valves to malfunction.
IMPORTANT: Dimensions shown in Figure 1a are for Juvenile Height grades Pre-K
thru 5 or 6, and in Figure 1b for Juvenile Height grades 6 thru 8 or 9.
1. Rough in 1/2" NPT hot and cold supply lines through wall at dimensions shown.
2. Rough in 1-1/2" NPT drain waste connection through wall at dimensions shown.
3. Install (10) 3/8" wall anchors with a minimum pull-out rating of 1,000 lbs. (supplied by
installer) at the locations shown in Figures 1a and 1b.
NOTE: The anchors will be used to mount the Express® bowl and frame to the wall.
Figure 1a
Installation Instructions continue . . .
SS-3/AST/WH97 Express® Lavatory System Dimensions
Juvenile Height Mounting (Grades Pre-K thru 5 or 6)
Express® Lavatory System SS-Series
SS-3/AST/WH97TAS Installation - Obsolete
6
4/24/08 Bradley Corporation • 215-1240 Rev. E; EN 08-805
Installation Instructions continue . . .
Figure 1b
Figure 2
SS-3/AST/WH97 Express® Lavatory System Dimensions
Juvenile Height Mounting (Grades 6 thru 8 or 9)
Loading...